EnnoPro Group Limited Product Model:CEBA158V
Address:7th Floor, Huarong Building, Qiaolian East, Bulong Road, Longgang District,Zip Code:
518129 | Shenzhen, Guangdong, China
Tel:0086 755 89205835 fax:+86 7558920 5835-812
Web:www.cebabattery.com E-mail: info@cebabattery.com
5.maintenance regulations
The SOC of our battery pack is 60%~80% when leaving the factory, in long-term storage, battery should
be stored in a charged state (usually the SOC is 80%). Have a charge and discharge maintenance to
battery pack when the storage time is over 6 months or battery module’s voltage is 15V,to prevent the
battery performance’s decline caused by the self-discharge. The maintenance regulations are as follows:
（1）Discharge: 2A discharge to 132V (that is to say: single cell 1.0V)
（2）Interval: 30 minutes
（3）Charge: 1.3A charge for 5 hours (voltage≥198V, -ΔV≥0.2V and temperature ≥50℃)
（4）Interval: 1hours
（5）Discharge: 2A discharge to 132V (that is to say: single cell 1.0V)
（6）Interval: 30 minutes
（7）Charge: 2A charge for 2.4 hours
6.Installation Cautions of battery pack
Notes: Installing this product should only be attempted by a qualified technician, the voltage of the
battery pack is very high, which has the shock hazards, so when installing the battery pack, you should
wear insulating gloves and use insulated handle tools.
6.1 Please operate according to assembly manual during the installation of Prius battery pack.
6.2 Do not mix our battery modules with those of other manufacturers, or new battery modules in use
with semi-used battery modules, and don’t mix battery modules within a battery pack with those in other
battery pack.
6.3 Don’t twist and bend battery modules and accessories when assembling battery pack.
6.4 Don’t connect the anode and cathode of battery module in reverse when assembling battery pack,
to prevent short circuits.
6.5 Fasten bolts and nuts with appropriate torque, avoid loose connection or damaging other accessories
with too big torque.
7. Use Cautions of battery pack
7.1 Ensure the normal operation of car management system during the use process, and forbid over-
charge and over-discharge to battery.
7.2 As storage battery is charged by gasoline engine, so external power supply charge is not needed.
However, if the vehicle parks for a long time, the electricity of high power storage battery will run out.
Therefore, be sure to drive the car for at least 30minutes or 16Km every several months.
7.3 If there is leaked liquid, don’t touch the spilled liquid, because this may be the alkaline electrolyte
that hybrid battery leaks. If skin and eyes contact to this liquid, please flush with plenty of water at once,
or if possible, wash with boric acid solution and see the doctor at once.
