Carrier KGALB0101KIT Bedienungsanleitung

KGALB0101KIT

Installation Instructions

LABEL KIT FOR FIXED SPEED, 2---STAGE

AND VARIABLE SPEED, 33.3 IN (846 MM)

MULTIPOISE, NON---CONDENSING FURNACES

NOTE: Read the entire instruction manual before starting the

installation

SAFETY CONSIDERATIONS

FIRE, EXPLOSION, ELECTRICAL SHOCK

HAZARD

Failure to follow this warning could result in personal

injury, death and / or property damage.

Improper installation, adjustment, alteration, service,

maintenance, or use can cause carbon monoxide poisoning,

explosion, fire, electrical shock, other conditions, which

could result in personal injury or death. Consult your

distributor or branch for information or assistance. The

qualified installer or agency must use only factory--

authorized kits or accessories when servicing this product.

!WARNING

Installing and servicing heating equipment can be hazardous due

to gas and electrical components. Only trained and qualified

personnel should install, repair, or service heating equipment.

Untrained personnel can perform basic maintenance functions

such as cleaning and replacing air filters. All other operations

must be performed by trained service personnel. When working

on heating equipment, observe precautions in the literature, on

tags, and on labels attached to or shipped with the unit, and other

safety precautions that may apply.

Follow all safety codes. In the United States, follow all safety

codes including the National Fuel Gas Code (NFGC) NFPA No.

54--2006/ANSI Z223.1--2009. In Canada, refer to the National

Standard of Canada, Natural Gas and Propane Installation Codes

(NSCNGPIC), CAN/CGA--B149.1 and .2--2010.

Wear safety glasses and work gloves. Have a fire extinguisher

available during start--up, adjustment procedures, and service

calls.

Recognize safety information. This is the safety--alert symbol !

When you see this symbol on the furnace and in instructions or

manuals, be alert to the potential for personal injury.

Understand the signal words DANGER, WARNING,

CAUTION, and NOTE. The words DANGER, WARNING, and

CAUTION are used with the safety--alert symbol. DANGER

identifies the most serious hazards which will result in severe

personal injury or death. WARNING signifies hazards which

could result in personal injury or death. CAUTION is used to

identify unsafe practices which would result in minor personal

injury, or product and property damage. NOTE is used to

highlight suggestions which will result in enhanced installation,

reliability, or operation.

INTRODUCTION

This instruction covers the installation of safety, service and

information labels used on Fixed Speed, 2--speed and

Variable--speed, 80 AFUE, 33.3--in. (846mm) high, induced--

combustion furnaces.

Table 1 – Kit Contents

PART NUMBER PART NAME

327558--- 101 Label, Warning

336996--- 101 Label, Clearance, and Warning

327801--- 201 Label, Info

337802--- 201 Label, Info

337803--- 201 Label, Info

I I K --- K G A L B --- 0 4 Installation Instructions

DESCRIPTION AND USAGE

This kit may be used to replace labels that are upside--down when the furnace is installed in the Downflow position. Only the labels that are

upside--down when the outer door and blower access door is installed are included in this kit. The unit rating plate is NOT included in this kit.

The unit rating plate is unique to each furnace and is not considered a service item.

Use the following tables to determine the correct label for the following furnaces:

STANDARD MODEL DELUXE MODEL 2 --- S P E E D M O D E L VARIABLE SPEED MODEL

Label Number 58STA/STX 58DLA/DLX

58PHA/PHX 58CTA/CTX 58CVA/CVX

327558--- 101 X X X X

336996--- 101 X X X X

337801--- 201 X X N/A N/A

337802--- 201 N/A N/A XN/A

337803--- 201 N/A N/A N/A X

X --- L a b e l u s e d

STANDARD MODEL DELUXE MODEL 2 --- S P E E D M O D E L VARIABLE SPEED MODEL

Label Number 310AAV/JAV 311AAV/JAV

313AAV/313JAV 312AAV/JAV 315AAV/JAV

327558--- 101 X X X X

336996--- 101 X X X X

337801--- 201 X X N/A N/A

337802--- 201 N/A N/A XN/A

337803--- 201 N/A N/A N/A X

X --- L a b e l u s e d

STANDARD MODEL DELUXE MODEL VARIABLE SPEED MODEL

Label Number PG8MAA/PG8JAA PG8MEA/PG8JEA PG8MVA/PG8JVA

327558--- 101 XXX

336996--- 101 XXX

337801--- 201 X X N/A

337802--- 201 N/A N/A N/A

337803--- 201 N/A N/A X

X --- L a b e l u s e d

APPLY THE CORRECT LABELS

1. From the unit rating plate and the tables above, determine the correct labels required.

2. Turn off electrical power to furnace at service switch, fuse, or circuit breaker.

3. Remove outer door and blower access door.

4. It is not necessary to remove old labels from doors. However, doors must be dry and free of dust, dirt, grease and oil. If necessary,

clean old label surfaces with household glass or surface cleaners.

5. Remove the paper backing from the appropriate label.

6. Orient the label in the correct position and apply over the surface of the old label. Prevent air bubbles in the new label by applying the

label at one corner and smooth the label out, working toward the opposite corner.

7. Repeat for the other labels.

8. Re--install the blower access door and unit outer door.

9. Turn on electrical power to furnace.

10. Check furnace for correct operation (refer to furnace Installation Instructions.)

Manufacturer reserves the right to change, at any time, specifications and designs without notice and without obligations.

C a t a l o g N o : I I K --- K G A L B --- 0 4

Replaces: IIK--KGALB--02

Printed in U.S.A. Edition Date: 02/12

Inhaltsverzeichnis

Andere Carrier Ofen Handbücher

Carrier

Carrier Performance 59TP5A Series Bedienungsanleitung

Carrier

Carrier PG96VAT Bedienungsanleitung

Carrier

Carrier 58DRC Bedienungsanleitung

Carrier

Carrier Infinity 96 58UVB Bedienungsanleitung

Carrier

Carrier 58RAV Series Bedienungsanleitung

Carrier

Carrier 130 Series Anleitungen und Rezepte

Carrier

Carrier 58SSC Anleitungen und Rezepte

Carrier

Carrier 58PHA/PHX Installation, start-up, operating... Bedienungsanleitung

Carrier

Carrier 800SA Leitfaden

Carrier

Carrier UPFLOW INDUCED-COMBUSTION FURNACES 58PAV Installations- und Benutzerhandbuch

Carrier

Carrier 101 Series Anleitungen und Rezepte

Carrier

Carrier Series 100 Installations- und Benutzerhandbuch

Carrier

Carrier 58CLA Leitfaden

Carrier

Carrier GAS FURNACE 58MXA Anleitungen und Rezepte

Carrier

Carrier 58GC Bedienungsanleitung

Carrier

Carrier 58UVB series Anleitungen und Rezepte

Carrier

Carrier 58CMR Leitfaden

Carrier

Carrier 986TC Leitfaden

Carrier

Carrier KGBFR0401B14 Bedienungsanleitung

Carrier

Carrier 58DFA Installations- und Benutzerhandbuch

Carrier

Carrier UPFLOW INDUCED-COMBUSTION FURNACES 58PAV Bedienungsanleitung

Carrier

Carrier 58EJA Leitfaden

Carrier

Carrier R95ESN Leitfaden

Carrier

Carrier 58ADP Abmessungen und Installationsanleitung

Beliebte Ofen Handbücher anderer Marken

Armstrong

Armstrong EG7H SERIES Bedienungsanleitung

Payne

Payne PG92ESA Leitfaden

SUPREME

SUPREME FEM10-M2301CM-A Montageanleitung

Ingersoll-Rand

Ingersoll-Rand S9V2B080D4VSAC/D Montageanleitung

Johnson Controls

Johnson Controls TM9T Leitfaden

Fluke

Fluke 9118A Bedienungsanleitung

Lennox

Lennox EL195UHE Elite Series Installations- und Betriebshandbuch

Intertherm

Intertherm M7RL Series Bedienungsanleitung

HDG

HDG Pelletmaster 15 Bedienungsanleitung

Pinnacle

Pinnacle Aero Bella AB-716C-QH Handbuch

Nortek

Nortek MG2S Series Bedienungsanleitung

VERDER

VERDER CARBOLITE GERO ABF 8/28 Handbuch

Goodman

Goodman GMV9 Handbuch

SUPREME

SUPREME SUP10-M2301C Montageanleitung

Dettson

Dettson AMT400B34-SM1PMA Montageanleitung

Evcon

Evcon DGD 60 MBH Bedienungsanleitung

Trane

Trane S8B1A026M2PSAB Montageanleitung

Hart Sceintific

Hart Sceintific 9113 Bedienungsanleitung