BLAUBERG Komfort EC S5B270 S14 Bedienungsanleitung

Air handling unit

Komfort EC S5B270 S14

Komfort EC S5B270-E S14

INSTALLATION GUIDE

INSTALLATION

Tools required

Pencil Drill Screwdriver Dowel Screws

To get the best performance of the unit and to minimize turbulence-induced air pressure losses, connect the straight air duct section to the

spigots while installing.

Minimum straight air duct length:

• equal to 1 air duct diameter on the intake side

• equal to 3 air duct diameters on outlet side

If the air ducts are too short or not connected, protect the unit parts from ingress of foreign objects.

To prevent uncontrollable access to the fans, the spigots may be covered with a protecting grille or other protecting device with mesh width

not more than 1/2inch.

While installing the unit, ensure convenient access for subsequent maintenance and repair.

The unit must be mounted on a ﬂat ﬂoor.

Installing the unit to an uneven surface could lead to the unit’s casing distortion and operation disturbance.

Do not expose the unit to direct sunlight.

www.blauberg.us MUI_83_Komfort EC S5B270 S14_EN-01

174 N. 36th Street, Lafayette, IN 47905

e-mail: [email protected]

The plate opposite to the service side must be ﬁxed with screws (included in the delivery set) before installation.

min 5

Unit oor mounting

Install the unit on the pre-mounted ﬂoor supports, minimum

5 7/8inch height, to ensure suﬃcient access for the drain pipe

connection to the U-trap and for condensate drain system

installation.

Unit wall mounting

Fasteners (dowels, self-tapping screws) for wall mounting

are not included in the delivery set and should be ordered

separately.

While choosing fasteners consider the material of the mounting

surface as well as the weigh of the unit, refer to the Technical

data section. Fasteners for unit installation should be selected

by a qualiﬁed technician.

Secure the wall bracket at required height. Hang the unit on

the wall bracket and secure it with a screw.

www.blauberg.us MUI_83_Komfort EC S5B270 S14_EN-01

174 N. 36th Street, Lafayette, IN 47905

e-mail: [email protected]

CONDENSATE DRAINAGE

Condensate drainage is required for the Komfort EC S5B270 S14 unit series. The Komfort EC S5B270-E S14 units are equipped with a heat

exchanger with an enthalpy membrane at the core. No condensate is formed in heat exchangers of this type, therefore, no condensate

drainage is required. The hole for the drain pipe connection is located at the bottom of the unit. Open the service panel, remove the heat

exchanger and ﬁlters, drill a hole (7/8inch in diameter) in a plastic pan in the exhaust air duct and install the drain pipe (supplied) in the hole.

Then connect the drain pipe to the sewage system using the SG-32 U-trap kit (purchased separately). The pipe slope downwards must be

at least 3°.

min 3°

Drain hose

U-trap

Sewage system

Drain pipe

The condensate drainage system is designed for normal operation in premises with air temperatures above 32 °F!

If the expected ambient air temperatures are below 32 °F, the condensate drainage system must be equipped with heat insulation and pre-

heating facilities.

www.blauberg.us MUI_83_Komfort EC S5B270 S14_EN-01

174 N. 36th Street, Lafayette, IN 47905

e-mail: [email protected]

CONNECTION TO POWER MAINS

The air-handling unit is rated for connection to single-phase AC 120V/60 Hz power mains. Connect the unit to power mains using the power

cord with the IEC plug (included in the delivery set).

The external power input must be equipped with an automatic circuit breaker built into the stationary wiring to open the circuit in the event

of overload or short-circuit. The position of the external circuit breaker must ensure free access for quick power-oﬀ of the unit. The trip

current must be in compliance with the consumption current, refer to Technical data.

Complete the electrical connections through the terminal block in the control unit as shown in the external wiring diagram.

Access to the control unit

External control units wiring diagram:

2 3 4 141312111098765 15

External device

NO (CO2 sensor)

PK re alarm panel

(remove the jumper

while connecting the contact)

120/60 Hz

Control

panel

Tx Rx +

GND Tx Rx +U

GND

0-10V

GND+U 0-10V NОNPE PК РК C

SM-L

SM-N

Humidity

sensor

White

Brown

Green

Yellow

Electric actuators

of the external air dampers

SM1

supply

L1 N

SM2

exhaust

L1 N

Designation Name Model Wire**

N.o External control device contacts LF230 2 x 20 AWG

SМ1* Supply air damper actuator LF230 2 x 20 AWG

SМ2 * Extract air damper actuator LF230 2 x 20 AWG

РК* Contact from ﬁre alarm panel NO 2 x 20 AWG

* Is not included in the delivery set.

** Maximum connecting cable length is 20 m!

www.blauberg.us MUI_83_Komfort EC S5B270 S14_EN-01

174 N. 36th Street, Lafayette, IN 47905

e-mail: [email protected]

Andere Handbücher für Komfort EC S5B270 S14

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere BLAUBERG Luftaufbereiter Handbücher

BLAUBERG

BLAUBERG FRESHBOX E120 Bedienungsanleitung

BLAUBERG

BLAUBERG Freshbox 100 Bedienungsanleitung

BLAUBERG

BLAUBERG CIVIC EC LB 300 Bedienungsanleitung

BLAUBERG

BLAUBERG BlauAir BL02 CFH 1500 Bedienungsanleitung

BLAUBERG

BLAUBERG Freshbox 100 WiFi Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT EC D5B 180 Bedienungsanleitung

BLAUBERG

BLAUBERG CIVIC EC DB 1000 Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT EC S S11 Series Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT EC S160 Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT LE350-3 Bedienungsanleitung

BLAUBERG

BLAUBERG BLAUBOX EC MW 700-4 S30 Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT EC DW Series Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT EC DB 160 Bedienungsanleitung

BLAUBERG

BLAUBERG Freshbox 100 WiFi Bedienungsanleitung

BLAUBERG

BLAUBERG VUT 270 V5B EC Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT EC LB S11 Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT ERV EC DB100 S14 Bedienungsanleitung

BLAUBERG

BLAUBERG Komfort EC S5B270 S14 Bedienungsanleitung

BLAUBERG

BLAUBERG Micra 100 WI-FI Bedienungsanleitung

BLAUBERG

BLAUBERG Komfort ERV EC DB 150 S14 Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT Roto EC S400 Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT Ultra D105-A Bedienungsanleitung

BLAUBERG

BLAUBERG KOMFORT EC LB Bedienungsanleitung

BLAUBERG

BLAUBERG VENTO Expert A50-1 W Bedienungsanleitung

Beliebte Luftaufbereiter Handbücher anderer Marken

Klimor

Klimor EVO-S Bedienungsanleitung

Salda

Salda SMARTY XP Leitfaden

Trenton

Trenton TPLP Series Bedienungsanleitung

Kemper

Kemper CleanAirTower Bedienungsanleitung

Daikin

Daikin DV PTC 14 Series Bedienungsanleitung

Haier

Haier HB2400VA1M20 Bedienungsanleitung

Webasto

Webasto BlueCool A-Series Bedienungsanleitung

RDZ

RDZ DA 701 Technisches Dokument

Carrier

Carrier 39T Abmessungen und Installationsanleitung

Armstrong Air

Armstrong Air BCE5V Series Bedienungsanleitung

ActronAir

ActronAir CAY500T Bedienungsanleitung

Carrier

Carrier 40MBDAQ Bedienungsanleitung

Allied

Allied A93UH1E Bedienungsanleitung

Nortek

Nortek B6VMAI Bedienungsanleitung

TemperZone

TemperZone Econex Pro OPA 1410RLTM4FPQD Wartungs- und Serviceanleitung

RDZ

RDZ WHR 200 Technisches Dokument

AAON

AAON H3 Series Betriebsanleitung

Lennox

Lennox VEOA042N432U Montageanleitung