Bushranger X-16 Bedienungsanleitung

COMMERCIAL SERIES

OPERATORS

MANUAL

2/24

BUSHRANGERTM X-16

X-16 Backpack Sprayer

3/24

BUSHRANGERTM X-16

COMMERCIAL SERIES

Operator's manual

Tank

Lever

Lance

Trigger valve

Diaphragm

Chamber

Nozzle

Lid

Hose

This manual contains information for the proper assembly, operation and

care of your sprayer.Carefully read and follow the instructions contained in

this manual before using your sprayer.

INTRODUCTION

SPRAYER VIEW

4/24

BUSHRANGERTM X-16

X-16 Backpack Sprayer

MODEL BushrangerX-16

Net weight 3.6kg

Tank

Capacity 16 (litres)

Material Polyethylene

Fill opening Ø 100 mm

PUMP

Type Piston

Material Brass

Working pressure 6 Kgf / cm

(max.)

Lance length 600 mm

Hose length 1350 mm

Nozzle tted JD 12P

Contents

of the

plastic

bag

Accessories plastic bag

Lever

Lance

Rod

Trigger valve

Manual

Tank

1 2

SPECIFICATIONS

5/24

BUSHRANGERTM X-16

COMMERCIAL SERIES

Introduce the shaft (1) in the free opening on the tank base

(on the same side of the chamber). Fit the shaft lock (2).



Be careful when taking the sprayer out of the

carton because the lever is loose and can

cause damage.

ATTENTION

INSTALLING THE SHAFT

Shaft lock (2)

Shaft (1)

INSTALLING THE LEVER



Lightly grease the orice on the top of the chamber.



Fit a at washer on the shaft and rod.



For easy assembly, install the lever on the shaft and the rod on the

chamber top at the same time.



Install the other at washers on the shaft and rod and lock

with the locked ring.

6/24

BUSHRANGERTM X-16

X-16 Backpack Sprayer

* Do not over tighten the screw cap.

1•Lance 2•Trigger



Push the lance into the trigger valve and secure

it with the screw cap.

ATTACHING THE LANCE TO THE TRIGGER VALVE

Rod

Lever Shaft

Locked ring Flat washers

Locked ring

7/24

BUSHRANGERTM X-16

COMMERCIAL SERIES



Before using the equipment, tighten the fastening nut (A).

IMPORTANT: This operation must be done by hand.

Do not use any type of tool.

TIGHTENING THE FASTENING NUT

ADJUSTING THE SHOULDER STRAP



The tank is contoured for the

operator's comfort. The shoulder

straps can be quickly adjusted to

properly position the sprayer on

the operator's back.

8/24

BUSHRANGERTM X-16

Handle

Buckle



Hold the strap buckle rmly with one hand, and pull the

handle downward with the other hand.

ATTENTION



After assembling the sprayer, ll the tank with clean water and pressure-

check the tank lid, diaphragm, tank bottom, lance and trigger valve for

leakage. Most leaks can be stopped by retightening the appropriate

connections and ttings. Any leakage must be repaired before returning

to service.

TIGHTENING



Hold the buckle rmly with one hand, and pull the strap

upward with the other hand.

LOOSENING

X-16 Backpack Sprayer

9/24

BUSHRANGERTM X-16

Filter assembly

Filter



After nishing the application, clean and wash all equipment in an approved

decontamination area.

MAINTENANCE



Remove all chemicals before storing the

sprayer. Chemical products have different

reactions and can damage the sprayer

components and environment as well as

cause personal injury.

ATTENTION

COMMERCIAL SERIES

10/24

BUSHRANGERTM X-16



Remove the pumping rod

from the chamber. Loosen

the gasket holder and

remove the assembly.



Remove the chamber (A)

from the cylinder (B). Clean

the ball (C) and the piston

cup (D); replace them if

necessary.

CYLINDER MAINTENANCE



Every 40 working hours, clean the chamber and lubricate the

components, as shown. Remove the chamber and lubricate the

piston cups.



Preferably, use graphite-base grease. It is recommended that you grease

with either silicone or vaseline. Do not apply grease excessively, this will

avoid clogging and impurities building up.

X-16 Backpack Sprayer

Inhaltsverzeichnis

Andere Bushranger Spritzpistole Handbücher

Bushranger

Bushranger X-15 Bedienungsanleitung

Beliebte Spritzpistole Handbücher anderer Marken

SNOWJOE

SNOWJOE Sunjoe 24V-GS-LTW-RM Bedienungsanleitung

Binks

Binks SV100 Bedienungsanleitung

Fimco

Fimco LG-4-3-1 Bedienungsanleitung

AG SPRAY

AG SPRAY FS-ATV-25BL Bedienungsanleitung

Nordson

Nordson MicroMax 2 Bedienungsanleitung

Bonide

Bonide 051 Bedienungsanleitung

zogics

zogics Z-DAS Bedienungsanleitung

KISANKRAFT

KISANKRAFT KK-KBS-165 Bedienungsanleitung

Matrix

Matrix SG 650 Bedienungsanleitung

Anest Iwata

Anest Iwata SGA-3 Kurzanleitung

paasche

paasche VV Datenblatt

Carlisle

Carlisle DeVilbiss JGA-510 Bedienungsanleitung

Gardena

Gardena 11120 Bedienungsanleitung

wiwa

wiwa 14025 R/F Bedienungsanleitung

Graco

Graco EM 390 Bedienungsanleitung

DeVilbiss

DeVilbiss LUNA2i Bedienungsanleitung

Graco

Graco HydroShield WMBH00 Stücklistenhandbuch

WAGNER

WAGNER W 125 Bedienungsanleitung