Alliance Laundry Systems BDEE6BGS173CW01 Betriebsanleitung

www.alliancelaundry.com

Troubleshooting

DRY684C

DRY726C

Part No. D515518ENR2

June 2018

Homestyle

Dryers

Refer to Page 6 for Model Numbers

the expressed written consent of the publisher.

D515518ENR2 1

Table of

Contents

Section 1 – Safety Information

Locating an Authorized Servicer ..................................................... 4

Section 2 – Introduction

Customer Service ............................................................................ 5

Nameplate Location ........................................................................ 5

Model Identification ........................................................................ 6

How Your Dryer Works .................................................................. 7

Section 3 – Troubleshooting

1. Dryer Motor Does Not Run ...................................................... 9

2. Dryer Stops in Cycle; Quits After the First Few Loads; Has a

Burning Smell; Cycles On Motor Thermal Protector ............... 11

3. Dryer Motor Runs But Cylinder Does Not Turn ...................... 12

4. Dryer Motor Does Not Stop ..................................................... 13

5. Dryer Runs Only When Door is Open ..................................... 14

6. Dryer Heating Assembly Does Not Heat or Burner

Does Not Ignite ......................................................................... 15

7. Igniter Does Not Glow (Gas Supply Sufficient) –

Gas Dryer Models ..................................................................... 17

8. Burner Ignites and Goes Out Repeatedly –

Gas Dryer Models ..................................................................... 18

9. Igniter Glows But Burner Does Not Ignite –

Gas Dryer Models ..................................................................... 19

10. Dryer Heater Assembly or Burner Shuts Off Prematurely ....... 20

11. Dryer Heater Assembly or Burner Repeatedly Cycles Off

On Limit Thermostat ................................................................ 21

12. Dryer Heater Assembly or Burner Does Not Shut Off ............. 23

13. Clothes Do Not Dry in Dryer ................................................... 24

14. Timer/Electronic Control Does Not Advance

in Automatic Cycle ................................................................... 25

15. Clothes Are Too Hot When Removed From Dryer .................. 26

16. Excessive Chattering or Vibrating Noise in Dryer ................... 27

17. Excessive Humming or Whistling Noise in Dryer ................... 28

Section 4 – Error Codes

Section 5 – Adjustments

18. Leveling Legs ........................................................................... 31

19. Burner Flame (Gas Models) ..................................................... 32

2D515518ENR2

Section 6 – Test Procedures

20. Timer Contacts ......................................................................... 34

21. Fabric Selector Switch .............................................................. 35

22. Drive Motor .............................................................................. 36

23. Motor Switch ............................................................................ 39

24. Burner System Operation ......................................................... 41

25. Electrical Circuit To Ignition System (Gas Models) ................ 42

26. Gas Valve Coils Check (Gas Models) ...................................... 42

27. Sensor Check (Gas Models) ..................................................... 43

28. Igniter Check (Gas Models) ..................................................... 43

29. Thermal Fuse (Electric Models) ............................................... 43

30. Heater Assembly (Electric Models) ......................................... 44

31. Cycling or Limit Thermostat .................................................... 44

32. Door Switch .............................................................................. 44

Section 7 – Internal Wiring of Dryer Motor Switch

D515518ENR2 3

Section 1

Safety Information

Throughout this manual and on machine decals, you will find precautionary statements (“CAUTION,”

“WARNING” and “DANGER”) followed by specific instructions. These precautions are intended for the personal

safety of the operator, user, servicer, and those maintaining the machine.

DANGER

Danger indicates an imminently hazardous situation that, if not avoided, will cause severe personal injury or death.

WARNING

Warning indicates a hazardous situation that, if not avoided, could cause severe personal injury or death.

CAUTION

Caution indicates a hazardous situation that, if not avoided, may cause minor or moderate personal injury or

property damage.

Additional precautionary statements (“IMPORTANT” and “NOTE”) are followed by specific instructions.

IMPORTANT

The word “IMPORTANT” is used to inform the reader of specific procedures where minor machine damage will

occur if the procedure is not followed.

NOTE

The word “NOTE” is used to communicate installation, operation, maintenance or servicing information that is

important but not hazard related.

In the interest of safety, some general precautions relating to the operation of this machine follow.

• Failure to install, maintain, and/or operate this machine according to the manufacturer’s

instructions may result in conditions which can produce serious injury, death and/or

property damage.

• Do not repair or replace any part of the machine or attempt any servicing unless specifically

recommended or published in this Service Manual and that you understand and have the

skills to carry out.

• Whenever ground wires are removed during servicing, these ground wires must be

reconnected to ensure that the machine is properly grounded and to reduce the risk of fire,

electric shock, serious injury, or death.

W284

WARNING

4D515518ENR2

Section 1 Safety Information

NOTE: The WARNINGS and IMPORTANT INSTRUCTIONS appearing in this manual are not meant to

cover all possible conditions and situations that may occur. Common sense, caution and care must be

exercised when installing, maintaining or operating the machine.

Always contact your dealer, distributor, service agent or the manufacturer about any problems or conditions you do

not understand.

Locating an Authorized Servicer

Alliance Laundry Systems is not responsible for personal injury or property damage resulting from improper

service. Review all service information before beginning repairs.

Warranty service must be performed by an authorized technician, using authorized factory parts. If service is

required after the warranty expires, Alliance Laundry Systems also recommends contacting an authorized

technician and using authorized factory parts.

To reduce the risk of electric shock, fire, explosion, serious injury or death:

• Disconnect electric power to the dryer(s) before servicing.

• Close gas shut-off valve to gas dryer(s) before servicing.

• Never start the dryer(s) with any guards/panels removed.

• Whenever ground wires are removed during servicing, these ground wires must be

reconnected to ensure that the dryer is properly grounded.

W001R1

WARNING

Repairs that are made to your products by unqualified persons can result in hazards due to

improper assembly or adjustments subjecting you, or the inexperienced person making such

repairs, to the risk of serious injury, electrical shock, or death.

W007

WARNING

If you or an unqualified person perform service on your machine, you must assume the

responsibility for any personal injury or property damage which may result. The manufacturer

will not be responsible for any injury or property damage arising from improper service and/or

service procedures.

W286

WARNING

D515518ENR2 5

Section 2

Introduction

Customer Service

If literature or replacement parts are required, contact

the source from whom the machine was purchased or

contact Alliance Laundry Systems at

+1 (920) 748-3950 for the name and address of the

nearest authorized parts distributor.

For technical assistance, call +1 (920) 748-3121.

Nameplate Location

When calling or writing about your product, be sure to

mention model and serial numbers. Model and serial

numbers are located on nameplate(s) as shown.

DRY2527N

Nameplate

6D515518ENR2

Section 2 Introduction

Model Identification

Information in this manual is applicable to these

dryers:

BDEE6BGS173CW01

BDEE6BGS173TW01

BDGE6BGS113CW01

BDGE6BGS113TW01

FDEE7RGS403UW01

FDLE7RGS303NW26

LDE30RGS543FW28

LDEA5RGS173TW01

LDEA5RGS173TW04

LDEE5BGS153TW01

LDEE5BGS173CW01

LDEE5BGS173TW01

LDEE5BGS303ZW30

LDEE5BGS543FW01

LDEE5RGS453UW01

LDEE7RGS153CW01

LDEE7RGS173CW01

LDEE7RGS303EW01

LDEE7RGS303UW01

LDEE7RGS403UW01

LDEE7RGS453UW01

LDEE7RGS543FW01

LDEE7RWS173TW01

LDG30RGS113FW28

LDGA5RGS113TW01

LDGE5BGS113CW01

LDGE5BGS113FW01

LDGE5BGS113TW01

LDGE7RGS113CW01

LDGE7RGS113FW01

LDGE7RGS303EW01

LDGE7RGS303EW80

LDGE7RSS303UW01

LDGE7RWS113TQ01

LDGE7RWS113TW01

LDGE7RWS303UW01

LDLE5BGS303NW26

LDLE5RGS303NW35

LDLE5RGS303UW01

LDLE7RGS303LW01

LDLE7RGS303LW26

LDLE7RWS303NW26

LSEA5FGS153TW01

LSEA5FGS153TW04

LSEA5FGS173TW01

LSEA5FGS173TW04

LSEE5AGS153TW01

LSEE5AGS173TW01

LSEE5AGW153TW01

LSEE5AGW173TW01

LSEE5AGW283CW01

LSEE5AGW293CW01

LSGA5FGS113TW01

LSGE5AGS083NW01

LSGE5AGS103NW01

LSGE5AGS113TW01

LSGE5AGW093CW01

LSGE5AGW113TW01

LSLE5AGS303LW01

LSLE5AGS303LW26

LSLE5AGS303NW22

LSLE5AGS303NW35

LSLE5AGW543NW23

LSLE5AGW543ZW01

PDEE4RGS173CG01

PDEE4RGS173CW01

PDEE4RGS173TG01

PDEE4RGS173TW01

PDEE4RGS433AG01

PDGE3BGS113CG01

PDGE3BGS113CW01

PDGE3BGS113TG01

PDGE3BGS113TW01

PDGE4RGS113CG01

PDGE4RGS113CW01

PDGE4RGS113TG01

PDGE4RGS113TW01

PDGE4RGS303AG01

UDEE5BGS173CW01

UDEE5BGS173CW08

UDGE5BGS113TW01

YDEE5BGS173CW01

YDEE7RGS153CW01

YDEE7RGS153TW01

YDEE7RGS173CW01

YDEE7RGS173TW01

YDEE7RGS303EW01

YDEE7RGS303UW01

YDEE7RGS403UW01

YDGE5BGS113CW01

YDGE7RGS113CW01

YDGE7RGS113TW01

YDGE7RGS303EW01

YDLE7RGS303NW26

YSEE5AGS153TW01

YSEE5AGS173TW01

YSGE5AGS113TW01

D515518ENR2 7

Section 2 Introduction

How Your Dryer Works

The dryer uses heated air to dry loads of laundry. When

the motor is started, the exhaust fan pulls room

temperature air in through louvers at the rear of the

dryer and over the heat source (burner flame for gas

and heating element for electric). The heated air moves

through the heater duct and into the cylinder, where it

circulates through the wet load. The air then passes

through the lint filter, air duct, and exhaust fan, where

it is vented to the outdoors.

DRY1819S

Lint

Filter

Cylinder

Heater

Duct Blower

Fan

8D515518ENR2

Section 3

Troubleshooting

IMPORTANT: Refer to wiring diagram for aid in testing dryer components.

To reduce the risk of electric shock, fire, explosion, serious injury or death:

• Disconnect electric power to the dryer(s) before servicing.

• Close gas shut-off valve to gas dryer(s) before servicing.

• Never start the dryer(s) with any guards/panels removed.

• Whenever ground wires are removed during servicing, these ground wires must be

reconnected to ensure that the dryer is properly grounded.

W001R1

WARNING

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Alliance Laundry Systems Trockner Handbücher

Alliance Laundry Systems

Alliance Laundry Systems HA025L Fehlerbehebungshandbuch

Alliance Laundry Systems

Alliance Laundry Systems BDEBCAGS173TN01 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems Clothes Dryer Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems TLW1991N Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems D715I Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 50 Pound Series Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 602004144 Fehlerbehebungshandbuch

Alliance Laundry Systems

Alliance Laundry Systems KE Series Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems Drying Cabinet Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems DC0220SFG Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems DRY725C_SVG Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems Drying Tumblers 50 Pound Capacity 75 Pound Capacity Model Identification Part No.... Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 513218R5 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems AE Series Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 512685R2 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems D355IE1B Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems DR5004WE Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems D0582 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 70420801 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 000 BTU Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems JT30XG Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 504523R3 Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems DRY2195N Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen DF7000WG Bedienungsanleitung

Beliebte Trockner Handbücher anderer Marken

Bosch

Bosch WTA79200GB Bedienungsanleitung

Amana

Amana W10233410A Bedienungsanleitung

Miele

Miele TWH 780 WP Bedienungsanleitung

Asko

Asko T760 Bedienungsanleitung

Bosch

Bosch Logixx 10 WTB76556GB Technisches Datenblatt

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Bedienungsanleitung

Electrolux

Electrolux EW2H328R2 Bedienungsanleitung

Beko

Beko DS8433RX1M Bedienungsanleitung

Dawlance

Dawlance Spinner DS 6000 C Bedienungsanleitung

Electrolux

Electrolux TP5080TW Bedienungsanleitung

AEG

AEG TR838P4OB Bedienungsanleitung

Indesit

Indesit IDV 75 Bedienungsanleitung

Infiniton

Infiniton SD-DG85C Bedienungsanleitung

BOMANN

BOMANN WT 5019 Bedienungsanleitung

Asko

Asko T793C Bedienungsanleitung

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Bedienungsanleitung

Frigidaire

Frigidaire CAQE7077KW0 Betriebsanleitung

Bosch

Bosch WTX8HKM9SN Bedienungsanleitung