Empire Comfort Systems Boulevard LS41THF-1 Kurzanleitung

LOG SET FOR USE WITH

DIRECT VENT FIREPLACE

MODELS:

DVTL41BP90(N,P)-1

WARNING: If not installed, operated and maintained

in accordance with the manufacturer's instructions,

this product could expose you to substances in fuel

or from fuel combustion which can cause death or

serious illness.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future

reference.

GAS-FIRED

INSTALLATION INSTRUCTIONS

AND

OWNER’S MANUAL

EMPIRE

Comfort Systems

LS41THF-1

CHARRED LOGS

WARNINGS

If the information in this manual is not followed ex-

actly, a re or explosion may result causing property

damage, personal injury or loss of life.

– Do not store or use gasoline or other ammable

vapors and liquids in the vicinity of this or any

other appliance.

– Installation and service must be performed by a

qualied installer, service agency or the gas sup-

plier.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any

phone in your building.

• Immediately call your gas supplier from neighbor’s

phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the re

department.

Page 1

fire-parts.com

33636-0-0314Page 2

TABLE OF CONTENTS

Important Installation Guidelines..............................................................................3

General Information .................................................................................................3

Log Identication ......................................................................................................4

Log Placement ..................................................................................................5 - 10

Master Parts Distributor List................................................................................... 11

How To Order Repair Parts ....................................................................................11

SECTION PAGE

fire-parts.com

33636-0-0314 Page 3

Proper Log Placement

Log placement is critical to proper burner performance. Logs must

be correctly positioned. The photos in this manual show the proper

pinned position for logs on this set. Owners need to be shown proper

log placement and instructed not to move the logs.

Logs must t rmly onto the burner when positioned as shown in

the photos. Misformed logs or logs with sloppy pin holes must be

replaced.

Proper Placement of Glowing Embers

Glowing embers can be added to burners for a glowing ember effect.

It must be positioned only on top of the burner. The photos in this

manual show the proper placement of glowing embers.

Make Owners Aware of Proper Log Set Operation

Properly installed and properly maintained log sets do not deposit

soot on the logs. If users see soot appear on a log, call for service.

Do not continue to operate the log set.

Qualied Installing Agency

Installation and replacement of gas piping, gas utilization

equipment or accessories and repair and servicing of equip-

ment shall be performed only by a qualied agency. The term

"qualied agency" means any individual, rm, corporation,

or company that either in person or through a representa-

tive is engaged in and is responsible for (a) the installation,

testing, or replacement of gas piping or (b) the connection,

installation, testing, repair, or servicing of equipment; that is

experienced in such work; that is familiar with all precautions

required, and that has complied with all the requirements of

the authority having jurisdiction.

The installation must conform with local codes or, in the

absence of local codes, with the National Fuel Gas Code,

ANSI Z223.1/NFPA54.*

*Available from the American National Standards Institute, Inc. 11 West

42nd St., New York, N.Y. 10018.

State of Massachusetts: The installation must be made

by a licensed plumber or gas tter in the Commonwealth

of Massachusetts.

Sellers of unvented propane or natural gas-red supple-

mental room heaters shall provide to each purchaser a

copy of 527 CMR 30 upon sale of the unit.

Appliance Certication

This logset is design certied in accordance with American National

Standard/CSA Standard ANSI Z21.88/CSA 2.33 and by Underwrit-

ers Laboratories for use with a Direct Vent Gas Fireplace Heater

and shall be installed according to these instructions.

IMPORTANT INSTALLATION GUIDELINES

GENERAL INFORMATION

fire-parts.com

33636-0-0314Page 4

LOG IDENTIFICATION

TOP VIEW FRONT VIEW DESCRIPTION PART

NUMBER

REAR LOG (A) 33582

RIGHT LOG (C) 33583

LEFT LOG (B) 33584

TOP BRANCH (D) 33585

LEFT FRONT TWIG (E) 33586

fire-parts.com

33636-0-0314 Page 5

Before you begin: Do not, handle these logs with your bare hands! Always wear gloves to prevent skin irritation. After handling

logs, wash your hands gently with soap and water.

All Logs

The positioning of the logs is critical to the safe and clean operation of this heater. Sooting and other problems may result if

the logs are not properly and rmly positioned in the appliance.

Refer to Figure 1 for the following warning.

Warning: Failure to position the parts in accordance with this diagram or failure to use only parts specically approved

with this appliance may result in property damage or personal injury.

Log Placement - Figure 1

LOG PLACEMENT

Attention: Refer to Page 4 Parts List and Parts View to order logs

for your appropriate model number.

Glowing embers should be dime-sized pieces that are uffed up

prior to placement onto the burner. A single layer of glowing embers

is sufcient; do not over-apply.

NOTE: Once the installation is complete with the log set and glowing

embers in place, operate the replace to verify ame appearance.

If there are ames directly impinging a log, turn off replace, then

remove the glowing ember material directly below where the ame

impingement occurred. This should eliminate sooting on the log,

and provide a more pleasing ame appearance.

Replacement of glowing embers must be purchased from Empire

Comfort Systems, Inc. Application of excess glowing embers may

adversely affect performance of the heater. WARNING: All previously

applied loose material must be removed prior to reapplication.

Replacement glowing embers Part Number

LS41THF 15999

PLACE GLOWING EMBERS (ROCK WOOL)

IN SHADED AREA ONLY.

FRONT VIEW - COMPLETED LOG SET INSTALLATION (WITHOUT EMBERS)

fire-parts.com

33636-0-0314Page 6

TOP VIEW

FRONT VIEW

1. Place the Rear Log (A) onto the rear of the burner cover so that it rests against the back of the rebox. Center the log so the ends

of the log are approximately 1 inch from the sides of the rebox.

Note: The back log may require some rotation so it rests against the rear wall of the rebox.

LOG PLACEMENT

fire-parts.com

33636-0-0314 Page 7

TOP VIEW

FRONT VIEW

2. Place Left Log (B) onto the left pin on the Rear Log (A) and angled down so that it rests on the front of the burner cover and

against the left wall of the rebox.

LOG PLACEMENT

fire-parts.com

33636-0-0314Page 8

TOP VIEW

FRONT VIEW

3. Place Right Log (C) onto the right pin on the Rear Log (A) and angled down so that it rests on the front of the burner cover and

against the right wall of the rebox.

LOG PLACEMENT

fire-parts.com

33636-0-0314 Page 9

TOP VIEW

FRONT VIEW

4. Place Top Branch (D) onto the pin on the Left Log (B) and angled down so that it is pinned and rests on the front of the burner

cover.

LOG PLACEMENT

fire-parts.com

33636-0-0314Page 10

TOP VIEW

FRONT VIEW

5. Place Left Front Log (E) onto the left two pins on the burner cover.

LOG PLACEMENT

fire-parts.com

Inhaltsverzeichnis

Andere Empire Comfort Systems Kamin im Innenbereich Handbücher

Empire Comfort Systems

Empire Comfort Systems DVP42FP3(0 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems DVX36FP32CLN-2 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems White Mountain Hearth VFP24FP20LN-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems DVL25FP32-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems CIBV-30-2 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems MV CONTROL DVL36BP30KN-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems DVCT30CBN95N-2 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems DVP36PP32EN-3 Series Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems VFLC10IN32N-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems DVF-36-3 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems VFLL38FP Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems VFP20IN30L10N-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems VFP36SP32E Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems VFFB-36D Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems vfp36pp32EN-2vfp36pp32Ep-2 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems VFP32BP20LN-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems DV25IN33L-3 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems DVCT40CSP95P Planungshandbuch

Empire Comfort Systems

Empire Comfort Systems WB17IN Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems OP32FB2MF-1 Bedienungsanleitung

Empire Comfort Systems

Empire Comfort Systems Boulevard VFLB60FP90N-1 Planungshandbuch

Empire Comfort Systems

Empire Comfort Systems BFM18MTN Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems VFD32FB0L-1 Kurzanleitung

Empire Comfort Systems

Empire Comfort Systems Mantis PV-28SV50-BN-1 Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Austro Flamm

Austro Flamm Heidi Back 2.0 945048 Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung