Hotpoint MSZ802DF Bedienungs- und Montageanleitung

Indesit Company UK Ltd

Service

Information

HOTPOINT

SIDE-BY-SIDE

FRIDGE

FREEZERS

(7 ~ Segment Version)

Models Comm.

Covered Code

Energy Band 'A' Models

MSZ801DF 48862

MSZ802DF 46196

MSZ803DF 48863

MSZ806DF 57217

5407399 Issue 2 March 2011

2 of 37

Service Manual UK

Indesit

Company

English

HEALTH AND SAFETY

For the servicing of refrigeration products, containing R134a refrigerant.

These instructions are in addition to any other Company procedures already published.

Published primarily for Indesit Company engineers working in the UK or Southern Ireland, for

which these instructions are MANDATORY.

General

1. This manual is not intended as a comprehensive repair/maintenance guide to the appliance.

2. It should only be used by suitably qualified persons having technical competence, applicable product

knowledge, suitable tools and test equipment.

3. Servicing of electrical appliances must be undertaken with the appliance disconnected. (unplugged

from the electrical supply).

4. Servicing must be preceded by earth continuity and insulation checks.

5. Personal safety precautions must be taken to protect against accidents caused by sharp edges on

metal and plastic parts.

6. After servicing, the appliance must be rechecked for electrical safety.

Refrigerant R134a - Safe Handling - Transporting & Storage

1. Work areas should be well ventilated and any immediate heat sources turned off.

2. Do not smoke where there is a possibility of refrigerant in the atmosphere. Customer/s should also

be advised.

3. Cylinders must not have heat applied, or stand close to a heat source, and should be stored out of

direct sunlight.

4. Should a sudden release of refrigerant occur, open windows or outside doors in the immediate

vicinity, then evacuate for a few minutes.

5. It is illegal to intentionally vent R134a refrigerant to atmosphere. Follow the company procedure on

collection and reclamation.

6. If a leak is identified the appliance must be repaired immediately if possible.

7. Where it is not possible to repair the appliance immediately the customer should be advised:

Appliance should be turned off and the refrigerant recovered.

8. Returned compressors must be sealed to prevent the escape of oil and refrigerant. Refer to the

Environmental responsibilities for service engineers in your Health and Safety booklet.

9. Cylinders (R134a) being transported must be in an upright position on the floor of the vehicle and

prevented from movement.

10. A green compressed gas label Part No. 8100062 should be displayed on the rear of the vehicle.

3 of 37

Indesit Company

Service Manual UK English

CONTENTS

Health & Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Index & Serial Number / Product Identity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 6

Appliance Dimensions & Water Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Detailed View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Control Panel Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 10

Description of Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Component Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 - 13

Temperature Tables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Alarm Conditions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Auto-Test and Fault Conditions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 - 17

Air Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 - 19

Ice-Maker Function and Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Power Module Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 - 22

Servicing & Dismantling Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 - 26

Compressor Connection Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Power Module Edge Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Connector Block Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

Theoretical Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Thermistor Sensor Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

Installation Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 - 36

PRODUCT IDENTITY

Example

705031421

1Industrial Code: 8539 695 15000

2Serial Number:

Printed on a separate label below the Rating Plate

Build number that day, e.g. 1421th built

Day of manufacture, e.g. 03rd of month

Month of manufacture, e.g. May

Year of manufacture, e.g. 2007

4 of 37

Service Manual UK

Indesit

Company

English

MODEL INTRODUCTION

The models included in this publication are 1765 mm high Side by Side no-frost Fridge Freezers that

were introduced in July 2007. All models are similar with regard to the furniture design, but there are

variations for exterior colour.

Models MSZ801DF, MSZ802DF, MSZ803DF and MSZ806DF interior:

The interior of the fridge has safety glass shelves, one meat drawer (chiller) and one humidity

controlled salad bin (crisper) with a glass cover. The door has two deep shelf, dairy shelf with a lid, a

commodity shelf and lower bottle shelf.

The interior of the freezer section has two drawers of varying sizes, two safety glass shelves of varying

sizes and ice cube maker. The door has four commodity shelves of varying sizes.

For banding and colour information, refer to the Front Cover and or Specifications page.

The appliance is “no-frost” design so defrosting is automatic.

All models have wheels at the rear and wheels / adjustable feet at the front.

The digital display interface module (7 ~ segment LED) is mounted in the front of the freezer door with

the drinks dispenser, the fast freeze button and ice maker controls are also mounted in the same area.

The fridge and freezer temperature settings are adjusted by selecting the + / - buttons next to the

relevant temperature display window. All functions are monitored and actioned by the power module

mounted at the rear of the appliance within the compressor compartment.

The climate class is N / ST signifying that it is designed to operate in ambient temperatures between

+16°C to +38°C.

As with many refrigeration appliances, it is important that it is installed and operated within the

recommended ambient temperature range and that there is adequate ventilation.

All appliances equipped with an automatic ice-maker and water dispenser must be connected to a

water supply that only delivers drinking water. See specification page for pressure requirements.

5 of 37

Indesit Company

Service Manual UK English

SPECIFICATIONS

GENERAL:

Manufactured in: Italy

Appliance Type: Side by Side

Static / No- Frost: No-Frost

Door Hinging - Freezer L/H & Fridge R/H

Reversible: No

Plug/Cable: UK / 1.6m

Water Pipe: 1.65m

Noise Level: 'A' band models ~ 45dB

Climate Class: (Rating Plate) N.ST = 16°C to 38°C

Refrigeration Type: No-Frost - Fin On Tube (FOT)

DIMENSIONS & WEIGHT:

Height: 1774 mm

Width: 902 mm

Depth: 752 mm

To allow product handling and sufficient air circulation, leave at least 10 mm clearance at the sides,

above the appliance and between the rear panel and the wall.

Weight Gross: 146 kg

Weight Net: 140 kg

CAPACITIES / VOLUME:

Gross Volume Net Volume

Fridge: 340 litre 335 litre

Freezer: 206 litre 155 litre

Freezing Capacities 24 hrs 12 kg

Conservation Time 5 hours

Introduction Date

Colours June 2007 July 2007 July 2008

Polar White MSZ801DF

Silver MSZ802DF

Stainless Steel MSZ803DF

Black MSZ806DF

Suffix 'DF' = dispenser models

6 of 37

Service Manual UK

Indesit

Company

English

TECHNICAL DATA:

Power Supply Voltage: 220/240 V

Power Supply Frequency: 50 Hz

Mains Water Supply: Min. 1.7 bar

Max. 8.1 bar

Freezer Lamp: E27 40W 220V - 240V

Dispenser Lamp: E14 10W 230 - 240V

Fridge Lamp (Blue Light): T-Click 40W 220V - 240V

ENERGY

Energy Class: A

Power Consumption: 1.39 kWh/24hr

Annual Consumption: 507.3 kWh/yr

COMPRESSOR WINDING

Manufacturer: Embraco

Type I/D: EGYS 90 HLP

Winding Resistance

Start: 21.3 :

Run: 12.3 :

Refrigerant/ Grams: R134a / 160g - Refer to the appliance rating plate

Insulation: C-Pentane

HEATER RESISTANCES

Evaporator Defrost Heater: 8.57 k:

COMPONENT RESISTANCES

Condenser Fan Motor: 4.49k:

Evaporator Fan Motor: 2.35k:

Water Dispenser Solenoid Valve: 8.68k:

Water Ice Maker Solenoid Valve: 8.71k:

7 of 37

Indesit Company

Service Manual UK English

APPLIANCE DIMENSIONS (all measurements are approximate)

WATER FILTER

1. Locate the water filter cartridge cap below the freezer compartment door.

Rotate the cap counter clockwise to a vertical position and pull the cap and filter cartridge out

through the base grille. Note: Since there is water in the cartridge, some spilling may occur.

2. Remove the cartridge cap by sliding it off the end of the old cartridge.

DO NOT DISCARD THE CAP.

3. Take the new cartridge out of its packaging and remove the protective cover from the o-rings.

Make a note of the installation date in the space provided on the new cartridge.

4. Slide the cartridge cap onto the new cartridge.

5. With the cartridge cap in the vertical position, push the new filter cartridge into the base grille until

it stops. Rotate the cartridge cap clockwise to a horizontal position.

6. RUN WATER THROUGH THE DISPENSER UNTIL THE WATER RUNS CLEAR (about 9-14 litres

or 6-7 minutes). This will clean the system and clear air from the lines. Note: As air is cleared from

the system, water may spurt out of the dispenser.

APERTURE MEASUREMENTS PLAN VIEW

(WITH DOORS OPEN 90° AND FULLY)

Cabinet Height = 1760 mm

Cabinet Height with doors = 1765 mm

Depth including door handles: 605 mm + 150 mm = 750 mm

Depth without doors = 605 mm

Depth without handles: 605 mm + 110 mm = 715 mm

8 of 37

Service Manual UK

Indesit

Company

English

DETAILED VIEW

REFRIGERATOR COMPARTMENT

A. Inside light

B*. Inside light (not tted)

C. Adjustable shelf

D. Shelf - drawer lid

E Crisper (Salad Bin)

F. Crisper adjustment (Humidity Control)

G. Meat / vegetable drawer (Chiller)

H. Meat / vegetable drawer adjustment

I. Dairy products compartment

J. Door trays

K. 2-litre door tray with bottle holder

L. 0.75 litre door tray

M. Water lter

FREEZER COMPARTMENT

N. Automatic ice-maker

O. Glass shelves / Racks (depending on the model)

P. Drawer / Bottom basket (depending on the model)

Q. Drawer / Top basket (depending on the model)

R. Ice cube drawer

S. Freezer door trays

T. Inside light

ADNR C

FEHGFMPQ

9 of 37

Indesit Company

Service Manual UK English

CONTROL PANEL INTERFACE

TEMPERATURE CONTROL PANEL

BUTTON DESCRIPTION FUNCTION

A Freezer

temperature

adjust / select

~ This function allows you to adjust the displayed temperature.

