Harvia CAULDRON Bedienungsanleitung
25022010
HARVIA CAULDRON
Instructions for Installation and Use
The flue connections of cauldrons must be made with
great care. The connecting pipe must fit tightly against the
pipe lining. The diameter of the flue outlet should be ca.
10–15 mm bigger than that of the connecting pipe. The
space between the pipe and the flue outlet must be tightly
sealed, for example, with mineral wool.
The inner cauldron is made of high-quality stainless
steel. Note! Foreign substances in water or transfered in
the cauldron by e.g. a grinding machine, such as iron, may
cause rust spots. These can easily be removed using a fine
(400) water sandpaper or emery paper on the surface. Do
not use steel wool for cleaning.
When the inner cauldron is filled with cold water, some of
the water may condense on the cauldron’s outer surface,
which may arouse suspicion of a possible leak in the
cauldron. This is, however, a natural phenomenon and will
disappear as the water warms up.
Rather than fill the cauldron to the brim, leave it a few
centimetres short of full to avoid overboiling. The cauldron
must never be heated when empty.
The inner cauldron can be removed for cleaning and
chimney sweeping. If the outer surface of the inner
cauldron is covered with a thick layer of soot, water will
heat up more slowly and the consumption of firewood
will increase.
Use only good quality wood (no resinous wood) in the
furnace. Burning should take place slowly. The fire can
be made very small by changing the position of the ash
box.
Cauldrons do not draw air as well as wood-burning
stoves due to the narrow and initially cold smoke duct
between inner cauldron and lining. Close the damper (sold
as an accessory) when the fire has finished burning to keep
the water warm longer.
The safety distance of inflammable materials is 150 mm
sideways and backwards, 500 mm to front and 1000 mm
up towards the ceiling. If the cauldron is placed on a
wooden base, a concrete slab at least 60 mm thick must be
cast between the base and the cauldron, or a corresponding
sheath must be put in place. The slab must extend at least
100 mm sideways past the cauldron walls and 400 mm
forward from the chamber door.
If a wood-burning stove is placed closer than 250 mm
from the cauldron, the stove and cauldron must be separated
by a non-flammable protective sheath that prevents the
stove’s heat from damaging the surface of the cauldron.
The purpose of the sheath is to protect the cauldron from
direct heat radiation from the stove. When equipped with
a sheath, the stove and cauldron can be located as close
ad 60 mm from each another.
NOTE! Impurities and chemicals in the water may
damage the metal parts of the cauldron.
The water used in the cauldron should meet the requirements
of clean household water. The following factors have an
essential influence on water quality:
humus concentration (colour, taste, precipitation);
recommended concentration is less than 12 mg/litre.
iron concentration (colour, odour, taste,
precipitation); recommended concentration is less
than 0.2 mg/litre.
hardness; the most important substances are
manganese (Mn) and calcium (Ca); recommended
content of manganese is less than 0.05 mg/litre, and
calcium less than 100 mg/litre.
NOTE! Do not allow water to freeze in the cauldron as
expanding ice may break the inner cauldron.
•
•
•
Note! The knob of the lid is
placed on the underside of
the lid for transportation.
Before use, remove the knob
and attach it on the upper
side of the lid.
Cauldron and wood-burning stove side-by-side
CAULDRON AND WOOD-BURNING STOVE SIDE-BY-SIDE
CONCRETE
WOOD PANEL
BRICK
NON-FLAMMABLE
PROTECTIVE PLATE
CAULDRON 80 L
min. 60 mm
min. 30 mm
min.
500 mm
The safety distance of inflammable materials
CONCRETE
min. 400
mm
530 mm
740 mm
590 mm
Ø145 mm
75 kg
min. 150
mm
min. 100
mm
min. 100
mm
min. 60
mm
min. 100
mm
min. 150
mm
min. 1000
mm
25022010
Ñîåäèíåíèå áàêà ñ äûìîõîäîì íåîáõîäèìî âûïîëíèòü
òùàòåëüíî. Ñîåäèíèòåëüíàÿ òðóáà äîëæíà ïëîòíî ïðèëåãàòü
ê îáøèâêå áàêà. Äèàìåòð îòâåðñòèÿ äûìîõîäà äîëæåí áûòü
ïðèìåðíî íà 10–15 ìì áîëüøå äèàìåòðà ñîåäèíèòåëüíîé
òðóáû. Ñîåäèíèòåëüíóþ òðóáó ñëåäóåò òùàòåëüíî óïëîòíèòü â
îòâåðñòèè äûìîõîäà, íàïðèìåð, ñ ïîìîùüþ ìèíåðàëüíîé âàòû.
Âíóòðåííèé áàê èçãîòîâëåí èç âûñîêîêà÷åñòâåííîé íåðæàâåþùåé
ñòàëè. Âíèìàíèå! Èìåþùèåñÿ â âîäå èëè ïîïàâøèå ïðè øëèôîâêå
áàêà ïðèìåñè, òàêèå, êàê æåëåçî, ìîãóò âûçâàòü ïîÿâëåíèå ðæàâûõ
òî÷åê. Îíè ìîãóò áûòü ëåãêî óäàëåíû ñ ïîìîùüþ ëåãêîé îáðàáîòêè
òîíêîé (¹400) øëèôîâàëüíîé áóìàãîé äëÿ âëàæíîé øëèôîâêè
èëè íàæäà÷íîé áóìàãîé.
Êðîìå òîãî, íåîáõîäèìî ïðèíÿòü âî âíèìàíèå, ÷òî ïðè çàïîëíåíèè
âíóòðåííåãî áàêà õîëîäíîé âîäîé âîäà ìîæåò êîíäåíñèðîâàòüñÿ
íà âíåøíåé ïîâåðõíîñòè âíóòðåííåãî áàêà, ÷òî ìîæåò ïîêàçàòüñÿ
ïðîòåêàíèåì. Êîíäåíñàöèÿ ÿâëÿåòñÿ íîðìàëüíûì ÿâëåíèåì è
ïðåêðàùàåòñÿ ñ íàãðåâàíèåì âîäû.
Ïðè çàïîëíåíèè áàêà óðîâåíü âîäû íåîáõîäèìî îñòàâèòü
íà íåñêîëüêî ñàíòèìåòðîâ íèæå âåðõíåãî êðàÿ áàêà â öåëÿõ
ïðåäóïðåæäåíèÿ âîçìîæíîãî ÷ðåçìåðíîãî êèïåíèÿ.
Âíóòðåííèé áàê ìîæíî âûíóòü äëÿ ìûòüÿ è î÷èñòêè îò ñàæè.
Òîëñòûé ñëîé ñàæè íà âíåøíåé ïîâåðõíîñòè áàêà çàìåäëÿåò íàãðåâ
âîäû è óâåëè÷èâàåò ðàñõîä äðîâ.
 òîïêå áàêà ðåêîìåíäóåòñÿ ñæèãàòü õîðîøèå ñóõèå äðîâà (íå
ñìîëèñòûå). Ãîðåíèå äîëæíî ïðîèñõîäèòü ñïîêîéíî, òÿãó ìîæíî
îòðåãóëèðîâàòü äî î÷åíü íåçíà÷èòåëüíîé ñ ïîìîùüþ çîëüíèêà.
Áàê íå èìååò òàêîé ñèëüíîé òÿãè, êàê äðîâÿíàÿ êàìåíêà ñàóíû.
Ïëîõàÿ òÿãà âûçâàíà áîëåå óçêèì è âíà÷àëå õîëîäíûì äûìîîòâîäîì
ìåæäó âíóòðåííèì áàêîì è îáøèâêîé. Äûìîâóþ çàñëîíêó
(äîïîëíèòåëüíîå óñòðîéñòâî) ñòîèò çàêðûòü ïî îêîí÷àíèè ãîðåíèÿ,
÷òîáû çàìåäëèòü îõëàæäåíèå âîäû.
Áåçîïàñíûå ðàññòîÿíèÿ îò áàêà äî ãîðþ÷èõ ìàòåðèàëîâ
ñîñòàâëÿþò: íàçàä è â ñòîðîíû - 150 ìì, âïåðåä - 500 ìì, ââåðõ
ê ïîòîëêó - 1000 ìì. Åñëè áàê óñòàíàâëèâàåòñÿ íà äåðåâÿííóþ
îñíîâó, òî ìåæäó áàêîì è îñíîâîé íåîáõîäèìî îòëèòü áåòîííóþ
ïëèòó òîëùèíîé íå ìåíåå 60 ìì èëè óñòàíîâèòü àíàëîãè÷íóþ
çàùèòó. Ïëèòà-îñíîâà äîëæíà âûñòóïàòü â áîêîâîì íàïðàâëåíèè
íå ìåíåå, ÷åì íà 100 ìì îò ñòåíîê áàêà, à â ïåðåäíåé ÷àñòè – íà
400 ìì îò äâåðöû òîïêè.
Åñëè äðîâÿíàÿ êàìåíêà óñòàíàâëèâàåòñÿ íà ðàññòîÿíèè ìåíåå
250 ìì îò áàêà, òî ìåæäó áàêîì è êàìåíêîé íåîáõîäèìî óñòàíîâèòü
òåïëîèçîëÿöèþ èç íåñãîðàåìîãî çàùèòíîãî ëèñòà, ÷òî çàùèòèò
ïîâåðõíîñòü áàêà îò òåïëîâîãî âîçäåéñòâèÿ êàìåíêè. Èçîëÿöèÿ
äîëæíà ïðåïÿòñòâîâàòü ïðÿìîìó èçëó÷åíèþ òåïëà ìåæäó êàìåíêîé
è áàêîì. Ïðè óñòàíîâêå òåïëîèçîëÿöèè êàìåíêà è áàê ìîãóò
ðàñïîëàãàòüñÿ äàæå íà ðàññòîÿíèè 60 ìì äðóã îò äðóãà.
 áàêå ñëåäóåò èñïîëüçîâàòü âîäó, êîòîðàÿ îòâå÷àåò òðåáîâàíèÿì
ê êà÷åñòâó õîçÿéñòâåííî-áûòîâîé âîäû. Íà êà÷åñòâî âîäû
çíà÷èòåëüíî âëèÿþò ñëåäóþùèå ôàêòîðû:
ñîäåðæàíèå ãóìóñà (öâåò, âêóñ, îñàäîê), ðåêîìåíäàöèè <12 ìã/ë;
ñîäåðæàíèå æåëåçà (öâåò, çàïàõ, âêóñ, îñàäîê),
ðåêîìåíäàöèè <0,2 ìã/ë;
æåñòêîñòü âîäû; íàèáîëåå âàæíûìè âåùåñòâàìè ÿâëÿþòñÿ
ìàðãàíåö (Mn) è êàëüöèé (Ca), ò.å. èçâåñòü. Ðåêîìåíäàöèè
äëÿ ìàðãàíöà <0,05 ìã/ë è êàëüöèÿ <100 ìã/ë.
•
•
•
¢¨¦·¥·¢¤¥¢§¨§¨£££´¥¦¤¤¦¥ª
ª¦¥
¨·¥¥·§¥£´
¢¨§¯
¥©¦¨¤³¡
¦£·®¦¥¥³¡£©ª
¢£
ÄÀÅÄÄ
ÄÀÅÄÄ
ÄÀÅ
ÄÄ
ª¦¥
ÄÀÅ
ÄÄ
ÄÄ
ÄÄ
ÄÄ
ØÄÄ
»
ÄÀÅ
ÄÄ
ÄÀÅ
ÄÄ
ÄÀÅ
ÄÄ
ÄÀÅ
ÄÄ
ÄÀÅ
ÄÄ
ÄÀÅ
ÄÄ
ÄÀÅ
ÄÄ
Beliebte Ofen Handbücher anderer Marken
Lennox
Lennox EL195UHE Elite Series Installations- und Betriebshandbuch
Intertherm
Intertherm M7RL Series Bedienungsanleitung
HDG
HDG Pelletmaster 15 Bedienungsanleitung
Pinnacle
Pinnacle Aero Bella AB-716C-QH Handbuch
Nortek
Nortek MG2S Series Bedienungsanleitung
VERDER
VERDER CARBOLITE GERO ABF 8/28 Handbuch
