Godrej VIROSHIELD Bedienungsanleitung

Godrej & Boyce Mfg. Co. Ltd. - Appliance Division

Prolonged direct exposure to UVC can be harmful to humans,

please follow all safety precautions mentioned in the User Guide.

WARNINGS AND SAFETY PRECAUTIONS

Prolonged direct exposure to UVC can be harmful to humans, please follow all safety

precautions mentioned in the User Guide.

• Always be reminded that the Godrej ViroShield must be used with caution and in

accordance with the proper use as indicated in the instructions and / or User

Manual which come together with the purchased product.

• The Godrej ViroShield should not be operated by children, or anyone below the

age of 18.

• Caution Note-This UV-C product is not designed to be used on the skin, the eyes

and any part of the body, among others. Inappropriate and improper use of the

UV-C product could be dangerous and harmful. Godrej & Boyce Mfg. Co. Ltd.

disclaims any and all liability for any damage arising from any inappropriate,

improper or negligent use of this UV-C product.

• Avoid spilling any fluids on any part of Godrej ViroShield. If spills do occur,

immediately disconnect Godrej ViroShield from the power source and contact

Technical Support (Toll Free:18002095511) for guidance on cleaning Godrej

ViroShield.

• Do not tamper with any of the safety precautions built into the device. Failure to

comply may result in exposing skin to UV-C. Prolonged skin exposure may

generate redness and an uncomfortable sunburn sensation. In case of exposure

of skin or eyes to UV-C or any of the symptoms developing, please see your

physician.

• Do not touch the door switch under any circumstances especially when the

device is Powered ON.

• Do not remove the door gasket. Do not fiddle with the UV-C tubes.

• Non-protected eyes or skin should never be exposed directly to UV-C.

• Never bypass the door protection switch or use the device with a damaged front

door. Never operate Godrej ViroShield if it has a damaged power cord, power

supply or plug.

• Do not use any power extension cord to run Godrej ViroShield.

• Ultraviolet tubes/lamps contain mercury, and therefore, in case of accidental

breakage ventilate the room and contact Godrej customer support

(18002095511) immediately. Do not attempt to operate or repair or dismantle the

product till the issue is rectified by an authorised Godrej personnel.

• All assembly, adjustment, modification, maintenance and/or repair should be

performed by qualified personnel authorized by Godrej & Boyce Mfg. Co. Ltd.

• Only Godrej & Boyce Mfg. Co. Ltd. approved replacement parts should be used

with maintaining the device.

• Do not remove any warnings, cautions, or descriptive labelling from the Godrej

ViroShield.

• Device should not be used for sterilization of surgical tools or any medical

equipment.

• Always power off the device before cleaning. An electrical shock could occur if the

device is powered on during cleaning.

• Information provided herein or on the product label or packaging should not be

considered as a substitute for advice from a healthcare professional.

Godrej Viroshield is a 30L UV-C based disinfecting system which disinfects

against more than 99% COVID 19 virus, germs and other harmful micro-or-

ganisms in 2 to 6 minutes*. It operates at ~ 254nm which is the optimal wave

length for neutralising pathogens, viruses & bacteria including SARS-COV-2

which is of the corona family of virus. It is suitable for disinfecting - Food

Packages, Vegetables, Personal Items including wallets, mobiles, chains,

watches, parcels, documents etc.

DO NOT use for power banks.

It operates on 183-260 V AC main Supply and Works on Home Inverter.

For best results operate at an ambient temperature of 0°C- 45°C with

10-85% humidity.

KNOW YOUR PRODUCT

Sanitise larger items,

sanitise more items

together

LARGER CAPACITY

Protects against virus,

bacteria and harmful microbes

DISINFECTS AGAINST

99%+ COVID 19

VIRUSES

Auto cut-off in case of

accidental door opening

AUTO CUT-OFF

4UV-C Tubes* with 6 side

reflective interiors

360° UV-C COVERAGE

No see through surface and

magnetic door sealing

with gasket

100% UV LEAK PROOF

CABINET

Ltr.

1 YEAR

COMPREHENSIVE

WARRANTY

YEAR

LEAK

*3 to 7 minutes and 2 UV-C tubes in case of ViroShield 2.0

• What all items can be disinfected in the UV-C system?

- Food & beverages such as Leafy Vegetables, Fruits, Packed Dairy

Products, Beverages, Packaged Food; Personal Products such as

Wallets, Hand Bags, Gold Ornaments, Watches, Sunglasses, Keys,

Currency Notes; Electronics such as Laptops, Mobiles, Headphones;

Healthcare items such as Masks, Hand Gloves, Thermometer;

Baby Products such as Toys, Shoes; Office items such as Books,

Documents, Parcels.

• Is UV-C Disinfection system safe to use?

- The UV-C Disinfection system incorporates certain safety measures for

human use. Godrej ViroShield comes with Auto Cut-off in case of

accidental door opening, no see-through Surface and also comes with

magnetic door sealing & gasket. This helps avoid any UV-C radiation

exposure to the user.

• Does UV-C disinfect the items from inside?

- The device is used for surface disinfection only. Only those parts get

disinfected that are exposed to UV-C radiation.

• Can water be purified using UV-C Disinfection system?

- The device is effective for surface disinfection of objects and not for

treating drinking water.

• Can the UV-C Disinfection system disinfect electronic items?

- Yes, the system can be used to disinfect electronic items such mobile,

laptop, headphones etc. except Power banks.

• For how long can I expose any item to UV radiations?

- Longer the exposer better is the disinfection. The timer is set for a maxi-

mum of up to 6 minutes*.

FREQUENTLY ASKED QUESTIONS (FAQs)

• Can the product be used to sterilize medicines?

- Viroshield can be used for almost all kinds of surface disinfection but

if you are using ViroShield to disinfect medicines, we recommend seeking

medical advice, given the varying nature of different medicines.

For example, for items like vaccines, UV exposure may not be advisable.

*Maximum of 7 minutes in case of ViroShield 2.0

PARTS NAME

Part No Part Name Qty.

1 UV Lamp 4*

2 Bottom Shelf 1

3 Leg 4

4 1

5 1

DO NOT touch the door switch. Keep away from children.

Prolonged direct exposure to UV-C can be harmful to humans,

please follow all safety precautions mentioned in this User Guide.

On/Off Switch

LED Indicator

Door Switch

Door

* 2 UV Lamps in case of ViroShield 2.0

1. Take out unit from the carton (box) after removing shipping tapes.

2. Remove all packing material and accessories.

3. Examine the unit for any damage such as dents or broken door.

Do not install if unit is damaged.

4. Remove any protective film found in or around the unit

5. Select a level surface that provides enough open space for the intake

and/or outlet of vents at back side.

6. A minimum clearance of 3 inches (7.5cm) is required between the unit

and rear walls.

7. Do not remove the legs from the bottom of the unit.

8. Place the unit as far away from radio and TV as possible. Operation of

unit may cause interference to your radio or TV reception.

Plug unit into a standard household outlet - 240 V 5 amp. Be sure about

proper voltage.

9. Do not expose the product to sunlight

INSTALLATION GUIDE

If installed near or over a heat source, the unit could be damaged and

the warranty would be void.

7.5cm

WARNING: Do not install unit over other heat-producing appliance.

Neutral Live

Earth

10. Before plugging in the unit, ensure that the wall socket

wiring has correct live and neutral connection as per

IS 1293 standard. Incorrect wiring of live and neutral

connection may hamper the efficient working of ViroShield

and cause it to malfunction. It is recommended that the

wall socket wiring is checked and Verified by a qualified

electrician.

OPERATING INSTRUCTIONS

1. Plug in the power cord and switch on the unit using on-off switch

located at back side. The switch will glow, indicating power ON.

2. Open the door and place items on the grill only,

Note: Care to be taken while placing the articles – they should not fall

onto the UV tube located below the wire shelf.

Note: User may experience a temporary smell of adhesive inside the

unit.

3. Maintain gap between articles, so that all sides are exposed to UV light.

4. Once the door is closed, the green LED on top and a short beep would

indicate the start of the disinfection process, throughout the 6-minutes*

cycle a short beep in intervals of 30 seconds and the glowing green

LED on top would indicate the ongoing disinfection process.

5. After 6 minutes* the green LED will cut-off and the unit will sound a long

buzzer indicating completion of cycle.

Note: When operational, any visible violet light from the closed unit

does not contain radiation and is harmless to humans.

6. Open the door and remove the disinfected items.

Note: Maximum cycle time is 6 minutes*. In case the door is opened in

the middle, the cycle time will be reset to zero.

7. The same process can be repeated by simply shutting the door again.

Note: If the door is closed without placing any items inside the Viro

Shield, the unit will go through a self-cleaning cycle for 6 minutes* and

will remain in standby mode. This is recommended only if the unit is

being used frequently.

Green LED

ON + Short

Beep

Green LED

OFF + Long

Buzzer

6 minutes* cycle

with short beep

every 30 seconds

Green LED OFF

For proper disinfections for bulky items, leafy vegetables, odd shaped items may need reposi-

tioning, so as to ensure that there is UV exposure at all surface. You can do this while unit is

working by opening the door & repositioning the items on different surface & reclosing the

door. The cycle will restart on its own (You may need to do this 2 or 3 times for vegetables &

odd shape items. But do not open the door until a minimum exposure time of 30 to 50 secs is

given on each surface). When not in use kindly switch off the supply from plug point.

Note:

* Maximum cycle time is 7 minutes in case of ViroShield 2.0

Cleaning & Maintainance:

1. Turn off the unit & remove the power plug from wall socket before

cleaning.

2. Keep it in off condition for 20 mins before cleaning.

3. The outside surface should be clean with damp cloth , do not use abrasive

cleaner.

4. To remove any dust, wipe the inside of the door and seal area including

gasket with damp cloth

5. The Internal cabinet should be wiped carefully with damp cloth without

touching the UV tubes.

6. UV tube should be cleaned carefully with hair brush.

USAGE TIPS

DO NOT touch the door switch. Keep away from children.

TROUBLESHOOTING

If problem persist call Customer Help Line Number: 1-800-209-5511

TECHNICAL SPECIFICATION

PROBLEM

POSSIBLE CAUSE

Please check the wall socket switch.

Please check the switch at the back of ViroShield.

UV lights will work only when the door is closed

completely. If the LED indicator is on and the buzzer

is beeping every 30 seconds, it means that the UV

lights are powered on.

If there is still some doubt, one can press the door

switch in the cabinet momentarily, to check that the

lights are working. We strongly recommend not

doing this often for your safety since prolonged

direct exposure to UV Rays can harm your health.

Please check the correctness of wiring in the wall

socket. Refer to point 10 on Page 5 of this user

manual.

Not switching ON

UV not working

Light in the line tester

glows

MODEL

Gross Capacity 30 L 30 L

Germicidal Lamp 4 Lamps 2 Lamps

Outer Dimensions in mm (WxDxH)

Timer Setting 6 Minutes 7 Minutes

Power 50 W 25 W

Rated Input Voltage 230V 50 Hz 230V 50 Hz

Power Cable 3 Pin 6A 1.5 mts 3 Pin 6A 1.5 mts

Output

254-265 nm UVC light 254-265 nm UVC light

Operating Temperature 0°C- 45°C, 10-85% 0°C- 45°C, 10-85%

humidity humidity

Operating Voltage Range 183-260 V 183-260 V

VIROSHIELD 4.0 VIROSHIELD 2.0

436 x 473 x 460 436 x 473 x 460

LEGAL INFORMATION

Godrej & Boyce incorporates UV-C sanitizing technology (254nm

wavelength UV-C tubes) into personal use devices for consumers

We strongly advise you to read on the possible effects of UV-C

rays/transmissions. If you have any questions or doubts about the use

of our UV-C products, please carefully read and follow the instructions

in the manual (also available at www.godrejappliances.com) and be

mindful of the warnings on the labels on the product. Please ensure that

eyes and other sensitive and vulnerable parts of the body are not

inserted in the product as it is not suitable to be used on these. Always

keep the product away from children and adults needing care, while

switched on.

We disclaim any and all liability for any damage arising from the

purchase and/or use of the product. Please use the product only for the

purpose stated on the product and for no other purpose. Please do not

disassemble or perform any experimentations or modify the product in

any way – Godrej & Boyce shall not be in any way liable for any

consequences of such actions. Always be reminded that the product

must be used with caution and in accordance with the proper use and

safety guidelines and precautions as indicated in the instructions and/or

manuals given with the purchased product. In case of any help,

guidelines or doubts please contact us on 18002095511

By confirming your purchase of this product herein offered, you hereby

acknowledge and unconditionally accept the terms and conditions for

the use of the product as well as the disclaimers stated herein

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Godrej Sterilisator Handbücher

Godrej

Godrej UV CASE Bedienungsanleitung

Beliebte Sterilisator Handbücher anderer Marken

Dust Free

Dust Free LightStick Bedienungsanleitung

Euronda

Euronda E9 Next 18L Bedienungsanleitung

UVPLUS

UVPLUS ALS UVP201R Bedienungsanleitung

SterileLight

SterileLight Illumicide SL-UVC-IDC-01-B Bedienungsanleitung

Norka

Norka BUENOS AIRES UV-C 997 100 02 Series Bedienungsanleitung

CertoClav

CertoClav Vacuum Pro 45 Bedienungsanleitung

Chicco

Chicco SterilNatural 2in1 Bedienungsanleitung

Market Forge Industries

Market Forge Industries Sterilmatic Bedienungsanleitung

Philips AVENT

Philips AVENT SCF271/20 Bedienungsanleitung

Easypix

Easypix SteriBox SB1 Bedienungsanleitung

ASP

ASP sterrad NX Bedienungsanleitung

Vital Baby

Vital Baby NURTURE advanced pro UV mini Bedienungsanleitung

NUK

NUK 10.256.444 Bedienungsanleitung

Chicco

Chicco SterilNatural Bedienungsanleitung

Philips

Philips SCF276/01 Bedienungsanleitung

Reverberi

Reverberi BABY S Bedienungsanleitung

Technaxx

Technaxx TX-151 Bedienungsanleitung

Memmert

Memmert SF PLUS Series Bedienungsanleitung