Champion 100414 Bedienungsanleitung

OPERATOR'S MANUAL

MODEL #100414

2000W PORTABLE

INVERTER GENERATOR

REV 20220309 Champion Power Equipment, Inc., Santa Fe Springs, CA USA

or visit championpowerequipment.com

READ AND SAVE THIS MANUAL. This manual contains important safety precautions which should be read and understood before operating the product. Failure to

do so could result in serious injury. This manual should remain with the product.

Speciﬁcations, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice.

at championpowerequipment.com

100414 - 2000W PORTABLE INVERTER GENERATOR TABLE OF CONTENTS

TABLE OF CONTENTS

Introduction.................................................. 3

Safety Deﬁnitions ......................................... 3

Important Safety Instructions...................... 4

Fuel Safety ........................................................ 6

Safety Labels...................................................... 7

Safety Symbols.................................................... 8

Operation Symbols ................................................ 9

Quick Start Label Symbols.......................................10

Controls and Features .................................11

Generator .........................................................11

Power Panel ......................................................12

Outlet Panel ......................................................13

Parts Included ....................................................13

Assembly.....................................................14

Unpacking ........................................................14

Add Engine Oil....................................................14

Add Fuel ..........................................................15

Grounding ........................................................16

Operation.....................................................16

Generator Location...............................................16

Surge Protection .................................................17

Starting the Engine...............................................17

Connecting Electrical Loads .....................................18

Do Not Overload Generator ......................................18

Eco (Economy) Mode.............................................19

12V DC Automotive Style Outlet .................................19

Parallel Operation ................................................20

Stopping the Engine..............................................20

Maintenance............................................... 20

Cleaning the Generator ..........................................20

Changing the Engine Oil .........................................21

Cleaning and Adjusting the Spark Plug(s) .......................21

Cleaning the Air Filter ............................................21

Cleaning the Spark Arrestor .....................................21

Replacing Fuel Light Batteries...................................22

Adjusting the Governor...........................................23

Maintenance Schedule...........................................23

Storage ....................................................... 23

Short Term Storage (up to 1 year) ...............................23

Long Term Storage (more than 1 year)..........................24

Removing from Storage..........................................24

Speciﬁcations............................................. 25

Generator Speciﬁcations.........................................25

Engine Speciﬁcations ............................................25

Oil Speciﬁcations.................................................25

Fuel Speciﬁcations ...............................................25

Temperature Speciﬁcations......................................25

ICES–002 Warning...............................................25

Troubleshooting.......................................... 26

Warranty* ................................................... 27

Warranty Qualiﬁcations ..........................................27

Repair/Replacement Warranty...................................27

Do Not Return The Unit To The Place Of Purchase .............27

Warranty Exclusions .............................................27

Other Exclusions .................................................27

Limits of Implied Warranty and Consequential Damage........27

Contact Information ..............................................27

100414 - 2000W PORTABLE INVERTER GENERATOR INTRODUCTION

INTRODUCTION

Congratulations on your purchase of a Champion Power Equipment

(CPE) product. CPE designs, builds, and supports all of our

products to strict speciﬁcations and guidelines. With proper

product knowledge, safe use, and regular maintenance, this

product should bring years of satisfying service.

Every effort has been made to ensure the accuracy and

completeness of the information in this manual at the time of

publication, and we reserve the right to change, alter and/or

improve the product and this document at any time without prior

notice.

Since CPE highly values how our products are designed,

manufactured, operated and are serviced, and also highly value

your safety and the safety of others, we would like you to take the

time to review this product manual and other product materials

thoroughly and be fully aware and knowledgeable of the assembly,

operation, dangers and maintenance of the product before use.

Fully familiarize yourself, and make sure others who plan on

operating the product fully familiarize themselves too, with the

proper safety and operation procedures before each use. Please

always exercise common sense and always err on the side

of caution when operating the product to ensure no accident,

property damage, or injury occurs. We want you to continue to use

and be satisﬁed with your CPE product for years to come.

When contacting CPE about parts and/or service, you will need to

supply the complete model and serial numbers of your product.

Transcribe the information found on your product’s nameplate

label to the table below

CPE TECHNICAL SUPPORT TEAM

1-877-338-0999

MODEL NUMBER

100414

SERIAL NUMBER

DATE OF PURCHASE

PURCHASE LOCATION

SAFETY DEFINITIONS

The purpose of safety symbols is to attract your attention to

possible dangers. The safety symbols, and their explanations,

deserve your careful attention and understanding. The safety

warnings do not by themselves eliminate any danger. The

instructions or warnings they give are not substitutes for proper

accident prevention measures.

DANGER

DANGER indicates a hazardous situation which,if not avoided,

will result in death or serious injury.

WARNING

WARNING indicates a hazardous situation which, if not

avoided, could result in death or serious injury.

CAUTION

CAUTION indicates a hazardous situation which, if not avoided,

could result in minor or moderate injury.

NOTICE

NOTICE is used to address practices not related to physical

injury.

100414 - 2000W PORTABLE INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS

IMPORTANT SAFETY INSTRUCTIONS

DANGER

Generator exhaust contains carbon monoxide, a colorless,

odorless, poisonous gas. Breathing carbon monoxide will

cause nausea, dizziness, fainting or death. If you start to feel

dizzy or weak, get to fresh air immediately.

OPERATE GENERATOR OUTDOORS ONLY IN A WELL

VENTILATED AREA AND POINT EXHAUST AWAY.

DO NOT operate the generator inside any building, including

garages, basements, crawlspaces and sheds, enclosure or

compartment, including the generator compartment of a

recreational vehicle.

DO NOT allow exhaust fumes to enter a conﬁned area through

windows, doors, vents or other openings.

DANGER

Using a generator indoors CAN KILL YOU IN MINUTES.

Generator exhaust contains carbon monoxide. This is a poison

you cannot see or smell.

NEVER use inside a home or garage, EVEN IF doors and

windows are open.

ONLY use OUTSIDE and far away from windows, doors,

and vents.

Install battery-operated carbon monoxide alarms or plug-in

carbon monoxide alarms with battery back-up according to the

manufacturer’s instructions.

WARNING

Although the generator contains a spark arrester, maintain

a minimum distance of 5 ft. (1.5 m) from dry vegetation to

prevent ﬁres.

DANGER

Operate equipment with guards in place.

Rotating parts can entangle hands, feet, hair, clothing and/or

accessories. Traumatic amputation or severe laceration can

result.

Keep hands and feet away from rotating parts.

Tie up long hair and remove jewelry.

DO NOT wear loose-ﬁtting clothing, dangling drawstrings or

items that could become caught.

DANGER

Generator produces powerful voltage.

DO NOT touch bare wires or receptacles.

DO NOT use electrical cords that are worn, damaged or frayed.

Use only Champion electrical cords for proper application.

DO NOT operate generator in wet weather.

DO NOT allow children or unqualiﬁed persons to operate or

service the generator.

Use a ground fault circuit interrupter (GFCI) in damp areas and

areas containing conductive material such as metal decking.

Connection to your home’s electrical system requires a

listed 30A transfer switch installed by a licensed electrician

and approved by the local authority having jurisdiction. The

connection must isolate the generator from the utility power

and must comply with all applicable laws and electrical codes.

WARNING

Do not use generator for medical and life support uses.

In case of emergency, call 911 immediately.

NEVER use this product to power life support devices or life

support appliances.

NEVER use this product to power medical devices or medical

appliances.

Inform your electricity provider immediately if you or anyone in

your household depends on electrical equipment to live.

Inform your electrical provider immediately if a loss of power

would cause you or anyone in your household to experience a

medical emergency.

100414 - 2000W PORTABLE INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS

WARNING

Spark from removed spark plug wire can result in ﬁre or

electrical shock.

When servicing the generator:

Disconnect the spark plug wire and place it where it cannot

contact the plug or any other metal object.

DO NOT check for spark with the plug removed.

Use only approved spark plug testers.

WARNING

Running engines produce heat. Severe burns can occur on

contact. Combustible material can catch ﬁre on contact.

DO NOT touch hot surfaces.

Avoid contact with hot exhaust gases.

Allow equipment to cool before touching.

Maintain at least 3 ft. (91.4 cm) of clearance on all sides to

ensure adequate cooling.

Maintain at least 5 ft. (1.5 m) of clearance from combustible

materials.

WARNING

Rapid retraction of the recoil cord will pull hand and arm

towards the engine faster than you can let go. Broken bones,

fractures, bruises or sprains could result. Unintentional

startup can result in entanglement, traumatic amputation or

laceration.

When starting engine, pull the recoil cord slowly until

resistance is felt and then pull rapidly to avoid kickback.

DO NOT start or stop the engine with electrical devices

plugged in and turned on.

CAUTION

Exceeding the generator’s running capacity can damage the

generator and/or electrical devices connected to it.

DO NOT overload the generator.

DO NOT tamper with the governed speed.

DO NOT modify the generator in any way.

CAUTION

Start the generator and allow the engine to stabilize before

connecting electrical loads.

Connect electrical equipment in the off position, and then turn

them on for operation.

Turn electrical equipment off and disconnect before stopping

the generator.

CAUTION

Improper treatment or use of the generator can damage it,

shorten its life or void the warranty.

Use the generator only for intended uses.

Operate only on level surfaces.

DO NOT expose generator to excessive moisture, dust,

or dirt.

DO NOT allow any material to block the cooling slots.

If connected devices overheat, turn them off and disconnect

them from the generator.

DO NOT use the generator if:

–Electrical output is lost

–Equipment sparks, smokes or emits ﬂames

–Equipment vibrates excessively

100414 - 2000W PORTABLE INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Fuel Safety

DANGER

GASOLINE AND GASOLINE VAPORS) ARE HIGHLY

FLAMMABLE AND EXPLOSIVE.

Fire or explosion can cause severe burns or death.

Gasoline and gasoline vapors:

–Gasoline is highly ﬂammable and explosive.

–Gasoline can cause a ﬁre or explosion if ignited.

–Gasoline is a liquid fuel but it’s vapors can ignite.

–Gasoline is a skin irritant and needs to be cleaned up

immediately if spilled on skin or clothes.

–Gasoline has a distinctive odor, this will help detect potential

leaks quickly.

–In any petroleum gas ﬁre, ﬂames should not be extinguished

unless by doing so the fuel supply valve can be turned OFF.

This is because if a ﬁre is extinguished and a supply of fuel is

not turned OFF, then an explosion hazard could be created.

–Gasoline expands or contracts with ambient temperatures.

Never ﬁll the gasoline tank to full capacity, as gasoline needs

room to expand if temperatures rise.

When adding or removing gasoline:

Turn the generator off and let it cool for at least two minutes

before removing the gasoline cap. Loosen the cap slowly to relieve

pressure in the tank.

Only ﬁll or drain gasoline outdoors in a well-ventilated area.

DO NOT pump gasoline directly into the generator at the gas

station. Use an approved container to transfer the fuel to the

generator.

DO NOT overﬁll the gasoline tank.

Always keep gasoline away from sparks, open ﬂames, pilot lights,

heat and other sources of ignition.

DO NOT light or smoke cigarettes.

When starting the generator:

DO NOT attempt to start a damaged generator.

Make certain that the gasoline cap, air ﬁlter, spark plug, fuel lines

and exhaust system are properly in place.

Allow spilled gasoline to evaporate fully before attempting to start

the engine.

Make certain that the generator is resting ﬁrmly on level ground.

When operating the generator:

DO NOT move or tip the generator during operation.

DO NOT tip the generator or allow fuel or oil to spill.

When transporting or servicing the generator:

Make certain that the fuel valve is in the OFF position,

the gasoline tank is empty.

Disconnect the spark plug wire.

When storing the generator:

Store away from sparks, open ﬂames, pilot lights, heat and other

sources of ignition.

Do not store generator or gasoline near furnaces, water heaters,

or any other appliances that produce heat or have automatic

ignitions.

WARNING

Never use a gasoline container, gasoline tank, or any other fuel

item that is damaged or appears damaged.

100414 - 2000W PORTABLE INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Top

Safety Labels

These labels warn you of potential hazards that can cause serious injury. Read them carefully.

If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement.

Mufﬂer Side

LABEL DESCRIPTION

El uso de un generador en interiores PUEDE MATARLO EN MINUTOS. El escape del generador contiene monóxido de

carbono. Éste es un veneno que no se puede ver ni oler. NUNCA lo use dentro del hogar ni el garaje, INCLUSO SI las

puertas y ventanas están abiertas. Úselo SÓLO a la INTEMPERIE lejos de ventanas, puertas, y oriﬁcios de ventilación.

PELIGRO

ONLY use OUTSIDE

and far away from

windows, doors,

and vents.

NEVER use inside

a home or garage,

EVEN IF doors and

windows are open.

1308-L-SF-C

Utiliser un générateur à l’intérieur PEUT VOUS TUER EN QUELQUES MINUTES. L’échappement du générateur contient du

monoxyde de carbone. Il s’agit d’un poison que vous ne pouvez ni voir ni sentir. Ne l’utilisez JAMAIS dans la maison ou le

garage MÊME SI les portes et les fenêtres sont ouvertes. Utilisez-le UNIQUEMENT À L’EXTÉRIEUR, loin des fenêtres,

portes et trappes de ventilation.

DANGER

Using a generator indoors CAN KILL

YOU IN MINUTES. Generator exhaust

contains carbon monoxide. This is a

poison you cannot see or smell.

DANGER

K485 --- --- ---

ColorsLPN 1308-L-SF

Rev C

Size 204x 46 mm

Artwork Notes

3mm corner radius; 2mm safe margin;

white to be

printed shown in 50% process magenta

Revision Changes

B: Updated size match DF generator

C: Nee d add the text height

This ar twork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

CO Danger

1161-L-SF-A

K485 2945 109 ---

ColorsLPN 1161 -L- SF

Rev A

Size 121 x 4 0 mm

Artwork Notes

3mm corner radius; 2mm safe margin;

white t o be

print ed shown in 50% p rocess mag enta

Revision Changes

---

This art work belongs to Cha mpion Power Equipmen t. The contents ar e conﬁdential and p rivileged and shall n ot be disclosed to or us ed by or for

outside p arties withou t the explicit conse nt of Champion Power E quipment.

Safety Icons

UNLEADED FUEL ONLY. Minimum octane rating

of 87. Maximum 10% ethanol.

GASOLINA REGULAR SOLAMENTE. 87 octanos

como mínimo. Máximo de etanol de 10%.

ESSENCE SANS PLOMB SEULEMENT. Indice

d’octane minimal de 87. Maximum 10 % d'éthanol.

1032-L-OP-B

K109 --- --- ---

ColorsLPN 1032-L-OP

Rev B

Size 78 x 20 mm

Artwork Notes

3mm corner radius; 2mm safe margin

Revision Changes

B: -Changed Octane rating from 85 to 87 (20200421)

This artwork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

Fuel

1310-L-SF-A

WARNING DO NOT TOUCH! Exhaust gases, mufﬂer

and engine components are extremely HOT

and cause burns.

Operation of this equipment may create sparks that can start ﬁres

around dry vegetation. A spark arrestor may be required. The

operator should contact local ﬁre agencies for laws and regulations

relating to ﬁre prevention requirements. If installed, clean every 100

hours or every season.

ADVERTENCIA ¡NO TOCAR! Los gases de escape, el silenciador y los compnonentes

del motor están extremadamente CALIENTES y causan quemaduras.

La operación de este equipo puede producir chispas que pueden

provocar incendios alrededor de la vegetación seca. Un supresor de chispas puede que sea necesario. El

operador debe comunicarse con las agencias locales de bomberos para las leyes y reglamentos relativos

a los requisitos de prevención de incendios. Si está instalado, limpie cada 100 horas o cada temporada.

AVERTISSEMENT NE PAS TOUCHER! Les gaz d’échappement, le silencieux et les

pièces du moteur sont extrêmement CHAUDS et peuvent causer

des brûlures.

Cet équipement peut créer des étincelles et provoquer un incendie dans la végétation sèche. Un

pare-étincelles peut être requis. L’opérateur doit communiquer avec le service d’incendie local pour

connaître les lois et les règlements en matière de prévention des incendies. Si elle est installée,

nettoyez toutes les 100 heures ou chaque saison.

K152 --- --- ---

ColorsLPN 1310-L-SF

Rev A

Size 88 x 56 mm

Artwork Notes

3mm corner radius; 2mm safe margin;

white to be

printed shown in 50% process magenta

Revision Changes

---

This ar twork belongs to Champion Power Equipment. The contents are conﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment.

Hot Surface

CHAMPION POWER EQUIPMENT, INC.

12039 SMITH AVENUE

SANTA FE SPRINGS, CA 90670

USA / É.-U.

1-877-338-0999

WWW.CHAMPIONPOWEREQUIPMENT.COM

MADE IN CHINA / FABRIQUÉ EN CHINE

AC AMPS

AMPÈRES C.A.

FREQUENCY (Hz)

FRÉQUENCE (Hz)

RPM

TR / MIN

PHASE

POWER FACTOR

FACTEUR DE

PUISSANCE

AC VOLTS

VOLTS C.A.

MANUFACTURE DATE

DATE DE FABRICATION

SERIAL NO.

N° DE SÉRIE

MODEL

MODÈLE

2782-L-PR-A

4010077

Certified to CSA

Standard C22.2 No. 100

Certifié selon la norme

CSA C22.2 N° 100

INSULATION CLASS

CLASSE D’ISOLATION

MAX AMBIENT TEMP.

TEMP. AMBIANTE MAX.

GASOLINE WATTS

WATTS D'ESSENCE

13.3

100414

4500

1.0

120

1600

104°F

40°C

XXXXXXXXXXXX

XXXX

K--- --- --- ---

ColorsAPN 2782-L-PR

Rev A

Size 147 x 40 mm

Artwork Notes

3mm corner radius; 2mm safe margin.

CYAN text to be ﬁlled out during produ ction.

Revision Changes

This ar twork belongs to Champion Power Equipment. The contents are con ﬁdential and privileged and shall not be disclosed to or used by or for

outside parties without the explicit consent of Champion Power Equipment .

Dataplate

(not shown)

100414 - 2000W PORTABLE INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Safety Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these

symbols will allow you to more safely operate the product.

SYMBOL MEANING

Read Operator’s Manual. To reduce the risk of injury, user must read and understand operator’s manual

before using this product.

Clearance. Keep all objects at least 5 feet (1.5m) from generator. Heat from the mufﬂer and exhaust gas

can ignite combustible objects.

Ground. Consult with local electrician to determine grounding requirements before operation.

Electric Shock. Failure to use in dry conditions and to observe safe practices can result in electric

shock. Improper connections to a building can allow current to backfeed into utility lines, creating an

electrocution hazard. A transfer switch must be used when connecting to a building.

Fire/Explosion. Fuel and its vapors are extremely ﬂammable and explosive. Fire or explosion can cause

severe burns or death. Keep generator at least 5 feet (1.5m) from all objects to prevent combustion.

Hot Surface. To reduce the risk of injury or damage, avoid contact with any hot surface.

Open Flame Alert. Fuel and its vapors are extremely ﬂammable and explosive. Keep fuel away from

smoking, open ﬂames, sparks, pilot lights, heat, and other ignition sources.

Wet Conditions Alert. Do not expose to rain or use in damp locations.

100414 - 2000W PORTABLE INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Operation Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these

symbols will allow you to more safely operate the product.

SYMBOL MEANING

Engine START

Engine RUN

Engine STOP

STOP or OFF

Run out of fuel. Stopping the

generator.

Fuel Level

Power Output. Percentage of available

power from generator being used.

Remaining Fuel Time

Overload Reset Switch

ECO

Economy Mode Switch

SYMBOL MEANING

Maintenance Required Indicator

Low Oil Level Indicator

Receptacle Status

Circuit Breaker Reset: Push

Ground Terminal

Neutral Floating. Neutral circuit IS

NOT electrically connected to the frame/

ground of the generator.

Parallel Connection(s)

100414 - 2000W PORTABLE INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS

Quick Start Label Symbols

Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these

symbols will allow you to more safely operate the product.

Starting the Engine

DANGER

Move generator outside and far away from windows,

doors and intake ventilation covers.

1. Check oil level.

Recommended oil is 5W-30.

2. Check gasoline level.

When adding gasoline, use a minimum octane rating of 87

and an ethanol content of 10% or less by volume.

3. Turn the fuel cap vent lever to the “ON” position.

4. Turn EZ Start dial counterclockwise to the full “CHOKE”

position.

5. Pull the recoil cord.

6. Turn the EZ Start dial to the “RUN” position.

7. Plug in desired device.

Stopping the Engine

1. Turn off and unplug all connected electrical loads.

2. Turn the EZ Start dial to the “STOP” position.

2783-L-OP-B

71 2 3 4 5 6 1 2



5W-30



LPN 2783 -L-OP

Rev B

Size 256 x 48 mm

Artwork Notes

3mm corner radius; 2mm safe margin;

whit e to be

prin ted shown i n 50% proce ss magent a

Revision Changes

B-Changed choke direction

This ar twork belong s to Champion Power E quipment. The co ntents are con ﬁdential and pr ivileged and shal l not be disclosed t o or used by or for

outsid e parties with out the explicit con sent of Champion Po wer Equipment.

KCG1 376 152 186

Colors

Inhaltsverzeichnis

Andere Champion Generator Handbücher

Champion

Champion 42432 Bedienungsanleitung

Beliebte Generator Handbücher anderer Marken

Duracell

Duracell DG66M-R62 Bedienungsanleitung

North Star

North Star M165967M Bedienungsanleitung

Wanco

Wanco WI6000 Bedienungsanleitung

Gude

Gude GSE 1200 4T Bedienungsanleitung

Mastervolt

Mastervolt WHISPER 12 ULTRA Bedienungsanleitung

Miller

Miller Big Blue 450X Duo CST Bedienungsanleitung

Powerhorse

Powerhorse 1661132 Bedienungsanleitung

Pulsar

Pulsar PG3500 Bedienungsanleitung

Pulsar

Pulsar PG4500B Bedienungsanleitung

SDMO

SDMO HX 6000 TB-2 UK Bedienungsanleitung

Yamaha

Yamaha EF6600DE - Premium Generator Bedienungsanleitung

Generac Power Systems

Generac Power Systems 4.6L Bedienungsanleitung

Mastervolt

Mastervolt Whisper 6 Bedienungsanleitung

Black & Decker

Black & Decker BD 4500 Bedienungsanleitung

Pulsar

Pulsar PG10000B Bedienungsanleitung

Homelite

Homelite UT905000S Bedienungsanleitung

Wen

Wen 56310i Bedienungsanleitung

Intelligen

Intelligen INS-1500 Bedienungsanleitung