BMW 039 0259 B Bedienungsanleitung

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

Navigation system III retroﬁt kit

(System with additional monitor)

BMW 5 Series touring (E

39/2)

These installation instructions are only valid for LHD cars.

Technical and electrical knowledge required

The installation time is approx. 4.5 hours but this may vary depending on the condition of the

car and the equipment in it.

Retrofit/Installation kit No.65 90 136 830

Parts and Accessories

Installation Instructions

039 0259 B

EN/2

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

Contents

Section Page

1. Important information for the installation of the navigation system . . . . . . . . . . . . . 3

2. Tools and equipment required. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3. Preparations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

4. Parts list . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

5. Connection diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

6. Installation and cabling diagram for navigation system wiring harness A,

monitor wiring harness B,

navigation computer adapter cable C and monitor adapter cable D . . . . . . . . . . . . 15

7. Installation and cabling diagram for additional tacho A signal cable E and

GPS aerial extension F . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

8. To install the GPS aerial . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

9. To install the navigation system wiring harness A

and additional tacho A signal cable E . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

10. To install the monitor wiring harness B, navigation computer adapter cable C

and monitor adapter cable D . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

11. To install and connect the monitor, gooseneck and remote control. . . . . . . . . . . . . 23

12. To prepare the installation site for the navigation computer . . . . . . . . . . . . . . . . . . 27

13. To install and connect the navigation computer . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

14. Coding, concluding work and function test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

15. Calibration and language settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

16. Car hand-over . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

17. Circuit diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

EN/3

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

1. Important information for the installation of the navigation system

Only for use in the BMW dealer organisation.

The navigation system may only be installed by a specialist workshop that has the required

special tools and manuals.

Ensure that the cables/lines are not kinked or damaged as you install them in the car.

Additional cables/lines that you install must be secured with cable ties.

Item numbers refer only to the overview drawings and to the texts next to the appropriate figure.

These installation instructions are only valid for E39/2 LHD cars.

Electrical knowledge is required.

The following are not supplied with the installation kit and must be ordered separately:

- The switch module depends on the equipment and must be ordered separately using the

Electronic Parts Catalogue (EPC).

- The switch module must

not

be installed as described in installation instructions 01 29 0

002 825 in section 2.2 (cars with navigation system II).

The installation work

must

be completed as described in section 2.1 (cars with telephone/

mobile phone).

- There are two languages available in the navigation system (German and English).

To set other languages and announcements for the navigation system you will need the

software CD (41).

- The boot trim at the rear left.



These installation instructions are for E39/2 cars:

· without SA 358 (climate comfort windscreen)

- without SA 602 (on-board monitor with TV)

- without SA 609 (navigation system).



The branch

of the navigation system wiring harness

must be extended using a white/

yellow cable l = 500mm from the workshop stock prior to installation



Subject to technical modifications

EN/4

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

2. Required tools and equipment

Hot air blower Oscillating saw

Textile adhesive tape Pneumatic saw

Set of 1/2 inch socket wrenches Set of Philips screwdrivers

1/4 inch socket set Set of flat screwdrivers

Combination pliers Set of Torx sockets

Angle cutter BMW disconnection tool

Drill Universal knife

20 mm step drill Set of files

Set of twist drill bits Torch

Felt pen (water-soluble)

EN/5

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

3. Preparations

Also on cars from product revision 09/99 without tacho A signal at the black 12-pin plug

connector X322 in the boot on the left.

TIS instruction No.

Conduct a brief test

---

Disconnect the battery 12 00 ...

Remove the centre console trim on the passenger side 51 16 239

Remove the rear seat bench 52 24 005

Remove the rear seat backrest 51 44 001

Remove the door sill strips on the driver’s side at the front and rear 51 47 000/51 47 030

Remove the bottom part of the B pillar trim on the driver’s side

---

Remove the boot floor 51 47 101

Remove the trim at the rear left of the boot (to be replaced by a

new trim)

51 47 151

Remove the left boot trim

---

Remove the right boot trim

---

Remove the bottom A pillar trim on the driver’s side

---

Remove the glove compartment 51 16 360

Remove the DSP amplifier holder (if fitted) 65 11 070

Remove the instrument cluster trim

---

Remove the instrument cluster

---

EN/6

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

039 0318 B

4. Parts list

EN/7

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

4. Parts list

PowerNAVIGATIONCOMPUTER

VDOayton

10 11 12 13 14

15 16 17 19

039 0319 B

EN/8

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

4. Parts list

7,5A

20 23

22 24

41403938

30 31 32 33 34 35

36 37

039 0320 B

EN/9

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

4. Parts list

42 43 44

45 46 47 48 49

039 0324 B

EN/10

Retrofit / Installation kit No. 65 90 0 136 830

Installation Instructions No. 01 29 0 142 620 Issue date: 10.2001

4. Parts list

Legend

A Navigation system wiring harness

B Monitor wiring harness

C Navigation computer adapter cable

D Monitor adapter cable

E Additional tacho A signal cable

F GPS aerial extension

1 GPS aerial

2 Hexagonal screw (plastic) (attachment of GPS aerial holder)

3 Expanding rivet for securing the GPS aerial holder (x2)

4 Holder for GPS aerial

5 Black 1-pin socket casing (7x)

6 Shrink hose

7 Navigation computer

8 Holder for DSP amplifier

9 Navigation computer holder

10 Cable tie

11 Removal bar (x2)

12 Hexagonal screw with washer M5x14

13 Speed nut M5

14 Cable clip

15 Hexagonal self-tapping screw with washer, 4.8x16

16 Plastic expanding nut 4.8

17 Plastic cap nut

18 Monitor

19 Monitor installation bracket

20 Retaining plate for gooseneck

21 Spacer bush (retaining plate for gooseneck)

22 Hexagonal screw with washer (M8x40) (retaining plate for gooseneck)

23 Retaining clip (top gooseneck fastening)

24 Gooseneck cover cap (with monitor removed)

25 Gooseneck installation foot (2-part)

26 Gooseneck with connection cable

27 Remote control

28 Remote control holding station with connection cable

29 Holding station mounting plate

30 Locking washer

31 Toothed washer (monitor)

32 Rotary knob (monitor)

33 Countersunk screw M5x10 (monitor installation bracket)

34 Philips screw 1/4”x 5/8”(rotary knob)

35 Self-tapping screw 4.8x38 (installation foot)

36 Self-tapping screw 3.5x30 (retaining clip)

37 Screw M5x16 (installation foot)

Inhaltsverzeichnis

Andere BMW Auto-Navigationssystem Handbücher

BMW

BMW Motorrad Navigator Street Bedienungsanleitung

BMW

BMW Motorrad Navigator V Gebrauchsanweisung

BMW

BMW 65 90 0 151 635 Bedienungsanleitung

BMW

BMW MSN Direct Konfigurationshandbuch

BMW

BMW EE0001 Bedienungsanleitung

BMW

BMW 01 40 2 960 980 Benutzerhandbuch

BMW

BMW E46 Bedienungsanleitung

BMW

BMW Motorrad Navigator V Bedienungsanleitung

BMW

BMW Traffic Pro Bedienungsanleitung

BMW

BMW iDrive Bedienungsanleitung

BMW

BMW iDrive Bedienungsanleitung

BMW

BMW V12 Bedienungsanleitung

BMW

BMW Motorrad Navigator III Bedienungsanleitung

BMW

BMW Navigation Portable Pro Bedienungsanleitung

BMW

BMW Motorrad Navigator V Gebrauchsanweisung

Beliebte Auto-Navigationssystem Handbücher anderer Marken

Clarion

Clarion Navigation In-Car Entertainment Bedienungsanleitung

Rosen

Rosen DP-1001 Bedienungsanleitung

Alpine

Alpine INE-W970HD Bedienungsanleitung

Blaupunkt

Blaupunkt TravelPilot DX-N Bedienungsanleitung

Pioneer

Pioneer MZ360500EX Bedienungsanleitung

Sanyo

Sanyo NVM-4030 - Easy Street - Automotive GPS... Bedienungsanleitung

AvMap

AvMap Geosat 2C Bedienungsanleitung

Eonon

Eonon GE01B Bedienungsanleitung

Pioneer

Pioneer AVIC-Z920DAB Bedienungsanleitung

Nextar

Nextar M3-MX - Automotive GPS Receiver Bedienungsanleitung

Furrion

Furrion NV2200 Bedienungsanleitung

Mio

Mio MOOV 200-Series Bedienungsanleitung

Prestigio

Prestigio GeoVision 5150 Bedienungsanleitung

Magellan

Magellan Maestro 4210 - Automotive GPS Receiver Konfigurationshandbuch

Garmin

Garmin StreetPilot c510 Bedienungsanleitung

Garmin

Garmin nüvi 2200 Bedienungsanleitung

Garmin

Garmin 2610/2650 Bedienungsanleitung

Mazda

Mazda 107006AN Bedienungsanleitung