Costway TS10023 Bedienungsanleitung

Please give us a chance to make it right and do better !

Contact our friendly customer service department for help first.

Replacements for missing or damaged parts will be shipped ASAP !

Do NOT return this item. US:cs.us@costway.com

UK:cs.uk@costway.com

AU:[email protected]

US office: Fontana UK office: Ipswich AU office: Truganina

Zip line kit

TS10023

USER’S MANUAL

THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP FOR FUTURE REFERENCE.

Before You Start

General Warnings:

The product must be installed and used under the supervision of an adult.

Read through each step carefully and follow the proper order.

Remove all packaging, separate and count all parts and hardware.

Please ensure that all parts are correctly installed, incorrect installation can lead to

a danger.

We recommend that, where possible, all items are assembled near the area in

which they will be placed in use, to avoid moving the product unnecessarily once

assembled.

Ensure a secure surface during installation, and place the product always on a flat,

steady and stable surface.

Please use this product with caution. The use of this product requires superb skills

to avoid accidents to the user or others due to a fall or collision.

Please wear suitable protective equipment during use, e.g. protective helmet,

gloves, knee pads, elbow pads etc.

Warnings:

Attention! Use it with protective equipment.

Attention! Not use it in the traffic.

Attention! The product is not suitable for the children under 3 years.

Please read all instructions carefully and keep it for future reference.

CAUTION:

ADULT SUPERVISION AND ASSEMBLY

IS REQUIRED. WITH ADULT SUPERVISION

FOR AGES

8+*

MAX WEIGHT

400 LBS

180 KG

BE SAFE! - ALWAYS FOLLOW THESE SAFETY RULES

● TO BE SETUP AND INSTALLED ONLY BY AN ADULT.

● NOT RECOMMENDED FOR CHILDREN UNDER 8 YEARS OF AGE

● WEAR SUITABLE SHOES AND CLOSE FITTING CLOTHING. NO JEWELRY,

SCARVES OR OTHER LOOSE CLOTHING.

● MAKE SURE EVERYTHING IS INSTALLED CORRECTLY AND INSPECT AND

TEST THE LINE BEFORE EACH USE.

● IF WORN OR DAMAGED PARTS ARE FOUND, CONTACT US FOR

REPLACEMENT PARTS – DO NOT SUBSTITUTE WITH OTHER PARTS OR

INJURY MAY RESULT.

● REMAIN SEATED FOR THE ENTIRE RIDE, WAIT UNTIL YOU HAVE STOPPED

COMPLETELY BEFORE LETTING GO OF THE TROLLEY OR DISMOUNTING

SEAT.

● ONE RIDER ONLY AT A TIME.

● KEEP PEOPLE AND ANIMALS AT LEAST 25FT (7.62 M) AWAY FROM THE

ZIPLINE COURSE WHEN IN USE.

● NEVER USE THE LINE WHEN IT IS WET OR IF THERE IS RAIN OR

LIGHTNING IN THE AREA.

● DO NOT PLACE FINGERS OR HAIR INSIDE OF TROLLEY OR SERIOUS

INJURY MAY RESULT.

● ADULT SUPERVISION IS REQUIRED AT ALL TIMES.

● MAXIMUM WEIGHT 400 LBS (180 KG).

CABLE WEIGHT TEST

MARK CABLE AT EACH CABLE CLAMP AND FIST GRIP.

AFTER USING TEST WEIGHT TO TEST ZIP LINE, INSPECT MARKS FOR

INDICATION OF CLAMP SLIPPAGE.

ATTACH A TEST WEIGHT, EQUAL TO WEIGHT OF HEAVIEST PARTICIPANT,

UP TO 400 LBS (180 KG). TO TROLLEY MOUNTED ON CABLE. (!! WARNING

!!NEVER USE A PERSON AS A TEST WEIGHT WHEN PERFORMING THE

WEIGHT TEST.)

Bounce test weight up and down. Observe anchors at either end of cable for

excessive movement.

Allow test weight to settle at the lowest point of the cable.

Cable sag is measured from the lowest point on the cable to the attachment

height of the cable on the ending anchor.

Inspection

Detach test weight and inspect termination hardware and anchors for proper

configuration and strength.

Check for slippage of cable through cable clamps and fist grips to verify they

are adequately tightened.

WHAT ‘S IN THE PACKAGE?

100ft Wire line 6ft Sping brake round seat

Handle pulley Safety belt Safety rope

8.2ft Ratchet

and webbing line

3*U-clamps 2*Locking

carabiner

Wrench Carry bag 2*Tree protector

1.How high should l install my zipline?

As a general rule ,we recommend installing the finish point of the course 6ft

to 8ft off the ground,and 2ft taller than the tallest rider.

When picking the start point of the course, it needs to be higher than the

finish point to create a safe angle to ride down.

We recommend giving the course an 8-10% slope. To calculate this, take the

length of your course and multiply it by 0.8 or 0.1.Then take that number,

and add it to the height of your course’s finish point. This number is your

recommended starting height.

Warning! Assembly by an adult. Not suitable for

children under 36 months. Long cord. Strangulation

hazard.

HOW TO INSTALL ZIP LINE?

2.After determining the height, stick the tree protector on the tree.

After that, the wire line is passed through the hole and tightened up, and

hung on the tree protector. (Note: please hang the wire line at the starting

point of the track.)

3.Pass the other end of the wire rope through the brake spring.

4.Put the ratchet wheel on the tree protector at the end of the track

and tighten up.

5.Straighten the wire rope and find a spot on it. Make sure that this

point exceeds about half of the edge of the total length of the ratchet

wheel and the webbing line.

be careful

Do not use buildings or playground structures (unless specifically built for zip

lines), live power/telephone poles, dead trees or stumps, trees with rot,

disease, structural cracks, excessive lean, exposed roots, or

trees in boggy, wet, sandy, loose soil. This is only a partial list.

You must use your good judgment in determining what is not

an appropriate anchor point. If in doubt, contact us by Email.

6.Put the webbing line set on in the just fixed wire rope ring.Then

use the ratchet to tighten the webbing belt.

Note that before tightening the ratchet, make sure that the wire rope has

been straightened as far as possible.

7.Open the handle pulley and place it at the starting point of the

track.

Hang the round seat and adjustable strap on the handle pulley with the

locking buckle.

The wire rope is wound into a ring at the just

marked point, and the wound ring is fixed with a

U-shaped buckle.

8.Adjust the round seat to the length you need.

You can adjust it to the most suitable length through the buckle on the top

or the knot on the bottom.

9.Put the safety belt on your body and tighten it.

Then connect the safety belt to the adjustable strap with another buckle. (At

the same time, please check that the adjustable belt and handle pulley have

been reliably connected.)

Note: When you finish installing the zip line kit, it is recommended that you

have them tested.

Take care to reduce the probabilities of injury.

We sincerely hope you enjoy your zip line kit as much as possible.

Inhaltsverzeichnis

Andere Costway Spielgeräte und Spielplatzausstattung Handbücher

Costway

Costway TP10028 Bedienungsanleitung

Costway

Costway NP11069 Bedienungsanleitung

Costway

Costway SP37803 Bedienungsanleitung

Costway

Costway NP10355 Bedienungsanleitung

Costway

Costway NP10534 Bedienungsanleitung

Costway

Costway NP10769 Bedienungsanleitung

Costway

Costway NP11236DE Bedienungsanleitung

Costway

Costway TY327185 Bedienungsanleitung

Costway

Costway TS10028 Bedienungsanleitung

Costway

Costway NP10533 Bedienungsanleitung

Costway

Costway SP37804 Bedienungsanleitung

Costway

Costway TY570391 Bedienungsanleitung

Costway

Costway TY325112 Bedienungsanleitung

Costway

Costway NP10428 Bedienungsanleitung

Costway

Costway Giant 4-In-A-Row Game Bedienungsanleitung

Costway

Costway 10239487 Bedienungsanleitung

Costway

Costway OP70640 Bedienungsanleitung

Costway

Costway OP70404 Bedienungsanleitung

Costway

Costway TP10052 Bedienungsanleitung

Costway

Costway TS10041 Bedienungsanleitung

Costway

Costway TP10035 Bedienungsanleitung

Costway

Costway TP10013 Bedienungsanleitung

Costway

Costway TS10066 Bedienungsanleitung

Costway

Costway NP10356 Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

HAGS

HAGS Lillie Expansion module w Dolly Bedienungsanleitung

Percussion Play

Percussion Play Surface Fixed Rainbow Trio Chimes Pentatonic 6... Bedienungsanleitung