Austin SEVEN Bedienungsanleitung

'i"-

HANDBOOK

OF THE

"SEVEN"

fPUBqCATION No. 1725

PRICE ONE SHILLING.

r.'tHE

AUSTIN MOTOR CO. LTD.

LONGBRIDGE :: BIRMINGHAM

-;iT

':S'

'1i%1~

HANDBOOK

OF THE

"SEVEN" ,>

PRICE -ONE SHILLING

THE AUSTIN MOTOR CO. LTD.

G.P.O. BOX 41

LONGBRIDGE - BIRMINGHAM

T.I.,h"" . PRIORY 2101

Toi.gwm" "SPEEDILY.TELEX. NORTHFlELD"

C"bl,." "SPEEDILY.BIRMINGHAM.ENGLAND" Cod" BENTLEY'S

LONDON SHOWROOMS.

479~483, Oxford Street, W.1.

Tel,ph"".

MAYFAIR 7620 "Tel.gwm"

"AUSTlNETTE. TELEX. LONDON"

AND

HOLLAND PARK HALL

HOLLAND PARK AVENUE, W.ll

Tel"h"",. PARK 8001

RepairandServieeDepotfor "Seven" and"Ten" Cars:-

25, NORTH ROW, LONDON, W.!.

Toi.ph"", MAYFAIR 6211

S.p"mb". 1938 I, "{"",, W of", Book 1725 /

P!eM. quo" {h. "mb"

'""'m," ,"'CA'"

A .FOREWORD

THEinlormation contained in this Handbook is intended only

to guide and assist the owner or driv~r 01an Austin car to preserve

the car in its proper satislactory running condition. The publi-

cation must not be considered as a complete manual.

... The handbook does not in any manner vary or extend the liability

01 the Company. which is limited to the Warranty jssued with the car.

Where no inlormation is given for a particular adjustment it may be

regarded as one which the average owner would entrust to a garage.

When the occasion for adjustments 01 this character arises the owner

should seek the aid of the local Austin dealer.

Both owner and dealer are encouraged 10call upon IheService Depart-

ment 01 the Company lor advice, whether upon the management of the

car, the eHecting 01 adjustment, or methods 01 repair. Owners need

nol suppose that they will have to apply all the attentions given in this

book, but careful notice should be taken 01 the chapters dealing with

maintenance.

CAUTION,

Parts of genuine Auslin manufacture only should be used when a

replacemenl is made, 10 ensure Ihal Ihe service given by Ihe original

shall be maintained by the replacement. Imilations cannol be relied upon

10 do Ihis.

If imilations are used, Ihe Company's guarantee is infringed and

becomesnull and void.

Always gel your replacemenlsfrom authorised Austin Dealers, as(they

stock only genuine Austin Spare Parts.

Should repairsbeexecuted by other than an authorised Austin Dealer,

for safety's sake always oblain aguarantee Ihat genuine Austin Spare

Paris are used.

See Ihe slalemenl 01 the end of Ihis book with reference 10

Accessories.

In correspondencealways quote your car number; body number will

befound on the scuttle under Ihe bonnet 011the nearside, chassis number on

chassis under the bonnel on offside.

AFTER SALES SERVICE

Every Austin Dealer is under agreement to give to Austin Cars

purchased Irom him "Alter Sales Service" during the period 01 the lirst

1,000 miles running of such <.a(S. (See page 70).

CONTENTS

AMMETER READINGS

ATTENTIONS. D.ily, W"kly. M.m,hly. O"",ionolly

BATTERY. The .

BODYWORK. Co" of

BRAKES, Adi""ing. Rdining. ek

BRAKE GEAR. Luh,i,,'ion of

CABRIOLET

CARBURETTER. Adj",'men'. ,le.

CHASSIS LUBRICATION CHART

CLUTCH. Luh,i,,'iou of Mech.ni,m

CLUTCH. Taking up wear

COMBUSTION CHAMBER. CIoanio,

CONTROL OF THE CAR

COOLING SYSTEM

DYNAMO, The

DOOR KEYS

ELECTRICAL EQUIPMENT, The

ENGINE, Lubri,,',on of ..

S'arting,he

FAN

FUEL SYSTEM

FUSE. Adion 01,he

GEARBOX,Lub,i",ion of

GREASE GUN. How '0 u" ,he

HOOD (Co" 00 .. ..

HUBS (Fmn' ond Road Luh,i",ion of

IGNITION, Timing

" Sy,'em, The

INFLATING SEAT INTERIORS

LAMPS. Co" of ..

LUBRICANTS. Choi" of

LUBRICATION CHART

PETROL PUMP

REAR AXLE, Lub,i,,',on of

ROAD SPRINGS

RUNNING ADJUSTMENTS

SHOCK ABSORBERS..

SPEEDOMETER DRIVE

STEERING. Adju,'men' of .

STEERING GEAR. Lub,i",ion of

THE NEW CAR

TOOLS

TYRES, Th,

VALVE TAPPETS. Adju,'m,n' 01

WHEEL, Changinga

WIRING. Diagram

'. 3

PAGE

10,46

36 and 37

36and 37

20,22

44,51

36 .nd 37

The Au,tin Seveu de lux. Saloou.

THE AUSTIN SEVEN

THE Austin Seven is acknowledged to be the best small car in the

world.

It is designed lor, and will carry in comlort, lour adults up to a

weight 01 40 stones and 56 Ibs. 01 luggage.

There are live models made, the Cabriolet, the de luxe Saloon, the

Saloon with lixed head, the Tourer and the Two-Seater. The closed

models are alike in general lines and general equipment. Particularly

good leatures are the wide doors and the lour side windowswhich are ~

mechanically raised or lowered.

The large single panel windscreen, which can be opened wide and

secured by an ingenious lever lastening easily reached from the driver's

scat, is another advantage. The Tourer, with its easily operated hood,

and side curtains which open with the doors, provides complete protection

in even the most inclementweather. '

Both Iront seats are separately adjustable. They tilt lorward and allow

ready access to the rear seats or luggage space.

The Austin Seven has a 4-cylinder, water-cooled engine, synchromesh

gears, and bevel drive. Lubrication is by pump, and cooling is on the

thermo-syphon system assisted by lan.

The complete equipment includes electric starting and lighting

switches, loot operated "dip and switch" lor headlamps, air strangler,

electric horn, speedometer, electric windscreen wiper, automatic return

direction indicators, licence bolder, shock absorbers. spare wheel and

tyre and blank 'number plates. All littings are chromium plated, except

the wheel centres, which are 01 stainless steel.

The Austin Seven is particularly suitable lor the woman driver.

It requires little physical ellort to drive and control, and lor that reason

its use enables her to do shopping calls without latigue, visit her lriends,

attend social and other !unctions, or make excursions or trips in any'

direction in any weather.

For the same reasons business men lind it an excellent vehicle, and

commercial travellers and others whose occupation compels Irequent calls

over an extended area have in the little car an embodiment 01 all they

require. Calls can be made in places where trains, trams and 'buses are

inlrequent.

In large establishments, where the instant use 01 a car is 01 vital

importance in cases 01 emergency, such as sudden illness or accident, the

Seven has been installed as a "tender," and in addition to its superiority

over large unwieldy cars lor short runs, has proved a real time and money

saver.

As40-42miles per gallon is the average petrol consumption, the cost 01

transit is below the cost 01 lares on any public conveyance.

Its speed, economy, reliability and road-holding qualities have been

admitted beyond dispute.

Many thousands of motorists have had their lirst experiences on a

"Seven"; thousands more will lollow them.

Having successlully passed through lilteen years 01 severe use and

trial, it has emerged a really success!ul and popular lavourite and its

splendid qualities are internationally recognized.

"'I The Austin Seven T wo.Seater

Th, dim,n,ion, 01 the modd, 'a<y. M.»mum I,ngth 10ft. 7in.

(3,260mm.) Width 4ft.3in.(I,295mm.); H,ight 5ft.3in. (1,600mm.);

Wh,dh.." 6ft. 9in. (2,057mm.); Tm,k, fcont, 3ft.4in. (1.016mm.)

ma<,3ft. 7in. (1,092mm.). wound d,a<.n", 6,in., 61in. .nd 7tin.,

mo,ding to mod,1.

