Calspas THE CHILL SPA Bedienungsanleitung

LTR20231170

9/23/2023

www.calspas.com

LTR2031170

9/23/2023

SINCE 1978

THE CHILL SPA

PLATINUM™SERIES

2023

Owner’s Manual

QUICK START GUIDEQUICK START GUIDE

LTR#117000937

LTR20231170

9/23/2023

www.calspas.com

IMPORTANT SAFETY INSTRUCTIONS

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

When using installing and using this spa, basic safety precautions should always be followed, including:

1. DANGER: RISK OF SEVERE INJURY OR DROWNING!

• DO NOT allow children to be in or around a spa unless a responsible adult supervises them.

• Keep the spa cover on and locked when not in use.

• See instructions enclosed with your cover for locking procedures.

2. DANGER: RISK OF SEVERE INJURY OR DROWNING!

• The suction ttings in this spa are sized to match the specic water ow created by the pump. Should the

need arise to replace the suction ttings, or the pump be sure the ow rates are compatibl1e.

• Never operate the spa if the suction tting or lter baskets are broken or missing. Never replace a suction

tting with one that is rated less than the ow rate marked on the original suction tting.

3. DANGER: RISK OF SEVERE INJURY FROM ELECTRIC SHOCK OR DEATH FROM ELECTROCUTION!

• Install the spa at least 5 feet (1.5 meters) from all metal surfaces. As an alternative, a spa may be installed

within 5 feet (1.5 meters) of metal surfaces if each metal surface is permanently bonded by a minimum #8

AWG solid copper conductor to the outside of the spa’s control box.

• DO NOT permit any external electrical appliances, such as lights, telephones, radios, televisions, and etc.,

within 5 feet (1.5 meters) of the spa. Never attempt to operate any electrical device from inside the spa.

• Replace a damaged power cord immediately.

• DO NOT bury the power cord.

• Connect to a grounded, grounding-type receptacle only.

4. WARNING: RISK OF HYPERTHERMIA (OVER-HEATING) CAUSING SEVERE INJURY, BURNS, WELTS

OR DEATH!

• Water temperature in excess of 104°F (40°C) may be injurious to your health.

• The spa water should never exceed 104°F (40°(). Water temperatures between l00°F (38°C) and 104° F (40°C)

are considered safe for a healthy adult.

• Lower water temperatures are recommended for young children and when spa use exceeds 10 minutes.

• Before using the spa, the user should measure the water temperature since the tolerance of water tempera-

ture-regulating devices varies.

5. WARNING: TO REDUCE RISK OF INJURY

• Prolonged exposure to hot air or water can induce hyperthermia. Hyperthermia occurs when the internal

temperature of the body reaches a level between 3°F (2°C) to 6°F (4°C) above the normal body temperature

of 98.6°F (37°C). While hyperthermia has many health benets, it is important not to allow you body’s core

temperature to rise above 103°F(39.5°C).

• High water temperatures have a high potential for causing fetal damage during pregnancy. Women who

are pregnant, or think they are pregnant should always check with their physician prior to spa usage.

• The use of alcohol, drugs or medication before or during spa use may lead to unconsciousness, with the

possibility of drowning.

LTR20231170

9/23/2023

www.calspas.com

10.

11.

12.

Do notpermita ny electricappliance, suchas a light,t elephone, radio,or television

within 5 feet(1.5 m) of a spa.

5.5 Hypothermia

Hypothermia occurs when the body’s temperature drops

below 95˚ F (35˚ C).

Signs of mild hypothermia (95˚ F to 89.6˚ F // 35˚ C to 32˚ C ) include:

Shivering and chattering teeth

Exhaustion

Clumsiness, slow movements and reactions; prone to falling

Sleepiness

Weak pulse

Fast heart rate (tachycardia)

Rapid breathing (tachypnea)

Pale skin color

Confusion and poor judgment/loss of awareness

6 Proper Ventilation: Proper ventilation of Chill Spa necessary for optimal operation.

The Chill Spa uses a water chiller which will generate warm exhaust air from the cooling of the Chill Spa. The

Chill Spa is designed for outdoor use, for proper airow allow up to 3’ - 5’ feet of space around the unit

without obstructions. DO NOT OBSTRUCT THE EXHUAST VENTS, blocking these vents will be dentrimental

to the operation of the Chill Spa, with higher energy consuption and slower cooling speeds.

Never install the unit in a closed room with a limited air volume in which the exhaust air expelled from

the unit will be reused, or close to shrubbery that could block the air inlet. Suchlocations impair the

continuous supply of fresh air, resulting in reduced eciency and possibly preventing sucient

cooling/heating output.

DO NOT USE THE CHILL SPA FOR

EXTENDED PERIODS OF TIME

Extended use of the chill spa in

tempertures bellow 60F can increase

your risk of hypothermia.

Contact medical services if

symptoms of hypothermia arise.

Call 911 in a medical emergency.

LTR20231170

9/23/2023

www.calspas.com



 





















 





















































































































































































































































































































































































 









 















□



□





□





□





□



□



































        

      









 









LTR20231170

9/23/2023

www.calspas.com

Chill Spa Quick Start Guide

1. Remove Filter Skimmer.

Remove the Skimmer from the lter housing by gently pulling

upward, this must be reinstalled after the spa has been filled up

and primed. ENSURE THE SPA POWER IS OFF DURING DRAIN

AND DURING REFILL.

2. Remove The Filter .

Once the skimmer is removed, the lter can be removed by

holding the lter by the tab, turning counter-clockwise. Once

the lter is removed, soak the lter in water for about 15 minutes

before reinstallation.

3. Filling the Chill Spa.

Preventing airpockets in the plumbing is essential, for this reason

insert the hose through the lter canister to prevent air pockets

from forming. failure to do so can cause damage to the

refrigeration system.

NOTE: Never ll your spa with soft water.

Soft water makes it impossible to maintain the proper water

chemistry and may cause the water to foam, which will ultimately

harm the nish of the spa and void your warranty.

You may ll your ll your spa with well water provided the fol-

lowing conditions are met: Have a Total Dissolved Solids (TDS)

and metals test performed by a qualied person after the ll-up

process but before any spa use

LTR20231170

9/23/2023

www.calspas.com

Chill Spa Quick Start Guide

4. Water level

Fill the spa up to 4’’ from the rim of the spa. Once the Chill Spa is lled

reinstall the lter clockwise. DO NOT OVER TORQUE/TIGHTEN this can

damage the damage the lter housing over time. once the lter is back

in its place you can slide the skimmer back onto the lter housing. the

skimmer slides into the hilter housing with two sliding tabs on the top of

the skimmer.

The water level will shift once a person enters the Chill Spa, adjust your

water level based on the shift of the waterline once the unit is being

used.

5. Connect the Chill Spa to power.

Using the supplied 15 amp GFCI plug, connect it to the outlet running

from the dedicated 15 amp circuit. Once connected press the“jets”

button to prime the internal pump.

6. Programing the Cooling unit.

Begin by using the main spa controls and hold the button for 2

seconds and the temperture will appear on the display. once it does you

may let go of that button and press the cool button to lower the spa

to 39 F, once that is done press the“Set” button to save the desired

temperture. Additional programing may be needed.

Refer to page 25 if after one hour has passed and the temperture has not

lowered.

7. Open Air Vents.

Once water is circulating, press the switch on the left hand side of the

Chill spa to open and close the air vent. When the air vents are opened

this allows more pressure to exit the jets for a deeper massage. this will

assist in clearing the plumbing of any air pockets.

Note: The Chill Spa has several paths for condensation to exit. A

small pool of water forming on the base of the spa is considered

normal. The amount of condensation varies based on the weather

and ambient humidity.

LTR20231170

9/23/2023

www.calspas.com

Setting Temperature and Time

This Chill Spa is equipped with a SmarTouch Control System.

SmarTouch Digital comes to you with a universal set of default settings. If you choose to keep these set-

tings, then you only need to remember 2 things: how to set the spa temperature and to press the SET key

whenever you are done using the spa.

WIRING DIAGRAM FOR SC-1100 (JR.)

WIRING DIAGRAM FOR SC-3000

IN A HURRY - READ THIS

SmarTouch Digital comes to you with a universal set of default

settings. If you choose to keep these settings, then you only

need to remember 2 things: how to set the spa temperature and

to press the SET key whenever you are done using the spa.

Setting Temperature

The UP(TEMP) & DOWN(TIME) arrows.

Press and hold for 2 sec. the UP (TEMP) arrow key.

Controller will display current spa temperature.

Use the UP or DOWN arrow keys to select

desired temperature.

*To enter new temperature press → SET key.

The controller will:

- Lock-in the new temperature.

- Display current spa temperature.

IMPORTANT: Always turn down the heat before you drain the spa.

*Note:

Both buttons are used to select, increase

or decrease temperature or time setting.

Note: Both keys are active when pressed

individually and held down 2 seconds, to

eliminate accidental changes.

Page 23

If no buttons asre pressed the screen will reset within 30 seconds the

controller reverts to the previous setting and the change will not take

effect.

The SET Key

After using the spa, press the SET key to tell the micro controller you

are done using the spa. It will then take over the spa’s management,

including the different filtration cycles, heat maintenance, economy

modes and protection against freezing.

Page 4

LTR20231170

9/23/2023

www.calspas.com

Setting Temperature and Time

SETTING TIME-OF-DAY

Setting Time-Of-Day

Press and hold for 2 sec. the DOWN (Time) arrow key.

Controller will display 12:00 noon. Use OR to set the

correct time-of-day.

*After every selection “Hours , Minutes” press

→

SET key.

Cool-Down Timer

A 30-second timer keeps the low speed jets, ON, after the heater turns

OFF, to remove all residual heat from the heater element.

User Timer

A built-in, 20 minutes elapsed-time clock switches off any active function.

Economy mode. Water & Energy Management.

The Economy mode manages water temperature, filtration and energy

consumption knowing “when” to heat to maintain water temperature.

The Economy mode starts when the heater is turned off and the spa is

not in use.

Upon entering the ECONOMY mode the message “ECON” is displayed.

During the Economy mode the spa controller is in stand-by, three hours

at a time, monitoring and sampling the water temperature.

At the end of every Economy period which is 3 hours the controller ac-

tivates the low jets only for 5 minutes to perform the following:

1-Filter and sanitize the water. Check your spa manual for the type of

sanitizer in your spa.

2- Stabilize the water temperature and heat if necessary, in that case the

low jets run more than 5 minutes for the duration of the heating cycle.

Important: Tie down your spa cover to minimize heat loss and to con-

serve energy.

Note: The message “ECON” is not an error code.

WIRING DIAGRAM FOR SMTD 1000

WIRING DIAGRAM FOR SMTD 2000

COM2

J14

Page 5 Page 22

NOTES

___________________________________

NOTES

___________________________________

Inhaltsverzeichnis

Andere Calspas Whirlpool Handbücher

Calspas

Calspas Avalon A526 Bedienungsanleitung

Calspas

Calspas F-1325 Bedienungsanleitung

Calspas

Calspas PATIO Bedienungsanleitung

Calspas

Calspas ESCAPE Bedienungsanleitung

Calspas

Calspas PATIO Bedienungsanleitung

Calspas

Calspas Inground Series Bedienungsanleitung

Calspas

Calspas 2006 Portable spas Bedienungsanleitung

Calspas

Calspas Avalon A726B Bedienungsanleitung

Calspas

Calspas Home Resort Z-524L Bedienungsanleitung

Calspas

Calspas LTR20101058 Bedienungsanleitung

Calspas

Calspas Spa Wrap Bedienungsanleitung

Calspas

Calspas Villa Spa Home Resort Bedienungsanleitung

Calspas

Calspas Rejuvenation Series Bedienungsanleitung

Calspas

Calspas Portable Spas Bedienungsanleitung

Calspas

Calspas LTR20111058 Bedienungsanleitung

Calspas

Calspas Portable Spa Bedienungsanleitung

Calspas

Calspas Swim-Pro F-1641 Bedienungsanleitung

Calspas

Calspas Home Resorts FA-1325 Bedienungsanleitung

Calspas

Calspas Platinum Series Bedienungsanleitung

Calspas

Calspas Platinum Series Bedienungsanleitung

Calspas

Calspas 5100 Bedienungsanleitung

Calspas

Calspas GFCI Bedienungsanleitung

Calspas

Calspas Home Resorts Escape Series Bedienungsanleitung

Calspas

Calspas LTR20051000 Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Jacuzzi

Jacuzzi ARGA ARG101C0110 Stücklistenhandbuch

Morphy Richards

Morphy Richards Essentials PC4006 Bedienungsanleitung

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6042 Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

Jacuzzi

Jacuzzi alimia Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung