Bradford White Copper Brute II BWCH Bedienungsanleitung

User's Manual Document 1273A

H2361100A

WARNING

If the information in this manual is not

followed exactly, a re or explosion may

result causing property damage, personal

injury or loss of life.

Do not store or use gasoline or other

ammable vapors and liquids in the vicinity

of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not

use any phone in your building.

• Immediately call your gas supplier from a

nearby phone. Follow the gas supplier's

instructions.

• If you cannot reach your gas supplier, call

the re department.

Installation and service must be performed by a

qualied installer, service agency, or gas supplier.

FOR YOUR SAFETY: This product must be installed and serviced by a professional service technician,

qualied in boiler installation and maintenance. Improper installation and/or operation could create

carbon monoxide gas in ue gases which could cause serious injury, property damage, or death.

Improper installation and/or operation will void the warranty.

AVERTISSEMENT

Assurez-vous de bien suivres les instructions

données dans cette notice pour réduire au

minimum le risque d’incendie ou d’explosion

ou pour éviter tout dommage matériel, toute

blessure ou la mort.

Ne pas entreposer ni utiliser d’essence ni

d’autres vapeurs ou liquides inammables dans

le voisinage de cet appareil ou de tout autre

appareil.

QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:

• Ne pas tenter d’allumer d’appareils.

• Ne touchez à aucun interrupteur. Ne pas vous

servir des téléphones dansle bâtiment où

vous êtes.

• Appelez immédiatement votre fournisseur de

gaz depuis un voisin. Suivez les instructions

du fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de

gaz, appelez le sservice des incendies.

L’installation et l’entretien doivent être assurés par

un installateur ou un service d’entretien qualié ou

par le fournisseur de gaz.

User's Manual

for

Hydronic Boiler

Model BWCH

Water Heater

Model BWCV

Sizes 500-2000

U.S. Reg. 2,765,423

™

Copper Brute II

Page 2 Bradford White Corp

TABLE OF CONTENTS

SECTION 1.

Caring For Your Copper Brute II

1A. General Care ...................................................... 3

1B. Annual Inspection of Flues and Vents ................ 3

1C. Shutting Down the Copper Brute II .....................3

1D. To Restart the Copper Brute II ............................ 3

1E. In the Event of Power Failure ............................. 3

1F. Full Service Every 3 Years .................................. 3

Page 3

Copper Brute II (500-2000), Users Manual

SECTION 1.

Caring For Your Copper Brute II

Your Copper Brute II will require very little

Maintenance. However, as with any ne appliance

there are certain steps that should be taken to ensure

continuing optimum performance.

1A. General Care

Keep the area around the Copper Brute II clean

and free from combustible materials, gasoline and

other ammable liquids and vapors.

The Copper Brute II must be completely isolated

and protected from any source of corrosive chemical

fumes such as trichlorethylene, perchlorethylene,

chlorine, etc.

Keep grille openings on the boiler free for proper

ventilation of interior components.

Do not obstruct or block a free ow of air to the

boiler to ensure proper ventilation.

If desired, clean the jacket surfaces with a damp

cloth and mild detergent. Do not use ammable

cleaning materials.

If sidewall vented, keep the vent terminal clear

of obstructions — do not pile snow against the vent

terminal. Clean the air lter(s) often, and then develop

an appropriate maintenance schedule.

1B. Annual Inspection of Flue and Vents

Visually inspect the vent pipe once a year. Should

any deterioration exist, have the affected parts replaced

by a qualied service person.

1C. Shutting Down the Copper Brute II

1. Switch off the main electrical disconnect switch.

2. Close all manual gas valves.

3. If freezing is anticipated, drain the Copper Brute

II and be sure to also protect the building piping

from freezing. This step to be performed by a

qualied service person.

1D. To Restart the Copper Brute II

If drained, follow the Installation and

Operation Manual for proper lling and purging.

1. Switch off the main electrical disconnect switch.

2. Close all manual gas valves.

3. WAIT FIVE (5) MINUTES.

4. Set the aquastat or thermostat to its lowest

setting.

5. Open all manual gas valves.

6. Reset all safety switches (low water cut off,

manual reset high limit, etc.).

7. Set the temperature controller to the desired

temperature setting and switch on electrical

power.

8. Burner will go through a prepurge period and

ignitor warm-up period, followed by ignition.

1E. In the Event of a Power Failure

The Copper Brute II can not be operated during

an electrical power outage. If there is an extended

power outage with danger from freezing, then the

Copper Brute II (and all other water systems) should

be drained completely. When draining the boiler, turn

off main electrical disconnect switch. When placing

back in service, refer to start-up instructions in the

Installation and Operation Manual for lling and

purging. Draining and lling shall only be done by a

qualied service person.

1F. Full Service Every Three (3) Years

In addition to the annual visual inspections, a

qualied service agency should conduct a detailed

inspection of all ue product carrying areas of the

boiler and its venting system.

WARNING

Do not use this boiler if any part has been

under water. Immediately call a qualied

service technician to inspect the boiler and to

replace any part of the control system and any

gas control which has been under water.

WARNING

Should overheating occur or the gas supply

fail to shut off, do not turn off or disconnect the

electrical supply to the pump. Instead, shut

off the gas supply at a location external to the

boiler.

FOR SERVICE

Contact your installing contractor, gas utility,

Bradford White dealer, or call Bradford White

for the nearest authorized representative in

your area.

H2361100A

Ambler, PA 19002

Tech. Service (800) 334-3393

Service Parts (800) 538-2020 www.BradfordWhite.com

Warranty Service (800) 531-2111 Litho in U.S.A. © Bradford White 1501 Document 1273A

200 Lafayette St.

Middleville, MI 49333

Warranty: (800) 531-2111

Dieses Handbuch passt für folgende Modelle

Andere Bradford White Kessel Handbücher

Bradford White

Bradford White BRHHH Bedienungsanleitung

Bradford White

Bradford White Brute XTR Series Bedienungsanleitung

Bradford White

Bradford White BWCH Bedienungsanleitung

Bradford White

Bradford White Copper Brute II Bedienungsanleitung

Bradford White

Bradford White Brute MagnaTech HTD Bedienungsanleitung

Bradford White

Bradford White Brute Deluxe BMT2H0200 Betriebsanleitung

Bradford White

Bradford White Brute Elite BNTH Bedienungsanleitung

Bradford White

Bradford White Laars NEOTHERM NTH Series Betriebsanleitung

Bradford White

Bradford White LAARS OmniTherm OCH1250 Bedienungsanleitung

Bradford White

Bradford White FTCW199 Bedienungsanleitung

Bradford White

Bradford White Laars MINI-THERM JVH Betriebsanleitung

Bradford White

Bradford White Brute BNTH Bedienungsanleitung

Bradford White

Bradford White FT Series Bedienungsanleitung

Bradford White

Bradford White JVS Bedienungsanleitung

Bradford White

Bradford White Brute XTR Series Betriebsanleitung

Bradford White

Bradford White Laars Linc MagnaTherm FT CFH1000 Bedienungsanleitung

Bradford White

Bradford White Brute BNTH Bedienungsanleitung

Bradford White

Bradford White Brute OmniTech BONV2500 Betriebsanleitung

Bradford White

Bradford White brute elite 125 BLMH Bedienungsanleitung

Bradford White

Bradford White FT Series Betriebsanleitung

Bradford White

Bradford White Brute LX BLXCW-125 Bedienungsanleitung

Bradford White

Bradford White Copper Brute ll BWCH Bedienungsanleitung

Bradford White

Bradford White Brute Mini Bedienungsanleitung

Bradford White

Bradford White Brute MagnaTech BMGH1600 Bedienungsanleitung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung