2
Important Health and Safety Information for Installers and Service Engineers
Health and Safety at Work Act 1974
Consumer Protection Act 1987
COSHH Regulations 1988
The following information is given as a requirement of the
above legislation.
Great care is taken by GAH (HEATING PRODUCTS) LIMITED
to ensure that Electrastream systems are designed and
manufactured to meet general safety requirements when
properly used and installed as recommended in this manual.
It is the responsibility of Users and Engineers to ensure that
adequate protective clothing and glasses are worn when
working with the Electrastream system.
SEALS AND INSULATIONSEALS AND INSULATION
SEALS AND INSULATIONSEALS AND INSULATION
SEALS AND INSULATION
Insulation and sealing materials are used in the construction
of the Electrastream cylinders. Units are sealed and when
used in the manner for which they are intended the insulating
and sealing materials do not present any known hazard.
However always observe the following recommendations:-
1. Avoid inhalation of fibres or dust, wear face mask.
2. Avoid eye contamination by fibres or dust - wear eye
protection.
3. As far as possible avoid any skin contact with Fibreglass
Insulation, Glass Rope, Mineral Wool, Insulation Pads and
Ceramic Fibre.
PPPPPatent application 01514800.2atent application 01514800.2
atent application 01514800.2atent application 01514800.2
atent application 01514800.2
©©©©© 2010 GAH (HEATING PRODUCTS) L 2010 GAH (HEATING PRODUCTS) L
2010 GAH (HEATING PRODUCTS) L 2010 GAH (HEATING PRODUCTS) L
2010 GAH (HEATING PRODUCTS) LTD.TD.
TD.TD.
TD.
ElectrastrElectrastr
ElectrastrElectrastr
Electrastream is a Team is a T
eam is a Team is a T
eam is a Trademark of GAH (HEATING PRODUCTS) Lrademark of GAH (HEATING PRODUCTS) L
rademark of GAH (HEATING PRODUCTS) Lrademark of GAH (HEATING PRODUCTS) L
rademark of GAH (HEATING PRODUCTS) LTD.TD.
TD.TD.
TD.
Manual by Harber Technical Services Tel/Fax 01263 515444
E-mail:info@harbertech.co.uk www.harbertech.co.uk
GAH (Heating PrGAH (Heating Pr
GAH (Heating PrGAH (Heating Pr
GAH (Heating Products) Ltd.oducts) Ltd.
oducts) Ltd.oducts) Ltd.
oducts) Ltd.
Building 846
Bentwaters Parks
Rendlesham
Woodbridge
Suffolk IP12 2TW
TTTTTel:el:
el:el:
el: 01394 42116001394 421160
01394 42116001394 421160
01394 421160
Fax:Fax:
Fax:Fax:
Fax: 01394 42117001394 421170
01394 42117001394 421170
01394 421170
www.gah.co.uk
In pursuance of a policy of constant development, GAH (HEATING PRODUCTS) LIMITED
reserve the right to change Electrastream parts or design without notice, therefore
certain details included in this manual may not be correct at the time of printing. Any
modification and improvements detailed in this manual does not commit GAH to update
any system previously supplied.
Manual Part No. ...................MAN1019
Manual Ref ..........................ES02
Issue ...................................13
Date ....................................25/02/13
GAH (HEATING PRODUCTS) LIMITED will not accept
responsibility for any damage or personal injury caused
by not giving due consideration to the above safety
recommendations.
OTHER MATERIALSOTHER MATERIALS
OTHER MATERIALSOTHER MATERIALS
OTHER MATERIALS
SEALANTS, ADHESIVES AND PAINTS
Sealants, Adhesives and Paints are used in the construction of
the Electrastream components. When used in the manner for
which they are intended they do not present any known hazard.
ELECTRICELECTRIC
ELECTRICELECTRIC
ELECTRIC
The Cylinder Tri-Core Heater, Pump, Thermostats and Contactor
Box all have electrical supply of 230V (enough to endanger
life).
Always isolate before connection, adjustment, servicing and
repair.
When the Tri-Core Heater cover is removed high power live
electrical terminals are exposed.
ISOLATE THE TRI-CORE HEATER BEFORE REMOVING ITS
COVER.
Earth protection - Earth Continuity Conductors must be fitted
and must comply with IEE Wiring Regulations.
HTS REF GAH ELECTRASTREAM 25/02/13
HEALHEAL
HEALHEAL
HEALTH & SAFETYTH & SAFETY
TH & SAFETYTH & SAFETY
TH & SAFETY
4
IMPORTANT INFORMATION
IMPORTIMPORT
IMPORTIMPORT
IMPORTANT INFORMAANT INFORMA
ANT INFORMAANT INFORMA
ANT INFORMATIONTION
TIONTION
TION
BEFORE STARBEFORE STAR
BEFORE STARBEFORE STAR
BEFORE STARTING THE INSTALLATION OF THE ELECTRASTREAM CHECK ALL COMPONENTS HAVE BEEN DELIVERED AND ARETING THE INSTALLATION OF THE ELECTRASTREAM CHECK ALL COMPONENTS HAVE BEEN DELIVERED AND ARE
TING THE INSTALLATION OF THE ELECTRASTREAM CHECK ALL COMPONENTS HAVE BEEN DELIVERED AND ARETING THE INSTALLATION OF THE ELECTRASTREAM CHECK ALL COMPONENTS HAVE BEEN DELIVERED AND ARE
TING THE INSTALLATION OF THE ELECTRASTREAM CHECK ALL COMPONENTS HAVE BEEN DELIVERED AND ARE
IN SATISFACTORY CONDITION - RIN SATISFACTORY CONDITION - R
IN SATISFACTORY CONDITION - RIN SATISFACTORY CONDITION - R
IN SATISFACTORY CONDITION - Refer to 1-3.efer to 1-3.
efer to 1-3.efer to 1-3.
efer to 1-3.
Delivery
Standard Electrastream systems will be delivered wrapped on single pallet with cylinder together with box containing control box
and loose components.
Pre-Plumbed Electrastream systems will be delivered wrapped on single pallet with cylinder, control box and all components fully
assembled.
Pack should be lifted using suitable sized pallet truck or fork lift truck.
WEIGHTS OF PACKED CYLINDERS and COMPONENTS
Storage
Prior to installation the cylinder and box should remain on its pallet with wrapping intact and stored upright. The cylinder and
components must be stored safely in a dry, frost free environment and protected from accidental damage.
WARNING TO THE USERWARNING TO THE USER
WARNING TO THE USERWARNING TO THE USER
WARNING TO THE USER
DO NOT rDO NOT r
DO NOT rDO NOT r
DO NOT remove or adjust any component paremove or adjust any component par
emove or adjust any component paremove or adjust any component par
emove or adjust any component part of the unvented water heater: contact the t of the unvented water heater: contact the
t of the unvented water heater: contact the t of the unvented water heater: contact the
t of the unvented water heater: contact the INSTALLERINSTALLER
INSTALLERINSTALLER
INSTALLER.....
In the event of hot water/steam being emitted at the discharIn the event of hot water/steam being emitted at the dischar
In the event of hot water/steam being emitted at the discharIn the event of hot water/steam being emitted at the dischar
In the event of hot water/steam being emitted at the discharge pipe or tundish, switch the system Off and contact installer - rge pipe or tundish, switch the system Off and contact installer - r
ge pipe or tundish, switch the system Off and contact installer - rge pipe or tundish, switch the system Off and contact installer - r
ge pipe or tundish, switch the system Off and contact installer - refer toefer to
efer toefer to
efer to
Fault Finding section 7.Fault Finding section 7.
Fault Finding section 7.Fault Finding section 7.
Fault Finding section 7.
If the ElectrastrIf the Electrastr
If the ElectrastrIf the Electrastr
If the Electrastream system develops a fault or is not operating as expected: contact the eam system develops a fault or is not operating as expected: contact the
eam system develops a fault or is not operating as expected: contact the eam system develops a fault or is not operating as expected: contact the
eam system develops a fault or is not operating as expected: contact the INSTALLERINSTALLER
INSTALLERINSTALLER
INSTALLER.....
IMPORIMPOR
IMPORIMPOR
IMPORTANT TO THE INSTALLERTANT TO THE INSTALLER
TANT TO THE INSTALLERTANT TO THE INSTALLER
TANT TO THE INSTALLER
This installation is subject to Building RThis installation is subject to Building R
This installation is subject to Building RThis installation is subject to Building R
This installation is subject to Building Regulation Appregulation Appr
egulation Appregulation Appr
egulation Approval, notifoval, notif
oval, notifoval, notif
oval, notify the Ly the L
y the Ly the L
y the Local Authority of intention to install.ocal Authority of intention to install.
ocal Authority of intention to install.ocal Authority of intention to install.
ocal Authority of intention to install.
Use only manufacturUse only manufactur
Use only manufacturUse only manufactur
Use only manufacturers rers r
ers rers r
ers recommended recommended r
ecommended recommended r
ecommended replacement pareplacement par
eplacement pareplacement par
eplacement parts.ts.
ts.ts.
ts.
The following Information must be prThe following Information must be pr
The following Information must be prThe following Information must be pr
The following Information must be provided:-ovided:-
ovided:-ovided:-
ovided:-
sm e t s y S l i o Ce l g n i S l i o Ce l g n i S
s m e t s y Sd e bmu l P - e r P
l i o Cn i w T
s m e t s y Sd e bmu l P - e r P
'P'sulP
r o t a l umu c c A
l edoMth g i e wk c a P
✓
l edoMth g i e wk c a P
✓
l edoMth g i e wk c a P
✓
l edoMth g i e wk c a P
✓
031LEB
gk55
031PEB
gk17
512PTEB
gk771002gk53
051LEB
gk06
051PEB
gk6
03gk05
R521PEB
gk77
INSTALLED BY:-
Name ............................................................................................................
Address .........................................................................................................
Tel. ................................................................................................................
Completion Date ...........................................................................................
ELECTRICS BY:-
Name ............................................................................................................
Address .........................................................................................................
Tel. ................................................................................................................
Completion Date ...........................................................................................
