DIVEX 2 diver HP/LP control panel Betriebsanleitung
PP-OM-794 Rev1
OM338
OPERATING AND MAINTENANCE
MANUAL
for the
TWO DIVER, SURFACE CONTROL,
HP/LP AIR IN TRANSIT CASE,
HINGED LID
(Part No: PP033AA)
(Intentionally Blank)
OM338 i
PP-OM-794 Rev1 Approval Sheet
APPROVAL SHEET
DIVEX
MANUAL NUMBER: OM338
ADVITIUM NUMBER: PP-OM-794
DOCUMENT TITLE: Two Diver, Surface Control, HP/LP Air in Transit Case, Hinged Lid
REV DATE BY CHECK APP COMMENTS
0 11 October 2006 Christine Bain Original Issue
1 28 August 2012 Debbie Allan Simon Bryce Mark Stevens ECN:15335
2
3
4
5
6
7
ORIGINAL ISSUE DATE: 11 October 2006
ORIGINAL DOCUMENT BY: Christine Bain
CHECKED BY:
APPROVED BY:
ii OM338
Approval Sheet PP-OM-794 Rev1
(Intentionally Blank)
OM338 iii
PP-OM-794 Rev1 Table of Contents
CHAPTER 1 - SAFETY NOTICE .................................................................................................... 1
CHAPTER 2 - TECHNICAL SPECIFICATION ............................................................................... 3
CHAPTER 3 - GENERAL DESCRIPTION ..................................................................................... 5
CHAPTER 4 - INSTALLATION ...................................................................................................... 7
CHAPTER 5 - PRE-DIVE CHECK .................................................................................................. 9
CHAPTER 6 - OPERATION ......................................................................................................... 11
CHAPTER 7 - PNEUMO OPERATION ........................................................................................ 13
CHAPTER 8 - CYLINDER CHANGE OVER ................................................................................ 15
CHAPTER 9 - AUXILIARY LOW PRESSURE INLET ................................................................. 17
CHAPTER 10 - LOW H.P. WARNING ......................................................................................... 19
CHAPTER 11 - MAINTENANCE .................................................................................................. 21
CHAPTER 12 - MAINTENANCE SCHEDULE - 6 MONTHLY ..................................................... 23
CHAPTER 13 - APPENDICES ..................................................................................................... 25
TABLE OF CONTENTS
iv OM338
Table of Contents PP-OM-794 Rev1
(Intentionally Blank)
OM338 1
PP-OM-794 Rev1 Chapter 1
CHAPTER 1 SAFETY NOTICE
1.1 This unit must only be operated by suitably qualified personnel.
1.2 Read the instructions thoroughly before operating this equipment.
1.3 Only genuine manufacturer's spare parts may be used and the substitution of parts
from other manufacturers will invalidate the warranty and may cause damage to the
equipment. When ordering spare parts, please quote the serial number of the
assembly and the part numbers required.
1.4 This panel has been designed to supply air to breathing apparatus, for diving, and
the manufacturers will not be responsible for its use for any other purpose.
1.5 The user must make him/herself familiar with and observe national legal
requirements concerning the safe use and maintenance of the equipment. The
manufacturers ensure that the equipment complies with such regulations on
delivery but it remains the responsibility of the user to comply with the legal
requirements in use.
1.6 It is the responsibility of the user to establish the flow and pressure of air required for
the breathing apparatus to be employed and to ensure that the supply is adequate
for the use envisaged. This responsibility includes the provision of an adequate
reserve air supply.
CAUTION
COMPRESSED AIR IS POTENTIALLY DANGEROUS THIS EQUIPMENT
MUST BE USED CORRECTLY MISUSE COULD CAUSE SERIOUS
INJURY.
2OM338
Chapter 1 PP-OM-794 Rev1
(Intentionally Blank)
OM338 3
PP-OM-794 Rev1 Chapter 2
CHAPTER 2 TECHNICAL SPECIFICATION
Inlet Pressure L.P. 15 BAR maximum (220 psi)
H.P. 350 BAR maximum (5075 psi)
Hose Connections LP inlet 3/8" BSP male
HP inlet 1/4" BSP male
Diver supply 3/8" BSP male
Pneumo 1/4" BSP male
Overall External Dimensions Length 730mm (29”)
Width 610 mm (24”)
Height 380 mm (16”)
Weight approximately 40 kg (88lbs)
Pipework H.P. 8mm x 1mm stainless steel
L.P. 10mm x 1mm stainless steel
4OM338
Chapter 2 PP-OM-794 Rev1
(Intentionally Blank)
Inhaltsverzeichnis
Andere DIVEX Tauchinstrument Handbücher
