Electrolux E46GC67ESS - 46" Sealed Burner Gas Cooktop Bedienungsanleitung

Installation InstructionsInstallation Instructions

Installation Instructions

Cooktop

5995426250E30GC64ESS E36GC65ESS E46GC66ESS E46GC67ESS

2Safety

IMPORTANT SAFETY INSTRUCTIONS

Safety Precautions

Do not attempt to install or operate your unit until you have read the safety

precautions in this manual. Safety items throughout this manual are labeled with a

Warning or Caution based on the risk type.

Definitions

This is the safety alert symbol. It is used to alert you to potential personal injury

hazards. Obey all safety messages that follow this symbol to avoid possible injury

or death.

IMPORIMPOR

IMPORTT

TANTANT

ANTANT

ANT

Indicates installation, operation or maintenance information which is important but

not hazard related.

CACA

CAUTIONUTION

UTIONUTION

UTION

CAUTION indicates a potentially hazardous situation which, if not avoided, may result

in minor or moderate injury.

CACA

CAUTIONUTION

UTIONUTION

UTION

CAUTION used without the safety alert symbol indicates a potentially hazardous

situation which, if not avoided, may result in property damage.

WARNINGWARNING

WARNING

WARNING indicates a potentially hazardous situation which, if not avoided, could

result in death or serious injury.

WARNINGWARNING

WARNING

• Read all instructions before using the appliance.

• Improper installation, adjustment, alteration, service, or maintenance can cause

personal injury or property damage. Refer to these instructions and the

accompanying Use & Care Manual. For assistance or additional information,

consult a qualified installer, service agency, manufacturer (dealer), or the gas

supplier.

• For your safety:

- Do not obstruct the flow of combustion and ventilation air to the unit.

- Keep appliance area clear and free from combustible material, gasoline and

other flammable vapors and liquids.

- Do not use or attempt to use this appliance in the event of a power failure.

• This unit is designed as a cooking appliance. Never use it for warming or heating

a room.

• This appliance must not be used in combination with surface (countertop)

ventilation systems. The use of an overhead hood or downdraft is recommended

for ventilation.

• This appliance must be installed with the gas pressure regulator supplied with it.

• Disconnect the electrical supply before installing or servicing the appliance.

• This appliance must be grounded. Connect only to a properly grounded

electrical supply. Refer to “Electrical Requirements”.

• Install or locate this appliance only in accordance with these installation

instructions.

• Use this appliance only for its intended use as described in this manual. Do not

use corrosive chemicals or vapors in this appliance. This type of appliance is not

designed for industrial or laboratory use.

• As with any appliance, close supervision is necessary when used by children.

• Do not operate this appliance if it has a damaged electrical cord, plug, conduit or

wires, if it is not working properly, or if it has been damaged or dropped.

• This appliance should be serviced only by qualified service personnel.

• Some products, such as whole eggs, and sealed containers, such as closed glass

jars, may explode and should not be heated on this cooktop.

Safety

SAFETY PRECAUTIONS

4Safety

WARNINGWARNING

WARNING

• Based on safety considerations, the top burner flame should be adjusted so it

does not extend beyond the edge of the cooking utensil.

• Cooking utensils should not be used on the open top broiler section.

• If the information in this manual is not followed exactly, a fire or explosion

may result causing property damage, personal injury, or death.

• What to do if you smell gas:

- Do not try to light any appliance.

- Do not touch any electrical switch, do not use any phone in your building.

- Immediately call the gas supplier from a neighbor’s phone.

- Follow the gas supplier’s instructions.

- If you cannot reach your gas supplier, call the fire department.

• For your safety:

- Do not store or use gasoline or other flammable vapors and liquids in the

vicinity of this or any other appliance.

• Installation of this appliance must be performed by a qualified installer, service

agency or the gas supplier.

Finding Information

READ AND SAVE THESE INSTRUCTIONS

Read all instructions before installing the cooktop.

For your safety, please read and observe all safety instructions. This guide will help

you anticipate all installation connections.

QUESTIONS?

For toll-free telephone support in the U.S. and Canada:

1-877- 4ELECTROLUX (1-877-435-3287)

For online support and Internet product information:

www.electroluxusa.com

Post Office Box 212378, Augusta, Georgia 30917, USA

Attach your sales

receipt to this

page for future

reference.

NONO

NOTETE

TETE

Installer: Leave instructions with owner.

Owner: Read your cooktop Use & Care Manual. It contains important safety information

for operating this appliance. It also has many suggestions for getting the best results

from your cooktop.

6Finding Information

TABLE OF CONTENTS

Safety ................................................................... 2

Definitions .......................................................... 2

Important Safety Instructions .............................. 2

Safety Precautions ............................................. 3

Finding Information ........................................... 5

Please Read And Save This Guide ................... 5

Questions? ........................................................ 5

Table Of Contents .............................................. 6

Preparing for Installation .................................. 7

Verifying Package Contents ............................... 7

Cabinet/Counterop Preparation ......................... 7

Making the Gas/Electric Connection .............. 10

Requirements .................................................. 10

Installation ........................................................ 12

Installing the Cooktop ....................................... 12

Connecting the Gas ......................................... 12

Gas and Electric Requirements Table .............. 13

Installing the Burner Components .................... 14

Making the Electrical Connection ..................... 15

Operation ........................................................... 16

Verifying the Operation .................................... 16

Preparing for Installation

VERIFY PACKAGE CONTENTS

• Use & Care Manual • Cleaning Kit

• Hold Down Bracket Kit • Grill Drip Pan (E46GC67ESS only)

• Grate/Burner Cap Pack • Grill U-Burner (E46GC67ESS only)

• Burner Set • Grill Heat Control Channels (E46GC67ESS only)

• Gas Pressure Regulator • Grill (E46GC67ESS only)

• LP Conversion Kit • Grease Control Box (E46GC67ESS only)

CABINET/COUNTERTOP PREPARATION

The installation of this built-in appliance must be completed by a qualified appliance

technician or contractor. Proper installation is the owner’s responsibility.

Carefully check the location where the cooktop is to be installed. The cooktop

should be placed for convenient access, but away from drafts that may be caused

by open doors and windows or by HVAC duct outlets. Make certain that gas and

electrical power can be provided in the selected locations. Plan the installation so

that all minimum clearances are met or exceeded. Dimensions shown provide

minimum clearances, unless otherwise noted.

WARNINGWARNING

WARNING

• To reduce the risk of personal injury caused by reaching over a hot appliance,

cabinet storage space located directly above the cooktop should be avoided.

• Keep appliance area clear and free from combustible materials, gasoline and

other flammable vapors and liquids.

• Failure to provide proper clearances may result in a fire hazard!

• Do not store combustible materials or items adversely affected by heat

immediately below the cooktop.

• The back edge of the cooktop must remain a minimum of 2 1/2" (64mm) from any

combustible backsplash material. This will require special cabinet and

countertop dimensions.

8Preparing for Installation

Plan the installation so that the electrical connection, gas

shut-off valve, and pressure regulator are accessible from the

front of the cabinet.

IMPORIMPOR

IMPORTT

TANTANT

ANTANT

ANT

• When installing the cooktop into a laminated (Formica, etc.) or synthetic (Corian,

etc.) countertop, radius the corners of the cutout to prevent cracking of the

countertop.

• Follow the countertop manufacturer’s instructions regarding the minimum corner

radius, use of heat reflective tape, reinforcement of corners, etc.

• If cabinet storage space is to be provided directly above the cooktop, the risk of

personal injury may be reduced by installing a ventilating hood that projects

horizontally a minimum of 5 inches beyond the face of the cabinets.

• Allow a minimum 1/4 inch clearance between the bottom of the any cooktop

chassis and all combustible surfaces, including the upper edge of a drawer

installed below the cooktop. See Figure 1 and related table.

• Access to the underside of the cooktop and the junction box must be provided for

inspection and service.

• A fixed shelf should not be installed below the cooktop.

• Clearance inside the cabinet must allow for proper side mounting bracket

installation. See Figure 2 and related table.

• All models are designed for 24” (610mm) minimum base cabinet depth.

• The maximum depth of cabinets installed above cooking tops is 13 inches

(330mm).

13"

(330mm)

Maximum

3 1/8"

(79mm)

18"

(457mm)

Minimum

30"

(762mm)

Minimum

Clearances to Combustibles

1/4” (6mm)

Mimimum clearance

to combustible

surfaces

Under Cabinet Clearances

Model

E30GC64ESS

E36GC65ESS

E46GC66ESS/67ESS

“A” Minimum “A” Maximum

30” (762mm) 36” (914mm)

36” (914mm) 42” (1067mm)

54” (1372mm)48” (1219mm)

Model

E30GC64ESS

E36GC65ESS

E46GC66ESS/67ESS

“B” Minimum

29” (737mm)

35 1/4” (895mm)

46” (1168mm)

Figure 1

Figure 2

30"

(762mm)

21"

(533mm)

4" (102mm)

Chassis height

1/4" (6mm) Min.

to combustibles

below chassis

27 1/2"

(699mm)

19 7/8" (505mm)

3 1/8"

(79mm)

7 1/2" (191mm) Min.

to combustible

side wall above

the cooktop

(both sides)

2 1/4"

(57mm) Min.

Vertical

combustible

surface

Rear

wall

(51mm) Min.

25" (635mm)

Minimum

Cutout Dimensions for the

E30GC64ESS

21"

(533mm)

4" (102mm)

46"

(1168mm)

44 1/2"

(1130mm)

19 7/8" (505mm)

3 1/8"

(79mm)

1/4" (6mm) Min.

to combustibles

below chassis

7 1/2" (191mm) Min.

to combustible

side wall above

the cooktop

(both sides)

Vertical

combustible

surface

Rear

wall

2 1/4"

(57mm) Min.

(51mm) Min.

25" (635mm)

Minimum

6 1/2"

(165mm)

30 1/2"

(775mm)

14"

(356mm)

Cutout Dimensions for the

E46GC66ESS and E46GC67ESS

(E46GC67ESS model shown)

36"

(914mm)

21"

(533mm)

19 7/8"

(505mm)

33 3/4"

(857mm)

4" (102mm)

Chassis height

3 1/8"

(79mm)

1/4" (6mm) Min.

to combustibles

below chassis

7 1/2" (191mm) Min.

to combustible

side wall above

the cooktop

(both sides)

2 1/4"

(57mm) Min.

Vertical

combustible

surface

Rear

wall

(51mm) Min.

25" (635mm)

Minimum

Cutout Dimensions for the

E36GC65ESS

Preparing for Installation

Figure 3

Figure 4

Figure 5

10 Making the Gas/Electric Connection

REQUIREMENTS

Gas Supply Requirements

Check your local building codes for the proper method of installation. In the

absence of local codes, this appliance should be installed in accordance with the

National Fuel Gas Code ANSI Z223.1/NFPA 54. Be certain that the appliance being

installed is correct for the gas service being provided. Refer to the data plate

located on the bottom of the cooktop chassis.

WARNINGWARNING

WARNING

• If the gas or electric service provided does not meet the product specifications,

do not proceed with the installation. Call the selling dealer, the gas supplier, or a

licensed electrical or plumbing contractor.

• The grounding plug must not, under any circumstances, be cut or removed.

• This appliance must be installed by a licensed plumber or gas fitter when

installed within the Commonwealth of Massachusetts.

IMPORIMPOR

IMPORTT

TANTANT

ANTANT

ANT

• All gas cooktops have the gas and electrical located in the back right corner as

you face the front of the appliance.

• Each cooktop ships with a factory regulator in the box. All models utilize 1/2”

regulators.

IMPORIMPOR

IMPORTT

TANTANT

ANTANT

ANT

• No adjustment of burner settings is required. All valves and air mixture shutters

found in this appliance have been factory preset for natural gas.

• An LP Conversion Kit is included with this product. Do not use any other

conversion method or components other than the kit enclosed.

Andere Handbücher für E46GC67ESS - 46" Sealed Burner Gas Cooktop

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Electrolux Kochfeld Handbücher

Electrolux

Electrolux ICON E30GC64ESS Bedienungsanleitung

Electrolux

Electrolux E36GC70FSS - Icon 36 Inch Drop-In Gas... Bedienungsanleitung

Electrolux

Electrolux WHS642SA Bedienungsanleitung

Electrolux

Electrolux E36GC75GSS2 Bedienungsanleitung

Electrolux

Electrolux FPIC3695MS Bedienungsanleitung

Electrolux

Electrolux Electric Cooker Bedienungsanleitung

Electrolux

Electrolux E46GC66ESS Bedienungsanleitung

Electrolux

Electrolux ECCI3668AS Bedienungsanleitung

Electrolux

Electrolux EW30GC60IS2 Bedienungsanleitung

Electrolux

Electrolux Electric Cooktop Bedienungsanleitung

Electrolux

Electrolux CHC645BA Betriebsanleitung

Electrolux

Electrolux EW30EC55GB - 30" - Electric Cooktop Gebrauchsanweisung

Electrolux

Electrolux GHS607W Bedienungsanleitung

Electrolux

Electrolux E30IC75FSS - 30 Inch Drop-In Induction... Bedienungsanleitung

Electrolux

Electrolux EW30CC55GW - 30in Electric Cooktop Gebrauchsanweisung

Electrolux

Electrolux EHD90LLUM Bedienungsanleitung

Electrolux

Electrolux E36GC70FSS1 Bedienungsanleitung

Electrolux

Electrolux GAS COOKTOP Bedienungsanleitung

Electrolux

Electrolux E36IC75FSS4 Bedienungsanleitung

Electrolux

Electrolux EW30IC60I S Bedienungsanleitung

Electrolux

Electrolux ICON Designer E30EC65ESS Bedienungsanleitung

Electrolux

Electrolux EHG6341FOK Bedienungsanleitung

Electrolux

Electrolux E36IC80QSS Bedienungsanleitung

Electrolux

Electrolux EW30GC55GB - 30in Gas Cooktop Gebrauchsanweisung

Beliebte Kochfeld Handbücher anderer Marken

Bonnet

Bonnet OPTIMUM 700 Betriebsanleitung

Jenn-Air

Jenn-Air JGCP430 Bedienungsanleitung

Frigidaire

Frigidaire FES367FCC Kurzanleitung

Ztove

Ztove EZ2 DUO Bedienungsanleitung

Kleenmaid

Kleenmaid cooking GCTK9011 Installationsanleitung

Jenn-Air

Jenn-Air JGC2536EB00 Bedienungsanleitung

Waldorf

Waldorf RN8603E-B Bedienungsanleitung

Whirlpool

Whirlpool SMP658CNEIXL Bedienungsanleitung

Wolf

Wolf CI243C/B Bedienungsanleitung

Fulgor Milano

Fulgor Milano F5PGK305S1 Bedienungsanleitung

GE JP389 Bedienungsanleitung

Wells

Wells WV-2HFG Bedienungsanleitung

IKEA

IKEA Lagan HGA4K Bedienungsanleitung

Samsung

Samsung NA36N9755 Bedienungsanleitung

Miele

Miele KM 404 Bedienungsanleitung

Lacor

Lacor 69562 Technisches Datenblatt

Keating Of Chicago

Keating Of Chicago MG-2 Bedienungsanleitung

Jenn-Air

Jenn-Air CCE1400 Bedienungsanleitung