Glowworm Flexicom hx Bedienungsanleitung

To be left with the user

www.glow-worm.co.uk

Instructions for Use

High Efﬁciency Condensing System Boilers

Flexicom hx

www.glow-worm.co.uk

WARNING

GAS LEAK OR FAULT

Turn off the gas emergency control valve immediately. Eliminate all sources of ignition, i.e.smoking, blowlamps, hot air

guns etc. Do not operate electrical lights or switches either on or off. Open all doors and windows, ventilate the area.

SHEET METAL PARTS

This boiler contains metal parts (components) and care should be taken when handling and cleaning, with particular

regard to edges.

SEALED COMPONENTS

Under no circumstances must the User interfere with or adjust sealed parts.

Customer service call: 01773 828100 Technical helpline: 01773 828300

General and Sales enquiries Tel: 01773 824639 Fax: 01773 820569

Glow-worm is a licensed member of the Benchmark Scheme which aims to improve the standards of installation and

commissioning of domestic heating and hot water systems in the UK and to encourage regular servicing to optimise safety,

ef ciency and performance.

Benchmark is managed and promoted by the Heating and Hotwater Industry Council.

For more information visit www.centralheating.co.uk

www.glow-worm.co.uk

G.C. No. 41-315-28

G.C. No. 41-315-29

G.C. No. 41-315-42

G.C. No. 41-315-61

Flexicom

24hx

Flexicom

24hx

Flexicom

24hx

13109

Position of name

badge (typical shown)

G.C. No. 41-315-67

G.C. No. 41-315-68

Flexicom

15hx

Flexicom

12hx

Flexicom

18hx

Flexicom

24hx

Flexicom

30hx

Flexicom

35hx

www.glow-worm.co.uk

Important Information 5

Boiler Design 6

Boiler Safety Devices 7

Maintenance 8

Boiler Operation 9

CONTENTS

These instructions are an integral part of the boiler and must, to comply with the current issue of the Gas Safety (Installation and

Use) Regulations, be left with the user.

Please ensure that the installer has fully completed the Benchmark Checklist in the centre pages of the installation instructions

supplied with the product and that you have signed it to say that you have received a full and clear explanation of its operation.

The installer is legally required to complete a commissioning checklist as a means of complying with the appropriate Building

Regulations (England and Wales).

All installations must be notied to Local Area Building Control either directly or through a Competent Persons Scheme. A Building

Regulations Compliance Certicate will then be issued to the customer who should, on receipt, write the Notication Number on

the Benchmark Checklist.

Please read these instructions and follow them carefully for the safe and economical use of your boiler.

www.glow-worm.co.uk

Gas Safety (Installation and Use) Regulations

In your own interests and that of safety, it is the Law that ALL gas

appliances have been installed by a competent person approved at

the time by the Health and Safety Executive, in accordance with the

current issue of these regulations.

Control of Substances Hazardous to Health

Under Section 6 of The Health and Safety at Work Act 1974, we are

required to provide information on substances hazardous to health.

The adhesives and sealants used in this appliance are cured and give

no known hazard in this state.

Electrical Connection

The boiler MUST be earthed.

The boiler MUST be connected to a permanent 230V ac, 50Hz supply.

Connection of the whole electrical system of the boiler, including any

heating controls, to the electrical supply must be through one common

isolator and must be fused to 3 Amps maximum.

The colours of three core exible cable are, blue - neutral, brown - live,

green and yellow - earth.

All connections must be routed through the Installer Interface.

IMPORTANT NOTE

ALL electrical connections to the boiler must

be permanently xed to a wall or a sturdy

support feature.

Gas Category

This boiler is for use only on G20 natural gas.

Testing and Certication

This boiler is certicated to the current issue of EN 483 for

performance and safety.

It is important that no alteration is made to the boiler unless

approved, in writing, by Glow-worm.

Any alteration not approved by Glow-worm, could invalidate the

certication, boiler warranty and may also infringe the current issue of

the statutory requirements.

CE Mark

This boiler meets the requirements of Statutory Instrument, No. 3083

of the Boiler (Efciency) Regulations, and therefore is deemed to meet

the requirements of Directive 92/42/EEC on the efciency requirements

for new hot water boilers red with liquid or gaseous fuels.

Type test for purposes of Regulation 5 certied by: Notied body 0087.

Product/production certied by: Notied body 0086.

The CE mark on this appliance shows compliance with:

1. Directive 90/396/EEC on the approximation of the laws of the

Member States relating to appliances burning gaseous fuels.

2. Directive 73/23/EEC on the harmonisation of the Laws of the

Member States relating to electrical equipment designed for use within

certain voltage limits.

3. Directive 89/336/EEC on the approximation of the Laws of the

Member States relating to electromagnetic compatibility.

Important Information

www.glow-worm.co.uk

Boiler Design

Description

The boiler is designed to provide central heating from a fully

pumped open vented or sealed water system with an indirect

cylinder.

The daily pump exercise combined with the built-in frost

protection will help to maintain and protect the boiler.

Once the controls are set the boiler operates automatically.

Compartment or Cupboard Installations

Ventilation is not required for compartment or cupboard instal-

lations.

Do not use the compartment or cupboard for storage.

The minimum clearances to xtures are shown in diagram 1.

Pluming from ue terminal

Like all condensing boilers it will produce a plume of condensation

from the ue terminal in cool weather. This is due to the high

efciency and hence low ue gas temperature of the boiler. It

is normal and not a fault indication.

Electrical Supply Failure

The boiler will not work without an electrical supply and nor-

mal operation of the boiler should resume when the electrical

supply is restored.

If the boiler does not resume normal operation, check the ex-

ternal controls, it may be necessary to "reset" the boiler, refer

to the following section, "Boiler Safety Devices". Diagram 1

12652

A removable compartment door can be placed a minimum of

5mm in front of the appliance but there must be a

clearance of 600mm minimum from a xed surface

600

150 5

150

600

www.glow-worm.co.uk

Boiler Safety Devices

Overheat Reset

The boiler software is designed to recognise the potential for

an overheat lockout and will shutdown before this happens. To

restart the boiler, press the reset button, see diagram 2.

If the boiler fails to resume normal operation and all external

controls are calling for heat, then call your Installation/Servicing

company or Glow-worm service.

Frost Protection

With the gas and electric supplies ON and irrespective of any

room thermostat setting, the integral frost protection device will

operate the pump when the temperature of the boiler water

falls below 8OC.

A timer is used so that the temperature can be checked

periodically. After 10 minutes the pump will be stopped if the

temperature is higher than 10OC or has already reached 35OC.

The burner will only activate if the boiler temperature does not

reach 10OC after 30 minutes or at any time if the temperature

drops to 5OC.

The burner will switch off when the temperature reaches 35OC.

NOTE: Any other exposed areas of the system should be

protected by a separate frost thermostat.

Condensate Drain Blockage

As a safety feature the boiler will stop working if the condensate

drain becomes blocked. During freezing conditions this may be

due to the forming of ice in the condense drain external to the

house. Release an ice blockage by the use of warm cloths on the

pipe. The boiler should then restart. Contact your Installation/

Servicing company or Glow-worm service if the fault persists.

www.glow-worm.co.uk

General Note

Servicing/maintenance should be carried out by a

competent person approved at the time by the Health and

Safety Executive, in accordance with the rules in force in the

countries of destination.

If this boiler is installed in a rented property in the UK there

is a duty of care imposed on the owner of the property by the

current issue of the Gas Safety (Installation and Use) Regula-

tions, Section 35.

Servicing

This product should be serviced regularly to optimise its safety,

efciency and performance. The service engineer should com-

plete the relevant Service Record on the Benchmark Checklist

after each service. The Benchmark Checklist may be required in

the event of any warranty work and as supporting documenta-

tion relating to home improvements in the optional documents

section of the Home Information Pack.

To ensure the continued efcient and safe operation of the boiler

it is recommended that it is checked and serviced at regular

intervals. The frequency of servicing will depend upon the site

conditions and usage, but in general, once a year should be

enough.

To obtain service, please call your installer or Glow-worm’s own

service organisation using the telephone number on the inside

front cover of this booklet.

Cleaning

The boiler casing can be cleaned using a mild liquid detergent

with a damp cloth, then a dry cloth to polish.

Do not use any form of abrasive or solvent cleaner as you may

damage the paintwork.

Frost Protection

If the mains electricity and gas services are to be turned off for

any long periods during severe weather, it is recommended

that the whole system, including the boiler, should be drained

to avoid the risk of freezing.

Sealed Water Systems

The draining, relling and pressurising MUST be carried out by

a competent person approved at the time by the Health and

Safety Executive, contact your Installation/Servicing company

or Glow-worm Service.

Spare Parts

REMEMBER, When replacing a part on this boiler, use only

spare parts that you can be assured conform to the safety

and performance specication that we require. Do not use

reconditioned or copy parts that have not been clearly authorised

by Glow-worm.

If replacement parts are required contact Glow-worm’s own

service organisation using the telephone number on the inside

front cover of this booklet.

Please quote the name of the boiler, this infomation will be on

the name badge on the front case.

If in doubt seek advice from the local gas company or Glow-

worm’s own service organisation using the telephone number

on the inside front cover of this booklet.

Maintenance

www.glow-worm.co.uk

1. Check that the gas service isolation valve is open,

see diagram 2.

2. If you are in any doubt about the boiler being lled

with water contact your installer or Glow-worm's own

service organisation using the telephone number on

the inside front cover of this booklet.

Do not operate the boiler without water.

3. Check that the electrical supply to the boiler is ON and

there is no demand from any external controls.

4. The digital display will indicate the required water

temperature.

5. To operate the boiler follow the instructions as

described on the following pages.

6. Set any external controls as required.

Boiler Operation

14604

Diagram 2

www.glow-worm.co.uk

Description

The boiler User controls consist of a "MODE" button, refer

to diagram 3, which, when pressed and held for 2 seconds,

enters the Central Heating function indicated by a ashing

radiator symbol. After 5 seconds of inactivity the display will

reset to indicate the water temperature.

The "SELECTOR" buttons are used to turn OFF and set the

Central Heating temperature (38 - 82OC).

If a fault occurs, indicated by a ashing 'F' and code number,

press the reset button positioned below the digital display.

If a fault persists, indicated by a ashing 'F' and code

number, contact your installer/service provider or Glow-

worm Service using the telephone number on the inside front

cover of this booklet.

Boiler Operation - User Controls

Inhaltsverzeichnis

Andere Glowworm Kessel Handbücher

Glowworm

Glowworm ULTIMATE 30BF Betriebsanleitung

Glowworm

Glowworm 40 Betriebsanleitung

Glowworm

Glowworm 24ci Betriebsanleitung

Glowworm

Glowworm Economy Plus 30 B Betriebsanleitung

Glowworm

Glowworm ULTRACOM CXI Bedienungsanleitung

Glowworm

Glowworm Hideaway 100B Bedienungsanleitung

Glowworm

Glowworm ENERGY Bedienungsanleitung

Glowworm

Glowworm ENERGY 12s -A Bedienungsanleitung

Glowworm

Glowworm 30ci plus Betriebsanleitung

Glowworm

Glowworm Betacom2 24 Bedienungsanleitung

Glowworm

Glowworm Hideaway 40C FF Betriebsanleitung

Glowworm

Glowworm COMPACT 80e Bedienungsanleitung

Glowworm

Glowworm Easicom 3 28c Bedienungsanleitung

Glowworm

Glowworm Energy7 12r-A Bedienungsanleitung

Glowworm

Glowworm Ultrapower sxi 100sx Bedienungsanleitung

Glowworm

Glowworm Ultracom 24cxi Bedienungsanleitung

Glowworm

Glowworm Ultracom 2 24cxi Bedienungsanleitung

Glowworm

Glowworm swift flow 100e Bedienungsanleitung

Glowworm

Glowworm economy plus c 50 Benutzerhandbuch

Glowworm

Glowworm Micron 50FF Bedienungsanleitung

Glowworm

Glowworm Hideaway 40B FF Bedienungsanleitung

Glowworm

Glowworm XTRAMAX Betriebsanleitung

Glowworm

Glowworm Ultimate 60BF Betriebsanleitung

Glowworm

Glowworm swift flow 80 Bedienungsanleitung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung