Dometic RM1350M Handbuch

825129202

(French 825129252)

LaGrange, IN 46761

INSTALLATION

OPERATING

INSTRUCTIONS

MO 0939

RM1350

USA Corporate Ofce CANADA

Service Ofce 2320 Industrial Parkway Elkhart, IN 46516 Dometic, LLC

Dometic, LLC 46 Zatonski, Unit 3

2320 Industrial Pkwy. Brantford, ON N3T 5L8

Elkhart, IN 46516 For Service Center Assistance CANADA

Phone: 574-294-2511 Call: 800-544-4881 Phone: 519-720-9578

FOR YOUR SAFETY

If you smell gas:

1. Open windows.

2. Don’t touch electrical switches.

3. Extinguish any open ame.

4. Immediately call your gas supplier.

POUR VOTRE SÉCURITÉ

Si vous sentez une odeur de gaz:

1. Ouvrez les fenêtres.

2. Ne touchez à aucun interrupteur.

3. Éteignez toute amme nue.

4. Avertissez immédiatement votre

fournisseur de gaz.

FOR YOUR SAFETY

Do not store or use gasoline or other

ammable vapors and liquids in the

vicinity of this or any other appliance.

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser de l’essence

ni d’autres vapeurs ou liquides inamma-

bles à proximité de cet appareil ou de tout

autre appareil.

Improper installation, adjustment,

alteration, service or maintenance can

cause injury or property damage. Refer to

this manual. For assistance or additional

information consult a qualied installer,

service agency or the gas supplier.

Une installation, un réglage, une modi-

cation, une réparation ou un entretien non

conforme aux normes peut entraîner des

blessures ou des dommages matériels.

Lisez attentivement le mode d’emploi

fourni avec l’appareil. Pour obtenir de

l’aide ou des renseignements supplémen-

taires, consultez un installateur ou un

service d’entretien qualié ou le fournis-

seur de gaz.

warning avertissement

If the refrigerator stops cooling - or - if

ammonia emanates from it, immediately

turn the refrigerator off and contact a

Service Center.

Si le réfrigérateur cesse de refroidir - ou - si

de l’ammoniac s’en dégage, arrêtez immé-

diatement le réfrigérateur et contactez un

centre de réparation.

warning avertissement

- 3 -

contents

INTRODUCTION.................................................................... 4

installation instructions

CERTIFICATIONANDCODEREQUIREMENTS ............................................ 4

VENTILATION REQUIREMENTS ........................................................ 5

INSTALLATION PROCEDURE .......................................................... 6

CONNECTIONS..................................................................... 8

MOUNTING THE DOOR PANELS ...................................................... 10

operating instructions

REFRIGERATOR OVERVIEW.......................................................... 13

OPERATING INSTRUCTIONS ......................................................... 18

STORAGE COMPARTMENTS ......................................................... 20

PRODUCT CARE................................................................... 21

MAINTENANCE&SERVICE.......................................................... 22

REFRIGERATORREMOVAL.......................................................... 25

TROUBLESHOOTING ............................................................... 25

DIAGNOSTIC TEST ................................................................ 27

APPENDIX A - SPARE PARTS......................................................... 28

APPENDIXB-REARVIEWEQUIPMENT ................................................ 29

APPENDIXC-WIRINGDIAGRAM..................................................... 31

APPENDIXD-CONSUMERSUPPORT................................................. 34

APPENDIX E - DOMETIC WARRANTY .................................................. 35

APPENDIX F - MAINTENANCE SCHEDULE .................................................36

symbols

The following symbols are used throughout the manual:

Indicates a potentially hazardous situation, which, if not avoided, could result

in death or serious injury.

Indicates a potentially hazardous situation, which, if not avoided, may result in

minor or moderate injury.

Used without the safety alert symbol indicates, a potentially hazardous situation which, if not avoided

may result in property damage.

Information

Step-by-step instructions

CAUTION

WARNING

CAUTION

- 4 -

introduction

Thank you for entrusting us to supply your new quality-guaranteed refrigerator. The refrigerator is to be used as a recreational

device designed for storage of foods, frozen foods and making ice. Please, when the refrigerator is not in use as a recreational

device, turn the system off and open the doors.

This manual should be kept and stay with the refrigerator if it is ever moved or change owners. Read it carefully to ensure that you

know how to operate the refrigerator safely and correctly. Be aware of possible safety hazards when seeing alert symbols on the

refrigerator as well as in this manual.

To ensure safe and efcient operation, the refrigerator must be installed as described in this manual. The installation and servic-

ing should be performed by qualied personnel only and must conform to all relevant local authorities. Please read this manual

thoroughly before installing the refrigerator.

model denominations

The following model denominations are used:

RM1350M Manual door lock, door insert panels or steel doors.

RM1350MIM Manual door lock, ice maker and door insert panels.

RM1350IM Automatic door lock, ice maker and steel doors.

RM1350WIM Automatic door lock, ice maker, water dispenser, door insert panels or steel doors.

RM1350WID Automatic door lock, ice maker, water and ice dispensers, door insert panels or steel doors.

certification and code requirements







National Fuel Gas Code, ANSI Z223.1/NFPA 54•

(latest edition).

Recreational Vehicles Code, ANSI A119.2 (latest edition).•

Manufactured Home Construction and Safety Standard, Title•

24 CFR, Part 3280.

If an external electrical source is utilized, the refrigerator, when

installed, must be electrically grounded in accordance with

local codes or, in the absence of local codes, the National Elec-

trical Code, ANSI/NFPA 70 - (latest edition).



Natural Gas and Propane Installation Code, CSA B149.1•

CSA Z240 RV Series, Recreational Vehicles.•

Current CSA Z240.4, Gas-equipped Recreational Vehicles•

and Mobile Housing.

If an external electrical source is utilized, the refrigerator,

when installed, must be electrically grounded in accordance

with local codes or, in the absence of local codes, the Canadian

Electrical Code, CSA C22.1, Parts I and II - (latest edition).

INSTALLATION INSTRUCTIONS

- 5 -

clearances

Minimum clearances (in inches) to combustible materials:

Top (G) 0

Side (K) 0

Bottom (L) 0

ventilation requirements

The lower vent of the recommended kits is provided with proper

size openings. The ow of combustion and ventilating air must

not be obstructed.

The lower side vent is tted with a panel, which provides an

adequate access opening for ready serviceability of the burner

and control manifold of the refrigerator. This should be centered

on the back of the refrigerator.

general information

Provide necessary air circulation over the cooling unit. Open-

ings for air supply or for venting of combustion products shall

have a minimum dimension of not less than 1/4 inch.

Certied installations require one roof vent and one lower side

vent. Proper installation requires one lower fresh air intake

and one upper exhaust vent. The ventilation kits shown in this

manual have been certied for use with RM1350. The ventila-

tion kits must be installed and used without modication.

The certied vent system kits are listed in the following table.





LOWER VENT CUTOUT

13-5/8”

28-5/8”

certified vent system kits

 





5A =

Option 1

Roof Base

Roof Cover

Side Vent

3103633.XXX* or 3310893.XXX*

3103634.XXX* or 3310894.XXX*

3109349.XXX*

Option 3-E Upper side vent

Lower side vent

3109349.XXX*

* Fill in “XXX” with color code numbers. For color codes, contact

your supplier.

An opening toward the outside at oor level in the refrigerator

compartment has to be provided for ventilation of heavier-than-

air fuel gases

CAUTION













ventilation heights

It is essential that all maximum or minimum dimensions are

strictly maintained as the performance of the refrigerator is de-

pendent on adequate ow of air over the rear of the refrigerator.

For an installation with roof vent and lower side vent or double

side vent, the minimum ventilation height should be 63 inches

.















-









- 6 -

securing the refrigerator

It is important to follow the sequence in securing refrigerator

in enclosure since failure in doing so can cause leakage be-

tween the frame and cabinet. Any space between the counter,

storage area or ceiling and top of the refrigerator greater than

1-1/2 inches should be blocked. The heat produced at the rear

of the refrigerator will become trapped in this space, making

the top of the refrigerator hot and reduce the efciency of the

refrigerator.

After the refrigerator is put in place (ensuring a combustion

seal at the front frame), the refrigerator is to be secured in the

enclosure with six screws (not included).

installation procedure

A wood strip must be in place across the upper opening•

of the enclosure. The top frame of the refrigerator will be

anchored to the wood strip with screws.

installing the refrigerator

The refrigerator must be installed in a substantial enclosure•

and must be level.

Do not install the appliance directly on carpeting. Carpet-•

ing must be removed or protected by a metal or wood panel

beneath the appliance, which extends at least full width and

depth of the appliance.

All areas within the recess in which the refrigerator is•

installed must be sealed. Make sure that there is a complete

seal between the front frame of the refrigerator and the

top, sides and bottom of the enclosure. A length of sealing

strip is applied to the rear surface of the front frame for this

purpose. The sealing strip should provide a complete isola-

tion of the appliance’s combustion system from the vehicle

interior.







Wood strip

ventilation requirements



Height () mm 1632

inches 64-17/64

Width (B) mm 855

inches 33-11/16

Depth () mm 722 (steel doors)

750 (door insert panels)

inches 28 1/16 (steel doors)

29 1/2 (door insert panels)



Height (H) mm 1605

inches 63-3/16

Width (W) mm 832

inches 32-3/4

Depth () mm 662

inches 26-1/16

overall and recess dimensions





H A

- 7 -

INSTALL THE SIX SCREWS IN THE FOLLOWING

ORDER:





The refrigerator is provided with a lower front strip

(shipped as a loose part). Attach the front strip after

the refrigerator is set into the cutout opening.

Install the lower front strip by sliding it under thea)

bottom hinge plates.

Secure the refrigerator and the lower front stripb)

with two screws - one screw through each hinge.



Open the doors and fasten the refrigerator with two

screws through the holes underneath the top

decoration panel.



installing the drain water hose

TO INSTALL THE DRAIN WATER HOSE, FOLLOW

THESE STEPS:

Drill a hole through ooring. It is essential that it is 1.

drilled in the cut out opening of the base plate at the

rear of the refrigerator.

Make sure that the hose does not kink when run2.

through the oor.

Seal around the hose that goes through the drilled3.

hole. If a longer hose than supplied is required, the

installer needs to supply one in order for the water to

drain outside of the vehicle.





Ice maker

cord (optional)

Ice maker

cord (optional)

General view. Features may vary according to model.

installation procedure

- 8 -

alternator (d+) connection

D+ connection is only valid for models with the

automatic door locking system. The refrigerator requires the

connection of a signal wire from the alternator (D+) in order

to maintain the automatic door travel latch and the temporary

gas lockout function. The gas operation will automatically

be locked out for a period of 15 minutes when the engine is

switched off. This will prevent gas operation e.g. when stop-

ping at a refueling station.

Connect the vehicles alternator (D+) to the D+ on the

terminal block.

connections

electrical connection

120 v ac connection

The refrigerator is equipped with a three-prong (grounding)

plug for your protection against shock hazards and should be

plugged directly into a properly grounded three prong recep-

tacle. 



The free length of the cord is 3 feet. It is recommended that the

receptacle is located to the right side of the refrigerator (viewed

from the rear).

The receptacle should be 3” (from the

bottom of the plastic receptacle) above

the refrigerator mounting oor. This

allows easy access through the vent

door. The cord should be routed to

avoid direct contact with components

that could damage the cord insulation.

12v dc

The refrigerator requires a continuous 12V DC supply to

maintain operation. The DC supply connection is made to the

positive (+) and negative (-) terminals of the terminal block on

the back of the refrigerator.

Correct polarity must be observed when connecting to the DC

supply. Do not use the chassis or vehicle frame as one of the

conductors. Connect two wires at the refrigerator and route to

the DC supply. It is important that the wires to the 12V DC

terminal is of proper wire size.

The following table displays the recommended size and length

of the conductor wires.

maximum total conductor wire length

Wire length AWG

17 ft (5 m)

27 ft (8 m)

Example: If the distance between the refrigerator and the

12V DC supply is 17 ft, the total wire length is 34 ft and a wire

size of 14 AWG should be used.

Battery

B+

Alternator signal wire to the refrigerator D+

ALTERNATOR

Ignition switch

Charge light

D+ (Alternator signal wire)

Valid for refrigerator models

with the automatic door lock-

ing system.

3”

General view.

Features may vary

according to model.

- 9 -

gas connection

Hook up to the gas supply line is accomplished at the manual

gas valve, which is furnished with a 3/8” SAE (UNF 5/8” -18)

male are connection. All completed connections should be

checked for leaks with a commercial non corrosive bubble

solution.

Always use a back up wrench when loosening and

tightening connections.

The gas supply system must incorporate a pressure regulator

to maintain a supply pressure of not more than 11 inches water

column.

When testing the gas supply system at test pressures:

 - the refrigerator and its individual shutoff valve

must be disconnected from the gas supply piping system.

 - the appliance must be isolated from the gas

supply piping system by closing its individual manual shut-

off valve.

For detailed instructions on the installation and con-

nection to the gas supply, please contact your dealer

or distributor.

testing lp gas safety shut off

The gas safety shut off must be tested after the

refrigerator is connected to LP gas supply.

TO TEST THE GAS SAFETY SHUT OFF, FOLLOW THESE

STEPS:

Turn on the refrigerator and switch to GAS mode.1.

Check that the GAS indicator dot is illuminated and

the gas ame is lit.

Close the manual gas shut off valve at the back of2.

the refrigerator.

Wait for approx. 45 seconds. The message3.

“LP” is displayed (ashing).

Remove the protection cover.4.

Open the manual gas shut off valve. (Do not change5.

any button positions on the control panel.)

Apply a non corrosive commercial bubble solution6.

to the burner jet orice. No bubbles should appear at

the opening of the burner jet orice. The presence of

bubbles indicates a defective gas safety shut off, and

service is required.

connections

If no bubbles were present at the burner jet orice, 7.

rinse it with fresh water. Be careful not to damage

the burner jet orice.

Put back the cover.8.

Switch the refrigerator OFF and back ON again.9.

Normal operation of the burner should return.

Allow the burner to operate for a minimum of 510.

minutes.

water supply connection

rm1350im, rm1350mim, rm1350wim & rm1350wid

The water supply system must have a minimum pressure of

15 pounds per square inch gauge (psig). A 1/4” diameter water

line to the water valve should be used at the rear of the refrig-

erator. The water line must have a manual shutoff valve placed

where it is easily accessible.

WARNING



-





- 10 -

mounting the door panels

panel dimensions













RM1350M

RM1350MIM

RM1350WIM

RM1350WID (left)

inches 19-7/32 19-9/64 15-43/64 15-19/32

mm 488 486 398 396

RM1350WID (right) inches 9-9/32 9-13/64 15-43/64 15-19/32

mm 236 234 398 396



RM1350M

RM1350MIM

RM1350WIM (right)

RM1350WID

inches 40-1/32 39-31/32 15-43/64 15-19/32

mm 1017 1015 398 396

RM1350WIM (left)

Read the instructions thoroughly and check that the panel dimensions are in compliance with those given in the table below.

abc d e f

max min max min max min max min max min max min

inches 5-63/64 5-29/32 9-49/64 9-11/16 11-55/64 11-49/64 28-17/64 28-3/16 15-43/64 15-19/32 40-1/32 39-31/32

mm 152 150 248 246 301 299 718 716 398 396 1017 1015

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Dometic Kühlschrank Handbücher

Dometic

Dometic RMSL8500 Bedienungsanleitung

Dometic

Dometic 8 Series Bedienungsanleitung

Dometic

Dometic RM2351 Bedienungsanleitung

Dometic

Dometic RM 7401 Handbuch

Dometic

Dometic RC10.4T.70 Bedienungsanleitung

Dometic

Dometic CR Series Bedienungsanleitung

Dometic

Dometic Servel RGE400 Bedienungsanleitung

Dometic

Dometic REFRIGERATION 10-Series Bedienungsanleitung

Dometic

Dometic 5 Series Bedienungsanleitung

Dometic

Dometic NDR1292-S Bedienungsanleitung

Dometic

Dometic 8 Series Bedienungsanleitung

Dometic

Dometic RM2554 Handbuch

Dometic

Dometic CoolMatic CD Series Bedienungsanleitung

Dometic

Dometic REFRIGERATION 10-Series Bedienungsanleitung

Dometic

Dometic NEA1402 Bedienungsanleitung

Dometic

Dometic DM50NTE D CL Bedienungsanleitung

Dometic

Dometic HIPRO EVOLUTION Bedienungsanleitung

Dometic

Dometic CFF12 Bedienungsanleitung

Dometic

Dometic NRX0050 Bedienungsanleitung

Dometic

Dometic RM2662 Bedienungsanleitung

Dometic

Dometic CDF2 Bedienungsanleitung

Dometic

Dometic miniBar RH 465LD Bedienungsanleitung

Dometic

Dometic RMV 5301 Bedienungsanleitung

Dometic

Dometic TL200 Bedienungsanleitung

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

Sharp

Sharp SJ-BA31IEXW2-EU Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

Stengel

Stengel KU 1101 A++ Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

Amana

Amana ASD2524VES00 Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Samsung

Samsung RF323TE Bedienungsanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

True

True TS-28 Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung