Airwell DLV007 Bedienungsanleitung

INSTALLATION MANUAL

SAFETY PRECAUTIONS

● Readthefollowing"SAFETYPRECAUTIONS"carefullybeforeinstallation.

● Carryouttestrunningtoconrmthatnoabnormalityoccursafter the installation.Then,explaintousertheoperation,careandmaintenance asstatedin

instructions.Pleaseremindthecustomertokeeptheoperatinginstructionsforfuturereference.

Thisindicationshowsthepossibilityofcausingdeathorseriousinjury.

WARNING

Thisindicationshowsthepossibilityofcausingharmordamagetheequipment.

CAUTION

WARNING

1)Usequaliedinstallerandfollowcarefullythisinstructions.Otherwiseitwillcauseelectricalshock,waterleakage,orestheticproblem.

2)Installatastrongandrmlocationwhichisabletowithstandtheset'sweight.Ifthestrengthisnotenoughorinstallationisnotproperlydone,theset

willdropandcauseinjury.

3)Forelectricalwork,followthelocalnationalwiringstandard,regulationandthisinstallationinstruction.Anindependentcircuitandsingleoutletmust

beused.Ifelectricalcircuitcapacityisnotenoughordefectfoundinelectricalwork,itwillcauseelectricalshockorre.

4)Usethespeciedcableandconnecttightlyforindoorconnection.Connecttightlyandclampthecablesothatnoexternalforcewillbeactedonthe

terminal.Ifconnectionorxingisnotperfect,itwillcauseheat-uporreattheconnection.

5)Wireroutingmustbeproperlyarrangedsothatcontrolboardcoverisxedproperly.Ifcontrolboardcoverisnotxedperfectly,itwillcauseheat-up

atconnectionpointofterminal,reorelectricalshock.

6)Whencarryingoutpipingconnection,takecarenottoletairsubstancesotherthanthespeciedrefrigerantgointorefrigerationcycle.Otherwise,it

willcauselowercapacity,abnormalhighpressureintherefrigerationcycle,explosionandinjury.

7)Donotdamageoruseunspeciedpowersupplycord.Otherwise,itwillcausereorelectricalshock.

8)Thisequipmentmustbeearthed.Itmaycauseelectricalshockifthegroundingisnotperfect.

9)Donotinstalltheunitatplacewhereleakageofammablegasmayoccur.Incasegasleaksandaccumulatesatsurroundingoftheunit,itmay

causere.

10)Pleasediconnectthepowersupplywheninstallormaintenanceorsevicethissystem.

CAUTION

1)Selectionoftheinstallationlocation.

Selectainstallationlocationwhichisrigidandstrongenoughtosupportorholdtheunit,andselectalocationforeasymaintenance.

2)Donotreleaserefrigerant.

Donotreleaserefrigerantduringpipingworkforinstallation,reinstallationandduringrepairingarefrigerationparts.Takecareoftheliquidrefrigerant.

itmaycausefrostbite.

3)Itmayneedtwopeopletocarryouttheinstallationwork.

4)Donotinstallthisapplianceinalaundryroomorotherlocationwherewatermaydripfromtheceiling,etc.

5)Carryoutdrainagepipesasmentionedininstallationinstructions.Ifdrainageisnotperfect,watermayentertheroomanddamagethefurniture.

PartNO.IM.DLV1_A.1GB

MODELS

Ducttypeairconditioner

DLV007DLV009

DLV012DLV015

DLV018DLV021

DLV024

Unit:mm

Requiredtoolsforinstallationworks

NO. Tool NO. Tool NO. Tool

1Screwdriver 5Pipecutter

Torquewrench

18Nm(1.8kgf.m)

45Nm(4.5kgf.m)

65Nm(6.5kgf.m)

75Nm(7.5kgf.m)

2Electricdrill,holecore

drill(60mm) 6Reamer

3Hexagonalwrench 7Knife

4Spanner 8Measuringtape

Attachedaccessories

No. Accessoriespart Qty. No. Accessoriespart Qty. No. Accessoriespart Qty.

Centralcontrol

display(optional) 1 3

Draintube+clips

1 5

Unitoperationmanual

Installationmanual 2

Tie-Waps

6 4

Screwswasher

dowels 5 6

Gastubinginsulation

1SELECT THE BEST LOCATION

Whileselectingaplacefortheindoorunit

Allowmax.airowtothedesirespace.



Allowmaxreturnairow.



Ensureadequatedrainageofcondensedwater.



hedistancebetweenair-conditionerandobstaclesshouldmeetstherequirmentsinbelowg.

Leaveaminimum250mmfreespaceinfrontofthelter.



Allowafreeserviceaccesstoelectricalbox.



Alloweasyaccesstothebaseoftheindoorunitwhileprovidingenoughspacefromtheceiling.



Theinstallationheightshouldover2.3m.



2UNIT INSTALLATION

1.HOLESDRILLINGLOCATIONONTHECEILINGFORINDOORUNIT

Model AB

DLV007-DLV015 790 565

DLV018-DLV024 1090 565

2.DRAINAGEINSTALLATION

General

Foranefcientfunctioningofthedrainagesystem,pleasetakecareofthefollowing:

Alwaysbalancetheunitwith2downwardtothedrainagesideoftheunit.●

Use19mmtubedrainage.●

Itisrecommendedtoprepareadrainagepointbyprofessionalplumberclosetotheunit.●

Forproperdrainage,thepassagemustbeplannedwith1downslope.●

Preventanyupwardsorreverseowinanypart.●

Forpreventingofunpleasantsmellsintheroom,installasiphonintheinstallation.Installthedrainingtubewith6mmthicknesst● hermalinsulationsleeve.

Horizontaldrainage

Theunitincludesadrainpump,whichcanelevatecondensatewaterupto120cmfromtheunitlowestlevel.Thedrainagetubeisconnectedtotheupper●

drainagenozzle.

Thelowerdrainagenozzleroleistoemptythedrainpanbeforeservicingtheunit.●

Installonthedraintubewith5-10mmthicknessthermalinsulationsleevetopreventdrippings.●

Drainagetest

ForVRFsystempleasedodrainagetestafternishingallinstallations,wiringandpipingincluded,anddoingITEST(Installationtest)sucessfully:

(1)Poweronthesystem,andrunscoolingmode.

(2)Checkwhetherthepumpsoundisnormal.

(3)Slowlyinjectabout1,000ccofwaterintothedrainpan.Checkthedrainagethroughthetransparentdrainporttoseeifanydrainleakagehappens.

(4)Whenthecheckisnished,donotforgettocutoffthepowersupply.

3.UNITDIMENSIONS

Model ABC

DLV007-DLV015 750 696 790

DLV018-DLV024 1050 996 1090

4.ACCESSTOTHEUNIT

ΦLiquidPipe ΦGasPipe

DLV007 1/4" 1/2"

DLV009 1/4" 1/2"

DLV012 1/4" 1/2"

DLV015 1/4" 1/2"

DLV018 1/4" 1/2"

DLV021 3/8" 5/8"

DLV024 3/8" 5/8"

5.UNITINSTALLATION

Insert4M10or3/8threadsrodsintotheceiling.A.

Introducetherodsthroughtheslotsofunitsuspensionbrackets.B.

Positiontheshockabsorbers,addwashersandscrewthenutsuntiltheC.

unitisrmlysupported.

Incaseofagapbetweentheunitandtheceiling,putarubberoraD.

neoprenesheet.

565

Unit:mm

6.AIRFILTERLOCATION

Theairlterislocatedintherearsideoftheunit(defaultfromfactory)butcanbeeasilyrelocatedinthebottomoftheunitifitisrequired.

7.AIRFILTERCLEANING

Forcleaningthelterremoveitbypushinguptowardthebackoftheunitandpullitoutasdescribedbelow.

8.AIRFILTERRELOCATION

Removeairlterfromtheunit.1.

Removepanel4.2.

Removeltertrails2-3.3.

Insertltertrails2-3ontheoppositesideoftheunit.5.Closepanel4inthe4.

rearsideoftheunit.

Insertthelterintothetrails.5.

3DISPLAY CONTROL UNIT

1.LOCATIONCRITERIA

ItisrecommendedtoinstalltheDisplayControlUnitclosetoaceilinginacentralandneutralzoneattypicalconditions.Inaddition,the aesthetic aspect●

shouldbeconsidered.

TheDisplayControlUnitisconnectedtothemaincontrolboardontheairconditioner(theindoorunit)byacommunicationcable.Cableisconnectedtothe●

DisplayControlUnitbyaquick-connector.(8pinplug)

2.INSTALLATIONOFDISPLAYCONTROLUNITONWALL

Drilla12mmdiameterholeonthewall,forroutingthecommunicationcable.●

Opentheunitcover,drill3holesinthewalltomatchtheholesintheDisplayControlUnit,installtheinsertsandfastentheunittothewallwith3screws.●

TheDisplayControlUnitisprovidedofaspecialcommunicationcable,7meterslong,terminatedbyaplug,connectedinthehousingitselftoadistribution●

box,whichenablesthecontroloftheairconditionerfromseveraldifferentrooms,eachonefromitsownDisplayControlUnit.

