Harvia Sentiotec Concept R CP-RCB-090 Bedienungsanleitung

Version 12/17 Ident no CP-RCB-MA

INSTRUCTIONS FOR INSTALLATION AND USE

English

Sauna heater

Concept R combi black

CP-RCB-090 / 1-027-775: Concept R combi 9.0 kW

CP-RCB-105 / 1-027-776: Concept R combi 10.5 kW

Table of Contents

1. About this instruction manual 4

2. Important information for your safety 5

2.1. Intended use 5

2.2. Safety information for the installer 6

2.3. Safety information for the user 7

3. Product description 9

3.1. Scope of delivery 9

3.2. Accessories 9

3.3. Product functions 9

4. Installation and connection 10

4.1. Installation location and sensor position 10

4.2. Safety distances 11

4.3. Adjusting the height 11

4.4. Connection diagram for 400 V 3N~ 12

4.5. Connection diagram for 230 V 1N~ 13

4.6. Electrical connection 14

5. Commissioning 16

5.1. Filling the stone container 16

5.2. Inserting the ceramic bowl 16

 17

6. Operation 18

6.1. Finnish sauna mode 18

6.2. Combi mode 19

7. Maintenance 21

7.1. Extended periods of non-use 21

7.2. Cleaning the sauna heater 21

7.3. Changing the sauna stones 21

7.4. Cleaning the evaporator tank 22

7.5. Cleaning the ceramic bowl 22

7.6. Descaling the evaporator tank 23

8. Problem-solving by the installer 23

9. Disposal 23

10. Technical data 24

11. Dimensions 25

Instructions for installation and use p. 4/26

1. About this instruction manual

Carefully read these instructions for installation and use, and keep them near

the sauna. This ensures that you can refer to information about your safety and

the operation at any time.

Symbols used for warning notices

In these instructions for installation and use, a warning notice located next to

an activity indicates that this activity poses a risk. Always observe the warning

notices. This prevents damage to property and injuries, which in the worst case

may be fatal.

The warning notices contain keywords, which have the following meanings:

DANGER!

Serious or fatal injury will occur if this warning notice is not observed.

WARNING!

Serious or fatal injury can occur if this warning notice is not observed.

CAUTION!

Minor injuries can occur if this warning notice is not observed.

ATTENTION!

This keyword is a warning that damage to property can occur.

Other symbols

This symbol indicates tips and useful information.

Do not cover Read the operating instructions

These installation and operating instructions can also be found in the

downloads section of our website: www.sentiotec.com/downloads.

Instructions for installation and use p. 5/26

2. Important information for your safety

The Concept R combi sauna heater has been produced in accord-

ance with the applicable safety rules and regulations. However,

hazards may occur during use. Therefore adhere to the following



chapters.

2.1. Intended use

The Concept R combi is a sauna heater with integrated evaporator.

The Concept R combi is intended solely for heating sauna cabins

and for increasing the humidity within the sauna cabin. The Concept

R combi may only be used in conjunction with a sauna control unit

without a remote start function.

The Concept R combi sauna heater can also be used with a sauna

control unit with a remote start function, but only in conjunction with

the optional safety shutdown feature (CP-R-SWL).

The Concept R combi sauna heater can also be used in public

saunas, but only in conjunction with the optional safety shutdown

feature (CP-R-SWL).

Any use exceeding this scope is considered improper use. Improper

use can result in damage to the product, severe injuries or death.

Instructions for installation and use p. 6/26

2.2. Safety information for the installer

Installing and connecting the sauna heater may only be performed

when the power supply is disconnected.





A fully disconnecting all-pole isolating device compliant with



Always use silicone cables that are heat-resistant up to 150 °C

to connect the sauna heater.

Only install one sauna heater in the cabin. The Concept R combi

sauna heater must not be used together with other sauna heaters

in a sauna cabin.

The roof and walls of the sauna cabin must be manufactured

from low-resin, untreated or thermally treated wood, e.g. Nordic

-

als. If laminated wooden materials are used, make sure that the

adhesive used in them does not give off formaldehyde. If other

materials than wood are used in the sauna cabin, these materi-

als must be heat-resistant and corrosion-resistant and must not

cause any negative effects on the health of the sauna users.

The height of the sauna cabin must be at least 2.0 m.

 

sauna cabin in chapter 10. Technical data on page 24.

When positioning the sauna heater, observe the minimum safety

distances (see chapter 4.2. Safety distances on page 11).

Also comply with the regulations applicable at the installation

location.

For your own safety, consult your supplier in the event of prob-



instructions.

Instructions for installation and use p. 7/26

2.3. Safety information for the user

The device must not be used by children under 8 years of age.

The device may only be used by children over 8 years of age,

by persons with limited psychological, sensory or mental capa-

bilities or by persons with lack of experience/knowledge under

the following conditions:

– They are supervised.

– They have been shown how to use the device safely and

are aware of the hazards that could occur.

Children must not play with the device.

Children under 14 years of age may only clean the device if they

are supervised.

 -

ence of alcohol, medication or drugs.

Never operate the sauna heater without sauna stones, as this



Heat up the sauna heater and the evaporator for half an hour



the sauna cabin during this period. Then ventilate the sauna

cabin well (see on page 17).

 

sauna heater before the sauna control unit is switched on.

Instructions for installation and use p. 8/26

Never touch the sauna heater while it is operating. The surfaces

of the sauna heater and sauna stones become extremely hot.



the evaporator tank each time before starting combi mode. If the

overheating protection has switched off evaporator heating, or if

your sauna control unit reports a lack of water, allow the evaporator

to cool down BEFORE you pour water into the evaporator tank.

For your own safety, consult your supplier in the event of problems



Instructions for installation and use p. 9/26

3. Product description

3.1. Scope of delivery

Sauna heater

Instructions for installation and use

Ceramic bowl for herbs and fragrances

3.2. Accessories

Accessories Item number

 CP-RC-AF

Safety shut-off CP-R-SWL

Bracket set for heater railing CP-R-HSR

LINDEN wooden railing, large CP-R-L2

WALNUT wooden railing, large CP-R-N2

Emotion railingset LINDEN, large CPR-EMO-L2

Emotion railingset WALNUT, large CPR-EMO-N2

3.3. Product functions

The Concept R combi sauna heater is a combination heater. The following op-

erating modes are possible:

Finnish sauna mode: usually 80 to 100 °C; approx. 10% rel. humidity

Combi mode (only in combination with a combi control): approx. 40 to 65 °C,

35% to 70% humidity. The maximum permissible relative humidity decreases

with increasing temperature.

If you wish, you can put fragrances or dried herbs in the ceramic bowl over

the evaporator in combi mode. The rising steam releases essential oils from



Installation instructions, only for experts p. 10/26

4. Installation and connection

Take t h e following points i n t o account when p o s i t i o n i n g and connecting t he sauna

heater:





to the cabin roof above the centre of the heater.





A fully disconnecting all-pole isolating device compliant with overvoltage



The Concept R combi sauna heater is a free-standing heater. It does not need







example.

4.1. Installation location and sensor position

Position the heater centrally in front of the air intake opening in the cabin wall.

Fig. 1.

Install the temperature sensor with excess temperature cut-out to the cabin wall

above the centre of the sauna heater. Maintain a distance of 15 cm to the sauna

cabin roof.

WARNING!

Danger of electric shock

The sauna heater may only be installed and connected when the

power supply is disconnected.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Harvia Heizung Handbücher

Harvia

Harvia AV-4 Leitfaden

Harvia

Harvia PO12-U1 Betriebsanleitung

Harvia

Harvia KUBIC COMBI Bedienungsanleitung

Harvia

Harvia HAFU4502401 Betriebsanleitung

Harvia

Harvia sentiotec Concept R black Bedienungsanleitung

Harvia

Harvia HYB300230S Leitfaden

Harvia

Harvia AFB4 Bedienungsanleitung

Harvia

Harvia KIP-30-B1 Betriebsanleitung

Harvia

Harvia FORTE Bedienungsanleitung

Harvia

Harvia M45 Bedienungsanleitung

Harvia

Harvia M45 Bedienungsanleitung

Harvia

Harvia FG Series Bedienungsanleitung

Harvia

Harvia CS60 Bedienungsanleitung

Harvia

Harvia Type KIP45 Bedienungsanleitung

Harvia

Harvia L30 Bedienungsanleitung

Harvia

Harvia KV-45 Leitfaden

Harvia

Harvia JM-20 Instructions for and use Bedienungsanleitung

Harvia

Harvia HPCS6U1H Betriebsanleitung

Harvia

Harvia sentiotec HWO-035NS-P Bedienungsanleitung

Harvia

Harvia sentiontec Concept R mini Series Bedienungsanleitung

Harvia

Harvia HPCS6U1HB Bedienungsanleitung

Harvia

Harvia DIR-350-R-F Bedienungsanleitung

Harvia

Harvia FU60 Bedienungsanleitung

Harvia

Harvia HSWS6U1B Betriebsanleitung

Beliebte Heizung Handbücher anderer Marken

oventrop

oventrop Regucor Series Bedienungsanleitung

Blaze King

Blaze King CLARITY CL2118.IPI.1 Bedienungsanleitung

ELMEKO

ELMEKO ML 150 Bedienungsanleitung

BN Thermic

BN Thermic 830T Bedienungsanleitung

KING

KING K Series Leitfaden

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Kurzanleitung

Well Straler

Well Straler RC-16B Bedienungsanleitung

EUROM

EUROM 333299 Bedienungsanleitung

Heylo

Heylo K 170 Bedienungsanleitung

Eterna

Eterna TR70W Bedienungsanleitung

Clarke

Clarke GRH15 Bedienungsanleitung

Empire Heating Systems

Empire Heating Systems WCC65 Bedienungsanleitung

Wetekom

Wetekom 92 86 43 Bedienungsanleitung

Desa

Desa SPC170-F Bedienungsanleitung

Watlow

Watlow Watrod Electric Tubular Heaters Bedienungsanleitung

Haverland

Haverland ECO-DRY GPS Series Stücklistenhandbuch

Stelpro

Stelpro ASILVC2060 Series Bedienungsanleitung

iLO

iLO IHP2424 Betriebsanleitung