CPS FlexOM Gateway V2 Bedienungsanleitung

Quick Guide for FlexOM Gateway V2

2/23/2023

Revision 3

Page 1

Table of Contents

Product Features

Product Specifications

-- -- Dimensions and Interfaces

-- -- LED Indicators

-- -- Typical System Design and Diagrams

Hardware Installation

-- -- Daisy Chain Wiring

Using the CPS Connect Pro App

-- -- Check the Internet Connection

-- -- Modbus Device Settings

-- -- Modbus TCP

-- -- Reset / Restart

-- -- Option 1: Internal Wire-box Installation

-- -- List of Required Tools and Materials

-- -- 4G Cellular Antenna Installation (FlexOM-4G V2 only) 26

-- -- Safety Precautions 14

-- -- Option 2a: DIN Rail Side Mounting (in External DAS Box) 21

-- -- Option 2b: DIN Rail Flat Mounting (in External DAS Box) 24

CPS Warranty Policy 34

Page 2

Product Features

The FlexOM Gateway V2 is an IoT cloud-based gateway that allows the integration of

various hardware and system scenarios

Connect multiple CPS inverters and other devices to a single RS485 daisy chain

RS485 pass-thru allows third-party controller to act as a client in parallel with the FlexOM

Gateway V2

Enables diagnosis of RS485 wiring issues through the CPS FlexOM portal

Modbus TCP pass-thru (Third-party controllers can read/write commands to CPS inverters

through Modbus TCP.)

Easy mass deployment and configuration via the CPS Connect Pro app using built-in BLE

Reduces the need for truck rolls via remote firmware updates

Page 3

Product Specifications

RS485 Interface

No. of Ports 1 (A: 6-Pin Connector or B: 5-Pole Terminal Block)

Protocol Modbus RTU

Modbus RTU Mode Client

Terminator for RS485 120 ohms

Isolation 2.5 kV

AUX Interface

No. of Ports 1 (3-pole Terminal Block)

Protocol Modbus RTU

Modbus RTU Mode Server (RS485 Pass-thru)

Terminator for RS485 120 ohms

Isolation 2.5 kV

Ethernet Interface

10/100BaseTX Ports (RJ45 connector) 1

Connect to the Cloud Applications MQTT

SCADA controllers on the same LAN subnet Modbus TCP

Page 4

Modbus TCP

Mode Server

Max. No. of Client Connections 2

Cellular Interface (FlexOM-4G V2 product only)

Cellular Standards LTE-FDD/LTE-TDD, WCDMA

No. of SIM Slot 1

Cellular Antenna Connectors 1 SMA female

Bluetooth Interface

Standard BLE 4.2

Antenna Built-in

Power Parameters

Input Voltage 9 to 24 Vdc

Power Consumption 2.5 W, Max. 5 W

Power Connector Terminal Block

Environmental Limits

Operating Temperature -30°C to 85°C (-22 to 185°F), Natural convection

Storage Temperature -40 to 85°C (-40 to 185°F)

Ambient Relative Humidity 5 to 85% (non-condensing)

Page 5

Physical Characteristics

Housing Plastic

IP Rating IP 20

Dimensions 70 mm / 100 mm / 28 mm (2.76 in x 3.94 in x 1.10 in)

Weight 73g ( 0.16 lb )

Standards and Certifications (DoC)

CE-EMC EN 55032

EN 55035

EN 61000-3-2

EN 61000-3-3

CE-RED EN 301 908

EN 300 328

EN 301 489-1 / -17 / -52

EN 62368-1

CE-LVD EN 62368-1

FCC SDoC Part 15B

FCC ID Part 15C

Page 6

Dimensions and Interfaces

Dimensions without DIN rail housing

0.83 in

(21 mm)

3.98 in

(101 mm)

2.72 in

(69 mm)

Dimensions with DIN rail housing

1.26 in

(32 mm)

4.06 in

(103 mm)

3.03 in

(77 mm)

Page 7

Dimensions and Interfaces

Ethernet Port

AUX Port

Module Socket

Terminating Resistance Switch

6-PIN Port A:

Internal wire-box installation

(see installation option 1)

5-PIN Port B:

External DAS box installation

(see installation options 2a and 2b)

A+ B- G

Vin GND A+ B- G

Terminating Resistance Switch

Default

Caution:

If the length of either the cable connecting to the RS485 port or the AUX port

of the gateway is over 1000 meters, the switch for the 120 ohm terminating

resistor corresponding to the port must be set to ON.

Power Switch

POWER ON

Caution:

Before configuring the gateway,

ensure the power switch is set to ON.

Page 8

Connector for 4G antenna

SIM Card Slot

Note:

Confirm the gateway model by checking the model number and SN listed on the label on top of the

gateway card.

The FlexOM Gateway V2 cards must have an Internet connection to enable remote data

communications via the CPS Portal.

The standard FlexOM Gateway V2 requires an Internet connection via the Ethernet port.

The FlexOM-4G Gateway V2 includes a pre-installed SIM card and 5-year 4G cellular plan.

The FlexOM-4G Gateway V2 may not use, be configued with, or be activated with a third-party

SIM card.

Internet Interface:

Ethernet

Internet Interface:

4G wireless

(FlexOM-4G V2 only)

Dimensions and Interfaces

Page 9

The FlexOM Gateway V2 requires a connection to the Internet using Ethernet. Any LAN

firewall ports must be opened before commissioning the FlexOM Gateway V2.

The following ports must be opened both ways (for incoming and outgoing

communications):

TCP 1884 with destination IP 47.254.52.209

(mqtt.chintpowersystems.com)

Internet Interface: Ethernet (FlexOM Gateway V2)

Internet Interface: 4G (FlexOM-4G Gateway V2 only)

The FlexOM-4G Gateway V2 includes a pre-installed SIM card and is compatible with

AT&T, T-mobile, and Verizon networks. The standard 4G cellular data plan period is 5

years.

Once the FlexOM-4G Gateway V2 is powered on and the 4G antenna has been installed

(see page 26), it will automatically select and connect to the provider network with the

strongest or most stable signal.

Dimensions and Interfaces

Inhaltsverzeichnis

Andere CPS Tor Handbücher

CPS

CPS G2 Bedienungsanleitung

Beliebte Tor Handbücher anderer Marken

LST

LST M500RFE-AS Bedienungsanleitung

Kinnex

Kinnex Media Gateway Bedienungsanleitung

2N Telekomunikace

2N Telekomunikace 2N StarGate Bedienungsanleitung

Mitsubishi Heavy Industries

Mitsubishi Heavy Industries Superlink SC-WBGW256 Bedienungsanleitung

ZyXEL Communications

ZyXEL Communications ZYWALL2 ET 2WE Bedienungsanleitung

Telsey

Telsey CPVA 500 - SIP Bedienungsanleitung

RTA

RTA 460A-NNA4 Technisches Datenblatt

Shaw

Shaw Gateway HDPVR Bedienungsanleitung

ABB

ABB VSN900 Kurzanleitung

Commander

Commander Pulse Bedienungsanleitung

2N Telekomunikace

2N Telekomunikace ATEUS EasyGate 501309E Bedienungsanleitung

NETGEAR

NETGEAR C6300BD Bedienungsanleitung

Amit

Amit CDW531AM Bedienungsanleitung

HMS

HMS Netbiter EasyConnect EC150 Bedienungsanleitung

Huawei

Huawei EchoLife HG620 Bedienungsanleitung

AT&T

AT&T U-verse 3801 Gebrauchs- und Pflegehandbuch

Logic IO

Logic IO RTCU MX2 turbo Bedienungsanleitung

Suttle

Suttle MediaMAX MXM-521 Bedienungsanleitung