Catalina 310 Bedienungsanleitung

CATALINA 310

OWNER'S

MANUAL

Revised

5/1100

FOREWORD

Congratulations on the acquisition of your new Catalina Yacht. All Catalina

yachts are designed and built with care using quality materials to assure you

years of sailing enjoyment with a minimum of upkeep and maintenance.

Before attempting maintenance or operation of your Catalina Yacht, please

read the Catalina Yachts Limited Warranty booklet and fill out the enclosed

warranty registration card.

The registration card enables Catalina to inform you of developments and

modifications to enhance the performance or comfort of your yacht. It is

also important to be able to contact owners to comply with Coast Guard

defect notification requirements.

The launching and rigging of your Catalina Yacht should be handled by

experienced boat yard personnel under the direction of your authorized

dealer.

The index page lists the contents of this manual. Warrantees and

information regarding installed optional equipment have been included when

available and applicable.

Maintaining your yacht properly can become a satisfying part of your sailing

activities. A regular inspection is the best preventive maintenance. It will

help keep your boat safe and in good condition while in use, and insure

peace of mind when the boat is left unattended.

Take good care of your boat and take the time to learn and practice good

seamanship.

PREFACE

This manual is intended and supplied to help owners of Catalina Yachts

understand their boats and answer common questions about maintenance and

systems design specific to their boat.

This manual is not intended to provide sailing instructions. It is assumed the

operator will consult books written for that purpose, or take sailing lessons

or courses to gain knowledge necessary for the safe operation of the vessel.

The systems descriptions and illustrations in this manual apply to boats built

at the time of publication. Our policy of constant improvement necessitates

that changes have been made to the boat since its introduction. Therefore,

these illustrations and descriptions may not apply to boats built before the

time of publication.

Owners of earlier hulls, who have questions not answered herein should

consult with their local Catalina dealer, or write to, or e-mail Catalina

Yachts. Please include your hull number in all correspondence.

The maintenance check lists contained within this manual are intended as

guidelines for boats in normal service under typical conditions.

Climate and use will vary and may require additional or special

maintenance. Consult with your local boat yard or Catalina dealer for

specific maintenance and precautions recommended for your purposes and

climate.

Caution: The aluminum and other metal parts conduct electricity. Coming

in contact with or near an electrical power line or lightening can cause

severe injury or death. Stay away from overhead electrical power lines

when sailing and or launching the boat.

TABLE OF CONTENTS

PAGE

Forward

Preface

Table of Contents

Commissioning Check List

Maintenance Check List

Specifications

Sail Plan

Spar and Rigging Maintenance

Rigging Lengths

Deck Plan

Mainsheet Arrangement

Mainsheet Traveler

Boom Yang

Solid Yang and Purchase

Halyards Arrangement

Shroud Rigging

Mast Sub Assembly

Boom

Outhaul Assembly

Electrical 12 Volt DC 32

Electrical Plan, DC 35

Mast Light Wiring 37

Electrical, AC 1101115 Volt 38

AC Plan 40

115 VAC Wiring Diagram 41

230 VAC Wiring Diagram 42

Control Panel 230 VACI12 VDC 43

Plumbing 45

Plumbing Plan 48

Head Plumbing 49

Auxiliary Power 50

Packing Gland 55

Prop Shaft and Log Alignment Procedure 56

Shaft Alignment Illustration 57

25XP Harness to Seaward Helm Pod 58

Steering 59

Accommodation 60

Accommodations Plan 62

LPG Plan 63

Decommissioning 64

OwnerlUser Responsibility 67

Lightning Protection 70

Commissioning Package 79

Literature and warranties for equipment, which may be supplied 80

with this manual.

Equipment and Materials Log 81

COMMISSIONING CHECK LIST

This check list is intended as a guide to aid in the proper delivery and commissioning of a new boat to the

originator purchaser. It may also be useful to review this list each time the boat is recommissioned after

storage.

PRE-LAUNCH CHECK: (before stepping mast)

1. Shaft turns freely by hand, zinc collar installed if required.

2. Check intake hoses and clamps.

3. __ Check all through hull fittings.

4. Drain plugs tight, __ engine, muffler and exhaust line OK.

5. Bottom clean, paint OK.

6. Hull sides clean, gel coat OK.

7. Decks clean, gel coat OK.

8. Interior varnish OK.

9. Cushions, curtains, clean and in place.

10. Lifelines, pelican hooks and pulpits rigged and OK.

11. Spreaders taped at base end, upper shroud and intermediate wired to tip end and

taped or boots installed.

12. Rigging lengths verified with check list in kit.

13. Mast and boom inspected; cotter pins, sheaves, tangs, spreaders, reef lines, outhaul,

OK.

14. Mast lights checked before mast stepped

15. Check overhead for electrical wires which may interfere with the space

required to raise the mast to its full upright position. If there are wires

of any kind anywhere near the boat. Do not raise the mast. Move boat

to any other location away from any wires. Contact with wires can be

fatal.

16. Masthead sheaves lubricated and rotate freely.

ELECTRICAL:

1. Lights operational:

_Running _Cabin _Bow _Anchor _Deck Light

2. Pumps Operational: _Pressure Water _Macerator Pump _Bilge Pump

3. Shore power outlet OK.

4. __ Check battery switch #1_ #2_ OK.

5. Check battery fluid level.

6. Check battery terminal for tightness.

7. Check battery tie down straps.

PLUMBING AND INTERIOR:

1. No leaks at through hull fittings with seacocks open or closed.

2. Fill all water tanks.

3. Check all water tanks at fittings and vents for leaks.

4. Test all faucets and foot pumps for leaks.

5. Check for leaks at sink drain, sink drains OK.

6. Put water in ice box and check for proper drainage.

7. Check manual bilge pump operation, handle present.

8. Check head by flushing and pumping.

9. Check shower sump drain line.

IO. Check holding tank, pump vent and fitting.

11. Check head and pump handle for leaks.

12. Main hatch no leaks, slides freely, hatch boards fit OK.

13. Cabin windows hose tested for leaks.

14. Anchor locker drains OK, no Leaks.

15. Stove operates OK; check tank, fuel line, burner and oven.

RIGGING AND HARDWARE:

1. Mast stepped.

2. Pin, tape and tune standing rigging

3. Blocks, cars, cleats rigged OK.

4. Test all winches, winch handles present.

5. Boom vang supports boom

6. Check chainplates for leaks (*note

Inhaltsverzeichnis

Andere Catalina Boot Handbücher

Catalina

Catalina 350 Bedienungsanleitung

Catalina

Catalina 36 Bedienungsanleitung

Catalina

Catalina Jenny Lane Bedienungsanleitung

Catalina

Catalina 250 Bedienungsanleitung

Catalina

Catalina C-22 1977 Bedienungsanleitung

Catalina

Catalina Capri 22 Bedienungsanleitung

Catalina

Catalina 22 1977 Bedienungsanleitung

Catalina

Catalina 250 Bedienungsanleitung

Catalina

Catalina Expo 14.2 Bedienungsanleitung

Catalina

Catalina 34 MK II Bedienungsanleitung

Catalina

Catalina Expo 12.5 Bedienungsanleitung

Beliebte Boot Handbücher anderer Marken

Raymarine

Raymarine ST70 Instrument Bedienungsanleitung

Pro-Line Boats

Pro-Line Boats Pro Line 19 Sport Bedienungsanleitung

Jeanneau

Jeanneau CAP CAMARAT 8.5 CC Bedienungsanleitung

Tiara Yachts

Tiara Yachts C49 2024 Bedienungsanleitung

Monterey Boats

Monterey Boats Sport Yacht 330 Bedienungsanleitung

J 105 Bedienungsanleitung

PURSUIT

PURSUIT OS 335 Bedienungsanleitung

Boston Whaler

Boston Whaler CONQUEST 345 Bedienungsanleitung

Jeanneau

Jeanneau SUN ODYSSEY 41 DS Bedienungsanleitung

Meridian

Meridian 490 Pilothouse Bedienungsanleitung

Advanced Elements

Advanced Elements AdvancedFrame Expedition AE1009 Bedienungsanleitung

Robo Marine Indonesia

Robo Marine Indonesia GEOMAR Bedienungsanleitung

Swallow Boats

Swallow Boats BayRaider Bedienungsanleitung

Intex

Intex Excursion 5 Set Bedienungsanleitung

X SHORE

X SHORE EELEX 8000 Bedienungsanleitung

ISLAND PACKET

ISLAND PACKET 370 Bedienungsanleitung

Sea Ray

Sea Ray 175 Sport Bedienungsanleitung

Regal

Regal 2300 Bedienungsanleitung