Heat & Glo SOHO-N-CEB Programmierhandbuch

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/11

Owner’s Manual

Installation and Operation

• DO NOT storeorusegasolineorotherﬂam-

mablevaporsandliquidsin thevicinityof this

or any other appliance.

• DO NOT sprayaerosolsinthe vicinity of this

appliance while it is in operation.

• What to do if you smell gas

- DO NOT try to light any appliance.

- DO NOT touch any electrical switch. DO

NOT use any phone in your building.

- Immediately call your gas supplier from

a neighbor’s phone. Follow the gas sup-

plier’s instructions.

- If you cannot reach your gas supplier, call

the ﬁre department.

• Installation and service must be performed

bya qualiﬁedinstaller,service agency,orthe

gas supplier.

WARNING: If the information in these

instructions is not followed exactly, a ﬁre

or explosion may result causing property

damage, personal injury, or death.

WARNING

This appliance has been supplied with an integral barrier

to prevent direct contact with the ﬁxed glass panel. DO

NOT operate the appliance with the barrier removed.

Contact your dealer or Hearth & Home Technologies if the

barrier is not present or help is needed to properly install one.

HOT SURFACES!

Glassandothersurfacesarehotduring

operation AND cool down.

Hot glass will cause burns.

• DO NOT touch glass until it is cooled

• NEVER allow children to touch glass

• Keep children away

• CAREFULLY SUPERVISE children in same room as

ﬁreplace.

• Alert children and adults to hazards of high temperatures.

High temperatures may ignite clothing or other ﬂammable

materials.

• DO NOT place articles on or against this appliance.

• Keep clothing, furniture, draperies and other ﬂammable

materials away.

This is a room sealed appliance and no other ventilation is

required than what is provided.

DO NOT DISCARD THIS MANUAL

NOTICE

• Leave this manual with

party responsible for use

and operation.

DO NOT

DISCARD

• Important operating

and maintenance

instructions included.

• Read,understandandfollow

these instructions for safe

installation and operation.

0086

These instructions are valid for the following countries: GB

Theseinstructions areonlyvalid ifthefollowing country symbolis

on the appliance. If this symbol is not present on the appliance,

it is necessary to refer to the technical instructions which will

provide the necessary information concerning the modiﬁcation

of the appliance to the conditions of use for the country.

Model:

SOHO-B-CEB

SOHO-N-CEB

SOHO-P-CEB

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/112

PLEASE READ THIS MANUAL BEFORE INSTALLING

AND USING THIS APPLIANCE.

IMPORTANT: Read all instructions carefully before starting installation.

Failure to follow these installation instructions may result in a possible ﬁre

hazard and will void the warranty. Save this manual for future reference.

It is the responsibility of the professionals involved with the service

and installation of the appliance to test the operation of the appliance

before leaving the installation site.

Heat & Glo, a brand of Hearth & Home Technologies, Inc.

7571 215th Street West, Lakeville, MN 55044

MODEL: SOHO-CEB IS BSI APPROVED FOR

NATURAL GAS, PROPANE OR BUTANE AS A

BALANCED FLUE FIREPLACE.

Refer to the appliance data plates for gas con-

sumptions and pressures.

Installation of this appliance should only be

carried out by an authorized person in accor-

dance with the manufacturer’s instructions.

Appliance is to be installed in full compliance

with the manufacturer’s instructions, and any

localauthorities’requirementsforgas,electrical

and building regulations.

This appliance and its components are tested

andsafe when installed inaccordancewiththis

Installation Manual. Report to your dealer any

parts damaged in shipment, speciﬁcally check

glass condition. The gas logs and ﬂue system

components are in separate packages. Read

all instructions before starting installation and

followthese instructions carefully during instal-

lation to ensure maximum beneﬁt and safety.

Failure to follow them will void your warranty

and may present a ﬁre hazard.

The Heat & Glo, a brand of Hearth & Home

Technologies Inc. warranty will be voided by,

and Heat & Glo, a brand of Hearth & Home

Technologies Inc. disclaims any responsibility

for the following actions:

• Installation of any damaged ﬁreplace or ﬂue

system component

• Modiﬁcation of the ﬁreplace or balanced ﬂue

systeminstallation other than as instructed

by Heat & Glo, a brand of Hearth & Home

Technologies Inc.

• Improper positioning of the gas logs or the

glass door

• Installationand/or use of any componentpart

notmanufactured orapprovedby Heat &Glo,

brand of Hearth & Home Technologies Inc.,

not withstanding any independent testing

laboratory or other party approval of such

component part or accessory.

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/11

Listing Label Information/Location

Model Name:___________________________________________ Date purchased/installed:__________________

Serial Number:__________________________________________ Location on ﬁreplace:_____________________

Dealership purchased from: _______________________________ Dealer Phone: __________________________

Notes: _______________________________________________________________________________________

_____________________________________________________________________________________________

A. Congratulations

Congratulationson selectingaHeat &Glogas ﬁreplace,an

elegant and clean alternative to wood burning ﬁreplaces.

TheHeat& Glogasﬁreplaceyouhave selectedisdesigned

to provide the utmost in safety, reliability, and efﬁciency.

As the owner of a new ﬁreplace, you’ll want to read and

carefully follow all of the instructions contained in this

owner’s manual. Pay special attention to all cautions and

warnings.

This owner’s manual should be retained for future

reference. We suggest that you keep it with your other

important documents and product manuals.

The information contained in this owner’s manual, unless

noted otherwise, applies to all models and gas control

systems.

Your new Heat & Glo gas ﬁreplace will give you years of

durable use and trouble-free enjoyment. Welcome to the

Heat & Glo family of ﬁreplace products!

We recommend that you record the following pertinent

information about your ﬁreplace.

Serial Number

Type of Gas

The model information regarding your speciﬁc ﬁreplace can be found on

the rating plate usually located in the control area of the ﬁreplace.

Homeowner Reference Information

Model Number

SAMPLE

Heat & Glo, a brand of Hearth & Home Technologies Inc.

7571 215th Street West, Lakeville, MN 55044 USA

PIN: 87BU58 MADE IN USA

Gas Type G20 G20 G20/25

AT,ES,DK,GB,GR,LU,NO,SK

CAT III

2H 2E 2E+

Pn 20 mbar 20 mbar 20/25 mbar

8.7 mbar 9.5 mbar 9.5/11.5 mbar

Injector #42 DMS #42 DMS #42 DMS

Efficiency Class 2 2 2

Gas Rate / .70 .70 .70/.68

m3 h

This appliance must be installed in accordance with

the rules in force, and used only in a sufficiently

vented space. Consult instructions before installa-

tionanduseofthisappliance.

DONOT REMOVEORCOVER THISLABEL.

XXXXXXXX

XXXX-XXX

Model:

Serial:

DE FR

Destination

Heat Input (Net) 7.32 kW 7.32 kW 7.32 kW

Electrical Requirements: 230 V / 50 hz / 1A

Burner Pressure

BSI

Read this manual before installing or operating this appliance.

Please retain this owner’s manual for future reference.

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/114

Safety Alert Key:

• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.

• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.

• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

• NOTICE: Used to address practices not related to personal injury.

Table of Contents

A. Congratulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

B. Limited Lifetime Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . 6

1 Listing and Code Approvals

A. Appliance Certiﬁcation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

B. Additional Related Standards. . . . . . . . . . . . . . . . . . . . . . . 8

C. Gas Pressure Requirements . . . . . . . . . . . . . . . . . . . . . . . 8

D. High Altitude Installations. . . . . . . . . . . . . . . . . . . . . . . . . . 8

E. Non-Combustible Materials Speciﬁcation. . . . . . . . . . . . . . 8

F. Combustible Materials Speciﬁcation . . . . . . . . . . . . . . . . . 8

G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

User Guide

2 Operating Instructions

A. Gas Fireplace Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

B. Your Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

C. Clear Space . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

D. Decorative Doors and Fronts . . . . . . . . . . . . . . . . . . . . . . 10

E. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

F. Remote Controls, Wall Controls and Wall Switches. . . . . 10

G. Before Lighting Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . 10

H. Control Module Operation . . . . . . . . . . . . . . . . . . . . . . . . 11

I. Lighting Instructions (IPI) . . . . . . . . . . . . . . . . . . . . . . . . . 12

J. After Fireplace is Lit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

K. Frequently Asked Questions . . . . . . . . . . . . . . . . . . . . . . 13

3 Maintenance and Service

A. Maintenance Tasks-Homeowner . . . . . . . . . . . . . . . . . . . 14

B. Maintenance Tasks-Qualiﬁed Service Technician . . . . . . 15

Installer Guide

4 Getting Started

A. Typical Appliance System. . . . . . . . . . . . . . . . . . . . . . . . . 17

B. Design and Installation Considerations . . . . . . . . . . . . . . 18

C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . 18

D. Inspect Appliance and Components. . . . . . . . . . . . . . . . . 18

5 Framing and Clearances

A. Selecting Appliance Location . . . . . . . . . . . . . . . . . . . . . . 19

B. Constructing the Appliance Chase. . . . . . . . . . . . . . . . . . 20

C. Clearances. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

D. Mantel and Wall Projections. . . . . . . . . . . . . . . . . . . . . . . 21

6 Termination Locations

A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 22

7 Vent Information and Diagrams

A. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

B. Vent Table Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

C. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

D. Measuring Standards. . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

E. Flue Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

8 Vent Clearances and Framing

A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 31

B. Wall Penetration Framing. . . . . . . . . . . . . . . . . . . . . . . . . 31

C. Install the Ceiling Firestop . . . . . . . . . . . . . . . . . . . . . . . . 32

D. Install Attic Insulation Shield. . . . . . . . . . . . . . . . . . . . . . . 33

9 Appliance Preparation

A. Top Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

B. Installation of Non-combustible Facing Material . . . . . . . 35

C. Securing and Leveling the Appliance. . . . . . . . . . . . . . . . 36

D. Covers Removal For Servicing. . . . . . . . . . . . . . . . . . . . . 37

E. Components Removal For Service . . . . . . . . . . . . . . . . . 37

F. Parts Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

G. Adjustments And Replacement Parts. . . . . . . . . . . . . . . . 37

H. Install Trim and/or Surround. . . . . . . . . . . . . . . . . . . . . . . 37

I. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

10 Installing Vent Pipe (SLP Pipe)

A. Assemble Vent Sections. . . . . . . . . . . . . . . . . . . . . . . . . . 38

B. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 39

C. Secure the Vent Sections. . . . . . . . . . . . . . . . . . . . . . . . . 39

D. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 40

E. Install Support Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . 41

F. Install Firestops . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

G. Flue Termination. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

H. Heat Shield Requirements for Horizontal Termination . . . 43

I. Install Metal Roof Flashing. . . . . . . . . . . . . . . . . . . . . . . . 43

J. Assemble and Install Storm Collar. . . . . . . . . . . . . . . . . . 44

K. Install Vertical Termination Cap . . . . . . . . . . . . . . . . . . . . 44

11 Gas Information

A. Gas Pressure Requirements . . . . . . . . . . . . . . . . . . . . . . 45

B. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45

12 Electrical Information

A. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

B. IntelliFire Plus™ Ignition System Wiring . . . . . . . . . . . . . 47

C. Optional Accessories Requirements . . . . . . . . . . . . . . . . 47

D. Blower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/11

Î= Contains updated information.

E. Control Module Operation . . . . . . . . . . . . . . . . . . . . . . . . 48

13 Finishing

A. Mantel and Wall Projections. . . . . . . . . . . . . . . . . . . . . . . 56

B. Facing Material. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56

C. Framing and Finishing Instructions . . . . . . . . . . . . . . . . . 57

14 Appliance Setup

A. Remove Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . 58

B. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . . 58

C. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58

D. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58

E. Log Placement Instructions. . . . . . . . . . . . . . . . . . . . . . . 59

F. Install Media Rock Kit. . . . . . . . . . . . . . . . . . . . . . . . . . . . 60

G. IPI Module Reset Switch . . . . . . . . . . . . . . . . . . . . . . . . . 61

15 Troubleshooting

A. IntelliFire Plus™ Ignition System . . . . . . . . . . . . . . . . . . . 62

16 Reference Materials

A. Appliance Dimension Diagram. . . . . . . . . . . . . . . . . . . . . 64

B. Maintenance Tasks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65

C. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 66

E. Contact Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/116

B. Limited Lifetime Warranty

4021-645C 12-29-10 Page 1 of 2

Hearth & Home Technologies Inc.

LIMITED LIFETIME WARRANTY

Hearth & Home Technologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for

HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer.

WARRANTY COVERAGE:

HHT warrants to the original owner of the HHT appliance at the site of installation, and to any transferee taking ownership

of the appliance at the site of installation within two years following the date of original purchase, that the HHT appliance

will be free from defects in materials and workmanship at the time of manufacture. After installation, if covered compo-

nents manufactured by HHT are found to be defective in materials or workmanship during the applicable warranty period,

HHT will, at its option, repair or replace the covered components. HHT, at its own discretion, may fully discharge all of its

obligations under such warranties by replacing the product itself or refunding the verified purchase price of the product

itself. The maximum amount recoverable under this warranty is limited to the purchase price of the product. This warranty

is subject to conditions, exclusions and limitations as described below.

WARRANTY PERIOD:

Warranty coverage begins on the date of original purchase. In the case of new home construction, warranty coverage

begins on the date of first occupancy of the dwelling or six months after the sale of the product by an independent,

authorized HHT dealer/ distributor, whichever occurs earlier. The warranty shall commence no later than 24 months

following the date of product shipment from HHT, regardless of the installation or occupancy date. The warranty period for

parts and labor for covered components is produced in the following table.

The term “Limited Lifetime” in the table below is defined as: 20 years from the beginning date of warranty coverage for

gas appliances, and 10 years from the beginning date of warranty coverage for wood, pellet, and coal appliances. These

time periods reflect the minimum expected useful lives of the designated components under normal operating conditions.

See conditions, exclusions, and limitations on next page.

Parts Labor Gas Wood Pellet EPA

Wood Coal Electric Venting

XXXXXXX

All parts and material except as

covered by Conditions,

Exclusions, and Limitations

listed

XXX Igniters, electronic components,

and

lass

XXXXX Factor

-installed blowers

X Molded refractor

anels

XFire

ots and burn

ots

ears 1

ear X X Castin

s and baffles

7 years 3 years X X X Manifold tubes,

HHT chimne

and termination

ears 1 year X Burners, logs and refractory

Limited

Lifetime 3yearsXXXXX Fireboxandheatexchanger

XXXXXXX All replacement parts

ond warrant

eriod

Warranty Period HHT Manufactured Appliances and Venting

1 Year

Components Covered

3 years

2 years

90 Days

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/11

4021-645C 12-29-10 Page 2 of 2

WARRANTY CONDITIONS:

• This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor. A list of

HHT authorized dealers is available on the HHT branded websites.

• This warranty is only valid while the HHT appliance remains at the site of original installation.

• Contact your installing dealer for warranty service. If the installing dealer is unable to provide necessary parts, contact

the nearest HHT authorized dealer or supplier. Additional service fees may apply if you are seeking warranty service

from a dealer other than the dealer from whom you originally purchased the product.

• Check with your dealer in advance for any costs to you when arranging a warranty call. Travel and shipping charges

for parts are not covered by this warranty.

This warranty is void if:

• The appliance has been over-fired or operated in atmospheres contaminated by chlorine, fluorine, or other damaging

chemicals. Over-firing can be identified by, but not limited to, warped plates or tubes, rust colored cast iron, bubbling,

cracking and discoloration of steel or enamel finishes.

• The appliance is subjected to prolonged periods of dampness or condensation.

• There is any damage to the appliance or other components due to water or weather damage which is the result of, but

not limited to, improper chimney or venting installation.

LIMITATIONS OF LIABILITY:

• The owner’s exclusive remedy and HHT’s sole obligation under this warranty, under any other warranty, express or

implied, or in contract, tort or otherwise, shall be limited to replacement, repair, or refund, as specified above. In no

event will HHT be liable for any incidental or consequential damages caused by defects in the appliance. Some states

do not allow exclusions or limitation of incidental or consequential damages, so these limitations may not apply to you.

This warranty gives you specific rights; you may also have other rights, which vary from state to state. EXCEPT TO

THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY

SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE

EXPRESSED WARRANTY SPECIFIED ABOVE.

WARRANTY EXCLUSIONS:

This warranty does not cover the following:

• Changes in surface finishes as a result of normal use. As a heating appliance, some changes in color of interior and

exterior surface finishes may occur. This is not a flaw and is not covered under warranty.

• Damage to printed, plated, or enameled surfaces caused by fingerprints, accidents, misuse, scratches, melted items,

or other external sources and residues left on the plated surfaces from the use of abrasive cleaners or polishes.

• Repair or replacement of parts that are subject to normal wear and tear during the warranty period. These parts

include: paint, wood, pellet and coal gaskets, firebricks, grates, flame guides, light bulbs, batteries and the discolor-

ation of glass.

• Minor expansion, contraction, or movement of certain parts causing noise. These conditions are normal and com-

plaints related to this noise are not covered by this warranty.

• Damages resulting from: (1) failure to install, operate, or maintain the appliance in accordance with the installation

instructions, operating instructions, and listing agent identification label furnished with the appliance; (2) failure to

install the appliance in accordance with local building codes; (3) shipping or improper handling; (4) improper opera-

tion, abuse, misuse, continued operation with damaged, corroded or failed components, accident, or improperly/

incorrectly performed repairs; (5) environmental conditions, inadequate ventilation, negative pressure, or drafting

caused by tightly sealed constructions, insufficient make-up air supply, or handling devices such as exhaust fans or

forced air furnaces or other such causes; (6) use of fuels other than those specified in the operating instructions; (7)

installation or use of components not supplied with the appliance or any other components not expressly authorized

and approved by HHT; (8) modification of the appliance not expressly authorized and approved by HHT in writing;

and/or (9) interruptions or fluctuations of electrical power supply to the appliance.

• Non-HHT venting components, hearth components or other accessories used in conjunction with the appliance.

• Any part of a pre-existing fireplace system in which an insert or a decorative gas appliance is installed.

• HHT’s obligation under this warranty does not extend to the appliance’s capability to heat the desired space. Informa-

tion is provided to assist the consumer and the dealer in selecting the proper appliance for the application. Consider-

ation must be given to appliance location and configuration, environmental conditions, insulation and air tightness of

the structure.

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/118

A. Appliance Certiﬁcation

1 Listing and Code Approvals

C. Gas Pressure Requirements

Pressure requirements for SOHO-CEB ﬁreplace are

shown in table below.

Two taps are provided on the right hand side of the gas

control for a test gauge connection to measure the inlet

and outlet pressures.

MODELS: SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB

LABORATORY: BSI

TYPE: Gas Fireplace

STANDARD: Latest version of BS EN:613:2001

DIRECTIVE: GAD90/396/EEC

NOT INTENDED FOR USE AS A PRIMARY HEAT SOURCE.

This appliance is tested and approved as either supplemen-

tal room heat or as a decorative appliance. It should not be

factored as primary heat in residential heating calculations.

D. High Altitude Installations

NOTICE: Ifthe heatingvalue ofthe gashas beenreduced,

these rules do not apply. Check with your local gas utility

or authorities having jurisdiction.

When installing above 610 meter elevation:

Reduce input rate 4% for each 305 meters feet above

610 meters.

E. Non-Combustible Materials Speciﬁcation

Material which will not ignite and burn. Such materials are

those consisting entirely of steel, iron, brick, tile, concrete,

slate, glass or plasters, or any combination thereof.

Materials that are reported as passing ASTM E 136,

Standard Test Method for Behavior of Materials in a

Vertical Tube Furnace at 750 ºC and UL763 shall be

considered non-combustible materials.

F. Combustible Materials Speciﬁcation

Materials made of or surfaced with wood, compressed pa-

per, plant ﬁbers, plastics, or other material that can ignite

and burn, whether ﬂame proofed or not, or plastered or

unplastered shall be considered combustible materials.

G. Electrical Codes

All electrical safety testing has been done following the EN

60335-2-102 standard. Local codes apply.

The Heat & Glo gas appliances discussed in this Installer’s

Guide have been tested to certiﬁcation standards and listed

by the applicable laboratories.

This appliance must be installed in accordance with the

rules in force.

NOX Class 5 for G20, NOX Class 5 for G31

B. Additional Related Standards

Theinstallation mustcomply withthese installation instruc-

tions and all relevant parts of Local and National Building

Standards Regulations and those relevant recommenda-

tions of the following British Standards. BS 5871: Part 1

BS 8303 BS 5440: Parts 1 & 2 BS 6891 BSEN1856 Parts

1 & 2 BS 5482 Part 1, as well as IGE/UP/7.

The ﬁreplace and its individual shut-off valve must be dis-

connected from the gas supply piping system during any

pressure testing of the system at test pressures in excess

of 60 mbar.

If the ﬁreplace must be isolated from the gas supply pip-

ing system by closing an individual shut-off valve, it must

be of the handle-less type.

WARNING! Risk of Explosion! An in-line regulator

MUST be installed if the gas pressure exceeds 37 mbar.

Failure to install a regulator could damage valve.

Columnshighlighted ingray =The gascontrol valvesupplied withthis productis approved fora maximum

inlet pressure of 37 mbar. For pressures over 37 mbar, an in line pressure regulator must be installed

upstream from the gas control valve.

Natural Gas

(G20) Natural Gas

(G25) Butane

(G30) Propane

(G31)

CAT I2H, I2E, I2E+ I2E+ I3B/P I3P

Inlet Pressure 20 mbar 25 mbar 37 or 50 mbar 37 or 50 mbar

Burner Pressure 8,4 mbar 8,4 mbar 24 mbar 24 mbar

Gas Rate Max. 0,405 m3/h Max. 0,405 m3/h Max. 0,111 m3/hMax. 0,134 m3/h

Heat Input (Net) 4,0 kW 3,5 kW 3,6 kW 3,5 kW

Burner Injector DMS 50 (1,78 mm) DMS 50 (1,78 mm) DMS 61 (1,07 mm) DMS 58 (1 mm)

Pilot Injector 0,0121 0,0121 0,0181 0,0181

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/11

Figure 2.1 General Operating Parts

DECORATIVE DOORS

(NOT SHOWN)

SECTION 2.D.

FIXED GLASS ASSEMBLY

(NOT SHOWN)

SECTION 9.B.

MANTEL

SECTION 5.D

HEARTH

CLEAR SPACE

SECTION 2.C.

GRATE

2 Operating Instructions

User Guide

B. Your Fireplace

WARNING! DO NOT operate ﬁreplace before read-

ing and understanding operating instructions. Failure

to operate ﬁreplace according to operating instructions

could cause ﬁre or injury.

This appliance isnot intended foruse by persons(including

children) with reduced physical, sensory or mental capa-

bilities, or lack of experience and knowledge, unless they

have been given supervision or instruction concerning use

of the appliance by a person responsible for their safety.

Children should be supervised to ensure that they do not

play with the appliance.

A. Gas Fireplace Safety

WARNING

This appliance has been supplied with an integral barrier

to prevent direct contact with the ﬁxed glass panel. DO

NOT operate the appliance with the barrier removed.

Contact your dealer or Hearth & Home Technologies if the

barrier is not present or help is needed to properly install one.

HOT SURFACES!

Glassand othersurfacesare hot during

operation AND cool down.

Hot glass will cause burns.

• DO NOT touch glass until it is cooled

• NEVER allow children to touch glass

• Keep children away

• CAREFULLY SUPERVISE children in same room as

ﬁreplace.

• Alert children and adults to hazards of high temperatures.

High temperatures may ignite clothing or other

ﬂammable materials.

• Keep clothing, furniture, draperies and other ﬂammable

materials away.

If you expect that small children or vulnerable adults may

come into contact with this ﬁreplace, the following precau-

tions are recommended:

• Install a physical barrier such as:

- A decorative ﬁrescreen.

- Adjustable safety gate.

• Install a switch lock or a wall/remote control with child

protection lockout feature.

• Keep remote controls out of reach of children.

• Never leave children alone near a hot ﬁreplace,whether

operating or cooling down.

• Teach children to NEVER touch the ﬁreplace.

• Consider not using the ﬁreplace when children will be

present.

To prevent unintended operation when not using your ﬁre-

place for an extended period of time (summer months,

vacations, trips, etc):

• Remove batteries from remote controls.

• Turn off wall controls.

• Unplug 6 volt adapter plug and remove batteries on IPI

models.

Heat & Glo • SOHO-B-CEB, SOHO-N-CEB, SOHO-P-CEB • 2111-980 Rev. F • 8/1110

C. Clear Space

WARNING! DO NOT place combustible objects in front

of the ﬁreplace or block louvers. High temperatures may

start a ﬁre. See Figure 2.2.

Avoid placing candles and other heat-sensitive objects on

mantel or hearth. Heat may damage these objects.

Figure 2.2 Clear Space

E. Fixed Glass Assembly

See Section 9.B.

F. Remote Controls, Wall Controls and Wall

Switches

Follow the instructions supplied with the control installed

to operate your ﬁreplace:

For safety:

• Install a switch lock or a wall/remote control with child

protection lockout feature.

• Keep remote controls out of reach of children.

See your dealer if you have questions.

G. Before Lighting Fireplace

Before operating this ﬁreplace for the ﬁrst time, have a

qualiﬁed service technician:

• Verify all shipping materials have been removed from

inside and/or underneath the ﬁrebox.

• Review proper placement of logs, ember material and/

or other decorative materials.

• Check the wiring.

• Check the air shutter adjustment.

• Ensure that there are no gas leaks.

• Ensurethat theglass issealed andin theproper position

and that the integral barrier is in place.

WARNING! Risk of Fire or Asphyxiation! DO NOT op-

erate ﬁreplace with ﬁxed glass assembly removed.

D. Decorative Doors and Fronts

WARNING! Risk of Fire! Install ONLY doors or fronts

approved by Hearth & Home Technologies. Unapproved

doors or fronts may cause ﬁreplace to overheat.

This fireplace has been supplied with an integral

barrier to prevent direct contact with the ﬁxed glass

panel. DO NOT operate the ﬁreplace with the barrier

removed.

Contact your dealer or Hearth & Home Technologies if

the barrier is not present or help is needed to properly

install one.

Formore informationrefer to theinstructions suppliedwith

your decorative door or front.

CLEAR SPACE

3 FT. IN FRONT OF FIREPLACE

Nine Hour Safety Shutdown Feature

The appliance has a safety feature that automatically

shuts down the ﬁreplace after nine hours of

continuous operation without receiving a command

from the wall switch or optional remote.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Heat & Glo Kamin im Innenbereich Handbücher

Heat & Glo

Heat & Glo EM41 Handbuch

Heat & Glo

Heat & Glo MEZZO48-B Bedienungsanleitung

Heat & Glo

Heat & Glo XLR-N-AU Bedienungsanleitung

Heat & Glo

Heat & Glo 6000PLUS Bedienungsanleitung

Heat & Glo

Heat & Glo 6KX-CU Bedienungsanleitung

Heat & Glo

Heat & Glo MEZZO-1000-AU Bedienungsanleitung

Heat & Glo

Heat & Glo Wood Burning Fireplace HST-48D Bedienungsanleitung

Heat & Glo

Heat & Glo Cosmo SLR Bedienungsanleitung

Heat & Glo

Heat & Glo 8000TV-OAK Bedienungsanleitung

Heat & Glo

Heat & Glo I25X-N-AU Bedienungsanleitung

Heat & Glo

Heat & Glo PRIMO-II-48 Bedienungsanleitung

Heat & Glo

Heat & Glo NORTHSTAR-BK Bedienungsanleitung

Heat & Glo

Heat & Glo SL-550TR-E Bedienungsanleitung

Heat & Glo

Heat & Glo 8000TR-OAK Bedienungsanleitung

Heat & Glo

Heat & Glo MONTANA-42C Bedienungsanleitung

Heat & Glo

Heat & Glo Wood Burning Fireplace HST-48D Bedienungsanleitung

Heat & Glo

Heat & Glo Soho24 Bedienungsanleitung

Heat & Glo

Heat & Glo Crescent II Bedienungsanleitung

Heat & Glo

Heat & Glo NORTHSTAR-BK Bedienungsanleitung

Heat & Glo

Heat & Glo FB-GRAND-S Bedienungsanleitung

Heat & Glo

Heat & Glo NORTHSTAR-BK Bedienungsanleitung

Heat & Glo

Heat & Glo 6000GCF-IPI Bedienungsanleitung

Heat & Glo

Heat & Glo RED60 Bedienungsanleitung

Heat & Glo

Heat & Glo PALOMA-BL Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch