Hitachi DV-P2E Bedienungsanleitung

DV-P2E

DVD PLAYER

1. SAFETY INFORMATION ...................................... 2

2. EXPLODED VIEWS AND PARTS LIST................ 3

3. SCHEMATIC DIAGRAM ..................................... 10

4. PCB CONNECTION DIAGRAM.......................... 24

5. PCB PARTS LIST ............................................... 33

6. ADJUSTMENT .................................................... 38

CONTENTS

7. GENERAL INFORMATION ................................ 46

7.1 DISASSEMBLY ........................................... 46

7.2 BLOCK DIAGRAM........................................ 47

8. PANEL FACILITIES AND SPECIFICATIONS.... 48

THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL.

•Refer to the service guide for DV-P2E.

IC information is described in the service guide.

STANDBY

FLOFF

14¡¢ £¥8

DIGITALVIDEO

96kHz

ANGLE

TITLE CHP/TRK REMAINTOTAL

GUI DOLBY

DIGITAL

with

LASTMEMORY

POWER

—OFF_STANDBY/ON

DVD PLAYER

ÛN¿◊<x

ledoM tnemeriuqeRrewoP lanoigeR edocnoitcirtser

E2P-VD V042–022CA 2

LABEL CHECK

IMPORTANT

THIS HITACHI APPARATUS CONTAINS

LASER OF CLASS 1.

SERVICING OPERATION OF THE APPARATUS

SHOULD BE DONE BY A SPECIALLY

INSTRUCTED PERSON.

LASER DIODE CHARACTERISTICS

MAXIMUM OUTPUT POWER : 7 mw

WAVELENGTH : 650 nm

Additional Laser Caution

1.Inside detection switch (S201 on the INSB assy) and loading-

status detection switch (S301 on the LOSB assy) are detected

by the microprocessor (IC501 in the DVDM assy).

• To permit the laser diode to oscillate, it is required to set the

inside detection switch for the inside position (S201 : ON) and to

set the loading-status detection switch for the clamp position (the

center terminal of S301 is shorted to +5V). The laser diode

oscillation will continue if pin 13 of IC101 is shorted to +5V (fault

condition) in the DVDM assy.

In the test mode ∗, the laser diode oscillates when microproces-

sor detects a PLAY signal, or when the PLAYkey is pressed

(S107 ON in the FLKB assy), with the above requirements satis-

fied.

2.When the cover is open, close viewing through the objective lens

with the naked eye will cause exposure to the laser beam.

∗: Refer to page 40.

(Printed on the Rear Panel)

1. SAFETY INFORMATION

This service manual is intended for qualified service technicians ; it is not meant for the casual do-it-

yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained

to properly and safely repair complex products such as those covered by this manual.

Improperly performed repairs can adversely affect the safety and reliability of the product and may

void the warranty. If you are not qualified to perform the repair of this product properly and safely, you

should not risk trying to do so and refer the repair to a qualified service technician.

2.1 PACKING

1 Power Cord PIADG1154

2 Operating Instructions PIVRE1075

(English/French/German/Italian))

3 Caution PIVRR1037

4 Audio Cord (L=1.5m) PIVDE1033

5 Video Cord (L=1.5m) PIVDE1048

NSP 6 Dry Cell Battery (R6P, AA) PIVEM-013

7 Operating Instructions PIVRF1046

(Spanish/Portguese/Dutch/Swedish)

8 Remote Control Unit PIVXX2595

9 Polyethylene Bag PIVHL1046

10 Battery Cover PIVNK3703

11 Protector A PIVHB1060

12 Protector B PIVHB1061

13 Packing Case PIVHG1765

14 Mirror Mat Sheet PIZ23-007

15 Serial Number Label PIRRW-168

(1) PACKING PARTS LIST

Mark No. Description Part No.

2. EXPLODED VIEWS AND PARTS LIST

NOTES: •Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.

•The mark found on some component parts indicates the importance of the safety factor of the part.

Therefore, when replacing, be sure to use parts of identical designation.

•Screws adjacent to mark on the product are used for disassembly.

1 Bonnet Case S PIVXX2539

2 DVD Plate PIVAM1075

3 Tray Panel Plate PIVNK4372

4 Tray Panel PIVNK4158

5 Tray PIVNL1731

6 • • • • •

7 • • • • •

8 Bridge PIVNE2069

9 Clamper Plate PIVNE2068

10 Clamper PIVNL1738

11 Tray Stopper Spring PIVBH1277

(1) EXTERIOR SECTION PARTS LIST

Mark No. Description Part No.

12 Tray Stopper PIVNL1739

13 Tray Label PIVRW1628

14 Screw PIBPZ26P080FZK

15 Screw PIIBZ30P080FMC

16 Screw PIBCZ40P060FNI

17 Screw PIBBZ30P080FMC

18 Caution Label PIVRW1697

19 Power Button Joint PIVNK4179

20 Power Button PIVNK4374

Mark No. Description Part No.

