Dacor EF42BDCB Bedienungsanleitung

Inst cti n heet

Evaporator rainTray Assembly Installation

Refrigerator Models: EF42BDCB, EF48BDCB, EF42BNDB,

EF48BNDB, IF42BDCB, IF48BDCB, IF42BNDB, IF48BNDB

Kit Part Numbers: W10199913 (42=inch models), W10199915 (48=inch models)

Electrical Shock Hazard

Disconnect power before servicing.

Replace all parts and panels before

operating.

Failure to do so can result in death

or electrical shock.

Kit Contains:

1 Clip 6 Sealer-Gum (Butyl)

1 Clamp 1 Evaporator DrainTray Assembly

1 Drain Tube 1instruction Sheet

Standard product manufacturing warranty applies.

IMPORTANT: Evaporator Drain Tray Freeze Up issue in 2003

thru 2007 production - Creates internal water leak from ceiling

of freezer causing water and ice to accumulate on the ceiling,

door and seals of freezer. Can also cause a no cool situation, a

noise issue when ice forms blocking evaporator motor and blade,

or damper diffuser failure.

NOTE: All steps must be followed for a proper repair.

1. Remove top grille.

2. Turn off power. See Figure 1.

POWER

SWITCH FIGURE1

3. Remove evaporator cover and components inorder to access

the evaporator drain tray.

4. Remove evaporator drain tray.

5. Clear any remaining ice off the evaporator and on the back

wall.

6. On the left side of the evaporator, remove and discard the

piece of foam. it will not be needed. See Figure 2.

NOTE: The foam piece might come off the evaporator and be

stuck on the old evaporator drain tray when removed.

FIGURE2

7. Locate and unplug evaporator defrost thermistor at the

connector. The defrost thermistor is mounted on the

evaporator. Follow wire and disconnect at the connector.

Leave the defrost thermistor permanently disconnected. See

Figure 3.

NOTE: This will initiate a 6 hour defrost cycle time, keeping the

evaporator clear from any ice build up.

IMPORTANT: Do not disconnect the Defrost Bi-Metal.

FIGURE3

Part No. 106405 Rev. B 12/08 page 1 of 2

8. Remove only the protective paper strips from the rope seal

(Butyl) on the evaporator drain tray assembly provided in the

kit, See Figure 4.

14. Using the gum sealer (Butyl), make sure to seal all wire

harness conduits to prevent any air leaks. See Figure 7.

FIGURE4

9. Install the new evaporator drain tray assembly. Make sure

pan is good and tight against the evaporator.

10. Hook up the drain tube. Do not tighten the clamp that is

included with the kit. See Figure 5.

FIGURE5

ANDAIRDIFFUSER

11. Seal aroundthe drain tube going through to the compressor

side, using gum sealer (Butyl) included in kit. See Figure 5.

12. Reconnect the yellow wires going to both of the heaters on

the tray.See Figure 5.

13, Onthe compressor side, makesure the drain tineispositioned

so the water wilt remain in the U trap in the drain tube. Install

the self adhesive clip supplied with the kit. Once in position,

make surethe hose clamp istight enough to prevent leaking.

Do not overtighten clamp. Tighten if necessary. Make sure

the gum sealer (Butyl) is sealed around the drain tube to

prevent any air leaks. See Figure 6.

NOTE: Make sure the clear polyethylene drain tube is installed

correctly in the drain pan. The "u" shape should be installed as

shown in Figure 6to create a liquid seal in the "a" shape.

FIGURE8

FIGURE7

15. Reinstall all parts and connections except for the defrost

thermistor disconnected in step 7.

16. Make sure refrigerator is level left to right and slightly tipped

backwards.

t7. Check for any breaches (gaps) in the door seals such as:

a. Breach from seal retreating from the front frame of the

cabinet, especially areas half-way up the cabinet and

freezer doors,

b. Breach from door alignment or bow.

c. Door "popping" open when the opposite door is

closed.

d. Side trim binding, due to instaIiation causing door to pop

open.

e. Check dispenser modeIs, and correct as necessary, any

breaches found on the fountain door assembly.

18. Turn on power. See Figure 1.

19. Replace top griIle.

20. Check operation on the following:

a. Check air damper is opening and closing. Running

in diagnostic mode may be necessary to verify

operation.

b. Check compressor operation.

c. Check evaporator fan motor operation.

d. Check ice maker /bucket assembly operation.

Dacor °1440 Bridge Gate Drive, Diamond Bar, CA 91765 • Tel: (800) 793-0093 ° www.Dacor.com 106405 Rev. B page 2 of 2

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Dacor Kühlschrank Handbücher

Dacor

Dacor EF36BNN Bedienungsanleitung

Dacor

Dacor DRR30 Series Bedienungsanleitung

Dacor

Dacor Discovery DYF42SBIWS Bedienungsanleitung

Dacor

Dacor EF36IWF Montageanleitung

Dacor

Dacor OF24LS Technisches Handbuch

Dacor

Dacor IF36BNNFSF Montageanleitung

Dacor

Dacor EF36BNNFSS Montageanleitung

Dacor

Dacor Epicure EF36LNDFSS Technisches Handbuch

Dacor

Dacor EF42BDCB Technisches Handbuch

Dacor

Dacor 106622 Bedienungsanleitung

Dacor

Dacor Side-by-Side Bedienungsanleitung

Dacor

Dacor DRF427500AP Bedienungsanleitung

Dacor

Dacor IF36LNBOL Benutzerhandbuch

Dacor

Dacor Millennia AFM36VSP Technisches Handbuch

Dacor

Dacor PF36BNDFBKPB Bedienungsanleitung

Dacor

Dacor DRF42 series Bedienungsanleitung

Dacor

Dacor DRR36 Series Bedienungsanleitung

Dacor

Dacor DRS4253 Series Bedienungsanleitung

Dacor

Dacor EF42DBSS Bedienungsanleitung

Dacor

Dacor EF48NBSS Bedienungsanleitung

Dacor

Dacor EF48DBSS Bedienungsanleitung

Dacor

Dacor DRF487 Series Bedienungsanleitung

Dacor

Dacor IF36LNBOL Bedienungsanleitung

Dacor

Dacor OF24LS Bedienungsanleitung

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

Sharp

Sharp SJ-BA31IEXW2-EU Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

Stengel

Stengel KU 1101 A++ Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

Amana

Amana ASD2524VES00 Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Samsung

Samsung RF323TE Bedienungsanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

True

True TS-28 Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung