Graco TrueCoat Plus II 24N812 Bedienungsanleitung

3A2852B

Operation

Quick Set-up Guide for TrueCoat Plus II

BackPack Sprayer

- For use with Graco hand-held sprayers (except Fine-Finish sprayers) -

- For portable spray applications of water-based and oil-based (mineral spirit-type)

architectural paints and coatings only -

- Not approved for use in explosive atmosphere locations -

Model 24N812

Maximum Working Pressure 12 psi (0.83 bar, 0.083 MPa)

IMPORTANT SAFETY INSTRUCTIONS

For complete warnings and safety

instructions, see sprayer manual.

ti16502b

WARNINGWARNINGWARNING

WARNING

FIRE AND EXPLOSION HAZARD

Use only water-based or oil-based (mineral spirit-type) materials with flash point greater than 100° F

(38° C). Do not use materials which state “FLAMMABLE” on the packaging. For more information about

your material, request MSDS from distributor or retailer.

Use oil-based material outdoors or in a well-ventilated indoor area with a flow of fresh air.

Before You Start

23A2852B

Before You Start

The ProPack Portable Spray Pack is shipped with a bat-

tery inside the air compressor which must be connected

before operation.

1. Remove contents from backpack including any

packing materials.

2. Remove air compressor from reservoir lid.

3. Open battery door on flat side of air compressor.

4. Remove 9V alkaline battery and remove shipping

seal from battery terminals.

5. Pull battery connector out of air compressor.

6. Connect battery and place inside air compressor.

7. Replace battery door.

8. Turn on power switch to test battery (red LED light

should turn on).

ti16510a

ti17593a

ti17825a

ti17591a

ti17824a

ti17595a

ti17596a

Before You Start

3A2852B 3

Setup Instructions

1. Perform Pressure Relief Procedure (see sprayer

manual).

2. Remove sprayer battery or unplug sprayer.

3. Remove material cup (M) and suction tube (T).

4. Align hose set adapter (A) with sprayer inlet (B) and

insert into sprayer. Thread hose set adapter ring

until tight.

5. Place liner (optional) into reservoir and fill with

material.

6. Install suction tube and strainer to inside of lid (be

sure to align center of strainer with center of reser-

voir lid). Install reservoir lid to reservoir and hand

tighten.

7. Thread suction hose nut (S) onto lid assembly and

hand tighten. Insert drain hose (H) onto lid assem-

bly barb and secure with clamp.

8. Install sprayer battery or plug sprayer into a properly

grounded outlet.

9. Place reservoir on floor, install and turn on air com-

pressor (P). Hold sprayer at approximately chest

level and prime sprayer until material just begins to

fill the drain hose (approximately 1 ft).

ti15504a

ti16514b A

ti16506a

ti16515a

ti16509b

1 ft

Suction

Hose

ti16504a

Drain

Hose

Before You Start

43A2852B

10. Place reservoir into backpack. NOTE: The air com-

pressor always needs to be on while the sprayer is

in operation (if the light is on, the air compressor is

on). If fluid level is at half or less, allow up to 2 min-

utes for reservoir to pressurize before initial use.

11. Pull strap until reservoir is firmly secured into back-

pack.

12. Close prime valve on sprayer.

13. Place backpack system on operator. You are now

ready to spray!

NOTE: If the tip needs to be changed while spraying, be

sure to follow Pressure Relief Procedure (see sprayer

manual). Turn air compressor off and slowly remove

from lid assembly. This will ensure pressure is released

from reservoir before changing the tip.

System is now pressurized. Failure to properly

depressurize system will result in material discharging

from hose and possible injury.

Always turn off and slowly remove air compressor from

lid assembly to depressurize system before removing:

• Hose set from sprayer

• Hose set from lid

• Lid from reservoir

ti16507a

ti16521a

ti15425a

CAUTION

ti16510a

All written and visual data contained in this document reflects the latest product information available at the time of publication.

Graco reserves the right to make changes at any time without notice.

For patent information, see www.graco.com/patents.

Original instructions. This manual contains English. MM 3A2852

Graco Headquarters: Minneapolis

International Offices: Belgium, China, Japan, Korea

GRACO INC. AND SUBSIDIARIES • P.O. BOX 1441 • MINNEAPOLIS MN 55440-1441 • USA

www.graco.com

Revision B- January 2013

Andere Graco Spritzpistole Handbücher

Graco

Graco 244113 Bedienungsanleitung

Graco

Graco 311322L Kurzanleitung

Graco

Graco 230-998 Bedienungsanleitung

Graco

Graco 231-547 Bedienungsanleitung

Graco

Graco GMAX II 5900 Bedienungsanleitung

Graco

Graco Delta Spray 237409 Bedienungsanleitung

Graco

Graco field lazer s100 Bedienungsanleitung

Graco

Graco magnum pro plus a30 Bedienungsanleitung

Graco

Graco 243238 Bedienungsanleitung

Graco

Graco 231979 Bedienungsanleitung

Graco

Graco 231421 Bedienungsanleitung

Graco

Graco Merkur G10W09 Stücklistenhandbuch

Graco

Graco 218-745 Bedienungsanleitung

Graco

Graco 257025 Bedienungsanleitung

Graco

Graco 17C301 Leitfaden

Graco

Graco 231-201 Bedienungsanleitung

Graco

Graco SaniSpray HP 130 Gebrauchs- und Pflegehandbuch

Graco

Graco SaniSpray HP 20 Gebrauchs- und Pflegehandbuch

Graco

Graco Mark V SpackMax Bedienungsanleitung

Graco

Graco 3A4803A Leitfaden

Graco

Graco XP-hf 572407 Bedienungsanleitung

Graco

Graco 232903A Bedienungsanleitung

Graco

Graco Series A Bedienungsanleitung

Graco

Graco Hydra-clean 24V616 Stücklistenhandbuch

Beliebte Spritzpistole Handbücher anderer Marken

SNOWJOE

SNOWJOE Sunjoe 24V-GS-LTW-RM Bedienungsanleitung

Binks

Binks SV100 Bedienungsanleitung

Fimco

Fimco LG-4-3-1 Bedienungsanleitung

AG SPRAY

AG SPRAY FS-ATV-25BL Bedienungsanleitung

Nordson

Nordson MicroMax 2 Bedienungsanleitung

Bonide

Bonide 051 Bedienungsanleitung

zogics

zogics Z-DAS Bedienungsanleitung

KISANKRAFT

KISANKRAFT KK-KBS-165 Bedienungsanleitung

Matrix

Matrix SG 650 Bedienungsanleitung

Anest Iwata

Anest Iwata SGA-3 Kurzanleitung

paasche

paasche VV Datenblatt

Carlisle

Carlisle DeVilbiss JGA-510 Bedienungsanleitung

Gardena

Gardena 11120 Bedienungsanleitung

wiwa

wiwa 14025 R/F Bedienungsanleitung

DeVilbiss

DeVilbiss LUNA2i Bedienungsanleitung

WAGNER

WAGNER W 125 Bedienungsanleitung

My Clean Buddy

My Clean Buddy PW018 Bedienungsanleitung

HAZET-WERK

HAZET-WERK Hazet 9045 P-1 Bedienungsanleitung