16 18

14 9

234

Refer to

"2.3 FRONT PANEL

SECTION"

13 11 12 Refer to

"2.4 BOTTOM VIEW SECTION"

2.2 EXTERIOR SECTION

2.3 FRONT PANEL SECTION

1 FLKB Assy PIVWG1876

NSP 2 PWSB Assy PIVWG1937

NSP 3 DILB Assy PIVWG1881

4 Front Panel PIVNK4375

5 FL Lens PIVNK4376

6 Name Plate PIVAM1084

7 LED Lens PIPNW2019

8 Main Key PIVNK4373

9 • • • • •

10 PLAY Lens PIRNK2232

(1) FRONT PANEL SECTION PARTS LIST

Mark No. Description Part No.

11 FL Filter PIVEC1643

12 Illumination Lens PIVNK4168

13 Illumination Filter PIVEC2012

14 Illumination Holder PIVNK4098

15 Flexible Cable (14P) PIVDA1646

(FLKB CN101 – DVDM CN105)

16 Screw PIBBZ30P080FMC

Mark No. Description Part No.

478(1/3)

8(2/3)

8(3/3)

116

25 Refer to

"2.5 LOADING MECHANISM ASSY"

2331

21 23

2.4 BOTTOM VIEW SECTION

1 POWER SUPPLY Assy PIVWR1285

2 DVDM Assy PIVWS1371

3 AVJB Assy PIVWV1575

NSP 4 Loading Mechanism Assy PIVWT1147

5 Heat Sink PIVNE2134

NSP 6 Cord Stopper PIZCB-069Z

7 Flexible Cable (12P) PIVDA1648

(LOSB CN301 – DVDM CN107)

8 Radiation Seat PIVEB1282

9 • • • • •

NSP 10 PCB Holder PIVNE2122

11 Housing Assy (14P) PIVKP2161

(POWER SUPPLY CN201 – DVDM CN101)

NSP 12 PCB Holder PIPNW2100

13 Clamp PIDEC2007

14 Shell Clip PIDEC1184

15 Guard PIVNK4100

(1) BOTTOM VIEW SECTION PARTS LIST

Mark No. Description Part No.

NSP 16 Chassis PIVNA1876

17 Insulator PIPNW2766

18 Insulator Assy PIVXA1680

19 Flexible Cable (14P) PIVDA1646

(AVJB CN191 – DVDM CN803)

20 Flexible Cable (17P) PIVDA1650

(AVJB CN901 – DVDM CN802)

21 Rear Panel PIVNA2015

22 Housing Assy (4P) PIVKP2157

(DVDM CN801 – AVJB CN301)

23 Screw PIBBZ30P080FMC

24 Screw PIBBZ30P180FMC

25 Screw PIBBZ30P100FMC

26 • • • • •

27 • • • • •

28 MSWB Assy PIVWG1882

29 SCCB Assy PIVWV1577

30 Flexible Cable (8P) PIVDA1651

(SCCB CN100 – AVJB CN19)

NSP 31 Housing Assy (2P) PIVKP2160

(POWER SUPPLY CN102 – MSWB CN10)

Mark No. Description Part No.

2.5 LOADING MECHANISM ASSY

1 Servo Mechanism Assy-S PIVXX2538

2 Screw PIDBA1006

3 Drive Cam PIVNL1736

4 Drive Gear PIVNL1735

5 Lock Plate PIVNL1737

6 Loading Base PIVNL1730

7 Rubber Belt PIVEB1260

8 Gear Pulley PIVNL1733

NSP 9 LOSB Assy PIVWG1885

10 Loading Gear PIVNL1734

•LOADING MECHANISM ASSY PARTS LIST

Mark No. Description Part No.

11 Loading Motor Assy PIVXX2505

12 DC Motor PIPXM1027

13 Motor Pulley PIPNW1634

NSP 14 LOMB Assy PIVWG1886

15 Connector Assy (2P) PIPG02KK-E35

(LOMB CN401 – LOSB CN303)

16 Screw PIVBA1055

17 Screw PIZ39-019

18 Flexible Cable (8P) PIVDA1649

(LOSB CN302 – INSB CN202)

19 • • • • •

20 Stopper PIDNH2076

Mark No. Description Part No.

12 14

•Top View •Bottom View

Refer to

"2.6 SERVO MECHANISM

ASSY"

14 30

18 18

•Top View •Bottom View

2.6 SERVO MECHANISM ASSY

1 Spindle Motor Assy PIVXX2563

2 Magnet Holder Assy PIVXX2507

NSP 3 Magnet PIVYM1024

NSP 4 Magnet Holder PIVNE2070

5 Centering Ring PIVNL1746

6 Centering Spring PIVBH1278

NSP 7 Disc Table PIVNL1747

NSP 8 Motor PIVXM1071

9 Screw PIJGZ17P028FMC

10 Sub Guide Bar PIVLL1489

11 Guide Bar PIVLL1488

12 Mechanism Base PIVNL1748

13 Hook PIVNL1770

14 Hook Spring PIVBH1291

15 Slider PIVNL1745

16 HOLD SPRING PIVNC1011

NSP 17 Pickup Assy PIVWY1046

•SERVO MECHANISM ASSY PARTS LIST

Mark No. Description Part No.

18 Floating Rubber PIDEB1315

19 Float Base PIVNL1732

20 Gear D PIVNL1766

21 Gear Spring PIVBH1279

22 Gear E PIVNL1767

23 Gear F PIVNL1768

24 Motor PIVXM1062

NSP 25 INSB Assy PIVWG1883

26 Screw PIPBZ20P050FMC

27 Flexible Cable (20P) PIVDA1680

(DVDM CN102 – Pickup Assy)

28 Connector Assy (3P) PIVKP2150

(INSB CN201 – FGSB CN101)

NSP 29 Table Sheet PIDEC2040

30 Screw PIPBA1048

NSP 31 FGSB Assy PIVWG1884

NSP 32 Sheet PIVEC1959

Mark No. Description Part No.

1234

H H

DVDM ASSY

(PIVWS1371 )

DILB ASSY

(PIVWG1881)

1/3 3/3

()

FLKB ASSY

(PIVWG1876)

PWSB ASSY

(PIVWG1937)

AVJB ASSY

(PIVWV1575)

SCCB ASSY

(PIVWV1577)

SR IN

3.1 OVERALL CONNECTION DIAGRAM, LOMB, LOSB, INSB

AND FGSB ASSEMBLIES

3. SCHEMATIC DIAGRAM

Inhaltsverzeichnis

Andere Hitachi DVD-Player Handbücher

Hitachi

Hitachi DV-P788A Bedienungsanleitung

Hitachi

Hitachi PDV302 Bedienungsanleitung

Hitachi

Hitachi PDV343E Bedienungsanleitung

Hitachi

Hitachi DVP325EUK Bedienungsanleitung

Hitachi

Hitachi DV-P325U Bedienungsanleitung

Hitachi

Hitachi DV-P325U Bedienungsanleitung

Hitachi

Hitachi DV-P533U Bedienungsanleitung

Hitachi

Hitachi DV-P250U Bedienungsanleitung

Hitachi

Hitachi DVP335EUK Bedienungsanleitung

Hitachi

Hitachi DV-P745U Bedienungsanleitung

Hitachi

Hitachi DV-P345UK Bedienungsanleitung

Hitachi

Hitachi DVP420UK Bedienungsanleitung

Hitachi

Hitachi DVP305E Bedienungsanleitung

Hitachi

Hitachi DV-P755U Bedienungsanleitung

Hitachi

Hitachi DV-P705U Bedienungsanleitung

Hitachi

Hitachi DV-P725U Bedienungsanleitung

Hitachi

Hitachi DVPF2E Bedienungsanleitung

Hitachi

Hitachi 22LD3750DC Bedienungsanleitung

Hitachi

Hitachi DV-W1U Bedienungsanleitung

Hitachi

Hitachi DV-P788A Bedienungsanleitung

Hitachi

Hitachi VIP9550 Bedienungsanleitung

Hitachi

Hitachi HTD-K185UK Bedienungsanleitung

Hitachi

Hitachi DVP425UK Bedienungsanleitung

Hitachi

Hitachi DV-P745U Bedienungsanleitung

Beliebte DVD-Player Handbücher anderer Marken

Sony

Sony DVP-F11 Bedienungsanleitung

Philips

Philips DVP3560K/F8 Bedienungsanleitung

LENCO

LENCO DVP-740 X2 Bedienungsanleitung

JVC

JVC XV-N650BEU Bedienungsanleitung

Aiwa

Aiwa XD-DV370 Bedienungsanleitung

MedeaWiz

MedeaWiz Sprite 4K DV-S4 Bedienungsanleitung

Denon

Denon DVM-1805 - DVD Changer Bedienungsanleitung

Toshiba

Toshiba SD-3815 Bedienungsanleitung

Tevion

Tevion 44330 Bedienungsanleitung

Samsung

Samsung DVD-HD860 Bedienungsanleitung

Sylvania

Sylvania DP170SL8 Bedienungsanleitung

Toshiba

Toshiba SD-P1200 Bedienungsanleitung

JVC

JVC XV-D9000E Bedienungsanleitung

Dolby Laboratories

Dolby Laboratories CP650 Bedienungsanleitung

Philips

Philips DVD737K/931 Bedienungsanleitung

Denon

Denon DVD-5900 Bedienungsanleitung

Philips

Philips DVD 951 Bedienungsanleitung

Philips

Philips DVDR3460 Bedienungsanleitung