Airwell HA 34 RC Bedienungsanleitung

Industrial Range

Climatisation

R 22

HEATPUMP

Roof Top Units

HA 34 RC

HA 45 RC

HA 52 RC

HA 61 RC

HA 75 RC

HA 89 RC

HA 110 RC

INSTALLATION INSTRUCTIONS TH 3886 - B 3990132

FROM EMAILAIR

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

The power supply must be

switched off before working on

the unit

Congratulations for having selected an AIRWELL air conditioner.

SAFETY DIRECTIONS

Follow the safety rules in force when you are working on your appliance.

Installation and maintenance of the equipment must only be performed by qualified

specialists in accordance with the rules of good workmanship and prevailing stan-

dards and instructions.

Make sure that the power supply and its frequency are adapted to the required electric

current of operation, taking into account specific conditions of the location and the

current required for any other appliance connected with the same circuit.

WARNING

Cutoff power supply before starting to work on the appliance.

The manufacturer declines any responsibility and the warranty becomes void if these

instructions are not respected.

If you meet a problem, please call the Technical Department of your area.

If possible, assemble the mandatory or optional accessories before placing the

appliance on its final location.(see instructions provided with each accessory)

In order to become fully familiar with the appliance, we suggest to read also our

Technical Instructions .

The information contained in these Instructions are subject to modification without advance notice.

GENERAL RECOMMENDATIONS

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

SUMMARY

DESCRIPTION

General Specifications...............................................................................3-6.

Dimensions.................................................................................................7-9.

INSTALLATION

Commisioning..............................................................................................11-12.

MAINTENANCE

Regular maintenance................................................................13-14

ELECTRICAL DIAGRAM N-716..................................................................13-16.

DECLARATION OF CONFORMITY

Under our own responsability, we declare that the product designated in this manual comply

comply with the provisions of the EEC directives listed hereafter and with the nationnal legisl-

gislation into wich these directives have been transposed.

HA 34 RC / 45RC / 52RC / HA 61RC

HA 75 RC / HA 89 RC / HA 110 RC

MachinERY DIRECTIVE 9 / 37 / CEE

Low Voltage Directive (DBT) 73/23/CEE amended by Directive 93/6 CEE

Electromagnetic Compatibility Directive 9/336/CEE

Pressurised Equipment Directive (DESP) 97/23/ CEE

sub-module A, category I for models HA 35 - HA 35 RC

sub-module A1, category II for the other products HA 43 to HA 95 RC,

with monitoring by TÜV Rheinland 0035

With the identification number : 7HL 02

and that the following paragraphs of the harmonised standards have been applied.

NF EN 60 204 -1/ 1998 NF EN 60 335-1 / 1995 NF EN 60 335 - 2 40 / 1994

NF EN 55 011 / 1998 NF EN 50 082 -2 1995 NF EN 255 /1997

NF EN 814 /1997 NF EN 378 /99

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

CONTENTS OF PARCEL

1 HA package units

1 bag with reference material

RECEIVING UNIT

Upon receipt, the unit should be carefully examined for any damage which may have occurred in transit, and such

damage should be noted on the carriers delivery documents.

It is the consignees responsibility to make any subsequent claims upon the carrier or the respective insurance

company.

LIFTING UNIT

When slinging the unit care must be taken to prevent rope damage to the paintwork or components. In particular the

drain connections on the unit must be avoided.

R 22

END PRODUCT PART NUMBERS

COOLING SPECIFICATIONS

- These package units are precharged in the factory and do not require any additional

refrigerant charge during installation.

R 22

Model HA34

d j

HA45

d j

HA52

d j

HA61

d j

HA75

d j

HA89

d j

HA110

d j

2128 g 3530 g 3400 g 4280 g 5920 g 7100 g 6680 g

Alimentation

Power supply

Betriebsspannung

HA 34RC HA 45RC HA 52RC HA 61RC HA 75RC HA 89RC HA 110RC

3N ~ 415V - 50Hz 7HL022062A 7HL022063A 7HL022064A 7HL022066A 7HL022065A 7HL022067A 7HL022068A

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

WARNING / CAUTION

* These values are given for guidance. They must be checked and adjusted according to

prevailing standards. They depend on the system installed and the cables used.

** fuse must mandatorily be provided on the system input.

Fuses not supplied

Cables not supplied

ecnailppafoepyT 57AH

98AH

011AH

ylppusrewoP

zH05-V514~N3 ..

pmuptaehro(naf+gnilooC

)gnitaeh

tnerrucmumixaM

MagnitaresuF

**EDV/ESAgnitaresuF

tnerrucgnitratslatoT

*noitceselbaC

²mm

4G5

7.52

6G5

5.82

6G5

R 22

CONTENTS OF PARCEL

R 22

ecnailppafoepyT 54AH

25AH

16AH

ylppusrewoP

zH05-V514~N3 ...

pmuptaehro(naf+gnilooC

)gnitaeh

tnerrucmumixaM

MagnitaresuF

**EDV/ESAgnitaresuF

tnerrucgnitratslatoT

*noitceselbaC

²mm

3.61

5,2G5

3.81

501

5,2G5

ecnailppafoepyT 43AH

ylppusrewoP

zH05-V514~N3 .

pmuptaehro(naf+gnilooC

)gnitaeh

tnerrucmumixaM

MagnitaresuF

**EDV/ESAgnitaresuF

tnerrucgnitratslatoT

*noitceselbaC

²mm

5,2G5

R 22

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

Fork direction on fork lift truck

mm(ecnaraelcmuminiM )

ABCDE

0060080060040003

HANDLING

INSTALLATION OF THE UNIT

- Minimum clearance to be provided for maintenance

access

NET WEIGHT

Modell HA 34 HA 45 HA 52 HA 61 HA 75 HA 89 HA110

Heatpump 140 Kg 200 Kg 210 Kg 216 Kg 265 Kg 305 Kg 310 Kg

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

LOCATING THE UNIT

his series of packaged air conditioning units is designed for outdoor, rooftop or ground level installation.

he unit must be installed on a firm level foundation, of adequate strength to support its full operating weight. Some

form of vibration isolation such as rubber waffle pads should be installed between the unit and the supporting

structure.

1- he unit must not be located where it will be subjected to heavy downpour of roof drainage and must be above

ground level in areas that are prone to storm water flooding.

2- It must be high enough to permit good drainage of defrost water and allow any heavy ice to fall away form the

coil during defrost cycle.

Minimum recommend height is 250mm above ground level.

3- Keep exposed duct connections to a minimum to reduce duct losses.

4- When locating unit give consideration to, and locate unit as remote as possible from neighbours sleeping

areas to minimise noise, as heat pump loads are greatest at night time.

5- Where prevailing winter winds are known, if possible, position the outdoor coil away from the winds to reduce

defrost cycle time.

6- If possible, orient the unit outdoor coil towards the morning sun. his increases efficiency in heating and de-

creases the solar load on the unit in the summer cooling cycle.

7- he unit must be pitched slightly towards the indoor condensate drain outlet to provide positive drainage of

condensates.

8- All electrical and ductwork connections to the unit must be made via flexible connections to prevent transmis-

sion of vibration.

9- Service and air flow clearances must be allowed as indicated on the unit dimension sheet. If should be noted

that major service may require removal of the top panels. Particular attention should be paid to avoiding ob-

structions to the vertical condenser air discharge which may result in recirculation of the outdoor air.

10- In addition to the service clearances noted on the dimension sheet it is essential that provision is made for

adequate and safe service access.

11- he standard outdoor fans fitted to the units will not accept any resistance to air flow. Consequently, should it

be necessary to duct outdoor air to or from the unit, the ductwork system (including entering and leaving

weatherproof louvres if fitted) must be of negligible pressure loss.

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

DIMENSIONS HA 34

DIMENSIONS HA 45 - 52

1090

1148

145

25.4 O.D copper drain

155 390 390 155

683

25 duct flanges 156 272

144

535

1120 mounting centres14 14

234292

99561

87todrain

98 316

107

761

1282 mounting centres19 19

264 345

100 579

90 to drain

25 duct flanges

782

154 470 556 140

1320

155

25.4 O.D copper drain

25.4 0.D DRAIN

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

DIMENSIONS HA 61 - 75

DIMENSIONS HA 89 -110

154 470 556 140

25 duct flanges

978

1320

155

25.4 O.D copper drain

90 to drain

99 806

3773913031698

264 345

1282 mounting centres19 19

1320

157

Copper drain

25.4 O.D

157

137 508 538 138

25 duct flanges

118 4

98 402

739

264 344

99 1032

1282 mounting centres19 19

90 to drain

25.4 0.D DRAIN

Roof Top Units HA / 34 /45 /52 /61 / 75 / 89 / 110 RC Roof Top Unit

CONDENSATE DRAIN LINE

- Raise the appliance to provide traps on the condensate drain lines

- Drain port: dia. 1"

CAUTION:

Never braze the condensate drain pipe to the appliance outlet fittings.

CAUTION

- For Heatpump models, if the outdoor temperature is likely to fall below +1°C, provide a

system to prevent the condensates from freezing (e.g. heating cord).

75mm

min

150mm

Slope10mm/m

min

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Airwell Klimaanlage Handbücher

Airwell

Airwell johnson Multi Splits Series Bedienungsanleitung

Airwell

Airwell IU-MINV-HW-9H Bedienungsanleitung

Airwell

Airwell HKD Bedienungsanleitung

Airwell

Airwell AWPO-AELIAN012-C11 Bedienungsanleitung

Airwell

Airwell May series Bedienungsanleitung

Airwell

Airwell AWAU-YCZ218-H11 Bedienungsanleitung

Airwell

Airwell FDM018 Bedienungsanleitung

Airwell

Airwell SAF024 Bedienungsanleitung

Airwell

Airwell AW-DDV009-N11 Leitfaden

Airwell

Airwell KN-24SH Betriebsanleitung

Airwell

Airwell CN 9 Bedienungsanleitung

Airwell

Airwell CD DCI Series Bedienungsanleitung

Airwell

Airwell AWAU-YCVFD224-H13 Bedienungsanleitung

Airwell

Airwell johnson DCH Series Bedienungsanleitung

Airwell

Airwell Delta 25 Bedienungsanleitung

Airwell

Airwell DS48RCF Bedienungsanleitung

Airwell

Airwell AWSI-CBV005-N11 Bedienungsanleitung

Airwell

Airwell CFMD-035N-01M25 Leitfaden

Airwell

Airwell ZDAA-2040-09M25 Bedienungsanleitung

Airwell

Airwell SDMX R32 Leitfaden

Airwell

Airwell VVFA Series Bedienungsanleitung

Airwell

Airwell MAY 90RCE Bedienungsanleitung

Airwell

Airwell AWAU-YWC220-H13 Bedienungsanleitung

Airwell

Airwell AW-SDM048-N11 Montage- und Bedienungsanleitung

Beliebte Klimaanlage Handbücher anderer Marken

Panasonic

Panasonic CS-E12HKEW Bedienungsanleitung

nedis

nedis ACMB1WT7 Bedienungsanleitung

Daikin

Daikin FCFV50A Bedienungsanleitung

Fujitsu

Fujitsu Inverter ASBA30JFC Bedienungsanleitung

Toshiba

Toshiba RAS-M10SMUV-E Bedienungsanleitung

Daikin

Daikin FXLQ20MAVE Bedienungsanleitung

CIAT

CIAT Magister 2 Series Leitfaden

Bestron

Bestron AAC6000 Bedienungsanleitung

Frigidaire

Frigidaire FFRE0533S1E0 Bedienungsanleitung

Samsung

Samsung AS09HM3N Bedienungsanleitung

Frigidaire

Frigidaire CRA073PU11 Betriebsanleitung

Soleus Air

Soleus Air GB-PAC-08E4 Bedienungsanleitung

McQuay

McQuay MCK020A Bedienungsanleitung

Webasto

Webasto Frigo Top 25 DS Bedienungsanleitung

Frigidaire

Frigidaire FAZ12ES2A Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric MSC-GE20VB Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric PLA-M100EA Bedienungsanleitung

Daikin

Daikin Split Sensira R32 Bedienungsanleitung