To adjust the temperature press the relevant +/-button until the

required freezer temperature is displayed on the left.

B Super freeze ~ This function activates the super freeze (fast freeze) so fresh

food can be frozen. To enable press until the super freeze

symbol appears on the Display. It will automatically disable after

48 hours or when the button is pressed again.

C Stand-by function ~ This function turns off the refrigerator and freezer compartments

to enable press and hold for 3 seconds: the display will go out

and a dash will appear on the left display.

To disable press and hold for 3 seconds: the display will return to

the previous set temperatures.

D Reset ~ This function can be used in the event of an alarm when an

acoustic signal and relevant indicator lights are activated.

To disable the acoustic alarm signal press the reset button.

E Fridge

temperature

adjust / select

~ This function allows you to adjust the displayed temperature.

To adjust the temperature press the relevant +/-button until the

required fridge temperature is displayed on the right.

F Holiday function ~ This function allows the fridge compartment to be deactivated if

the user is going away for sometime, the fridge will maintain

adequate temperature for preventing the formation of odours,

therefore not necessary to switch the appliance off.

B+F Control panel

Lock function

(Child lock)

~ This function locks the fridge and freezer controls.

To lock press and hold both the super freeze and super cool

buttons simultaneously for 3 seconds until the lock symbol

appears in the display and is accompanied by an acoustic signal.

10 of 37

Service Manual UK

Indesit

Company

English

CONTROL PANEL INTERFACE

ICE & DISPENSER CONTROL PANEL

BUTTON DESCRIPTION FUNCTION

G Dispenser light ~This function switches on the dispenser light. To enable / disable

press the button.

H Stand-by function ~ This function turns off the ice maker.

To enable the ice maker press and

hold until the ice or crushed ice

symbol is displayed.

To disable the ice maker press and

hold until the ice or crushed ice symbol is extinguished.

J Ice mode function ~ This function allows you to select between ice cubes or crushed

ice to be dispensed.

K Reset ~ This function resets the water filter

replacement time.

Normally the water filter symbol is Green

(Blue on some models).

= Water Filter OK (Blue on some models)

= Water Filter requires replacing soon.

= Water Filter needs replacing.

L Ice maker lock ~ This function locks the ice maker

and water dispenser controls.

To lock press and hold for 3

seconds until the lock symbol

appears in the display and is

accompanied by an acoustic signal.

To unlock press and hold for 3 seconds until the symbol is

extinguished.

LKJH

Andere Handbücher für MSZ802DF

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Hotpoint Kühlschrank Handbücher

Hotpoint

Hotpoint FFFM 1 Series Bedienungsanleitung

Hotpoint

Hotpoint RLAV21 Series Bedienungsanleitung

Hotpoint

Hotpoint FFM81 Instructions for and use Bedienungsanleitung

Hotpoint

Hotpoint HTN17BBTRWW - 16.6 cu. Ft. Top Freezer... Bedienungsanleitung

Hotpoint

Hotpoint HL161I Bedienungsanleitung

Hotpoint

Hotpoint CSX20 Technisches Datenblatt

Hotpoint

Hotpoint HTS18CBSELWW and Betriebsanleitung

Hotpoint

Hotpoint FF200M Bedienungsanleitung

Hotpoint

Hotpoint RLA80 Bedienungsanleitung

Hotpoint

Hotpoint HM 3x AA F Bedienungsanleitung

Hotpoint

Hotpoint HTS16BCR Bedienungsanleitung

Hotpoint

Hotpoint HM 3x AA Bedienungsanleitung

Hotpoint

Hotpoint ENXTY 19xxx X FW Bedienungsanleitung

Hotpoint

Hotpoint 15 Bedienungsanleitung

Hotpoint

Hotpoint FFUL Series Bedienungsanleitung

Hotpoint

Hotpoint HBT 18I Bedienungsanleitung

Hotpoint

Hotpoint 8217 Bedienungsanleitung

Hotpoint

Hotpoint 22 Series Originalbetriebsanleitung

Hotpoint

Hotpoint ENXTYH 19 FW Series Bedienungsanleitung

Hotpoint

Hotpoint CTX18 Montageanleitung

Hotpoint

Hotpoint HTM16BBR Bedienungsanleitung

Hotpoint

Hotpoint MSZ 900 DF (UK) Bedienungsanleitung

Hotpoint

Hotpoint CTF16E Montageanleitung

Hotpoint

Hotpoint HTR16BBELWW Benutzerhandbuch

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

Sharp

Sharp SJ-BA31IEXW2-EU Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

Stengel

Stengel KU 1101 A++ Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

Amana

Amana ASD2524VES00 Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Samsung

Samsung RF323TE Bedienungsanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

True

True TS-28 Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung