Hearth and Home Technologies TCT375 Bedienungsanleitung

Hearth & Home Technologies • TCT375 Terra Cotta Termination Cap • 4014-033 Rev D • 02/16 1

Models:

TCT375

Terra Cotta Termination Cap

Installation

Instructions

This chimney termination cap has been tested for use with specic Hearth & Home Technologies replaces. Check with

your local building code agency before you begin installation to ensure compliance with local codes, including the need for

permits and follow-up inspections. If you encounter any problems regarding code approvals, or if you need clarication of

any of the instructions contained here, contact your Hearth & Home Technologies dealer. For the dealer nearest you, please

visit www.hearthnhome.com

Note: An arrow () found in the text signies change

in content.

Figure 1 TCT375 Dimensions

CAUTION! Risk of Cuts/Abrasions. Wear protective

gloves and safety glasses during installation. Sheet

metal edges are sharp.

WARNING! Risk of Fire. Intended for use with a

metal chase top only.



Hearth & Home Technologies • TCT375 Terra Cotta Termination Cap • 4014-033 Rev D • 02/16

1. Chase Top

The chase top must have structural support under it to sup-

port the cap and to provide anchor points for the cap. See

Figure 2 for minimum dimensions. Attach the chase top. Pro-

ceed to Step 2.

• Fasten and seal the four ends of the angle.

• Fasten and seal the cap to the angle.

• Caulk all screws (or nails) in the chase top.

If you are unable to put supports under the chase top to sup-

port the cap (as shown in Figure 2), we suggest using two

pieces of aluminum angle (1/2 inch x 3/4 inch).

• Cut the pieces so the lengths equal the depth at the narrow

outside dimension of the chase. See Figure 3.

• Center the base of the termination cap over the chimney

(inside the chase) and slide the inner ue inside the inner

ue of the chimney and the outer section over the outside

of the chimney.

• Adjust the termination cap so the cap is square with the

chase and mark the position using the holes provided in

the feet as a guide.

• Drill through the chase top using a 1/8 inch diameter drill at

the marked locations. Securely attach the cap to the chase

using the screws provided in the fastener package.

• Assemble the top of the termination cap.

• Caulk all screws (or nails) in the chase top.

Chimney

Pipe

Chase Top

Termination Cap

Chase

Collar

2 in. (51 mm)

Minimum Height

Remove 2 screws

from front & back

to lift the top off

Place waterproof sealer

under each flange of the

termination cap and on

top of each screw to

help prevent leaks.

The last section of pipe

must stop between 2 in.

(51 mm) above top of

chase and 4-3/4 in. (121

mm) below top of chase

2 in. (51 mm)

4-3/4 in. (121 mm)

Figure 4 - Install Cap

Note: The last chimney section must be located within 2

inches above or 4-3/4 inches below the chase top. See

Figure 4.

Note: Periodic re-caulking may be needed to prevent leaks

from developing.

14-1/2 in. min.

15 in. max.

(chase)

(2 in. x 4 in. supports)

14-1/2 in. min.

15 in. max.

Figure 2 - 2x4 Supports

(chase)

(angle supports)

(chase top)

Figure 3 - Angle Supports

2. Install Chimney Sections and Cap (See Figure 4)

• Assemble the SL Series chimney sections to between

4-3/4 inches below the chase top and 2 inches above the

chase top.

• Remove the top of the Terra Cotta Cap.

• Install the cap on the chimney pipe so it rests on the chase

top.

• Slip the two pieces of aluminum angle (wide ange down)

under the bottom lip of the cap on two sides. The angle

can be fastened down at the ends of the chase. Make

sure the pieces are tight against and supporting the cap

before you fasten the ends.



Andere Hearth and Home Technologies Kaminzubehör Handbücher

Hearth and Home Technologies

Hearth and Home Technologies HEAT-ZONE-GAS Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies Contour36 Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies STONEKIT Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies PHSI-MCE Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies GO318MTCH Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies Expedition-I Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies PHTRIM-MCE-36 Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies DV425 Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies GFK-160VF Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies Quadra-Fire SANTAFEI-C Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies Grand Vista 60 Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies GV60BK Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies PVLP-SLP Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies Heat-Zone HZLIN-ADP Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies Cinch Pipe & Termination Cap System Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies PHFR-MCE-36 Bedienungsanleitung

Hearth and Home Technologies

Hearth and Home Technologies REM-KIT Bedienungsanleitung

Beliebte Kaminzubehör Handbücher anderer Marken

Valor

Valor L2 1700K Bedienungsanleitung

Exodraft

Exodraft Xzense Bedienungsanleitung

Whalen

Whalen Ruso MNFP62BF23-6 Bedienungsanleitung

Lopi

Lopi Hearthview 864 Bedienungsanleitung

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Bedienungsanleitung

EdilKamin

EdilKamin SERBATOIO 250 Kurzanleitung

Bronpi

Bronpi KIT-1 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Bedienungsanleitung

Travis Industries

Travis Industries 33 DVI Bedienungsanleitung

Superior

Superior ASD3628-TI Bedienungsanleitung

pleasant hearth

pleasant hearth OFP28WG Bedienungsanleitung

IHP

IHP Astria Series Bedienungsanleitung

Firegear

Firegear FG-H-2110SS Bedienungsanleitung

Nibe

Nibe Contura C i31 Bedienungsanleitung

kozy heat

kozy heat KZK-052 Bedienungsanleitung

SimpliFire

SimpliFire SF-WM36 Bedienungsanleitung

Bluegrass Living

Bluegrass Living BC18NR Kurzanleitung

pleasant hearth

pleasant hearth IRIS SCROLL Bedienungsanleitung