Antunes GST-1H Bedienungsanleitung

Belt Removal:

1. Press and release the Power button to turn the unit

off. The Tortilla Warmer enters a cool-down mode.

Wait until the unit automatically shuts down and

OFF appears on the display.

2. Unplug the power cord.

3. Wearing heat resistant gloves, remove the all

accessories, Top cover (if applicable) feeder, chute,

rear panel and set aside (Figure 1)

Figure 1.

(Accessories may be different depending on model number)

4. Facing the front of the unit, move to the right side

panel. Rotate the unit as necessary for access.

5. Unlock the side panel door using a screwdriver,

coin, or similar tool. Open the side panel (Figure 2).

GST BELT REPLACEMENT INSTRUCTIONS (P/N 1012999)

Figure 2.

General

If you experience any problems with these instructions, con-

tact the factory Technical Service Department at 630-784-1000

or toll free in the U.S. at 877-392-7854.

WARNING

Turn the unit off, unplug the power cord and allow the

unit to cool down before performing any service or

maintenance on the unit.

ANTUNES www.antunes.com 180 Kehoe Blvd., Carol Stream, Illinois 60188

TOOLS: Heat Resistant Gloves, Flat Head Screw Driver,

Clean Sanitized Towel and Approved Sanitizer

PARTS INCLUDED

Main Belt Replacement Kit

1 Pack: P/N 7001766

2 Pack: P/N 7001659

Instruction Sheet: P/N 1012999

AFFECTED PRODUCTS: GST-1H

TOP COVER

FEEDER

CHUTE

HEATED LANDING ZONE

CLIP

BACK PANEL

BOTTOM

FRONT

ROLLER

SIDE

PANEL

DOOR

LOCK

LEVER

TOP

FRONT

ROLLER

Figure 3.

LIFT THIS

BRACKET

6. TOP BELT:

Remove tension on the Top Belt by pushing the Top

FRONT Roller IN and UP until it locks into position.

7. BOTTOM BELT:

Remove tension on the Bottom Belt by pushing the

Bottom FRONT Roller IN and DOWN.

8. Rotate the knobs shown in gure 3 half turn.

NOTE: If your unit came with clips attached to

the knobs, remove and discard them

9. Lift up on the tension brackets until it locks in the up

position and does not drop down. Repeat process

for opposite side of unit.

KNOB

LOCK LEVER

P/N 1012999 Rev. A 03/19

NOTE: If the brackets will not move, rotate the knobs

from Step 8 a half turn until the brackets can be

lifted up.

10. Disengage the lock lever by pulling it towards you

while lifting up on the bracket (Figure 3)

11. Slide the Belt(s) to be replaced out of the unit and

discard (Figure 4).

12. With belt(s) removed, wipe all expopsed rollers and

the top and bottom heater cover plates with a clean

sanitized towel to remove any debris (Figure 4).

NOTE: Any debris stuck on the roller/ cover plates

can damage the belts.

GST-BELT REPLACEMENT INSTRUCTIONS (P/N 1012999)

ANTUNES www.antunes.com 180 Kehoe Blvd., Carol Stream, Illinois 60188

Figure 4.

Installing Belts:

1. Wipe both sides of the new Belt(s) with a clean,

sanitized towel sprayed with an approved sanitizer

and allow to air dry.

2. BOTTOM BELT:

Slide the new bottom belt over the bottom rollers

(Figure 4).

3. TOP BELT:

Slide the new top belt over the top rollers (Figure 4).

and allow to air dry.

NOTE: You may need to lift the upper roller

assembly when installing the belts.

NOTE: Make sure the snaps are aligned evenly

on the rollers. The snaps on the belts should

face inside and should be aligned with the

grooves on the roller. Belts must be installed so

the exposed diagonal seam of the belt is away

from the direction of belt travel.

4. Restore tension on the bottom belt by pushing UP and

OUT (Figure 2)

6. Restore the tension on the top belt by pushing DOWN

and OUT (Figure 2)

7. Lock the brackets shown in Figure 5 by rotating the

highlighted knob so the brackets drop down into

place. Push down on each bracket to ensure they are

in position.

8. Engage the lock lever as shown in Figure 3.

Make sure the lock lever is properly inserted into the

slotted grooves.

9. Close and lock the side panel (Figure 7).

Figure 5.

CLIP

KNOB

LEFT

BRACKET

RIGHT

BRACKET

Figure 7.

10. Reinstall the accessories (Figure 3).

11. Plug the power cord into the appropriate outlet, turn

the unit on. Return the unit to use

P/N 1012999 Rev. A 03/19

Andere Handbücher für GST-1H

Andere Antunes Toaster Handbücher

Antunes

Antunes Chick-fil-A RT-2 Bedienungsanleitung

Antunes

Antunes VCT-35 Bedienungsanleitung

Antunes

Antunes VCTM-2 Bedienungsanleitung

Antunes

Antunes Roundup DST-200 Bedienungsanleitung

Antunes

Antunes Roundup VCT-2000 Bedienungsanleitung

Antunes

Antunes GST-2V Bedienungsanleitung

Antunes

Antunes GST-1H Bedienungsanleitung

Antunes

Antunes Gold Standard GST-5V Bedienungsanleitung

Antunes

Antunes Roundup VCT-2000 Bedienungsanleitung

Antunes

Antunes HEBT-5V Bedienungsanleitung

Antunes

Antunes HCT-5H Bedienungsanleitung

Antunes

Antunes VCT-2 Bedienungsanleitung

Antunes

Antunes HEBT-3V Bedienungsanleitung

Antunes

Antunes GST-3V Bedienungsanleitung

Antunes

Antunes VCT-1000CF Bedienungsanleitung

Antunes

Antunes VCT-20 Bedienungsanleitung

Antunes

Antunes Roundup VCT-2000 Bedienungsanleitung

Antunes

Antunes VCT Series Bedienungsanleitung

Antunes

Antunes GST-3V-9210881 Bedienungsanleitung

Antunes

Antunes VCT-2 Bedienungsanleitung

Antunes

Antunes Roundup VCT-2000 Bedienungsanleitung

Antunes

Antunes Roundup MT-12 Bedienungsanleitung

Antunes

Antunes VCT-2 Bedienungsanleitung

Antunes

Antunes VCT-1000 Series Bedienungsanleitung

Beliebte Toaster Handbücher anderer Marken

Taurus

Taurus ARCTIC 960648 Bedienungsanleitung

Redfox

Redfox TO 920 G Bedienungsanleitung

Moulinex

Moulinex LS340D11 Bedienungsanleitung

Amica

Amica TD 3021 Bedienungsanleitung

Electrolux

Electrolux EAT978 Bedienungsanleitung

SEVERIN

SEVERIN SA 9275 Bedienungsanleitung

Breville

Breville the Big One BTS100 Bedienungsanleitung

Sunbeam

Sunbeam TA2540 Bedienungsanleitung

ARENDO

ARENDO 305716 Bedienungsanleitung

Life

Life Crispy AT-001 Bedienungsanleitung

Beko

Beko TAM 6201 I Bedienungsanleitung

Zephir

Zephir ZHC485 Bedienungsanleitung

H.Koenig

H.Koenig TOS9 Bedienungsanleitung

ZIEGELMULLER

ZIEGELMULLER Ritter ET 10 Produkthandbuch

HURAKAN

HURAKAN HKN-TOP3 Bedienungsanleitung

Philips

Philips HD2565 Bedienungsanleitung

Bosch

Bosch DesignLine Plus TAT4P44 GB Series Bedienungsanleitung

Panasonic

Panasonic NT-ZP1-V Bedienungsanleitung