Heatilator BIR50-B Bedienungsanleitung

Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

WOODBURNING FIREPLACE

Fire Risk.

WARNING

For use with solid wood fuel only.

Other fuels may overre and generate poisonous

gases (i.e. carbon monoxide).

Model(s):

Installation Manual

Installation and Fireplace Setup

WARNING

HOT SURFACES!

Glass and other surfaces are hot during

operation AND cool down.

Hot glass will cause burns.

• DO NOT touch glass until it is cooled

• NEVERallowchildrentotouchglass

• Keepchildrenaway

• CAREFULLY SUPERVISE children in same room as

replace.

• Alertchildrenandadultstohazardsofhightemperatures.

High temperatures may ignite clothing or other ammable

materials.

• Keep clothing, furniture, draperies and other ammable

materialsaway.

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

BIR50-B

NOTICE: DO NOT discard this manual!

• DO NOTstoreorusegasolineorotheram-

mablevaporsandliquidsinthevicinityofthis

oranyotherappliance.

• DO NOToverre.Overringwillvoidyour

warranty.

• Complywithallminimumclearancestocom-

bustiblesasspecied.Failuretocomplymay

causehousere.

WARNING: If the information in these

instructions is not followed exactly, a re

or explosion may result causing property

damage, personal injury, or death.

Installation and service of this

appliance should be performed by

qualiedpersonnel.Hearth&Home

Technologies recommends HHT

Factory Trained or NFI certified

professionals.

2Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

Safety Alert Key:

• DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury.

• WARNING!Indicatesahazardoussituationwhich,ifnotavoidedcouldresultindeathorseriousinjury.

• CAUTION! Indicatesahazardoussituationwhich,ifnotavoided,couldresultinminorormoderateinjury.

• NOTICE:Indicatespracticeswhichmaycausedamagetothereplaceortoproperty.

Table of Contents

1 Product Specic & Important Safety Information

A.ApplianceCertication 4

B.Non-CombustibleMaterials 4

C.CombustibleMaterials 4

2 Getting Started

A.TypicalFireplaceSystem 5

B.DesignandInstallationConsiderations 6

1.SelectingFireplaceLocations 6

2.LocatingFireplace&Chimney 7

C.ToolsandSuppliesNeeded 8

D.InspectFireplaceandComponents 8

E.FireplaceSystemRequirements 8

3 Framing and Clearances

A.FireplaceDimensions 9

B.Clearances 10

MinimumClearancestoCombustibles 10

C.ConstructtheChase 11

D.FrametheFireplace 12

E.SecureandLeveltheFireplace 13

F. ProtectiveMetalHearthStrips 13

G.OutsideAirKit 14

4 Chimney and Termination Installation

A.ChimneyRequirements 15

B.Clearances 17

C.InstallationNotes 17

D.FrameOpenings 17

E.CutRoofOpening 17

F. InstallFirestop 17

G.AssembleChimneySections 18

H.UsingOffsets/Returns 18

I. OffsetElbowInstallation 19

J. SupplementarySupport&Stabilizer 19

K.InstallAtticInsulationShield 20

L. InstallRoofRadiationShields 20

M.AttachFlashing 20

Field-ConstructedChaseTopFlashing 21

N.FinishTop 22

O.ChimneyTerminationRequirements 23

5 Shrouds

A.ShroudRequirements 24

B.HouseStyleShroud 25

C.Arch/MailboxStyleShroud 26

D.PyramidStyleShroud 26

6 Finishing

A.FinishingMaterial 27

B.HearthExtension,BuildingandFinishing 29

1.FireplaceInstalledFlushontheFloor

 andHearthExtensionRaisedto

 BottomofFireboxOpening 29

2.RaisedHearthExtensionandRaisedFireplace 30

3.FireplaceOpeningandHearthExtensionFlush

 withtheFloor 31

C.Non-CombustibleSealantMaterial 31

D.Sidewalls/Surrounds 32

E.MantelandWallProjections 32

7 Fireplace Setup

A.InstallHearthMoldedBrickPanel 33

B.InstallBackMoldedBrickPanel 33

C.InstallSideMoldedBrickPanel 33

D.InstallScreens 34

E.InstallMortar(Optional) 34

F.Grate 34

G.GasLog/LighterProvision 35

H.WoodBurningInserts 35

8 Reference Materials

A.ChimneyComponents 36

B.OptionalComponents 36

►

Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

Customer:

Lot/Address

Model (circle one): BIR50-B

YES IF NO, WHY?

WARNING! Risk of Fire or Explosion! Failure to install fireplace acording to these instructions can lead to a fire or

explosion.

Verifiedthatthechaseisinsulatedandventilated(Pg.11)

Verifiedclearancestocombustibles.(Pg.10)

Fireplaceisleveledandsecured.(Pg.13)

Hearthextensionsize/heightdecided.(Pg.29)

Outsideairkitinstalled.(Pg.14)

Chimneyconfigurationcomplieswithdiagrams.

Firestopsinstalled.

Roofflashinginstalled.

Chimneyinstalled,lockedandsecuredinplacewithproperclearance.

Terminationsinstalled.

Installer:

Shrouds Section 5 (Pg. 24)

Shroudsproperlyinstalledperinstructions.

Dealer/Distributor Phone #

Serial #:

Chimney Section 4 (Pg. 15)

Fireplace Install

Protectivehearthstripsinstalledpermanualrequirements.(Pg.13)

Attic insulation shield installed.

ATTENTION INSTALLER:

Follow this Standard Work Checklist

Thisstandardworkchecklististobeusedbytheinstallerinconjuctionwith,notinsteadof,theinstructionscontainedinthis installation

manual.

Date Installed:

Location of Fireplace:

4059-704•RevC•4-17-13

Commentscommunicatedtopartyresponsible

Combustiblematerialsnotinstalledinnon-combustibleareas.

Verifiedallclearancesmeetinstallationmanualrequirements.

Mantelsandwallprojectionscomplywithinstallationmanualrequirements.

Allpackagingandprotectivematerialsremoved.

Fireplace Setup Section 7 (Pg. 33)

__________________________by______________________on________

Moldedbrickpanelsinstalledcorrectly.

Optionaldoorsproperlyinstalled.

•Photographingtheinstallationandcopyingthischecklistforyourfile.

•Thatthischecklistremainvisibleatalltimesonthefireplaceuntiltheinstallationiscomplete.

Hearth & Home Technologies recommends the following:

Grateproperlyinstalled

Firescreeninstalledproperly.

(Builder/Gen.Contractor)(Installer)(Date)

Comments:Furtherdescriptionoftheissues,whoisresponsible(Installer/Builder/OtherTrades,etc.)andcorrectiveaction

needed:_________________________________________________________________________________________________

Manualbagandallofitscontentsareremovedfromthefireplaceandgiventotheparty

responsibleforuseandoperation.

________________________________________________________________________________________________________

Hearthextensioninstalledpermanualrequirements.

Finishing Section 6 (Pg. 27)

4Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

WARNING! Risk of Fire! Hearth & Home Technologies

disclaims any responsibility for, and the warranty and

agency listing will be voided by the following actions.

DO NOT:

• installoroperatedamagedreplace

• modifyreplace

• install other than as instructed by Hearth & Home

Technologies

• operate the fireplace without fully assembling all

components

• overre

• installunventedgaslogsets

• installanycomponentnotapprovedbyHearth&Home

Technologies

• installpartsorcomponentsnotListedorapproved

Improper installation, adjustment, alteration, service or

maintenance can cause injury or property damage. For

assistance or additional information, consult a qualied

installer, service agency or your dealer.

B. Non-Combustible Materials

• Materialswhich willnot igniteand burn,composed of

anycombinationofthefollowing:

- Steel - Iron

- Brick - Tile

- Concrete - Slate

- Glass - Plasters

• MaterialsreportedaspassingASTM E 136, Standard

Test Method for Behavior of Metals, in a Vertical Tube

Furnace at 750° C

C. Combustible Materials

• Materialsmadeoforsurfacedwithanyofthefollowing

materials:

- Wood - Compressedpaper

- Plantbers - Plastic

- Plywood/OSB - Sheetrock(drywall)

• Anymaterialthatcanigniteandburn;ameproofedor

not,plasteredorun-plastered

1 Product Specic & Important Safety Information

A. Appliance Certication

Thisreplacesystemhasbeentestedandlistedinac-

cordancewithUL127standardsbyUnderwritersLabo-

ratoriesInc.forinstallationandoperationintheUnited

States.

ThisreplacemaybeinstalledinsleepingroomsEX-

CEPTinmanufacturedhomes.Ifinstalledwithagaslog

set,provisionsfortheNationalFuelGasCodemustbe

met.

Thisreplacehasbeentestedandlistedforusewith

theoptionalcomponentsspeciedinthismanual.These

optionalcomponentsmaybepurchasedseparatelyand

installedatalaterdate.Theoutsideairkitsmustbe

installedatthetimeofreplaceinstallation.

HeatilatorisaregisteredtrademarkofHearth&Home

Technologies.

Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

2 Getting Started

Additional lateral

support for chimney

above roof (or enclosed

in chase) if needed

Ceiling firestop

on floor of attic

Support straps

on rafter supports

chimney (not shown)

Termination cap

Chimney penetrates roof

preferably without affecting

roof rafters

Framing headed off

in ceiling joists

Enclosed space above

and around fireplace

Mantel and surround

Decorative facing

and trim

Hearth extension

Factory-built fireplace

Protective metal

hearth strip(s)

Combustible

framing/header

on top of

V-shaped

standoffs

(spacers)

Chimney system

Attic insulation shield must be used

here to keep insulation away

from chimney if attic is insulated

Attic Shield Collar

Storm Collar

Outside Air

(both sides)

Chase Top Flashing

(4) Roof Radiation Shields

A. Typical Fireplace System

Figure 2.1 Typical Fireplace System

6Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

1/2 in. (13 mm) all

configurations

1-1/2 in. min. air space

from fireplace to

combustible materials.

1/2 in. min. air space at

nailing flanges.

Note:

In an exterior chase

or projecting into a

garage

Across a

corner

As a

room

divider Along a wall

92 in.

(2337 mm)

48 in.

(1219 mm)

MINIMUM

24 in. (610 mm)

from fireplace opening to

any perpendicular wall

)

)))))))))))))))

)

)))))))))))))))

)

))

)

))

)

Model # A B C D E F G

in. 85 7/8 61 7/8 103 1/4 51 5/8 25 1/4 73 28 1/2

mm 2181 1572 2623 1311 641 1854 724

BIR-50

*12 in. (305 mm) extra space

included for each outside air

connection. If outside air duct has

no bend, this dimension may be

reduced as long as minimum

clearances are met.

Figure 2.2 Fireplace Locations

NOTICE:

• Illustrationsandphotosreecttypicalinstallationsand

are FORDESIGNPURPOSESONLY.

• Illustrations/diagramsarenotdrawntoscale.

• Actualinstallation/appearancemayvaryduetoindividual

design preference.

• Hearth&HomeTechnologiesreservestherighttoalter

its products.

NOTICE: In addition to these framing dimensions, also

reference the following section:

• Framing and Clearances (Section 3).

NOTICE:

Aminimum1-1/2in.airclearanceatthebackand

sidesofthereplaceassemblymustbemain-

tained.

Chimneysectionsatanylevelrequirea2in.mini-

mum air space clearance between the framing

and chimney sections.

B. Design and Installation Considerations

NOTICE: Checkbuildingcodespriortoinstallation.

• InstallationMUSTcomplywithlocal,regional,stateand

national codes and regulations.

• Consultinsurancecarrier,localbuildinginspector,re

ofcialsorauthoritieshavingjurisdictionoverrestrictions,

installationinspectionandpermits.

• Before installing,determinethefollowing:

- Wherethereplaceistobeinstalled.

- Theventsystemcongurationtobeused.

- Gassupplypiping.

- Electricalwiring.

- Framingandnishingdetails.

- Whetheroptionalaccessories-devicessuchasa

fan,wallswitchorremotecontrol-aredesired

1. Selecting Fireplace Locations

Thisreplacemaybeusedasaroomdivider,installed

alongawall,acrossacornerorusedinanexteriorchase.

SeeFigure2.2.

Locatingthereplaceinabasementshouldbeavoided.

Locatingnearfrequentlyopeneddoors,centralheat

outletsorreturns,orotherlocationsofconsiderableair

movementcanaffecttheperformance.

Considerationshouldbegiventothesefactorsbefore

deciding on a location.

Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

2. Locating Fireplace & Chimney

Locationofthereplaceandchimneywillaffectperfor-

mance.

• Installwithinthewarmairspaceenclosedbythebuilding

envelope.Thishelpstoproducemoredraft,especially

duringlightinganddie-downofthere.

• Installingthereplaceinabasementisnotrecommended.

• Penetratethehighestpartoftheroof.Thisminimizes

the effects of wind loading.

• Locate termination cap away from trees, adjacent

structures,unevenrooflinesandotherobstructions.

• Minimizetheuseofchimneyoffsets.

• Considerthereplacelocationrelativetooorandceiling

and attic joists.

• Takeintoconsiderationtheterminationrequirementsin

Section4.

Marginal Location:

• Below peak

Location NOT recommended:

• Not the highest point of the roof

• Wind loading possible

Multi-level Roofs

Windward

Leeward

Recommended Location:

• Above peak

Recommended:

• Insulated exterior chase

in cooler climates

Recommended Location:

• Above peak

• Inside heated space

Location NOT recommended:

• Too close to tree

• Below adjacent structure

• Lower roof line

• Avoid outside wall

Marginal Location:

• Wind loading possible

Figure 2.3 Recommended Chimney Locations

• Installtheoutsideairkitwiththeintakefacingprevailing

winds during the heating season.

• Ensure adequate outdoor air for all combustion

appliancesandexhaustequipment.

• Ensurefurnaceandairconditioningreturnventsarenot

locatedintheimmediatevicinityofthereplace.

• Avoidinstallingthereplaceneardoors,walkwaysor

smallisolatedspaces.

• Recessedlightingshouldbea“sealedcan”design.

• Attichatchesweatherstrippedorsealed.

• Atticmountedductworkandairhandlerjointsandseams

taped or sealed.

8Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

C. Tools and Supplies Needed

Beforebeginningtheinstallationbesurethefollowing

toolsandbuildingsuppliesareavailable:

Reciprocatingsaw Framingmaterial

Pliers Non-combustiblesealant

Hammer Gloves

Phillipsscrewdriver Framingsquare

Flatbladescrewdriver Electricdrillandbits

Plumbline Safetyglasses

Level Tapemeasure

1/2-3/4in.length,#6or#8self-drillingscrews

Misc.screwsandnails

D. Inspect Fireplace and Components

WARNING! Risk of Fire and/or Explosion! Damaged

parts could impair safe operation. DO NOT install dam-

aged,incompleteorsubstitutecomponents.Keepre-

place dry.

• Removereplaceandcomponentsfrompackagingand

inspectfordamage.

• Vent system components and doors are shipped in

separatepackages.

• Reporttoyourdealeranypartsdamagedinshipment.

• Read all the instructions before starting the

installation. Follow these instructions carefully

during the installation to ensure maximum safety

and benet.

E. Fireplace System Requirements

TheHeatilatorreplacesystemrequirementsconsistof

the following:

• Fireplace

- Molded brick panels (hearth panel Included with

replace,sideandbackpanelssoldseparately)

- Firescreen(includedwithreplace)

- HearthExtension(soldseparately)

- Grate(includedwithreplace)

• OutsideAirSystem

- AirInletHood(includedwithreplace)

- Flex(required,soldseparately)

• ChimneySystem

- AtticInsulationShield(soldseparately)

- Chimneyterminationcap(soldseparately)

• Non-combustiblenishmaterial

Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

3 Framing and Clearances

A. Fireplace Dimensions

16 1/8 in.

408 mm

Gas Line

Knockout

11 1/8 in.

282 mm

6 7/8 in.

175 mm

5 in.

129 mm

50 in.

1270 mm

60 7/8 in.

1546 mm

3 3/4 in.

97 mm

38 in.

965 mm

54 in.

1372 mm

74 1/8 in.

1883 mm

70 3/4 in.

1797 mm

16 1/8 in.

408 mm

11 1/8 in.

282 mm

6 7/8 in.

175 mm

5 in.

129 mm

45 1/8 in.

1146 mm

11 in.

281 mm

27 1/2 in.

699 mm

74° TYP.

Gas Line

Knockout

22 1/2 in.

572 mm

61 7/8 in.

1572 mm

5 1/2 in.

140 mm

Figure 3.1 Fireplace Dimensions

10 Heatilator • Birmingham BIR50-B Installation Manual • 4059-701 • Rev G • 06/29/15

1/2 in. air space

established by

spacers

Chase Top

Flashing

Roof

Radiation Shield

1/2 in.

Air Space

Spacers furnished with

complete Chase Top Flashing

(May be field-fabricated)

1/2

Storm collar must

be installed 1 in.

off chase top

CHASE TOP CLEARANCES

1 1/2” Ventilation Opening

around Chimney Pipe

(insulation)

0 in. to level

of standoffs

Attic

Insulation Shield

(ceiling)

(roof)

(attic)

(ceiling)

Attic Shield Collar

Ceiling Firestop

Storm Collar

Chase Top Flashing

1-1/2 in. (38 mm)

to back & sides

of appliance

(except at nailing

flanges where it is

1/2 in. [13 mm])

Must have 2 in. (51 mm)

minimum clearance

to any combustible materials

including header

0 in.

to floor

2 in. (51 mm) min.

Shaded areas

represent

2 in. (51 mm) min.

air space clearance

required around pipe

Combustible Object

48 in.

1219 mm

1 in.

B. Clearances

WARNING! Risk of Fire!

You must comply with all minimum air space clearances

tocombustiblesasspeciedinFigure3.2.DO NOTpack

required air spaces with insulation or other materials.

Framing or nishing material used on the front of, or in

frontof,thereplacecloserthantheminimumslistedmust

beconstructedentirelyofnon-combustiblematerials(i.e.,

steel studs, concrete board, etc.). Failure to comply may

causere.

Figure 3.2 Clearances to Combustible Materials

Minimum Clearances to Combustibles

WITHIN ENCLOSURE AREA

Fireplacetobackwall 1-1/2in.(38mm)

Fireplacetosidewall 1-1/2in.(38mm)

Top standoffs to header 0in.(0mm)

Door opening to sidewall 24in.(610mm)

MANTEL

Mantelminimumheight 63-3/4in.(1619mm)

Maximummanteldepth 12in.(305mm)

Andere Handbücher für BIR50-B

Inhaltsverzeichnis

Andere Heatilator Kamin im Innenbereich Handbücher

Heatilator

Heatilator GDFL4136IFT Bedienungsanleitung

Heatilator

Heatilator I80 Sicherheitsleitfaden

Heatilator

Heatilator RAVE42-IFT-B Bedienungsanleitung

Heatilator

Heatilator CD4236IR-C Bedienungsanleitung

Heatilator

Heatilator Wood Burning Fireplace EL36 Series Bedienungsanleitung

Heatilator

Heatilator ADI60 Montageanleitung

Heatilator

Heatilator CRAVE4836-B Bedienungsanleitung

Heatilator

Heatilator HEIR36H-IFT Bedienungsanleitung

Heatilator

Heatilator NEVO4236I Bedienungsanleitung

Heatilator

Heatilator Wood Burning Fireplace ST36D Bedienungsanleitung

Heatilator

Heatilator Novus Plus Handbuch

Heatilator

Heatilator I80 Gebrauchsanweisung

Heatilator

Heatilator Gas Fireplace GBFL4136I Bedienungsanleitung

Heatilator

Heatilator RBV4236IH Bedienungsanleitung

Heatilator

Heatilator CD4236IR-D Bedienungsanleitung

Heatilator

Heatilator Novus NDV3630 Bedienungsanleitung

Heatilator

Heatilator NEVO3630I-B Bedienungsanleitung

Heatilator

Heatilator GDCH60 Series Bedienungsanleitung

Heatilator

Heatilator G112HAE Handbuch

Heatilator

Heatilator Eco-Choice WS18-AU Bedienungsanleitung

Heatilator

Heatilator Aveo ADVT3428 Sicherheitsleitfaden

Heatilator

Heatilator GBI25 Series Handbuch

Heatilator

Heatilator I60 Bedienungsanleitung

Heatilator

Heatilator HR Handbuch

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100I-GD-B Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch