Advantech CompactPCI MIC-3665A Bedienungsanleitung

Advantech CompactPCI™

MIC-3665A/B

Dual Gigabit Ethernet

PMC Function Modules

Modular Industrial Computer

This document is copyrighted, 2004. All rights are reserved. The original

manufacturer reserves the right to make improvements to the products described in

this manual at any time without notice. No part of this manual may be reproduced,

copied, translated or transmitted in any form or by any means without the prior

written permission of the original manufacturer. Information provided in this

manual is intended to be accurate and reliable. However, the original manufacturer

assumes no responsibility for its use, nor for any infringements upon the rights of

third parties which may result from its use.

Acknowledgements

! IBM and PC/AT are trademarks of International Business Machines Corporation.

! Intel and is trademark of Intel Corporation.

! Microsoft Windows® is a registered trademark of Microsoft Corp.

! PICMG™, CompactPCI™, and the PICMG™ and CompactPCI™ logos are

trademarks of the PCI Industrial Computers Manufacturers Group.

! All other product names or trademarks are properties of their respective owners.

FCC

This device complies with the requirements in part 15 of the FCC rule：Operation is

subject to be following two conditions：

(1）this device may not cause harmful interference

(2）this device must accept any interference received, including interference that

may cause undesired operation.

Part No. 2002366500 1st Edition

Printed in Taiwan DEC. 2004

Product warranty

Advantech warrants to you, the original purchaser, that each of its products will be

free from defects in materials and workmanship for one year from the date of

purchase.

This warranty does not apply to any products which have been repaired or altered

by persons other than repair personnel authorized by Advantech, or which have

been subject to misuse, abuse, accident or improper installation. Advantech

assumes no liability under the terms of this warranty as a consequence of such

events.

Because of Advantech’s high quality-control standards and rigorous testing, most of

our customers never need to use our repair service. If an Advantech product is

defective, it will be repaired or replaced at no charge during the warranty period. For

out-of-warranty repairs, you will be billed according to the cost of replacement

materials, service time and freight. Please consult your dealer for more details.

If you think you have a defective product, follow these steps:

1. Collect all the information about the problem encountered. For example, CPU

speed, Advantech products used, other hardware and software used, etc. Note

anything abnormal and list any on-screen messages you get when the problem

occurs.

2. Call your dealer and describe the problem. Please have your manual, product,

and any helpful information readily available.

3. If your product is diagnosed as defective, obtain an RMA (return merchandise

authorization) number from your dealer. This allows us to process your return more

quickly.

4. Carefully pack the defective product, a fully-completed Repair and Replacement

Order Card and a photocopy proof of purchase date (such as your sales receipt) in

a shippable container. A product returned without proof of the purchase date is not

eligible for warranty service.

5. Write the RMA number visibly on the outside of the package and ship it prepaid to

your dealer.

Packing List

Ensure that the following materials have been received, immediately after opening

the box containing your MIC-3665 card:

• One MIC-3665 Dual Gigabit Ethernet PMC card

• One CD-ROM disc containing device drivers

• One warranty certificate

• This user's manual

If any of these items are missing or damaged, contact your distributor or sales

representative immediately.

Technical Support and Sales Assistance

If you have a technical question, please visit Advantech's support website, located

at: http://support.advantech.com.tw. For more information about Advantech's

products and sales service, please visit our homepage located at:

http://www.advantech.com.tw

iii

Contents

Acknowledgements.................................................................... i

Product warranty………………………………………………………………. ii

Packing List............................................................................... iii

Technical Support and Sales Assistance……………………………….. iii

Contents.................................................................................... iv

Tables and Figures..................................................................... iv

Chapter 1: Introduction ............................................................. 1

1.1 Description ........................................................................... 2

1.2 Features................................................................................ 3

1.3 Specifications......................................................................... 4

1.4 Safety Precautions.................................................................. 5

Chapter 2: Hardware and Drivers Installation ........................... 6

2.1 Initial Inspection.................................................................... 7

2.2 MIC-3665 Connector Locations................................................. 8

2.3 Card Installation..................................................................... 8

2.4 Cable connecting info………........................................................ 9

2.5 Front Panel LED Indicators....................................................... 9

2.6 Drivers/Utilities Installation...................................................... 10

Appendix A: Pin Assignment..................................................... 11

A.1 RJ-45 Pin Assignments……….................................................... 12

A.2 PMC Pin Assignments............................................................... 12

Tables and Figures

Figure 2-1: MIC-3665 connector locations ....................................... 8

Figure 2-2: MIC-3665 front panel LEDs............................................ 10

Table 2-1: MIC-3665 Gigabit Ethernet physical media support……………. 9

Table 2-2: MIC-3665 LED Indicator definitions.................................. 9

Table A-1: MIC-3665 RJ-45 pin assignments..................................... 11

Table A-2: MIC-3665 PMC pin assignments……………………………………………. 12

Introduction

1.1 Description

The MIC-3665 provides dual high performance Gigabit Ethernet interface controller

port on a single-wide PMC module. Both RJ-45 and fiber interfaces are available on

different modules. The RJ-45 Ethernet network interface complies with the IEEE

802.3 for 10BaseT and 100BaseTx, and IEEE 802.3ab for 1000BaseT over category

5 twisted pair cable. Both full duplex and half duplex modes are available. The

MIC-3665 eliminates machine bottlenecks and allows easy migration from existing

Category-5 networks to Gigabit Ethernet. Featuring cost-effective and flexible

auto-negotiating 10/100/1000 Mbps performance, the MIC-3665 is designed to

automatically scale with growing networks. Another choice is Fiber SFP LC Interface

based on IEEE 802.3z for 1000Base-X which provides dual integrated low powered

MAC/SERDES functionality. The MIC-3665 fiber module alleviates bottlenecks and

increases uptime with Gigabit performance in multi-mode fiber-optic networks. The

fiber module also delivers high throughput while conserving CPU resources. The

MIC-3665 is able to cache up to 64 packet descriptors in a single burst for efficient

PCI bandwidth use. A large 64 Kbytes on–chip buffer maintains superior

performance as available PCI bandwidth changes. Programmable host memory

receiving buffers (256 Bytes to 16 Kbytes) and cache line size (16 Bytes to 256

Bytes) enable efficient use of PCI bandwidth as well, allowing back-to-back

transmission with minimum interface latency. It also features a 100BaseTX and

1000BaseT auto-detection CSMA/CD interface controller. It supports a number of

sophisticated features, including auto-negotiation, collision detection, link detection,

I/O is via one front panel RJ-45 connector. The module is compliant with standard

single-wide PMC IEEE P1386.1 and PCI 2.3 specifications.

1.2 Features

•High performance wire speed, each port 1.9 Gb sustained raw throughput over

133/100/66 PCI-X

•One adapter for all common platforms with driver support for Linux and Windows

•Supports 33/66 MHz, 32/64 bit PCI interfaces and 100/133 MHz PCI-X

•Installs in any PCI-capable CompactPCI system with a vacant PMC Mezzanine slot

(PMC card)

•Utilizes 3.3 volt power supply and contains onboard power regulators

•Full duplex Gigabit Ethernet Interface over standard CAT-5/CAT-5e cabling

•Complies with all PCI revision 2.3 mechanical and electrical requirements

•Fully IEEE 802.3u, IEEE 802.3ab, 802.3z and IEEE 1386 compliant

•Compatible with all 10/100/1000Base-T/TX hubs, switches and routers

•Link quality monitor evaluates and adjusts to actual line conditions by managing

echo and cross-talk cancellation, equalization, timing and skew compensation

•Automatic gain control maximizes signal strength

•Burst rate of upto 256dwords (1024 bytes) over PCI bus

•Optional jumbo packets, 802.3x full-duplex flow control with automatic pause,

802.1D and 802.1Q priority with multiple priority queues

•10BaseT/100BaseTX/1000BaseT Ethernet port using front panel RJ-45 connector

•1000Base-X Fiber LC interface, single front panel SFP connector

•Single-wide 32/64 bit PMC module

•LED indicators for speed (10/100/1000) and link/activity

•Auto-negotiating protocol selection

•Transmit and receive FIFOs

•Drivers for VxWorks, NetWare (5.1/6.0/6.5), DOS, Novell ODI, OS/2, Linux (kernel

2.4), FreeBSD (Kernel 4.7), Windows® 95/98/NT/2000/XP/2003

(Professional/Server, 32/64 Bit) available

1.3 Specifications

• IEEE 802.3/802.3u 10Base-T/100Base-TX compatible

• IEEE 802.3ab 1000Base-T compatible

• IEEE 802.3z 1000Base-X (1000Base-SX, 1000base-LX) compatible*.

• CompactPCI Mezzanine Specification Revision 1.0

• Complies with PCI Bus Specification 2.3

• RJ-45 connector: The RJ-45 connector can use IEEE 802.3 10 Base-T compliant

Category 3, 4, or 5 cables. It can only use a Category 5 UTP cable for 100Mbps

/1Gbps operation. Select a high-quality brand of Category 5 cable from your local

supplier. The maximum length of the cable is 100 meters

• Fiber SFP (Small Form Factor) connector: Supports 802.3z (1000Base-X)

Fiber transceivers. Both single mode and multimode (1000Base-SX, 1000Base-LX)

are supported.

• Controller chip: Intel 82546GB

• Driver support: VxWorks, NetWare (5.1/6.0/6.5), DOS, Novell ODI, OS/2, Linux

(kernel 2.4), FreeBSD (Kernel 4.7), Windows® 95/98/NT/2000/XP/2003

(Professional/Server, 32/64 Bit)

• Power consumption: +3.3 V @ 1.0 A (max.)

• Operating temperature: 0 ~ 60° C (32 ~ 140° F)

• Storage temperature: -20 ~ 70° C (-4 ~ 158° F)

• Dimensions: 51 mm x 100 mm (2.0" x 3.9")

• Weight: 0.2 kg (0.44 lb)

• Emissions: CE mark to CISPR 11 Class A; FCC Class A.

*Agilent® HFBR-57M5AP (1000Base-SX multimode 850nm module) is fully

tested, and is suggested for multimode usage.

1.4 Safety Precautions

Follow these simple precautions to protect yourself from harm and your system

from damage.

1. To avoid electric shock, always disconnect the power from your system chassis

before you work on it. Don't touch any components on the card or other cards while

the system is on.

2. Disconnect power before making any configuration changes. The sudden rush of

power as you connect a jumper or install a card may damage sensitive electronic

components.

3. Always ground yourself to remove any static charge before you touch your CPU

card. Be particularly careful not to touch the chip connectors. Modern integrated

electronic devices, especially CPUs and memory chips, are extremely sensitive to

static electric discharges and fields. Keep the card in its antistatic packaging when it

is not installed in the PC, and place it on a static dissipative mat when you are

working with it. Wear a grounding wrist strap for continuous protection.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Advantech Industrie-PC Handbücher

Advantech

Advantech ITA-2111 Installations- und Betriebshandbuch

Advantech

Advantech FWA-1330A Installations- und Betriebshandbuch

Advantech

Advantech iDAQ-900 Series Bedienungsanleitung

Advantech

Advantech ASMB-976 Series Bedienungsanleitung

Advantech

Advantech AIIS-1200 Series Bedienungsanleitung

Advantech

Advantech UNO-2484G Bedienungsanleitung

Advantech

Advantech UTC-315 Series Bedienungsanleitung

Advantech

Advantech ECU-1051TL Installations- und Betriebshandbuch

Advantech

Advantech ECU-4553 Series Bedienungsanleitung

Advantech

Advantech IPPC-6192A Bedienungsanleitung

Advantech

Advantech ARK-3202V -S6A1E Bedienungsanleitung

Advantech

Advantech MIC-3000 Series Bedienungsanleitung

Advantech

Advantech SOM-6872 Bedienungsanleitung

Advantech

Advantech POC-S176 Series Bedienungsanleitung

Advantech

Advantech PCE-2032 Installations- und Betriebshandbuch

Advantech

Advantech UTC-310GP-ATB0E Bedienungsanleitung

Advantech

Advantech EPC-S202 Bedienungsanleitung

Advantech

Advantech DLTV72INT Bedienungsanleitung

Advantech

Advantech UNO-1372GH Bedienungsanleitung

Advantech

Advantech UNO-2000 Series Bedienungsanleitung

Advantech

Advantech ITA-5710 Series Installations- und Betriebshandbuch

Advantech

Advantech Watchdog Timer UNO-2170 Bedienungsanleitung

Advantech

Advantech DLoG DLT-V4108 Bedienungsanleitung

Advantech

Advantech EPC-R3710NO-XAA100 Bedienungsanleitung

Beliebte Industrie-PC Handbücher anderer Marken

Chipsee

Chipsee PPC-A72-101 Bedienungsanleitung

MSI

MSI MS-9A76 Bedienungsanleitung

Stackrack

Stackrack THOR200 Bedienungsanleitung

Moxa Technologies

Moxa Technologies DA-682C Series Bedienungsanleitung

Nodka

Nodka eBOX-3000-ETC Bedienungsanleitung

Siemens

Siemens SIMATIC IPC627E Bedienungsanleitung

MSI

MSI MS-9A89 Bedienungsanleitung

Artila

Artila Matrix-516 Bedienungsanleitung

Siemens

Siemens SIMATIC Rack PC 840 V2 Bedienungsanleitung

Beckhoff

Beckhoff CX9020 Bedienungsanleitung

Dell

Dell Embedded Box PC 5000 Bedienungsanleitung

IBASE Technology

IBASE Technology ASB200-918 Series Bedienungsanleitung

Lenovo

Lenovo ThinkCentre M90q Betriebsanleitung

IXXAT

IXXAT Econ 100 Bedienungsanleitung

Kontron

Kontron KBox A-151-TGL Bedienungsanleitung

AXIOMTEK

AXIOMTEK ICO500-518 Series Bedienungsanleitung

JLT

JLT 1214N Bedienungsanleitung

Beckhoff

Beckhoff C6925 Bedienungsanleitung