Bond HYMH20027-61 Bedienungsanleitung

Owner’s Manual

Item#

Model#

HYMH20027-61

10" ROUND GAS FIRE COLUMN

52145

DANGER CARBON MONOXIDE HAZARD

This appliance can produce carbon

monoxide which has no odor.

Using it in an enclosed space can kill you.

Never use this appliance in an enclosed

space such as a camper, tent, car or

home.

INSTALLER: Leave this

manual with the appliance.

CONSUMER: Retain this

manual for future reference.

DANGER

WARNING

For outdoor use only.

Improper installation, adjustment, alteration, service or maintenance can cause injury or

property damage. Refer to the owner's information manual provided with this appliance.

For assistance or additional information consult a qualified installer, services agency or

the gas supplier.

FIRE OR EXPLOSION HAZARD

If you smell gas:

Shut off gas to the appliance.

Extinguish any open flame.

If odor continues, leave the area immediately.

After leaving the area, call your gas supplier

or fire department.

Failure to follow these instructions could

result in fire or explosion, which could cause

property damage, personal injury, or death.

Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance. An LP-cylinder not connected

for use shall not be stored in the vicinity of

this or any other appliance.

WARNING: If the information in this

manual is not followed exactly, a fire or

explosion may result causing property

damage, personal injury, or loss of life.

•

Installation and service must be performed

by a qualified installer, service agency,

or the gas supplier.

Bond Manufacturing Co., Inc. | Page 2

WARNING

Before you assemble or operate this unit, please carefully read this entire manual. Failure to do so

SAFETY INFORMATION

•

burner obstructions before use.

•

•Combustible materials should not be within 60 inches of the top of the unit, or within 48 inches

around the entire unit.

•

anywhere near the appliance.

•Users should be alerted to the hazards of high surface temperatures and keep a safe distance to

avoid burning or clothing ignition.

•

Do not transport it while in operation.

•

unit.

•Keep ventilation openings in cylinder enclosure (FIREBOWL BODY) free and clear of debris.

•

•The conversion or attempted use of natural gas in a propane unit is dangerous.

•

•Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.

•

•Inspect the burner before each use of the appliance. If there is evidence of damage, the burner must

be replaced prior to the appliance being put into operation. Use Manufacturer approved or supplied

replacement burner only.

•

used.

•

•A dented or rusty propane cylinder may be hazardous and should be checked by your gas supplier

prior to use.

•

•The installation of this unit must adhere to local codes or Propane Storage and Handling Code,

CSA B149.2.

Solid fuels shall not be burned in this appliance. Never place clothing or other flammable

material on or near the firebowl.

1-866-771-2663 | Page 3

•

•Transport and store the empty gas cylinders carefully and properly.

•If you see, smell or hear the hiss of escaping gas from the propane cylinder: 1. Disconnect propane

gas cylinder, 2. Do not attempt to correct the problem yourself, 3. Get to your gas supplier and/or the

•

operating this appliance.

•

•This appliance is designed for use with a 16.40Z (1Lb) propane gas cylinder (disposable). The

cylinders of the U.S. Department of Transportation (DOT) or the National Standards of Canada, CAN/

CSA-B339, cylinders, Spheres and Tubes for Transportation of Dangerous Goods;and Commission,as

applicable.

•Cylinders must be stored outdoors in well-ventilated area out of the reach of children.

•Disconnected cylinders must have valve caps tightly installed and must not be stored in a building or

any other enclosed area.

•Do not light or use gas unit if lava rocks are wet. Ensure lava rocks are completely dry before

igniting.

•Pumice stones/lava rocks/LavaGlass®could hit somebody’s face or eyes during initial start of this

•During Ignition procedure, one should NEVER get his/her face close to and or above the burner. In

•Children should never operate this unit. Children must be supervised while near this unit.

•

inspected annually and cleaned regularly.

•Children and adults should be alerted to the hazards of high surface temperatures and should

stay away to avoid burns or clothing ignition.

•Young children should be carefully supervised when they are in the area of the appliance.

•

near the appliance.

•Any guard or other protective device removed for servicing the appliance shall be replaced

prior to operating the appliance.

•

may be required as necessary. It is imperative that the control compartment, burners and

circulating airways of the appliance are kept clean.

The cylinder must be disconnected when the appliance is not in use.

Do not use a propane cylinder with a damaged valve and any other worn out parts.

Maximum gas supply: 250 psi; Min. gas supply: 10 psi.

•

Bond Manufacturing Co., Inc. | Page 4

SAFETY INFORMATION

Combustible materials should not be within 60

inches of the top of the unit, or within 48 inches

around the entire unit.

Min. Clearance

48 in (121.9 cm)

Min. Clearance

48 in (121.9 cm)

Min. Clearance

48 in (121.9 cm)

Min. Clearance

48 in (121.9 cm)

Only use the regulator and hose assembly provided with this unit. Replacement parts must be supplied

directly by Bond Manufacturing Co., Inc.

Inspect the burner before use of this unit. If the burner shows any kind of damage, do not operate

the appliance. For assistance with repair or replacement of the burner or any other parts, call Bond

Manufacturing Co., Inc. at 1.866.771.2663.

NOTE: You must follow all steps to properly assemble this heating item. Make sure the gas

valve is turned “OFF” before assembling. Do NOT attempt to assemble without proper tools.

1-866-771-2663 | Page 5

CONTENTS

Item Description Qty

A Lava Rocks 1 box (0 . 7kg)

B 1

Body

D 1

Protective Cover

Control Knob (preassembled)

Burner (preassembled)

Guard (preassembled) 1

Door (preassembled)

Bond Manufacturing Co., Inc. | Page 6

ASSEMBLY INSTRUCTIONS

3 . Place the lava rocks (A) onto the burner

(F) evenly.

WARNING

Keep away from the unit and have the unit to

burn 20 minutes for the first time use.

Always ensure that lava rocks/pumice stones/

LavaGlass®are completely dry before use. Failure

to do so will cause them to crack or pop.

To attach the 1 lb. propane gas tank

in the body (B), screw it to the regulator inlet

fitting inside the body (B).

1. Check that the control knob (E) for the gas

supply system is turned to the “OFF” position

before starting any assembly.

2.Open the door. (not included)

To ensure proper function, the guard (G) on this

burner (F) should be free of lava rocks at all times.

1-866-771-2663 | Page 7

OPERATION

To Light

To Extinguish

Before performing a leak test, be sure that no sparks can occur and you are in a spacious outdoor

area. Connect the propane gas tank to the regulator and turn the valve on the unit to the “off”

position. Brush a soap and water mixture on all connections. Turn the gas supply on; if bubbles

occur on any connection there may be a leak. If you smell gas or a leak is discovered turn the

gas valve off, disconnect propane gas tank and do not use the appliance until the leak is

repaired.

Pumice stones/lava rocks/LavaGlass®could pop up and strike somebody’s face during the process

should be a yellow/blue color between 1 - 7.5 inches in height.

1. Turn the control knob (E) clockwise to the ‘off’ position.

2. Disconnect propane cylinder to close the gas supply if not using for a period of time.

heating item.

1. After assembling the gas tank, push and turn the control knob (E) counter-clockwise, then use

a match or a lighter to light the firebowl. Keep holding down the control knbo for 15 seconds.

2. To adjust the flame, turn the control knob (E).

Bond Manufacturing Co., Inc. | Page 8

MAINTENANCE

•Before performing any maintenance always disconnect propane gas tank.

•Keep the heating item free and clear from combustible materials.

•Visually inspect burner for obstructions and keep tank enclosure free and clear from debris.

•Use a soft brush to get rid of the mild stains, loose dirt and soil after the burner and pumice stones/

lava rocks/LavaGlass®are completely cooled down. Wipe down with a soft cloth.

•Harsh weather conditions may cause stubborn stains, discoloration and possibly rust pitting.

•Permanent damage may occur if powder or solvent comes in contact with painted or plastic

components on this heating unit.

•Keep the heating unit stored away from direct sunlight.

• If storing this unit inside, disconnect the propane gas tank from the gas valve.

•Not using manufacturer approved or supplied parts/accessories may result in a defective condition

and void the warranty of this heating unit.

• Always place lid (if applicable) or protective cover on heating item when not in use.

Store your product indoors during winter months. Avoiding extreme cold temperatures will

prevent from exposure damage.

•

1-866-771-2663 | Page 9

TROUBLESHOOTING

Problem Cause Solution

No gas ﬂow Check if gas cylinder is empty

Regulator isn’t connected securely to the

tank

Tighten regulator connection to the gas

tank

Spider webs or insect nest in the burner

and guard

Check the burner and guard

Burner ports are clogged Turn all gas ﬂow connections off. Insert

an opened paperclip (or similar item) into

each of the burner ports to clear them

out.

Heating unit emits a lot of

black smoke

Flame is obstructed at burner ports Check that all burner ports are free of

any small lava rocks/pumice stones/

LavaGlass®pieces

High or gusting winds Increase ﬂame to ‘high’

No gas ﬂow Check if gas cylinder is empty

Burner won’t light with

a match

Flame blows out

easily

Bond Manufacturing Co., Inc. | Page 10

WARRANTY

If you have any questions or concerns, please contact Bond Manufacturing Co., Inc. at the below

resources:

CONTACT

Toll Free Phone 1-866-771-BOND (2663) | Monday - Friday, 8am - 4:30pm PST

Email customer[email protected]

Online www.bondmfg.com

This product has a one-year warranty against manufacturing defects in workmanship, or materials.

The manufacturer warranty will be voided by, and manufacturer disclaims any responsibility for, the

following actions:

•

•Use of any component part not manufactured or approved by Bond Manufacturing Co., Inc.

•Use and installation other than what is listed in this manual.

Please contact the manufacturer for replacement parts.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Sprachen:

Andere Bond Außenkamin Handbücher

Bond

Bond 52147 Bedienungsanleitung

Bond

Bond HYUTT10001-4 Bedienungsanleitung

Bond

Bond HYFP50025-1 Bedienungsanleitung

Bond

Bond 52010 Bedienungsanleitung

Bond

Bond Mondavi BH7001-1 Bedienungsanleitung

Bond

Bond HYFP50085-31 Bedienungsanleitung

Bond

Bond OLIVERA HYFP50086-1 Bedienungsanleitung

Bond

Bond HYFP50085-3 Bedienungsanleitung

Bond

Bond HYFP50085-26 Bedienungsanleitung

Bond

Bond 68183 Bedienungsanleitung

Bond

Bond BH5004-3 Bedienungsanleitung

Bond

Bond 51058 Bedienungsanleitung

Bond

Bond Cedar Ridge HYFP40205-132 Bedienungsanleitung

Bond

Bond 67641 Bedienungsanleitung

Bond

Bond 67836 Bedienungsanleitung

Bond

Bond PGF5820-2 Bedienungsanleitung

Bond

Bond HYFP30205-96 Bedienungsanleitung

Bond

Bond 66603 Bedienungsanleitung

Bond

Bond Newcastle BH5004-24 Bedienungsanleitung

Bond

Bond HYFP50095-45 Bedienungsanleitung

Bond

Bond Roxbury TableFire HYUTT10001-1 Bedienungsanleitung

Bond

Bond HYFP50085-36 Bedienungsanleitung

Bond

Bond BH65001-1 Bedienungsanleitung

Bond

Bond 50481 Bedienungsanleitung

Beliebte Außenkamin Handbücher anderer Marken

Outdoor Plus

Outdoor Plus PISMO OPT-2448 Bedienungsanleitung

Legacy

Legacy Fire Pit Bedienungsanleitung

Coleman

Coleman 5055-710 Bedienungsanleitung

Jensen

Jensen 300NG Bedienungsanleitung

FEUERHAND

FEUERHAND PYRON Bedienungsanleitung

Firegear

Firegear KWB-NG1 Kurzanleitung

Classics

Classics FP35077 Bedienungsanleitung

Jensen

Jensen 1590LP Bedienungsanleitung

Mayer Barbecue

Mayer Barbecue HEIZA MFK-220 Bedienungsanleitung

Costway

Costway NP11018 Bedienungsanleitung

Target

Target Foxborough Bedienungsanleitung

Blumfeldt

Blumfeldt Merano Bedienungsanleitung

Blooma

Blooma Brasero Ulong Bedienungsanleitung

The Fireplace

The Fireplace JETMASTER 700 D Bedienungsanleitung

Superior

Superior VRE4543EN Bedienungsanleitung

Morsø

Morsø Forno Bedienungsanleitung

dobar

dobar CONICO 35439E Bedienungsanleitung

EAST OAK

EAST OAK GFT22001 Bedienungsanleitung