Connectthequickconnectortotheappropriatesocketonthemaincontrolboardintheindoorunitelectricalbox.●

3.CONSIDERATIONSINLOCATINGTHEREMOTECONTROLUNIT

a)LocatetheRemoteControlUnitinsuchawaythatwhenmountedonitssupportonthewall,itwillbeinlinesightwiththeDisplayControl

Unit(atlessthan8m).

b)ItisrecommendedtoestablishthenallocationoftheRemoteControlUnitonlyaftertherstoperation,assuringpropertransmissionand

receptionbetweentheRemoteControlUnitandtheDisplayControlUnit.

1.MainControlBoardonIndoorUnit.

2.DistributionBoard.

3.CommunicationCable.

COLORCHART

Conn.Point WireColor Conn.Point WireColor

1Blue 5Purple

2Green 6Yellow

3Black 7Orange

4Brown 8Red

4ELECTRICAL WIRING CONNECTION

1.POWERSUPPLYWIRING

Unscrewandremovetheelectricalbox.●

Connectthepowersupplywiringstothepowersupplyterminalblock.●

Whendoingthis,pressthepowersupplywiringunderthewireclip.●

UNOCCUPIED DRY CONTACT

COMMUNICATIONWIRE

PROWER SOURCE WIRE

WINDOWS DRY CONTACT

ELB:ElectricityLeakageBreaker.

AH:Assistantheater.

PowerSupply

MainBusR/CWiring

2.MAINBUSANDR/CCOMMUNICATIONWIRING

Unscrewandremovetheelectricalbox.●

ConnecttheR/CwiringstoR1,R2terminalblockandthemainbuswiringstoF1,F2terminalblock.●

Pressthewiringsunderthewirecliptightly.●

3.TIGHTENINGTORQUEFORTHETERMINALSCREWS

Usethecorrectscrewdriverfortighteningtheterminalscrews.●

Ifthebladeofscrewdriveristoosmall,theheadofthescrewmightbedamaged,Andthescrewwillnotbeproperlytightened.Iftheterminalscrewsare●

tightenedtoohard,screwsmightbedamaged.

Refertothetablebelowforthetighteningtorqueoftheterminalscrews.●

Terminal Size Tighteningtorque

Terminalblock(total9pins) M4 1.2~1.5N.m

4.ELECTRICALCHARACTERISTICS

Unit Powersupply Fanmotor

MCA: Min.CircuitAmps(A)

MFA: Max.FuseAmps(A)

KW: FanMotorRatedOutput(KW)

LA: FullLoadAmps(A)

Model Hz Volts MCA MFA KW FLA

DLV007

50 220~240

0.64 16 0.12 0.38

DLV009 0.64 16 0.12 0.38

DLV012 0.64 16 0.12 0.38

DLV015 0.64 16 0.12 0.38

DLV018 0.73 16 0.14 0.45

DLV021 0.73 16 0.14 0.45

DLV024 0.73 16 0.14 0.45

Alleldsuppliedpartsandmaterialsandelectricsworksmustconformtolocalcodes.



Usecopperwireonly.



Allwiringmustbeperformedbyanauthorizedelectrician.



Everyindoorunitmusthaveasubcirclebreakerandthewholesystemmusthaveamaincirclebreaker.



Besuretogroundtheairconditioner.



Theapplianceshallbeinstalledinaccordancewithnationalwiringregulations,andshallbeprovidedtoensureall-poledisconnectionfromthesupplymains,



anddistancebetweenthepolesshallbemorethan3mm.

5.SPECIFICATIONSFORFIELDSUPPLIEDELBANDWIRE

Model Powersupplywiring RemotecontrollerwiringTransmission

wiring

FieldELB WireandSize wires Size

DLV007

16A

Mustcomply

withmaximum

currentandlocal

codes(≥0.75mm2)

Twisted-pairWire ≥1.0mm2

DLV009

DLV012

DLV015

DLV018

DLV021

DLV024

6.HEIGHTCOMPENSATIONSETTING

TheCompensationsettingaccordingtoinstallationheightcanbedonebyusingthedipswitch11and12oncontrollerPCB.

InstallationHeight HeightCode DS11 DS12

2.3-2.7(m) H0 OFF OFF

2.7-3.1(m) H1 OFF ON

3.1-3.5(m) H2 ON OFF

3.5(m) H3 ON ON

Note:Pleasedisconnectthepowersupplywhenchangethissetting.

Ifyoufeeltoonoisy,pleasesetDS11andDS12tolowerheightcodelevel.

CHECK ITEMS

BEFOREPOWERON

Isthereanygasleakageatarenutconnections?

⿌

Hastheheatinsulationbeencarriedoutatarenutconnection?

⿌

Istheconnectingcablebeingxedtoterminalboardrmly?Istheconnectingcablebeingclampedrmly?

⿌

IsthedrainageOK?(Referto"Checkthedrainage"section)

⿌

Istheearthwireconnectionproperlydone?

⿌

Istheindoorunitproperlyhookedtotheinstallationplate?Isthepowersupplyvoltagecompliedwithratedvalue?

⿌

AFTER POWER ON

Isthereanyabnormalsound?

⿌

Isthecoolingoperationnormal?

⿌

Isthethermostatoperationnormal?

⿌

Istheremotecontrol'sLCDoperationnormal?

⿌

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Airwell Klimaanlage Handbücher

Airwell

Airwell VRF Series Installations- und Betriebshandbuch

Airwell

Airwell Flow Logic II R410A Bedienungsanleitung

Airwell

Airwell Multi Split DUO 50 DCI Bedienungsanleitung

Airwell

Airwell AW-SDM048-N11 Montage- und Bedienungsanleitung

Airwell

Airwell AWSI-HHF009-N11 Betriebsanleitung

Airwell

Airwell FLO 7 N Bedienungsanleitung

Airwell

Airwell Dakota DCI Series Bedienungsanleitung

Airwell

Airwell Flo 9 INV Bedienungsanleitung

Airwell

Airwell AWSI-HMF009-N12 Bedienungsanleitung

Airwell

Airwell HAF Series Bedienungsanleitung

Airwell

Airwell DS 28 RCFA Bedienungsanleitung

Airwell

Airwell CAO 230 Bedienungsanleitung

Airwell

Airwell AWSI-HJD009-N11 Bedienungsanleitung

Airwell

Airwell CX 25 Bedienungsanleitung

Airwell

Airwell Delta 25 Bedienungsanleitung

Airwell

Airwell SBF Bedienungsanleitung

Airwell

Airwell AW-YHDM024-H91 Bedienungsanleitung

Airwell

Airwell WELLEA SPLIT AW-YHPS04-H91 Bedienungsanleitung

Airwell

Airwell FVVA-025N-01M22 Leitfaden

Airwell

Airwell CDMX-035N-09M25 Bedienungsanleitung

Airwell

Airwell CDMX-022N-09M25 Leitfaden

Airwell

Airwell OU-PSINV-70TH Bedienungsanleitung

Airwell

Airwell Comfort Series Bedienungsanleitung

Airwell

Airwell AWSI-DAV009-N11 Bedienungsanleitung

Beliebte Klimaanlage Handbücher anderer Marken

Panasonic

Panasonic CS-E12HKEW Bedienungsanleitung

nedis

nedis ACMB1WT7 Bedienungsanleitung

Daikin

Daikin FCFV50A Bedienungsanleitung

Fujitsu

Fujitsu Inverter ASBA30JFC Bedienungsanleitung

Toshiba

Toshiba RAS-M10SMUV-E Bedienungsanleitung

Daikin

Daikin FXLQ20MAVE Bedienungsanleitung

CIAT

CIAT Magister 2 Series Leitfaden

Bestron

Bestron AAC6000 Bedienungsanleitung

Frigidaire

Frigidaire FFRE0533S1E0 Bedienungsanleitung

Samsung

Samsung AS09HM3N Bedienungsanleitung

Frigidaire

Frigidaire CRA073PU11 Betriebsanleitung

Soleus Air

Soleus Air GB-PAC-08E4 Bedienungsanleitung

McQuay

McQuay MCK020A Bedienungsanleitung

Webasto

Webasto Frigo Top 25 DS Bedienungsanleitung

Frigidaire

Frigidaire FAZ12ES2A Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric MSC-GE20VB Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric PLA-M100EA Bedienungsanleitung

Daikin

Daikin Split Sensira R32 Bedienungsanleitung