Austro Engine AE50R Gebrauchsanweisung

ENGINE MANUAL
Operation / Maintenance / Installation
AE50R
AE50RA
AE50RAB
Doc. No. : E1.01.01 – E
Revision : 6
Date of Revision : 10 March 2011
The technical information contained in this document has been approved under the
authority of DOA No. EASA.21J.399 in conjunction with the Mandatory Design
Change MDC E1 - 116.
Affected Pages: Chapter Page
all all
Instruction:
- Replace the affected pages of the original manual with the
pages contained in this revision.
Austro Engine GmbH
Rudolf - Diesel – Straße 11
A – 2700 Wiener Neustadt
Austria

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page1-1
FOREWORD
We congratulate you on the acquisition of your new Austro Engine AE50R.
Skillful operation of the engine increases both safety and the enjoyment of flying. Please take
the time therefore, to familiarize yourself with your new AE50R.
This engine may only be operated in accordance with the procedures and operating limitations
of the Engine Manual.
This document is protected by copyright. All associated rights, in particular those of
translation, reprinting, radio transmission, reproduction by photo-mechanical or similar means
and storing in data processing facilities, in whole or part, are reserved.
Austro Engine is a part of Diamond Aircraft Industries GmbH.
Copyright © by: AUSTRO ENGINE GmbH
Rudolf-Diesel – Strasse 11
A – 2700 Wiener Neustadt
Austria
Phone : +43 – 2622 – 23000
Fax : +43 – 2622 – 23000 - 2711

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page1-2
1.1 Record of Revisions
All revisions of this manual, with the exception of -
Temporary Revisions
must be recorded in the following table. Revisions of approved chapters require the
countersignature of Austro Control GmbH.
The new or amended text is indicated by a vertical black line at the right hand side of the
revised page, with the revision number and data appearing at the bottom of the page.
If pages are revised which contain information valid for your particular serial number
(modification level of the engine, Equipment Inventory, etc.), then this information must be
transferred to the new pages in hand–writing.
Temporary revisions, if applicable, are inserted behind the cover page of this manual.
Temporary revisions are used to provide information on systems or equipment until the next
‘permanent’ revision of the Engine Manual. When a ‘permanent’ revision covers a Mandatory
or Optional Design Change (MDC or ODC), then the corresponding temporary revision is
superseded.
It is the responsibility of the operator to ensure that this manual is maintained to a current
status.
If you move, or the ownership of the engine/aircraft changes, please complete the change of
address card and send it to Austro Engine GmbH.

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page 1-3
Rev.
No. Reason Chapter Page(s) Date of
Revision Approval Date of
Approval Date In-
serted Signature
5
5.2.3 6
Editorial
changes 5.2.4 6
- -
1
Part No
Correction 11.1 26
15-02-06
- -
Page
numbering all all
1.2 1-4
8.1.5 8-1
8.5.4 8-3
9.4 9-3
9.5.
9.5.1
9.5.2
9-4
9.5.3 9-5
13.5.5 13-5
14-1
14.1 14-2
18.7.1 18-12
18.8.1 18-15
Editorial
Changes
18.8.2 18-16
2
Maintenance
Interval 12.1 12-1
10-04-06
1.1 1-3
1.2 1-4
3
New spark
plug
implemented 11.1 11-1
22-11-06
4 No. changed
1.1
1.2
8.3
11.1
1.3
1-4
8-1
11-1
10-11-08
5 Editorial
change
1.1
1.2
8.3
9.4
11.1
1-3
1-4
8-1
9-3
11-1

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page 1-4
6
All Diamond
Logos
changed to
Austro
Engine
Logo.
Oil
specification
changed
all all 10-03-11

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page 1-5
1.2 LIST OF EFFECTIVE PAGES
Ch. Page Date
1-1 10-March-2011
1-2 10-March-2011
1-3 10-March-2011
1-4 10-March-2011
1-5 10-March-2011
1
1-6
1-7 10-March-2011
10-March-2011
2 2-1 10-March-2011
3-1 10-March-2011
3 3-2 10-March-2011
4 4-1 10-March-2011
5-1 10-March-2011
5-2 10-March-2011
5 5-3 10-March-2011
6-1 10-March-2011
6-2 10-March-2011
6 6-3 10-March-2011
7-1 10-March-2011
7 7-2 10-March-2011
8-1 10-March-2011
8-2 10-March-2011
8 8-3 10-March-2011
8-4 10-March-2011
9-1 10-March-2011
9-2 10-March-2011
9-3 10-March-2011
9-4 10-March-2011
9
9-5 10-March-2011
10 10-1 10-March-2011
11-1 10-March-2011
11 11-2 10-March-2011
12-1 10-March-2011
12-2 10-March-2011
12 12-3 10-March-2011
13-1 10-March-2011
13-2 10-March-2011
13-3 10-March-2011
13-4 10-March-2011
13
13-5 10-March-2011
14-1 10-March-2011
14 14-2 10-March-2011
15-1 10-March-2011
15 15-2 10-March-2011
16 16-1
10-March-2011
Ch. Page Date
17-1 10-March-2011
17 17-2 10-March-2011
18-1 10-March-2011
18-2 10-March-2011
18-3 10-March-2011
18-4 10-March-2011
18-5 10-March-2011
18-6 10-March-2011
18-7 10-March-2011
18-8 10-March-2011
18-9 10-March-2011
18-10 10-March-2011
18-11 10-March-2011
18-12 10-March-2011
18-13 10-March-2011
18-14 10-March-2011
18-15 10-March-2011
18-16 10-March-2011
18-17 10-March-2011
18
18-18 10-March-2011
19-1 10-March-2011
19-2 10-March-2011
19 19-3 10-March-2011

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page 1-6
1.3 TABLE OF CONTENTS
Chapter
INTRODUCTION
(a non-approved chapter)..........................................................................................................1
PREFACE
(a non-approved chapter)..........................................................................................................2
SAFETY INFORMATION
(a non-approved chapter)..........................................................................................................3
(RESERVED)
(a non-approved chapter)..........................................................................................................4
GENERAL ENGINE DATA
(a non-approved chapter)..........................................................................................................5
OPERATING DATA / LIMITATIONS
(an approved chapter)...............................................................................................................6
COMPONENTS
(a non-approved chapter)..........................................................................................................7
DECRIPTIONS OF SYSTEMS
(a non-approved chapter)..........................................................................................................8
OPERATING THE ENGINE
(a non-approved chapter)..........................................................................................................9
ENGINE EMERGENCY PROCEDURES
(a non-approved chapter)........................................................................................................10
MAINTENANCE NOTES
(a non-approved chapter)........................................................................................................11
SCHEDULED MAINTENANCE
(a non-approved chapter)........................................................................................................12
COOLING SYSTEM
(a non-approved chapter)........................................................................................................13

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page 1-7
ENGINE INTERNAL INSPECTION
(a non-approved chapter)........................................................................................................14
GROUND RUN
(a non-approved chapter)........................................................................................................15
MAINTENANCE AND OVERHAUL
(a non-approved chapter)........................................................................................................16
TROUBLE SHOOTING
(a non-approved chapter)........................................................................................................17
NOTES FOR INSTALLERS OF ENGINES
(a non-approved chapter)........................................................................................................18
FORM SHEETS
(a non-approved chapter)........................................................................................................19

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page 2-1
2.0 PREFACE
Every reasonable effort has been made to ensure that the information contained in this
publication is correct when going to print.
However, as Austro Engine GmbH policy is one of continuous improvement, the information
given here may be superseded over a period of time by manual revisions or temporary by
Service Bulletins.
THIS MANUAL IS PUBLISHED BY:
Austro Engine GmbH
Rudolf – Diesel - Straße 11
A – 2700 Wiener Neustadt
Tel.: +43 (0) 2622 – 23000
Fax.: +43 (0) 2622 – 23000 - 2711
Internet: www.austroengine.at
This manual is for use with engines specified by Engine Type Certificate Data Sheet No
EASA.E.085.

AE50R, AE50RA
AE50RAB Engine Manual
Doc. No. E1.01.01-E Rev. 6 10-March-2011 Page 3-1
3.0 SAFETY INFORMATION
The instructions in this manual have been compiled to assist pilots and personnel responsible
for maintenance in the correct operation of the engines produced by Austro Engine GmbH.
Only correct operation and maintenance can ensure optimum availability throughout engine
life.
No recommendation in this manual absolves operators from compliance with any official
directive that may be issued by the controlling aviation authority of any country concerned, or
with any relevant Austro Engine GmbH Service Bulletins.
Austro Engine personnel are always happy to answer queries or give advice on individual
service problems. All queries to Austro Engine GmbH should be accompanied by details of the
engine model and serial number, hours operated and any other relevant information.
3.1 Safety Symbols
NOTE !
A note symbol shows an additional significant information.
CAUTION!
A caution symbol indicates special procedures which should be
followed to avoid the risk of serious damage to engine or to
components.
WARNING!
A warning symbol indicates special procedures, which must be
followed to avoid the risk of death or serious injury to persons.
Dieses Handbuch passt für folgende Modelle
2
Inhaltsverzeichnis
Andere Austro Engine Motor Handbücher






















