Gree MULTI21 CAS12HP230V1AC Bedienungsanleitung

CEILING CASSETTE

DUCTLESS SYSTEM

INSTALLATION MANUAL

Models:

CAS12HP230V1AC -12,000 BTUH

CAS18HP230V1AC -18,000 BTUH

CAS24HP230V1AC - 24,000 BTUH

Thank you for choosing the Gree Ceiling Cassette for

your Ductless Heat Pump System

Please read this installation manual carefully before installing and starting up the Ductless System with

Ceiling Cassettes. Take a moment to fill out the product and installation form on the back cover. Retain

both the manual and installation record for future reference.

Table of Contents.

Safety Precautions 3

System Requirements 4

Nomenclature 4

Suggested Tools 5

Product Dimensions 6

Product Overview 7

Installation of Ceiling Cassette 8

Installation of Refrigerant Piping 10

Installation of Condensate Piping 12

Installation of Power & Wiring 13

Installing of Wired Controller 14

Installing of Decorative Grille 16

Start Up and Check Out 18

Troubleshooting 19

GENERAL SAFETY PRECAUTIONS

Please read the following before installation

Recognize safety information. This is the safety-alert symbol. When you see this symbol on the

unit and in instructions or manuals, be alert to the potential for personal injury. Understand these signal

words: DANGER, WARNING, and CAUTION. These words are used with the safety-alert symbol.

DANGER identifies the most serious hazards which will result in severe personal injury or death.

WARNINGsignifies hazards which could result in personal injury or death.

CAUTION is used to identify unsafe practices which may result in minor personal injury or product and

property damage.

NOTE is used to highlight suggestions which will result in enhanced installation, reliability, or operation.

WARNING

Heat pumps, air conditioners & heating equipment should be installed, started up, and serviced

only by qualified installers and/or service technicians. Air conditioning, heat pumps and

refrigeration systems are hazardous due to high voltage electrical components, high refrigerant

pressures, and moving parts.

WARNING

ELECTRICAL SHOCK HAZARD

Failure to follow this warning could result in personal injury or death.

Before installing, servicing or modifying the system, the main electrical disconnect switch must be

in the OFF position. There may be more than one disconnect switch. Lock out and tag all

switches with a warning label.

General Safety Precautions

•A dedicated power supply circuit should be used in accordance with local electrical safety

regulations and National Electrical Codes (NEC).

•Ensure that the entire system is reliably grounded.

•Use proper size circuit breaker to protect equipment against short circuit and overload conditions.

•The system must be positioned at least 5 feet from flammable combustive liquids.

•

Observe all local codes and regulations.

NOTE: Your actual equipment and related devices may differ from the images shown in this manual.

This appliance is not intended for use by children without responsible adult supervision. Proper care

should be taken to ensure safety.

SYSTEM REQUIREMENTS

PIPE SIZE:

Model # Capacity

Size (Btu) Voltage Liquid Line Suction/Gas

Line Net/Gross

Weight

CAS12HP230V1AC

12,000

208/230 - 1ph 60 hz

1/4-in (6mm)

3/8-in (9.5mm)

44/51 lbs.

CAS18HP230V1AC

18,000

208/230 - 1ph 60 hz

1/4-in (6mm)

1/2-in (12-mm)

48/55 lbs.

CAS24HP230V1AC

24,000

208/230 - 1ph 60 hz

3/8-in (9.5mm)

5/8-in (16-mm)

66/84 lbs.

INTERCONNECTING CABLE:

Recommended 14/4 AWG stranded bare copper conductors THHN 600V unshielded wire

Note:Use shield cable if installation is in close proximity of RF and EMI transmitting devices.

CONDENSATE DRAINAGE:

Recommended condensate drainage system use pipe either the same diameter or with the diameter

larger (excluding the raising section) than that of the connecting pipe (nominal diameter 1-in, outside

diameter 1-1/4-in.)

Note:Insulate condensate all condensate drain pipes to prevent sweating and possible water damage.

NOMENCLATURE:

Series Designation Product Type

S - System

O - Outdoor units

CAS - Ceiling Cassette H - Indoor High Wall

D - Indoor Duct

C - Indoor Cassette

Cooling Capacity F - Indoor Floor/Ceiling

12 - 12,000 BTUH

18 - 18,000 BTUH Revision Level

24 - 24,000 BTUH

(ect..) Style/Color Designation

Model Type

AC -Cooling Only Electrical Rating

HP -Heat Pump 230V - 208/230V 60Hz 1PH

HC - Heat/Cool 115V - 115V 60Hz 1PH

Example: CAS18HP230V1AC

CAS

230V

SUGGESTED TOOLS

Standard Wrench

Adjustable/Crescent Wrench

Torque Wrench

Hex Keys or Allen Wrenches

Drill & Drill Bits

Hole Saw

Pipe Cutter

Screwdrivers(Phillips&Flatblade)

Manifold and Gauges

Level

R410A Flaring Tool

Clamp on Amp Meter

Vacuum Pump

Safety Glasses

Work Gloves

Refrigerant Scale

Micron Gauge

PRODUCTS DIMENSIONS

Ceiling Cassette Dimensions

Units: Inch (mm)

Minimum Indoor Clearance

Units: Inch (mm)

PRODUCT OVERVIEW

XK-19 Tether

Wired Controller

Remote

Controller

INSTALLATION OF CEILING CASSETTE

Step 1 - Selecting Location for Ceiling Cassette Unit

Select a location that allows for the following:

•Ensure the installation complies with the installation minimum dimensions and meets the

minimum and maximum connecting piping length and maximum change in elevation.

•Air inlet and outlet will be clear of obstructions, ensuring proper airflow throughout the room.

•Condensate can be easily and safely drained.

•All connections can be easily made to outdoor unit.

•Indoor unit is out of reach of children.

•A ceiling strong enough to withstand four (4) times the full weight and vibration of the unit.

•Filter can be easily accessed for cleaning.

•Leave enough free space to allow access for routine maintenance.

•Install at least 10 ft. (3 m) away from the antenna of TV set or radio. Operation of the air

conditioner may interfere with radio or TV reception in areas where reception is weak. An

amplifier may be required for the affected device.

•Do not install in a laundry room or by a swimming POOL.

•The location meets all the minimum clearance dimensions and the requirements of the schematic

diagram.

Step 2-Laying Out Location

•Locate the factory supplied installation template included in carton.

•Use the template to make an opening in the ceiling for the ceiling cassette main body.

•Mark the position of the hanger bolts, refrigerant lines and condensate drain pipes,

interconnecting cable and wired remote controller wires ( if applicable).

INSTALLATION OF CEILING CASSETTE

Step 3 – Installation of Mounting Hangers

Depending on the type of ceiling, attached the threaded hanger bolts (field supplied) securely to the

ceiling or support stud.

Before lifting Ceil Cassette unit to the installation location, insert the upper nuts, flat washers (with

insulation), flat washers (without insulation), lower nuts and locking nut (double) on the threaded hanger

bolts as show in diagram.

Note: Fit the washer with cushion so that the insulation faces downward.

Step 4 - Installation of Ceiling Cassette

Lift the Ceiling Cassette main body unit to the threaded hanger bolts. Insert the unit mounting brackets

between washers and then fasten it securely.

Step 5 -

Confirming Position of Ceiling Cassette

1. Adjust height of Ceiling Cassette main body to align with false ceiling. Be sure to confirm this,

otherwisecondensation may form due to air leakage, etc. Adjust mounting nuts as needed.

2. Confirm that the Ceiling Cassette main body is horizontally leveled. Adjust mounting nuts as

needed.

3. After checking the positioning of the Ceiling Cassette main body, tighten the nuts of the hanger

bolts securely to fasten the Ceiling Cassette main body in place.

4. The installation template may be used as a protective sheet toprevent dust from entering the

Ceiling Cassette when the decorative grilles are left unattached during the installation.

INSTALLATION OF REFRIGERANT PIPING

Step 6 – Drill Hole in Wall

1. Find and mark the proper location for the wall hole. Use the table below for the recommended

wall hole size.

Model # Capacity Size

(Btuh)

Wall Hole Size (Diameter)

CAS12HP230V1AC

12,000

2 1/4

CAS18HP230V1AC

18,000

2 3/4

CAS24HP230V1AC

18,000

2 3/4

Cut the wall hole with a 5° to 10° downward slant to the outdoors.

3. Insert a wall sleeve into hole to prevent damage to refrigerant pipes, insulation, condensate drain

hose and wiring.

4. Proper weather proofing of the wall surface and wall sleeve is essential to assure a trouble-free

installation. Apply sealant, caulking or equivalent weather proofing material around the perimeter

of the wall sleeve (interior & exterior) to eliminate outdoor air and water leaks into the living

space.

Note: Expandable foam insulation may be added to fill large wall gaps. Apply per manufacturer's

instructions.

Wall Hole Diagram

Andere Handbücher für MULTI21 CAS12HP230V1AC

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Gree Klimaanlage Handbücher

Gree

Gree GWC09QC-A3DNA3D Bedienungsanleitung

Gree

Gree MULTI24HP230V1EO Betriebsanleitung

Gree

Gree GMV5E Series Bedienungsanleitung

Gree

Gree FP-51XD/A-K Bedienungsanleitung

Gree

Gree GPC09AI-K3NNC6D Bedienungsanleitung

Gree

Gree GMV-N140U/A-T Bedienungsanleitung

Gree

Gree G-Cloud ME31-00/C4 Bedienungsanleitung

Gree

Gree GK-H03NH3AS Bedienungsanleitung

Gree

Gree Sapphire SAP18HP230V1A Bedienungsanleitung

Gree

Gree GMV-WQ72WM/A-F Bedienungsanleitung

Gree

Gree 13-04685 Bedienungsanleitung

Gree

Gree GJC08BU-A6NRNJ2A Bedienungsanleitung

Gree

Gree GMV-NX140P/A(X1.2)-K Bedienungsanleitung

Gree

Gree GPC10AN-K5NNA1A Bedienungsanleitung

Gree

Gree Livo+ Betriebsanleitung

Gree

Gree MULTI18HP230V1AO Bedienungsanleitung

Gree

Gree GPC07AK-K5NNA1A Bedienungsanleitung

Gree

Gree GWH09MB-K3DNA3K/I Bedienungsanleitung

Gree

Gree GJC12AF-E3DRNG2A Bedienungsanleitung

Gree

Gree GWH18PD-K3NNA1A Bedienungsanleitung

Gree

Gree GMV-Y120WL/A-T Bedienungsanleitung

Gree

Gree GJC07AF Series Bedienungsanleitung

Gree

Gree GMV-N56G/A3A-K Bedienungsanleitung

Gree

Gree GUD36W/A-D Bedienungsanleitung

Beliebte Klimaanlage Handbücher anderer Marken

Panasonic

Panasonic CS-E12HKEW Bedienungsanleitung

nedis

nedis ACMB1WT7 Bedienungsanleitung

Daikin

Daikin FCFV50A Bedienungsanleitung

Fujitsu

Fujitsu Inverter ASBA30JFC Bedienungsanleitung

Toshiba

Toshiba RAS-M10SMUV-E Bedienungsanleitung

Daikin

Daikin FXLQ20MAVE Bedienungsanleitung

CIAT

CIAT Magister 2 Series Leitfaden

Bestron

Bestron AAC6000 Bedienungsanleitung

Frigidaire

Frigidaire FFRE0533S1E0 Bedienungsanleitung

Samsung

Samsung AS09HM3N Bedienungsanleitung

Frigidaire

Frigidaire CRA073PU11 Betriebsanleitung

Soleus Air

Soleus Air GB-PAC-08E4 Bedienungsanleitung

McQuay

McQuay MCK020A Bedienungsanleitung

Webasto

Webasto Frigo Top 25 DS Bedienungsanleitung

Frigidaire

Frigidaire FAZ12ES2A Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric MSC-GE20VB Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric PLA-M100EA Bedienungsanleitung

Daikin

Daikin Split Sensira R32 Bedienungsanleitung