.. Fom.cylindm, w.t".rool,d, with d,tach,hl, hood.

Bo", 2.2in. (56 mm.); Stook"~3in. (76 mm.) ;

Cuhi, """,ity, 7475 cc.. RAC. mting, 7.8.

B"k, ho",.pow", 17.t 3,800 '.p.m.

Ignition, Coi!.

Oil ,i"ul.tion, hy pump: Sump """,ity 4 pin".

Cooling, Th,nno..yphon with film "di.to, .nd Ion. Cooling .y,t,m

"p"ity 10 pint'. Th", i. . 'p,ing Io.d,d "Ivc in top tank to

p,mnt o",lIow hy ,pl"h.

C,onbhafth",ing" Fcont,hall; Cout", pl.in; R"" colI"

THE NEW CAR.

It will Repay YOll to Read these Notes

Carefully.

CHASSIS SPECIFICATIONS

Dimensions..

'"Engin.

Fuol Feed

Start.r

Clutch ..

Gaarbox

Rear Axl.

Spring...

Frout Axle

Brak..

Wbeel. ..

Control.

Ligbting

Bodywork

Luggage

IFyou are not familiar with Austin cars

carefully.

Give the new car a general

examination to see that all is in order.

Before running, see the car is

supplied with fuel and water, that the

engine and gearhox have the neces-

sary quantities of oil and that the

battery contains tbe proper amount

of acid.

Cars delivered by road are ready

for running. There is no oil,

fuel or water in cars crated for over-

seas and the batteries are empty and

uncharged.

please read this Handbook

5 gallon(22.75Ii"",) tankat "". Fud ,upply hy A.C. pump.

EI,ct,i",!.

. . Flexihl,,ingl,-pI.t" ,p,ingload,d, the pI.t, ""..,.ing theIdction ,ing..

Fom ,O',d, Io<""d, .nd . 'mm; Th, top, thi,d .nd ",ond g""

hove ,yn,h,om"h ,ng.g,m,nt. which ,n,u'" ,mouth, noi"I""

wt,in g'" ,h.ng" to ,uit "..,.ing ,O',d,. Fi"t g", i. , Iowon'

to h, used in ,tarting with, lulllo.d, up .n indin,. 0' m,noeuvoing

the m in.n .wkw"d pi.". Th, mtio, of ,ngin"o co.d wheel. ""

top,5.125to I; thi,d, 851 to I; soeond,I353to I,.nd fint, 22.4tiii"

,m'", 28.8 to 1. B.II hea,ingsthcoughout.Oil",p"ity Iloin".

.. 1.lIo",ing.withdiff",nti.1.nd 1o<qu,tuh,.

B.1Ih",ings .nd th,.." thcoughout. Fin.1d,ivchy,h,ft .nd 'pi,,1

hm!. Oil cop"ity tpint.

IA. P,trol Pump Priming Lever.

S.th E. B. DrainPlug.

tartmg e ngme.

Before attempting to start the engine, make sure that the change speed

lever is in neutral position and the hand brake on.

II the car has been standing for some time, starting should he assisted

by using the hand priming lever on the petrol pump to give the carburetteI

a full supply of petrol.

.Give the engine a few turns with the starting handle to make sure that

the crankshaft is free (pushing the handle in to engage fully with the

starting nut, before turning it). The ignition key is turned to the right

to switch on the ignition and the charging and lighting switch is turned

to "High" or "Low" Charge.

t.dlipti, t"nsvcr" ,p,ing in hont.

Qu.rt"dlipti".t "".

Shock .hso,hm .m fitt,d to f,ont ,nd m".

.. . Fo,g,d, I "ction.

.. On.1Ifomwhool,withindividusl,dj..tm,nt.

.. SO'".I wimd,t"h,hl,. On"p", whooIwithtyre. Ty'" 4.00-17,

.nd 4.75-16 (E.L.P.)Dunlop. V.n" 4.00-18.

Th, m""imump"mi"ihI,lo.d fo, the lugg.g,coni" i, 56Ih..

Pull the combined strangler and

throttle control knob on the instru-

ment board to close the carburetter air

inlet, and pttll out the switch to

operate the starter. Be sure to

release the strangler wire after

the engine has started. Do not

allow the engine to race when first

starting up, as time must he allowed

for the oil to circulate and lubricate

various hearings.

B.II ,h.ng, 'p,od g,a<Im" .nd hook, Im"mountod "n",lIy. Foot

rontcol fo, dip .nd ,witch h"dlight,. Foot .,,01,,",00.

.. By g",.d,ivcn dyn,,"o, with 6.volt hatt,..,..

Two hu,k,t "", fo, d,iv" .nd p""ng", hoth h,ing hingodto allow

"'y ,nt"n" to the "" ".t. R", "at to ""y two .dul" 0<thm

,hild"n. Ampl, tool ",ommod.tion. Sp", wh,,1 .nd t}T'. On

toming modd, hood, ,ingl, pi", "",n .nd full ,id, ,croon. (tho"

ov" the doo" open with th,m). EI""i, horn, ,p"dom,'", di"ction

indi"to..., dodri, wind"",n wiO'" d,ivin. mino, .nd li"nce

hold,o.

'}" .

Never leave the ignition switch

on for any lengthy period while the

engine is not running. The warning

lamp on the switch board will remind

you of this.

." Difficulty in Starting.

,Difficulty in starting may he

caused either through 'sucking too

much petrol into the cylinders, or too

little. When starting with the throttle

all but closed, a strong suction takes

effect on the slow running jet. If

petrol is passing through the car-

huretter the suction can generally be

heard.

Str_ler and Throttle Control.

A-No=.l po.I<ion. B-F.., Idlin"

C-W.=in, Up.

If the engine fails to start quickly and it is thought that the mixture

getting into the cylinders may be too rich, the accelerator pedal should be

depressed half-way to reduce the suction. On firing, the engine will race,

and the throttle should be almost closed. If the engine does not fire, close

the throttle entirely, and try again. '

After a stop in hot weather, failure of the engine to start is more

likely to be due to a too rich mixture than one too lean, and one should

switch off only after quite closing tbe throttle. Re-start tbe engine with

the throttle closed.

Depress the clutch pedal before switching on. This ;"ill lessen the

starting load and help the starter to turn the engine at higher speed, as

well as save drain on the batteries.

If after the foregoing measures have been carried out the engine fails

to start, the reason will probably be faulty ignition or carburation.

If faulty ignition is suspected, first examine the wires and see that the

sparking plugs are connected. Then test the gap of the plug points by means'

of the thick end athe gauge provided

in the tool kit. If the points are dirty,

clean them.

If carburation gives trouble, the

slow running jet may be stopped up

or a main jet cboked. Blow them out

orally or with a tyre pump. Never

attempt to clean them by passing a

wire or other small metal object

through tlrem. This will definitely

injure the jets.

The engine should never be

allowed to run at high speeds during

its first 500 miles.

H725.

"Seven" Starting Handle Position.

Oil o""ion.n, " A .nd B.

Maximum desirable road speeds during the first 500 miles are:-

First gear, 7 m.p.h.: second gear, 11 m.p.h.; third gear, 18 m.p.h. and

top gear, 30 m.p.h.

The Starting Handle (Fixed type).

When the engine is running, see that the starting handle is not hanging

down. It should be replaced in a borizontal position at "9 o'clock."

(See page 8).

There is a catch which will secure it in its proper place there on the

off-sideofthecar. '

The starting handle should be oiled occasionally.

2 3 4 5 7 9 .0

Au"in "SeveD" Controls.

I. Wind"",n Wip",

2, Ch,ng' Spe,d Lover

3. H,ndbmk, Lover,

4 Dip ,nd Swilcb Con'm!.

5. Clulcb P,d,!.

6. Bmb P,d.!.

7. Accol,mtor P,d,!.

8. Horn Button.

9. Di"ction Indice'or Swi'ch

10.Vi,",

In.trumenr. are lllu.trated ODPage 11.

rTHE INSTRUMENTS

Fuel and Oil Gauges, Speedometer,

Windscreen Wiper.

A'FULL range 01 instruments is provided on all Austin Cars. They

are 01 the highest quality and the lollowing notes explain their uses,

Fuel Gauge.

The,luel gauge is electrically operated al)d automatically indicates the

approximate contents 01 the tank when the ignition control isswitched on.

When the tank is being relilled, switch 011and stop the engine and

then switch on again and the needle will record the amount 01 spirit

entering the tank. The capacity is live gallons.

The gauge requires no attention.

Oil Gauge.

The oil gauge indicates that oil is being pumped through the engine

lubrication system and it should be looked at frequently when the engine

is running to ascertain that sullicient pressure is registered.

When the engine is cold high pressure will be recorded, but this is

likely to drop as the oil becomes warmer. If no pressure is registered the

engine should be stopped and the cause 01the lault ascertained. otherwise

serious damage may be caused.

Flickering 01 the needle may indicate serious shortage 01 oil or a

damaged pipe line.

The gauge may indicate a pressure 0110 Ibs. or more when the engine

is cold or Irom 2 to 10 lbs. when hot. With the engine running at constant

speed the needle should be quite steady.

Windscreen Wiper,

The windscreen wiper is started by pulling out the handle and swinging

it aside to bring the wiper blade into position on the screen. Then move

the switch to the lelt.

On stopping the wiper move the switch to the right and replace the

handle in the top 01 the switch knob so that the blade is held out 01 the

driver's line 01 vision.

.Ammeter.

The ammeter indicates the rate 01discharge 01 the batteries, but does

not indicate current used by the starter motor.

No discharge should be indicated with no electrical equipment in

use or with headlamps on when the car is running at about 20 miles an

hour (30 kms.), or laster.

[

-- ~--- -..,

Switch Box.

When the engine is not'in use the ignition key should be withdrawn

Irom the switchbox. It can be withdrawn only when the ignition is "off."

The lighting switch also controls the rate at which the dynamo charges

the battery. "High Charge" should be used in the Winter and when the

car is used very little in the Summer. "Low Charge" is lor Summer use

when the batteries are not used a lot lor lighting, or frequent starting. and

the car is used fairly frequently.

Speedometer.

The figures on the speedometer record up to 100,000 miles or kilo.

metres and they automatically return io zero.

The flexible shaft of the speedometer drive from the gearbox should be

lubricated by oiling from the speedometer end every 2.000miles. To do

this uncouple the union nut behind the speedometer.

The shafting should also be taken down and thoroughly cleaned every

6.000miles. It should be lubricated along its length by applying thin

grease so that when the shaft is replaced in its tubing there will be a good

supply of lubricant.

Grease should also be smeared round the flange where it rubs the

washer of the key piece wh:ch connects to the speedometer.

Traflic Signals.

The trallic indicators are con.

trolled lrom the steering wheel.

Normally. after the car has turned a

corner they automatically return. but

when a slight turn has been made it

may be necessary to switch olf.

Panel Lights.

The instruments are illumin.

ated by two lamps controlled by the

same switch. The holders can be

swung aside to facilitate removal of

the bulbs. whichin emergencycan

belitted to the side or combinedstop

and tail lamp.

Dip Switch.

The headlamp dipping switch has two lunctions, one to give the

normal driving light and one to dip the near side head.lamp beam and at

the same time switch 011 the ollside headlamp.

If the headlights are on lull, a touch 01 the loot on the switch alters

the lamps to the "dip.and.switch" position and they remain so until

another touch returns them to the "lull on" position.

Continental headlamps have dual.filament bulbs and are dipped

in the same manner.

Windscreen.

The windscreen is opened by lifting the handle and pushing it lorward.

Tb. Im.rumen. PtmeI.

A-S'nn,L". F-W.rnln, L.mp.

B-oil G.u". o-I,nl<lon K.,.

C-Amm"... H-LI,h' Sw""'.

D-D..h L.mp Swl«h. 1- Fu.I G.u,..

E-Sp..dom"", ]-5,..", ConttoL

.,.

CONTROL OF THE CAR

How to Change Gear; Some Good

Driving Hints

THE driving seat 01 the Austin Seven is adjustable lor position and

tbis convenience sbould be taken advantage 01 to obtain tbe greatest

comlort.

To engage lirst gear, pusb out the clutcb and move tbe gear lever

into tbe lirst speed position. .

Sometimes it may bappen tbat wben tbe clutch is let in, tbere

is no apparent drive Irom tbe engine. Tbat is because tbere bas been no

proper engagement 01 tb, gears. Tberelore, pusb out tbe clutcb again,

and it will almost certainly be lound tbat tbe lever can then be moved

so as to give tbe proper gear engagement witbout using any lorce.

Start on'lirst speed, accelerate to about 8 m.p.b., pusb out tbe clutcb,

move tbe lever to neutral, and continue tbe movement 01 the lever steadily

to tbe second speed position and let in tbe clutcb gently. '

In moving from second to tbird speed, a similar action takes place.

Accelerate to about 18 m.p.b., declutcb, release tbe accelerator, move tbe

lever to neutral and continue tbe movement 01 tbe lever steadily into tbe

tbird speed.

To move from tbird to top, declutch, and move tbe lever steadily

into tbe position desired. It assists tbe cbange Irom top to third, and

tbird to second il tbe accelerator is held down while the change is made.

Change Early.

Always change gear early on a bill. Never allow tbe engine to labour

in any gear and expect it to pick up speed on changing into a lower one

wben the car has nearly stopped. Do not persist in attempting to drive

the car uphill in top gear wben the speed lalls below 18 m.p.h.-cbange

down.

If the car bas been driven back by tbe reverse gear, wait until it is

stationary belore engaging a lorward speed. Do not engage the reverse

gear when the car is travelling lorward. Serious damage to the gears will

be the result.

Keep the loot 011the clutch pedal

except in heavy trallic. Even then

do not allow tbe weight 01the loot to

be taken by tbe pedal. Tbe slipping

01the clutcb caused by tbis practice

beats and wears it badly.

When descending a long bill, or

before commencing a steep descent,

engage one 01 the lower gears, and

do not accelerate. The Gear Positi...,.

The engine will tb~n belp to retard the speed 01 tbe car. When

using the brake, keep tbe clutcb in, disengaging it at the last moment il

.topping tbe car.

Skidding.

Skidding is sometimes due to sudden braking on a greasy or loose

surlace and unduly slack tyres contribute to it. If the rear wheels skid,

release the brakes and turn the Iront wbeels towards the direction 01

the skid.

Synchromesh Gears.

Tbe gearbox bas lour lorward speeds and a reverse and the second

third and top gears have synchromesh engagement, which ensures silent

positive cbanges.

Cear cbanging may be sligbtly still in a new car until tbe moving

parts bave eased in use. Cbanging sbould not be done burriedly and

no attempt sbould be made to lorce tbe gear lever il engagement is not

made at tbe lirst attempt. Sbould

dilliculty be experienced in en-

gaging a gear wben tbe car is

.tanding, release tbe clutcb lor a

moment and tben try again.

Tbe syncbromesb mecbanism

is governed by a series 01 spring fQtt:',:

loaded balls as illustrated. Tbe

internal cone on tbe inner member

makes contact witb tbe gear

mne to syncbronise tbe speeds 01

botb members belore tbe dog

member, overcoming tbe resist-

ance 01 tbe ball A. moves on to

give positive gear engagement.

What Not to Do.

Second Speed Synchroni,ing Mecl.anism

A. Spring Ball Re,iotance.

Whatever you do, please do not make tbe lollowing mistakes :-

Do not lorget tbe ignition switcb wben starting up.

Do not make a last run witb tbe radiator mull closed.

Do not be cruel to tbe starter il tbe engine will not lire.

Do not toucb tbe starter switcb wbile a gear is engaged.

Do not leave tbe car in gear and witb tbe bandbrake 011.

Do not coast witb a gear engaged and tbe clutcb beld out.

Do not lill tbe radiator witb cold water wben tbe engine is bot.

Do not leave tbe ignition switcbed on wben tbe car is not running.

On no account run tbe engine in a closed garage. Tbe exbaust gasses

are bigbly toxic and a very small amount in a restricted atmospbere

will produce grave, il not latal results.

REGULAR ATTENTIONS Monthly Attentions.

ON this and the opposite page is a handy summary of all theattentions

descrihed in this handbook. The attentions under the daily,

weekly, and monthly headings are based on the assumption that the

maximum mileage per week does not exceed 500.

Under more strenuous conditions, for instance, very dusty or very

muddy roads, long distances at high speeds or with heavy loads, It wIll be

advisable to attend to the lubrication of chassis parts more frequently.

After the first few days" use tighten all nuts particularly those on

the engirle cylinder head. These may loosen a little because of the heat

generated, but if they receive this attention both they and the head will

remain !lecure against water leaks or loss of compression.

Waming.-After the car has been washed, or driven through water.

the hrake linings may be wet. Apply the brakes a number of times for

some distance in order to dry them.

Wet brakes are dangerous.'

Daily Attentions.

I. Examine the oil level in the

gearbox. It should be level

with the filler plug. Capacity,

It pints.

Change at first 1000 and

then every 6,000 miles.

2. Charge the back axle case with

special lubricant, using the

adapter on the grease gun.

Capacity fpint. .

Change at first 1000 and then

every 6000miles.

3. Grease all the hubs, as des- The Gearbox Oil Filler.

scribed later.

4. Charge the steering box with special lubricant,

5. Oil handbrake gear, pedal gear and joints, engine control joints, and

top of steering column.

6. Examine the battery and see that the connections are tight. (More

frequently in hot weather).

7. Give a charge of the special grease to the nipple on the fan spindle.

8, Give a few drops of oil to the distributor spindle bearing.

9. Grease the front end of the torque tube (behind the front seats).

10. Grease the splined end of the propeller shaft (behind the gear box)

Turn the shaft to expose the nipple.

11. Grease rear brake balance lever,

Examine water level in radi- .

ator and fill up to within one

inch of the top.

2. Examine oil level in the crank-

case and add more oil if

necessary. The dip rod indi-

cates the level of the oil.

Change the oil first at

500 miles, then every 2,000 to

3,000 miles (3,200 to 4,800

km), when the oil reservoir

gauze should be cleaned. The

sump capacity is half a gallon,

3. Fill up' the petrol tank if necessary. Care should be exer-

cised not to overfill the tank, which will contain five gallons.

Weekly Attentions,

I. With the grease gun charge-

Front spring shackle pins (4).

Front wheel swivel pins (2).

Steering cross tube (2).

Steering side tube joints (2).

Rear spring pins (2).

2. Oil the following-

Clutch release ring.

Foot brake pedal shaft (below steering box),

Brake cross shaft bearings (use a brush).

3, Examine both sets of brakes, and adjust if necessary.

4. Test the tyres for correct pressure and examine them for cuts, flints

and nails.

Occasional Attentions.

Clean the sparking plugs and check the settings.

Examine all bolts and nuts, such as road spring dips, cylinder head

nuts, wheel nuts, these three especially when the car is new.

Examine other parts, such as steering connections, the radius rod

JUlchoragebelow the gearbox, and the torque tube socket, neglect of which

might be followed by an expensive repair and inability to use the car for

.a lengthy period.

Occasionally dean the pump and carburetter petrol filters and float

-chamber strainers, and ever 2,000 to 3,000 miles the oil reservoir gauze

(when the engine oil is changed). Also ensure that the oil jets in the

-crankcase are dean.

Flush the radiator with plenty of dean water until it runs through dear.

Clean the ignition distributor, and the contact breaker points (adjust the

latter), the dynamo and starter commutators. Clean the shock absorbers.

.adjust the tappets, and the fan belt, decarbonize the engine and grind-in

the valves. Check the alignment of the front wheels.

D.e only recommended Oil..

14 15

" 4

-..-

WHEELS AND TYRES.

How to use the Jack; Correct Inflation

Pressures

WHENit becomes necessary t6 change a wheel hecause of a puncture

or for any other cause. the firstthing to do is to pull the handbrake

"hard on." The spare wheel must be lifted from the rear of the car.

Before it is used test the air pressure and if it is not up to the correct

figure. use the pump to rectify it. The proper pressures are tabulated

on the next page.

It is important~ have the car on

level ground. With the wheel brace

the three nuts of the wheel to be

removed should be slightly slackened.

but only enough for them to unscrew

freely later. The wheel is tb'en

jacked up.

If it is a rear wheel. the jack

should be put in from the'side, be-

tween the mudwing and the forward

edge of the.tyre, and should be placed

under the rear spring between the two

clips which embrace the spring leaves.

If a froni wheel is to be attended

to, first slacken the nuts by means of

the wheelbrace. Place the jack under

the front axle neaf but not under the

big nut at the end.

The operating bar (which is

stored under the rear seat cushion)

fits into the jack by means of a

square tube and 15secured in that position by a spring loaded ball.

The head of this bar which

engages with the jack must be

pushed well home so that a spring

loaded ball may engage with a slot,

which will prevent the head of the

bar slipping out while the jack is in

use.

The jack should be adjusted as

nearly as possible to the required

height by turning the head round by

hand before using the handle to lift

the car.

To detach the wheel from the

hub remove the three nuts by

H' ",.

How to use the Jack

on the "Seven."

~"".

".'

The Jack, .howing Extension 16

""'..

.-1,

means of the brace; on some models,

including vans. it is not necessary to

remove them entirely. Pull the wheel

outwards about tin. and turn it a

little to the left so that the large hole

will pass over the nut. The wheel can

now be pulled off the hub.

When replacing these slotted

hubs, make sure that the large holes

in the wheel centre are properly fitted

over their pegs, and tighten the wheel

nuts, each only a few turns at a time,

until they are quite tight and secure.

Should difficulty b" experienced

upon the first occasion of removing

the wheel from the hub. the wheel

nuts may be screwed right off. Before

replacing, wipe the outside of the brake drum and inside of the hub

with an oily rag as this will ease removal on future occasions.

". .,

Do not detach nut.. The wheel

will.lide over them.

Care of The Tyres.

The key to economical and efficient tyre service is to maintain the

correct pressures and test your tyres at least weekly. Any loss of air

pressure can be made up with very little effort.

A gauge applied to the valve must be used, for it is seldom possible

to detect under-inflation from the tyres' appearance.

Minimum presssures to which tyres should be inflated are :-

Atyre that loses more than three to four Ibs. per sq. inch in a week

should be regarded as "suspect." First, make sure that a new valve

"inside" is not required. If the tube is punctured make sure before refitting

that the puncturing object is not still embedded in the cover.

It is important that both front tyres be kept at same pressure. If

because of wear or other causes. the steering develops a tendency to wander

or show signs of wobble, the front tyre pressure may temporarily be varied.

....

Rear Tyres.

Tyre Size. Front

Tyres. One or two Fully

Passengers. Laden.

4.00-17 (Standard) 22 22 26

4.75-16 (E.L.P.) 20 18 22

4.00-18 (Van) 22 -26

4.75-16 (Van) 24 -26

Lbs. per sq. in.

Inhaltsverzeichnis

Andere Austin Automobil Handbücher

Austin

Austin Austin Seven Tourer Bedienungsanleitung

Beliebte Automobil Handbücher anderer Marken

Toyota

Toyota 2000 Tundra Bedienungsanleitung

CITROËN

CITROËN DS4 DSign Bedienungsanleitung

Lexus

Lexus 2015 CT 200h Bedienungsanleitung

Cadillac

Cadillac CTS 2008 Bedienungsanleitung

Mercedes-Benz

Mercedes-Benz M-class ML 55 AMG Bedienungsanleitung

Porsche

Porsche Boxster S Bedienungsanleitung

GMC

GMC 2010 Savana 1500 Cargo Bedienungsanleitung

KIAM

KIAM SPORTAGE 2014 Stücklistenhandbuch

GMC

GMC 2013 Terrain Montageanleitung

GMC

GMC T-Series 1999 Bedienungsanleitung

Mercury

Mercury 1998 Mystique Bedienungsanleitung

Mercury

Mercury 2007 Mariner Bedienungsanleitung

Mazda

Mazda 2007 Mazdaspeed 3 Leitfaden

Mazda

Mazda 2014 CX-5 Bedienungsanleitung

GMC

GMC Chevrolet Express 2022 Bedienungsanleitung

GMC

GMC 1997 Jimmy Bedienungsanleitung

Chevrolet

Chevrolet 2012 Malibu Bedienungsanleitung

Cadillac

Cadillac 2010 Escalade Bedienungsanleitung