Boulevard VFLL60FP90LN-1 Kurzanleitung

INSTALLATION INSTRUCTIONS

AND OWNER'S MANUAL

CONTEMPORARY LINEAR

VENT-FREE GAS FIREPLACE

MODELS

VFLL60FP90L(N,P)-1

VFLL72FP90L (N,P)-1

This appliance may be installed in an

aftermarket, permanently located, manufactured

(mobile) home, where not prohibited by local codes.

This appliance is only for use with the type of gas

indicated on the rating plate. This appliance is not

convertible for use with other gases.

INSTALLER:

Leave this manual with the appliance.

CONSUMER:

Retain this manual for future reference.

WARNING

If the information in this manual is not

followed exactly, a re or explosion may

result causing property damage, personal

injury or loss of life.

— Do not store or use gasoline or other

ammable vapors and liquids in the vicinity

of this or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do

not use any phone in your building.

• Immediately call your gas supplier from

a neighbor’s phone. Follow the gas

supplier’s instructions.

• If you cannot reach your gas supplier,

call the re department.

— Installation and service must be performed

by a qualied installer, service agency or

the gas supplier.

This is an unvented gas-red heater. It uses air

(oxygen) from the room in which it is installed.

Provisions for adequate combustion and

ventilation air must be provided.

Refer to pages 15 - 16.

This series is design certied in accordance with American

National Standard Institute (ANSI) Z21.11.2 by the Canadian

Standards Association Laboratories (CSA) as an Unvented

Room Fireplace and should be installed according to these

instructions.

GAS-FIRED

UL FILE NO. MH46389

Page 1

36776-0-0716Page 2

TABLE OF CONTENTS

Before You Start .............................................................................................................................................................. 3

Carton Contents .............................................................................................................................................................. 5

Hardware Pack................................................................................................................................................................ 6

Important Soot Prevention Steps..................................................................................................................................... 7

Product Specications..................................................................................................................................................... 8

Accessories ..................................................................................................................................................................... 9

Introduction.................................................................................................................................................................... 10

Important Information .....................................................................................................................................................11

Important Safety Information ......................................................................................................................................... 12

Safety Information for Users of LP-Gas......................................................................................................................... 13

Important Installation Guidelines ................................................................................................................................... 14

Water Vapor: A By-Product of Unvented Room Heaters ............................................................................................... 14

Provisions for Adequate Combustion & Ventilation Air .................................................................................................. 15

Fireplace Dimensions.................................................................................................................................................... 17

Junction Box Wiring Installation..................................................................................................................................... 18

Gas Supply.................................................................................................................................................................... 20

Clearances .................................................................................................................................................................... 21

Installation Option 1 - Clean Face.............................................................................................................................. 22

Framing - Clean Face.................................................................................................................................................. 23

Nailing Flanges & Mounting Brackets - Clean Face.................................................................................................... 24

Fireplace & Non-Combustible Board Installation - Clean Face ................................................................................... 25

Completing Installation - Clean Face & Flush Mount .................................................................................................. 30

Installation Option 2 - Flush Mount ........................................................................................................................... 26

Framing - Flush Mount ................................................................................................................................................ 27

Nailing Flanges & Mounting Brackets - Flush Mount................................................................................................... 28

Fireplace & Non-Combustible Board Installation - Flush Mount.................................................................................. 29

Completing Installation - Clean Face & Flush Mount .................................................................................................. 30

Fireplace Wiring............................................................................................................................................................. 32

LED Wiring .................................................................................................................................................................... 33

Decorative Glass Installation......................................................................................................................................... 34

Lighting Instructions....................................................................................................................................................... 36

Pilot Flame Characteristics............................................................................................................................................ 37

Flame Appearance ........................................................................................................................................................ 37

Proame - IP Control System........................................................................................................................................ 38

Operating Instructions ................................................................................................................................................... 39

Cleaning and Service .................................................................................................................................................... 40

Testing the Gas Supply Pressure .................................................................................................................................. 41

Troubleshooting............................................................................................................................................................. 42

Exploded View............................................................................................................................................................... 46

Parts List........................................................................................................................................................................ 47

Master Parts Distributor List .......................................................................................................................................... 48

How To Order Repair Parts ........................................................................................................................................... 48

For The Homeowner.................................................................................................................................................... 49

Home owner Reference Information.............................................................................................................................. 49

Important Information .................................................................................................................................................... 50

Removing & Replacing the Glass Front ........................................................................................................................ 51

Decorative Glass & Rock Placement............................................................................................................................. 52

Lighting Instructions....................................................................................................................................................... 53

Operating Instructions ................................................................................................................................................... 54

LED & Fireplace Wall Controls ...................................................................................................................................... 55

Using the Remote Control ............................................................................................................................................. 56

Warranty ........................................................................................................................................................................ 61

SECTION PAGE

36776-0-0716 Page 3

Unpacking the replace

1. Remove the four screws securing the plywood top to the

corner supports. Remove the plywood top and discard.

2. Remove the two screws securing each corner support to the

pallet. Remove the corner supports and discard.

3. Cut and the banding securing the replace to the pallet.

Discard the banding.

Figure 1

4. Remove the plastic wrap securing the instruction packet and

the hardware box to the replace.

Figure 2

5. Carefully remove the bundle from inside the replace. This

bundle contains two center glass supports and the burner

deector glass. Put the bundle in an out of the way place to

avoid damaging the components.

6. Lift the replace off the pallet and place it near the

installation site. If the replace must be placed on end so

that a hand truck may be used for transportation, remove all

loose components from inside the replace. Truck from the

left end (when facing the replace opening) only.

7. Carefully open the cardboard bundle remaining on the pallet.

This bundle contains the large non-combustible board and

the front glass barrier. Put the components in an out of the

way place to avoid damaging them.

Figure 3

BEFORE YOU START

HANDLE WITH CARE

GLASS

NOTICE

SHEET

GLASS LABEL

FRAGILE LABEL

CARTON LABEL

HANDLE WITH CARE

GLASS

HANDLE WITH CARE

GLASS

HANDLE WITH CARE

GLASS

HARDWARE

INSTRUCTION

PACKAGE

NON-COMBUSTIBLE

PANEL

FRONT GLASS

36776-0-0716Page 4

BEFORE YOU START

Sample Warnings and Denitions:

DANGER

Indicates a hazardous situation which, if not avoided, will result

in death or serious injury.

WARNING

Indicates a hazardous situation which, if not avoided, could

result in death or serious injury.

CAUTION

Indicates a hazardous situation which, if not avoided, could

result in minor or moderate injury.

Notice: Addresses practices not related to personal injury.

Installation Information

1. Read the soot prevention information on page 7.

2. Read the safety information on pages 12 - 13.

3. Frame the opening. See page 23 and 27.

4. Install the gas lines. See page 20.

5. Install the wiring. See pages 32 - 33.

6. Install the remote system. See page 38.

7. Light the replace and troubleshoot.

See pages 36 and 42 - 44.

8 For detailed instructions on operating the Proame - IP

Control System see pages 56 - 60.

9. For detailed instructions for the LED Controls, see page 55.

10. Show the homeowner how to operate the replace,

see page 53.

11. Show the homeowner how to do the basic maintenance.

Installation Considerations - Fireplace Installation

Guidelines

Determine where to install the replace. The replace can be

mounted on any of these surfaces:

1. A at hard combustible or non-combustible surface.

2. A raised platform of combustible or non-combustible

material.

If the replace is installed directly on carpeting, tile or other

combustible material other than wood ooring, it must be installed

on a metal or wood panel extending the full width and depth of

the replace.

This replace is designed to be installed in a zero-clearance

enclosure. This means combustible material such as framing

lumber can come in contact with the top and side standoff

spacers, and secured to combustible framing using the framing

brackets provided.

Determine the following before installation:

• Any desired accessories

• Gas supply piping (left side entrance).

• Electrical connections

• Electrical supply requirements for light.

(120V, 60Hz, 1 Amp) (left side entrance)

Finishing Options

Choose the nishing option.

Option 1 - Clean Face: This type of installation (page 22) will

allow for nishing around the replace opening with high

temperature paint.

Option 2 - Flush Mount: This type of installation will allow

you to apply tile, marble, stone or other non-combustible material

over the face of the replace cabinet, up to the replace

opening ange.

36776-0-0716 Page 5

CARTON CONTENTS

CARTON CONTENTS Items not shown to scale.

Index

Number Description Quantity

Supplied

1 Fireplace 1

2 Non-combustible Board - Top 1

3 Non-combustible Board - Side 2

4 Glass Front 1

5 Glass, Burner 1

6 Bushing 3

7 Standoff Supports 3

8 Receptical 2

9 Remote 1

10 AA Battery 8

11 AAA Battery 3

12 Hardware Pack 1

13 AC Adaptor 1

14 Wall Mounted Control Box 1

15 Remote Receiver 1

16 Battery Pack 1

17 Button Switch 2

18 Mounting Bracket 1

19 Wall Plate 1

20 Optional Inner Top Deector 1

For hardware pack contents, see page 6.

See Parts Lists on pages 46 - 47 for ordering replacement parts.

Do not order batteries, bolts, screws, washers or nuts. They are

standard hardware items and can be purchased at any local

hardware store.

13 6

15 16 17

BAG

36776-0-0716Page 6

HARDWARE PACK CONTENTS

Description Quantity

Supplied

10 X 1/2 Phillips Hex Head Screw 14

4 x 1/2 Phillips Pan Head Screw 4

#8 x 1 inch Self-Drilling Drywall Screw 9

Nailing Flange 4

See Parts Lists on page 46 - 47 for ordering replacement parts.

Do not order batteries, bolts, screws, washers or nuts. They are

standard hardware items and can be purchased at any local

hardware store.

HARDWARE PACK

1” PHILLIPS SELF-DRILLING SCREW

#10 X ½” HEX HEAD SCREW

NAILING FLANGES

#4 X ½” STAINLESS PHILLIPS HEAD SCREW

(Not to scale)

36776-0-0716 Page 7

IMPORTANT SOOT PREVENTION STEPS

IMPORTANT NOTICE

INSTALLER - SERVICE PERSON - HOMEOWNER

SOOT MAY BE CREATED IF THE FOLLOWING DIRECTIONS ARE NOT FOLLOWED.

A vent-free replace or burner draws room air to support

combustion. Lightweight particles suspended in the air –

including dust, carpet bers, candle or tobacco smoke, and pet

hair – will be drawn toward the replace. These can lead to soot

build up on logs, replace walls, and even walls of the room. To

prevent malfunctions and sooting, have your dealer perform an

inspection and cleaning each year – before the heating season. If

you have pets or excessive dust, more frequent cleaning may be

necessary. See cleaning and service section in this manual.

1. Ensure the air shutter is set to the specication. See Figures

4 to 6 on this page and Tables 1 and 2 on page 8.

2. Ensure burner, venturi, and air shutter are free of dirt, lint,

animal hair (i.e. cat and dog) or anything that may block the

needed air ow. See Cleaning and Service, page 40.

3. Do not place debris, additional logs or other articles on the

burner during operation.

4. Do not use scented air fresheners or candles while the

replace is in operation. They produce residue which may

cause soot.

6. Do not place glass media on burner or burner ports. The

glass media should only be placed on the replace oor.

7. Do not use rock wool (embers) or lava rock.

9. Annual inspection and cleaning by your dealer or a qualied

service technician is recommended to prevent malfunction

and/or sooting.

10. Install optional logs according to the installation instructions.

Only use Empire Logs specially made for this replace.

11. Verify the venturi tube is not bent or distorted. The main

burner orice must be centered in the venturi tube for proper

combustion and to prevent sooting.

WARNING

Do not allow fans to blow directly into or at the replace. Avoid

any drafts that alter burner ame patterns. Avoid any drafts that

alter burner ame patterns. Pay particular attention to ceiling

fans and exhaust fans.

Verify the air shutter for the correct setting. Refer to Tables 1 and

2 on page 8 for specic air shutter settings for each model.

LP Gas Models - The air shutter setting must be 1/4-inch. See

Figures 4 and 5, and Table 1 on page 8.

Figure 4 (1/4-inch opening shown)

Test 1/4 air shutter setting with a round object like a 1/4-inch drill

bit. The object should barely slide between the opening. See

Figure 5.

Figure 5 (1/4-inch opening shown)

NAT Gas Models- The air shutter setting must be fully closed.

See Figure 6 and Table 2 on page 8.

Figure 6

Notice: Orice shield removed for clarity.

36776-0-0716Page 8

PRODUCT SPECIFICATIONS

Table 1 - Air Shutter Opening - Natural Gas Models

Model Air Shutter Opening

VFLL60FP90 Fully Closed

VFLL72FP90 Fully Closed

Table 2 - Air Shutter Opening - LP Gas Models

Model Air Shutter Opening

VFLL60FP90 1/4 inch

VFLL72FP90 1/4 inch

VFLL60FP90LP VFLL60FP90LN VFLL72FP90LP VFLL72FP90LN

Input BTU/HR Maximum 38,500 40,000 38,500 40,000

Input BTU/HR Minimum 31,000 25,000 31,000 25,000

Orice 1.8mm #32 1.8mm #32

Notice: Air shutter settings are factory set and muay not be altered.

GAS SUPPLY PRESSURES (inches water column)

GAS TYPE MAXIMUM MINIMUM MANIFOLD

NAT 10.5 7.0 3.5

LP 13.0 11.0 10.0

36776-0-0716 Page 9

ACCESSORIES

Part Number Description

VFLL60 VFLL72

DG1CLF DG1CLF Decorative Glass, Crushed - 1/4 inch Clear Frost (One kit per one square foot) Recommended

DG1BKP DG1BKP Decorative Glass, Crushed - 1/4 inch Black Polished (One kit per one square foot)

DG1BUC DG1BUC Decorative Glass, Crushed - 1/4 inch Blue Clear (One kit per one square foot)

DG1BCR DG1BCR Decorative Glass, Crushed - 1/4 inch Copper Reective (One kit per one square foot)

DG1BZR DG1BZR Decorative Glass, Crushed - 1/4 inch Bronze Reective (One kit per one square foot)

Notice: Decorative crushed glass is required for installation. Clear Frost Crushed Glass is recommended. Decorative Glass Droplets

cannot be substituted for crushed glass. One box of crushed glass covers 1 sq. ft. Glass colors may be mixed, however transparent and

translucent crushed glass will allow LEDs to better shine through.

Notice:Requires ve square feet for VFLL60, six square feet for VFLL72.

Notice:Never place media material on or next to the burner.

Part Number Description

VFLL60 VFLL72

DFL601BL DFL721BL Decorative Front, Beveled, 1-inch, Black

DFL602BL DFL722BL Decorative Front, Beveled, 2-inch, Black

DFL602NB DFL722NB Decorative Front, Beveled, 3-inch, Brushed Nickel

VBP60LKR VBP72LKR Liner - Black Reective

VBP60LSS VBP72LSS Liner - Stainless Steel

LS60DF LS72DF Log Set

DG1AB DG1AB Decorative Glass Droplets - 1/2 inch Aqua Blue (One kit per one square foot)

DG1GC DG1GC Decorative Glass Droplets - 1/2 inch Glacier Ice (One kit per one square foot)

DG1SL DG1SL Decorative Glass Droplets - 1/2 inch Sangria Luster (One kit per one square foot)

DG1NXS DG1NXS Decorative Glass Drops - 1 inch Onyx Solid (One kit per one square foot)

DG1TZC DG1TZC Decorative Glass Drop - 1 inch Topaz Clear (One kit per one square foot)

DRFPA DRFPA Decorative Rock, Ceramic Fiber - Pebble (One kit per 1/2 square foot)

Notice: If installing a decorative front, an offset between the nishing materials and replace opening is required. Refer to page 25 and

29 as well as the installation instructions provided with the decorative front for more information.

Required Accessories

Optional Accessories

36776-0-0716Page 10

INTRODUCTION

Installation on Rugs and Tile

If this replace is installed directly on carpeting, tile or other

combustible material other than wood ooring the replace shall

be installed on a metal or wood panel extending the full width and

depth of the replace.

Qualied Installing Agency

Installation and replacement of gas piping, gas utilization

equipment or accessories and repair and servicing of equipment

shall be performed only by a qualied agency. The term qualied

agency means any individual, rm, corporation or company which

either in person or through a representative is engaged in and is

responsible for (a) the installation or replacement of gas piping or

(b) the connection, installation, repair or servicing of equipment,

who is experienced in such work, familiar with all precautions

required and has complied with all the requirements of the

authority having jurisdiction.

Commonwealth of Massachusetts: The installation must be

made by a licensed plumber or gas tter in the Commonwealth

of Massachusetts.

Sellers of unvented propane or natural gas-red supplemental

replaces shall provide to each purchaser a copy of 527 CMR

30 upon sale of the unit.

In the Commonwealth of Massachusetts, unvented propane

and natural gas-red space heaters shall be prohibited in

bedrooms and bathrooms.

The installation must conform with local codes or, in the absence

of local codes, with the National Fuel Gas Code, ANSI Z223.1.*/

NFPA 54.

*Available from the American National Standards Institute, Inc.

1430 Broadway, New York, N.Y. 10018.

High Altitudes

For altitudes/elevations above 2,000 feet (610m), ratings should

be reduced at the rate of 4 percent for each 1,000 feet (305m)

above sea level. Contact the manufacturer or your gas company

before changing spud/orice size.

Well Head Gas Installations

Some natural gas utilities use well head gas. This may affect the

Btu output of the unit. Contact the gas company for the heating

value. Contact the manufacturer before changing spud/orice

size.

Instructions to Installer

1. Leave instruction manual with owner after installation.

2. Have owner ll out and mail Product Registration Card

supplied with unvented replace.

3. Fill out Homeowner Reference Information on page 59.

4. Show owner how to start and operate unvented replace.

Always consult your local Building Department regarding

regulations, codes or ordinances which apply to the installation of

an unvented replace.

This replace may be installed in an aftermarket* manufactured

(mobile) home, where not prohibited by state or local codes.

*Aftermarket: Completion of sale, not for purpose of resale,

from the manufacturer.

WARNING

This appliance is equipped for natural or propane gas. Field

conversion is not permitted.

WARNING

Any change to this heaters or its controls can be dangerous.

Improper installation or use of the replace can cause serious

injury or death from re, burns, explosion or carbon monoxide

poisoning.

This replace is intended for supplemental heating.

Any alteration of the original design, installed other than as

shown in these instructions or use with a type of gas not shown

on the rating plate is the responsibility of the person and

company making the change.

Important

All correspondence should refer to complete Model Number,

Serial Number and type of gas.

During manufacture, this replace is treated with oils, lms and

bonding agents. These are not harmful but may produce smoke

and odor as they burn off during initial operation. This is normal.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Boulevard Kamin im Innenbereich Handbücher

Boulevard

Boulevard DVLL48SP90N-1 Kurzanleitung

Boulevard

Boulevard VFLB60SP90-1 Bedienungsanleitung

Boulevard

Boulevard LS60THF-1 DVLL60BP90N-1 Kurzanleitung

Boulevard

Boulevard VFLL72FP90LN-1 Kurzanleitung

Boulevard

Boulevard VFLL60SP90LP-1 Bedienungsanleitung

Boulevard

Boulevard DVLL41FP92N-1 Kurzanleitung

Boulevard

Boulevard LS60THF-1 DVLL60BP90N-1 Kurzanleitung

Boulevard

Boulevard VFLL60SP90LN-1 Bedienungsanleitung

Boulevard

Boulevard DVLL48NAT Kurzanleitung

Boulevard

Boulevard LS41TDF-1 Kurzanleitung

Boulevard

Boulevard DVLL48BP92N-1 Kurzanleitung

Boulevard

Boulevard VFSL30FP7010(N Kurzanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung