Alliance Laundry Systems LTS97A*N3000 Montageanleitung

www.comlaundry.com

SWD441C

Part No. 801805

October 2004

Service

Homestyle

Stacked Washer/

Dryers

Refer to Page 3 for Model Numbers

801805 1

the expressed written consent of the publisher.

Table of Contents

Model Identification ................................................3

Section 1 – Safety Information

Locating an Authorized Servicer ............................6

Section 2 – Introduction

Customer Service ....................................................7

Nameplate Location ................................................7

How Your Stacked Washer/Dryer Works ...............8

Section 3 – Troubleshooting

1. Washer Motor Circuit ....................................11

Dryer

2. Dryer Motor Does Not Run ...........................13

3. Dryer Stops In Cycle; Quits After The First Few

Loads; Has A Burning Smell; Cycles On Motor

Thermal Protector .........................................14

4. Dryer Motor Runs But Cylinder Does

Not Turn ........................................................15

5. Dryer Motor Does Not Stop ..........................15

6. Dryer Runs Only When Door is Open ...........16

7. Dryer Heating Assembly Does Not Heat or

Burner Does Not Ignite .................................16

8. Igniter Does Not Glow (Gas Supply Sufficient)

– Gas Dryer Models .......................................17

9. Burner Ignites And Goes Out Repeatedly – Gas

Dryer Models .................................................17

10. Igniter Glows But Burner Does Not Ignite – Gas

Dryer Models .................................................17

11. Dryer Heater Assembly Or Burner Shuts Off

Prematurely ....................................................18

12. Dryer Heater Assembly or Burner Repeatedly

Cycles Off On Limit Thermostat ...................18

13. Dryer Heater Assembly or Burner Does Not

Shut Off ..........................................................19

14. Clothes Do Not Dry in Dryer .........................19

15. Timer Does Not Advance In

Automatic Cycle ............................................20

16. Clothes Are Too Hot When Removed From

Dryer ..............................................................21

17. Excessive Chattering Or Vibrating Noise in

Dryer ..............................................................21

18. Excessive Humming Or Whistling Noise in

Dryer ..............................................................21

Washer Control

19. Washer Error Code Listing ............................23

20. Washer Will Not Start – No LEDs/Lights lit

(No response to start switch) ..........................24

21. Washer Will Not Start – Door Open Error

(Wash/Rinse LEDs Flashing – Door must be

closed and attempting to lock) .......................26

22. Washer Will Not Start – No Door Lock

(Door LED Flashing) .....................................28

23. Washer Motor Will Not Run

(Door/Final Spin LEDs Flashing) ..................30

24. Washer Will Not Fill – No Communication

Error (Wash/Door LEDs Flashing) ................32

25. Washer Overflows .........................................34

26. Pump Does Not Operate ................................36

27. Serial Communication Error

(Final Spin/Rinse LEDs Flashing) .................38

Section 4 – Grounding

28. Wall Receptacle Polarity Check (Washer Power

Cord) ..............................................................41

29. Dryer Ground Wires From Terminal Block or

Power Cord To Rear Bulkhead and From Rear

Bulkhead To Control Housing .......................42

30. Washer Ground Connections .........................44

31. Washer Ground Connections – Washers with

suffix 4350 in Model No. ...............................46

32. Dryer Ground Connections ............................48

Section 5 – Service Procedures

33. To Remove the Dryer .....................................51

34. Control Panel and Controls ............................52

35. Washer Control ..............................................54

36. Pressure Switch ..............................................55

37. Control Cabinet ..............................................55

38. Washer Lower Access Panel ..........................55

39. Inverter Control ..............................................56

40. Electric Drain Pump .......................................57

41. Washer Belt ....................................................58

42. Mixing Valve .................................................59

43. Washer Front Panel ........................................60

44. Washer Loading Door ....................................63

45. Washer Door Seal and Hose Assembly .........64

(continued)

2801805

46. Washer Door Switch ......................................66

47. Washer Door Latch Switch ............................66

48. Washer Motor ................................................67

49. Outer Tub Front Panel ....................................69

50. Washer Inner Basket Pulley ...........................71

51. Washer Inner Basket Assembly .....................71

52. Bearing Housing ............................................77

53. Dryer Access Panel ........................................79

54. Cabinet Top ....................................................80

55. Lint Filter .......................................................81

56. Dryer Loading Door .......................................81

57. Dryer Inner and Outer Door Panels and Door

Pull .................................................................82

58. Dryer Door Strike ...........................................82

59. Dryer Door Seal .............................................83

60. Dryer Front Panel and Panel Seal ..................84

61. Dryer Door Switch .........................................84

62. Dryer Door Catch ...........................................84

63. Dryer Door Hinge ..........................................86

64. Dryer Hold-down Clips and Locators ............86

65. Burner System Components (Gas Models) ....87

66. Burner Housing and Heat Shroud

(Gas Models) ..................................................89

67. Limit Thermostat ............................................89

68. Heater Assembly (Electric Models) ...............90

69. ThermoStat .....................................................90

70. Air Duct ..........................................................90

71. Dryer Motor and Exhaust Assembly ..............91

72. Dryer Front Bulkhead Assembly ...................95

73. Cylinder Belt ..................................................97

74. Dryer Cylinder Assembly ..............................98

75. Dryer Rear Seal ..............................................99

76. Cylinder Rollers ...........................................101

77. Outlet Cover .................................................101

78. Rear Bulkhead and Heater Duct ...................102

79. Terminal Block or Power Cord ....................104

Section 6 – Adjustments

80. Cabinet Leveling Legs .................................107

81. Washer Loading Door ..................................108

82. Washer Motor Belt Tension .........................109

83. Washer Door Catch ......................................110

84. Shipping Braces ...........................................111

85. Burner Flame (Gas Models) .........................112

Section 7 – Dryer Test Procedures

86. Timer Contacts .............................................113

87. Fabric Selector Switch .................................114

88. Drive Motor .................................................115

89. Motor Switch ...............................................118

90. Burner System Operation .............................120

91. Electrical Circuit To Ignition System

(Gas Models) ................................................121

92. Gas Valve Coils Check (Gas Models) .........121

93. Sensor Check (Gas Models) .........................122

94. Igniter Check (Gas Models) .........................122

95. Thermal Fuse (Electric Models) ..................123

96. Heater Assembly (Electric Models) .............123

97. Cycling or Limit Thermostat .......................123

98. Door Switch .................................................124

Section 8 – Internal Wiring of Dryer Motor

Switch ...................................................................125

801805 3

Model Identification

Information in this manual is applicable to these washers.

LTS97A*N3000

LTS97A*N3300

LTS97A*N4350

LTS99A*N3000

LTS99A*N3080

LTZ97A*N2802

LTZ99A*N0902

* Add Letter To Designate Color. W – White Q – Bisque

4801805

Notes

801805 5

Section 1

Safety Information

Throughout this manual and on machine decals, you will find precautionary statements (“CAUTION,”

“WARNING” and “DANGER”) followed by specific instructions. These precautions are intended for the personal

safety of the operator, user, servicer, and those maintaining the machine.

aDANGER

Danger indicates an imminently hazardous situation that, if not avoided, will cause severe personal injury or death.

aWARNING

Warning indicates a hazardous situation that, if not avoided, could cause severe personal injury or death.

aCAUTION

Caution indicates a hazardous situation that, if not avoided, may cause minor or moderate personal injury or property

damage.

Additional precautionary statements (“IMPORTANT” and “NOTE”) are followed by specific instructions.

IMPORTANT

The word “IMPORTANT” is used to inform the reader of specific procedures where minor machine damage will

occur if the procedure is not followed.

NOTE

The word “NOTE” is used to communicate installation, operation, maintenance or servicing information that is

important but not hazard related.

In the interest of safety, some general precautions relating to the operation of this machine follow.

• Failure to install, maintain, and/or operate this machine according to the manufacturer’s

instructions may result in conditions which can produce serious injury, death and/or property

damage.

• Do not repair or replace any part of the machine or attempt any servicing unless specifically

recommended or published in this Service Manual and that you understand and have the

skills to carry out.

• Whenever ground wires are removed during servicing, these ground wires must be

reconnected to ensure that the machine is properly grounded and to reduce the risk of fire,

electric shock, serious injury, or death.

W284

WARNING

6801805

Section 1 Safety Information

NOTE: The WARNINGS and IMPORTANT INSTRUCTIONS appearing in this manual are not meant to

cover all possible conditions and situations that may occur. Common sense, caution and care must be

exercised when installing, maintaining or operating the machine.

Always contact your dealer, distributor, service agent or the manufacturer about any problems or conditions you do

not understand.

Locating an Authorized Servicer

Alliance Laundry Systems is not responsible for personal injury or property damage resulting from improper

service. Review all service information before beginning repairs.

Warranty service must be performed by an authorized technician, using authorized factory parts. If service is

required after the warranty expires, Alliance Laundry Systems also recommends contacting an authorized

technician and using authorized factory parts.

To reduce the risk of electric shock, fire, explosion, serious injury or death:

• Disconnect all electric power to the machine and accessories before servicing.

• Close gas shut-off valve to gas dryer before servicing.

• Never start machine with any guards/panels removed.

• Whenever ground wires are removed during servicing, these ground wires must be

reconnected to ensure that the machine is properly grounded.

• Washer motor not grounded! Disconnect electric power before servicing motor.

W502

WARNING

Repairs that are made to your products by unqualified persons can result in hazards due to

improper assembly or adjustments subjecting you or the inexperienced person making such

repairs to the risk of serious injury, electrical shock or death.

W007

WARNING

If you or an unqualified person perform service on your machine, you must assume the

responsibility for any personal injury or property damage which may result. The manufacturer

will not be responsible for any injury or property damage arising from improper service and/or

service procedures.

W286

WARNING

801805 7

Section 2

Introduction

Customer Service

If literature or replacement parts are required, contact

the source from whom the machine was purchased or

contact Alliance Laundry Systems at (920) 748-3950

for the name and address of the nearest authorized

parts distributor.

For technical assistance, call (920) 748-3121.

Nameplate Location

When calling or writing about your product, be sure to

mention model and serial numbers. Model and serial

numbers are located on nameplate(s) as shown.

SWD1134P

Nameplate

8801805

Section 2 Introduction

How Your Stacked Washer/Dryer Works

SWD666N

Pressure Switch

(Located inside

control cabinet)

Control

(Located inside

control cabinet)

Electric

Drain Pump Motor

Outer

Tub

Inner

Basket

Mixing

Valve

Exhaust Fan

Inverter Control

(Mounted to base

of washer)

Motor

Cylinder

Air Duct

Lint

Filter

Heating Element

(Electric Models)

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Alliance Laundry Systems Waschmaschine Trockner Handbücher

Alliance Laundry Systems

Alliance Laundry Systems ATGE9AWP303AW01 Programmierhandbuch

Alliance Laundry Systems

Alliance Laundry Systems H242I Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems SWD447C Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems CI 1650/325 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems HTEB17-N2802 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems Pocket Hardmount Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems SWD441C Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen SF7 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems SWD444C Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems IAE180J Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems LTS87A*H Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems LTS84B*H Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems BT3LLFSG401UN01 Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 802714R4 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems DCG Series Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 802957R3 Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems Cissell CTS97AWN Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems SV6000WG Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems CP040PMN1 Betriebsanleitung

Alliance Laundry Systems

Alliance Laundry Systems SWD543C Leitfaden

Alliance Laundry Systems

Alliance Laundry Systems ATE50FGP171TW01 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems BFNBCASG113TN01 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems STEA17*H Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 801504R1 Bedienungsanleitung

Beliebte Waschmaschine Trockner Handbücher anderer Marken

Whirlpool

Whirlpool WFC8090GX Bedienungsanleitung

Whirlpool

Whirlpool LTE5243DQ6 Bedienungsanleitung

Bosch

Bosch XQG100-WDU285H00W Bedienungsanleitung

Beko

Beko HTE10736XS Bedienungsanleitung

AEG

AEG L76685NWD Bedienungsanleitung

LG FWV1128WTSA Bedienungsanleitung

Electrolux

Electrolux WTSL 6 E201 Bedienungsanleitung

AEG

AEG OKO_LAVAMAT 1260 Bedienungsanleitung

Blomberg

Blomberg LRI285411 Bedienungsanleitung

Franke

Franke FWD 1400-6EI Bedienungsanleitung

Hitachi

Hitachi BD-W3300 Bedienungsanleitung

Whirlpool

Whirlpool FWDG96148SBS GCC Installations- und Betriebshandbuch

Equator

Equator EZ 1720 Bedienungsanleitung

NEFF

NEFF V6540X1EU Technisches Datenblatt

Dawlance

Dawlance Spinner DS 9000 CM Bedienungsanleitung

Hoover

Hoover WDYNS 654D-80 Bedienungsanleitung

Hotpoint

Hotpoint H3D91WBUK Bedienungsanleitung

Dexter Laundry

Dexter Laundry C Series Kurzanleitung