Hestan GIMR15 Kurzanleitung

P/N 011026 rev B

Outdoor Ice Machine

Installation and Instruction

Manual

GIMR15

GIML15

15” OUTDOOR ICE MACHINE RIGHT HINGE

15” OUTDOOR ICE MACHINE LEFT HINGE

WARNING

Only qualied service technicians should install and service the ice machine. To

obtain the name and phone number of your local Hestan Certied Service

Representative, visit www.hestanoutdoor.com. No installation or service should be

undertaken until the technician has thoroughly read this Instruction Manual.

Likewise, the owner/manager should not proceed to operate the ice machine until

the installer has instructed them on its proper operation. Failure to install, operate,

and maintain the ice machine in accordance with this manual will adversely affect

safety, performance, component life, and warranty coverage and may result in

costly water damage. Proper installation is the responsibility of the installer. Product

failure or property damage due to improper installation is not covered under

warranty.

Hestan provides this manual primarily to assist qualied service technicians in the

installation, maintenance, and service of the ice machine.

Should the reader have any questions or concerns which have not been satisfactorily

addressed, please call, send an e-mail message, or write to the Hestan Technical Support

Department for assistance.

Phone: 1-888-905-7463

E-mail: outdoorwarranty@hestan.com

Hestan Commercial

3375 E. La Palma Ave.

Anaheim, CA 92806

Web Site: www.hestanoutdoor.com

NOTE: To expedite assistance, all correspondence/communication MUST include the

following information:

• Model Number

• Serial Number

• Complete and detailed explanation of the problem.

CONTENTS

Important Safety Information ................................................................................................. 4

I. Specications...................................................................................................................... 6

A. Construction.................................................................................................................. 6

B. Electrical Data ............................................................................................................... 7

C. Dimensions/Connections .............................................................................................. 8

1. GIM_15 .................................................................................................................... 8

II. Installation Instructions ...................................................................................................... 9

A. Checks Before Installation............................................................................................. 9

B. Location......................................................................................................................... 9

1. General .................................................................................................................... 9

2. Built-In Installation Site .......................................................................................... 10

C. Setup............................................................................................................................11

D. Electrical Connection ...................................................................................................11

E. Water Supply and Drain Connections ......................................................................... 12

F. Final Checklist.............................................................................................................. 13

III. Operating Instructions..................................................................................................... 14

A. Important Notes About Usage..................................................................................... 14

B. Startup ........................................................................................................................ 14

IV. Maintenance ................................................................................................................... 17

A. Maintenance Schedule................................................................................................ 17

B. Cleaning and Sanitizing Instructions ........................................................................... 18

C. Storage Bin Drain........................................................................................................ 22

D. Condenser................................................................................................................... 23

E. Optional Drain Pump AGDP........................................................................................ 23

V. Preparing the Ice machine for Periods of Non-Use.......................................................... 25

VI. Disposal.......................................................................................................................... 25

IMPORTANT

This manual should be read carefully before the ice machine is installed and

operated. Read the warnings and guidelines contained in this booklet carefully as

they provide essential information for the continued safe use and maintenance

of the ice machine. Retain this booklet for any further reference that may be

necessary.

Important Safety Information

Throughout this manual, notices appear to bring your attention to situations which could

result in death, serious injury, damage to the appliance, or damage to property.

WARNING Indicates a hazardous situation which could result in death or

serious injury.

NOTICE Indicates a situation which could result in damage to the

appliance or property.

IMPORTANT Indicates important information about the installation, use, and

care of the appliance.

WARNING

This ice machine should be destined only to the use for which it has been expressly

conceived. Any other use should be considered improper and therefore dangerous.

The manufacturer cannot be held responsible for injury or damage resulting from

improper, incorrect, and unreasonable use. Failure to install, operate, and maintain the

ice machine in accordance with this manual will adversely affect safety, performance,

component life, and warranty coverage and may result in costly water damage.

To reduce the risk of death, electric shock, serious injury, or re, follow basic

precautions including the following:

• Only qualied service technicians should install and service this ice machine.

• This ice machine must be installed in accordance with applicable national, state, and

local codes and regulations.

• This ice machine requires an independent power supply of proper capacity. See the

nameplate for electrical specications. Failure to use an independent power supply of

proper capacity can result in a tripped breaker, blown fuse, damage to existing wiring,

or component failure. This could lead to heat generation or re.

• THIS ICE MACHINE MUST BE GROUNDED: This ice machine is equipped with

a NEMA5-15 three-prong grounding plug to reduce the risk of potential shock

hazards. It must be plugged into a properly grounded, independent 3-prong wall outlet.

If the outlet is a 2-prong outlet, it is your personal responsibility to have a qualied

electrician replace it with a properly grounded, independent 3-prong wall outlet. Do not

remove the ground prong from the power cord and do not use an adapter plug.

• Do not use an extension cord.

• To reduce the risk of electric shock, make sure the control switch is in the "OFF"

position before plugging in or unplugging the ice machine.

• To reduce the risk of electric shock, do not touch the control switch or plug with damp

hands.

• Do not use an ice machine with a damaged power cord. The power cord should not be

altered, jerked, bundled, weighed down, pinched, or tangled. Such actions could result

in electric shock or re. To unplug the ice machine, be sure to pull the plug, not the

cord, and do not jerk the cord.

• Do not make any alterations to the ice machine. Alterations could result in electric

shock, injury, re, or damage to the ice machine.

WARNING, continued

• This appliance is not intended for use by persons (including children) with reduced

physical, sensory, or mental capabilities, or lack of experience and knowledge, unless

they have been given supervision or instruction concerning use of the appliance by a

person responsible for their safety.

• Children should be properly supervised around this appliance.

• Do not climb, stand, or hang on the ice machine door or allow children or animals to do

so. Serious injury could occur or the ice machine could be damaged.

• Be careful not to pinch ngers when opening and closing the door. Be careful when

opening and closing the door when children are in the area.

• Do not use combustible spray or place volatile or ammable substances near the ice

machine. They might catch re.

• Keep the area around the ice machine clean. Dirt, dust, or insects in the ice machine

could cause harm to individuals or damage to the ice machine.

NOTICE

• Protect the oor when moving the ice machine to prevent damage to the oor.

• Follow the water supply, drain connection, and maintenance instructions carefully to

reduce the risk of costly water damage.

• In areas where water damage is a concern, install in a contained area with a oor drain.

• Install the ice machine in a location that stays above freezing. Normal operating

ambient temperature must be within 45°F to 100°F (7°C to 38°C).

• If using the optional drain pump (AGDP), test its operation every time the ice machine

is cleaned and sanitized. See "IV.E. Optional Drain Pump AGDP" for details. If the

optional drain pump is not operating properly, water could back up and overow,

leading to costly water damage.

• To help ensure that the storage bin drain remains clear, follow the instructions in "IV.C.

Storage Bin Drain" once every 3 months or as often as necessary for conditions. If

the storage bin drain becomes clogged, water could build up in the bin and overow,

leading to costly water damage.

• If water collects in the bin and will not drain, turn off the ice machine and close the

water supply line shut-off valve. Call for service.

• Do not leave the ice machine on during extended periods of non-use, extended

absences, or in sub-freezing temperatures. To properly prepare the ice machine for

these occasions, follow the instructions in "V. Preparing the ice machine for Periods of

Non-Use."

• Keep ventilation openings, in the appliance enclosure or in the built-in structure, clear

of obstruction.

• Do not place objects on top of the ice machine.

• The storage bin is for ice use only. Do not store anything else in the storage bin.

I. Specications

A. Construction

Top Panel

Ice Making

Mechanism

Scoop Holder

Front Panel

Control Switch

Louver

Bin Control

Thermostat

Bulb

Slope

Magnet

Catch

Door

Power Cord

HESTAN ICE MACHINE

MODEL NUMBER GIM_15

SERIAL NUMBER

AC SUPPLY VOLTAGE 115-120/60/1

AMPERES 3.8 AMPS

DESIGN PRESSURE HI-240PSI LO-120PSI

REFRIGERANT 134a 4.2 OZ.

B. Electrical Data

See the nameplate for electrical and refrigeration specications. The nameplate is located

inside the storage bin.

We reserve the right to make changes in specications and design without prior notice.

Note: In the "MODEL NUMBER" the _ references either a (L) Left or (R) Right hinge

model

C. Dimensions/Connections

GIM_15

Units: mm [in.]

II. Installation Instructions

WARNING

• This ice machine must be installed in accordance with applicable national, state,

and local codes and regulations.

• CHOKING HAZARD: Ensure all components, fasteners, and thumbscrews

are securely in place after installation. Make sure that none have fallen into the

storage bin.

A. Checks Before Installation

• Visually inspect the exterior of the shipping container and immediately report any

damage to the carrier. Upon opening the container, any concealed damage should also

be immediately reported to the carrier.

• Remove the shipping carton, tape, and packing material. If any are left in the ice

machine, it will not work properly.

• Remove the package containing the accessories.

• Remove the protective plastic lm from the panels. If the ice machine is exposed to the

sun or to heat, remove the lm after the ice machine cools.

• See the nameplate inside the storage bin, and check that your voltage supplied

corresponds with the voltage specied on the nameplate.

B. Location

1. General

This ice machine is approved for indoor or outdoor use.

NOTICE

• Normal operating ambient temperature must be within 45°F to 100°F (7°C to

38°C); Normal operating water temperature must be within 45°F to 95°F (7°C

to 35°C). Operation of the ice machine, for extended periods, outside of these

normal temperature ranges may affect ice machine performance.

• This ice machine will not work at sub-freezing temperatures. To prevent damage

to the water supply line, drain the ice machine if the air temperature is going to go

below 32°F (0°C). See "V. Preparing the Ice machine for Periods of Non-Use."

For best operating results:

• The ice machine should not be located next to ovens, grills, or other high heat

producing equipment.

• The location must provide a rm foundation for the ice machine.

• This ice machine requires no side or top clearance. But allow enough space at rear for

water supply and drain connections and at least 15" (38 cm) clearance at front.

• The ice machine must be at oor level on a nished oor even if under a cabinet. In

areas where water damage is a concern, install in a contained area with a oor drain.

2. Built-In Installation Site

NOTICE

• Do not let the weight of the counter rest on the ice machine.

• Do not install the ice machine in a corner where the door will interfere with other

equipment or where the ice machine cannot be pulled out for service.

Installation Space

Model Height Width Depth

GIM_15 34" (864 mm) minimum 15" (381 mm) minimum 24" (610 mm) minimum

Min. 34"

(864 mm) Min. 15"

(381 mm)

Between Two Cabinets Between a Cabinet and

the End of a Counter

Support: Do not

let the weight

of the counter

rest on the ice

machine

Min. 23"

(584 mm)

Oven Ice machine

Between a Cabinet and

a Wall or Tall Cabinet

In a Corner

Secure: Do not

let the weight

of the counter

rest on the ice

machine

Min. 15"

(381 mm)

Min. 34"

(864 mm)

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere hestan Eiswürfelbereiter Handbücher

hestan

hestan GIML15 Kurzanleitung

Beliebte Eiswürfelbereiter Handbücher anderer Marken

Hoshizaki

Hoshizaki KMD-460MWJ Bedienungsanleitung

Sub-Zero

Sub-Zero 315I Gebrauchsanweisung

Unold

Unold 48945 Bedienungsanleitung

Kenmore

Kenmore 2217402A Bedienungsanleitung

Cornelius

Cornelius WM600 Betriebsanleitung

GE XPIO43SCSS Bedienungsanleitung

Hoshizaki

Hoshizaki KMD-901MAH Bedienungsanleitung

Whynter

Whynter FIM-450HA Bedienungsanleitung

U-Line

U-Line UMCR014-SC01A Installationshandbuch

Andrew James

Andrew James AJ000522 Bedienungsanleitung

Scotsman

Scotsman CME1356 Bedienungsanleitung

Scotsman

Scotsman ACM 25 Bedienungsanleitung

Kärcher

Kärcher IP 120 Bedienungsanleitung

U-Line

U-Line SS1095 Bedienungsanleitung

Maytag

Maytag MIM1554WRS - Ice Maker Bedienungsanleitung

Hoshizaki

Hoshizaki KM-630MAH Bedienungsanleitung

Princess

Princess Yonanas Bedienungsanleitung

Unold

Unold 48946 Bedienungsanleitung

hestan GIMR15 Kurzanleitung

Beliebte Eiswürfelbereiter Handbücher anderer Marken