IDEAL CXS 40 Bedienungsanleitung

USER’S

IDEALIDEAL

IDEAL

THETHE

THE

GUIDE

Concord

CXS 40 - 120

User’s guide to commercial central heating boilers

2Concord CXS 40-120 - User's Guide

CONCORD CXS 40 - 90 models only

ALL MODELS

THE GAS SAFETY (INSTALLATION AND

USE) REGULATIONS 1994 impose certain

statutory obligations on gas users. This

appliance must be installed by a Corgi

registered installer.

WARNING.

This appliance MUST be efficiently earthed

1. It is ESSENTIAL that the instructions in this booklet

are strictly followed, for safe, economical operation of

the boiler.

2. Do not obstruct ventilation ducts, grilles or openings in

the boiler room, or the passage of combustion and

ventilation air to the boiler.

3. Do not store objects around or on the boiler, and keep

access clear at all times.

4. Switch off and disconnect the electricity supply before

carrying out maintenance work.

5. Do not turn off the boiler if it is to be left unattended in

frosty weather.

MAINTENANCE

The appliance should be serviced at least once a year by

a CORGI registered installer.

CLEANING

For normal cleaning simply dust with a dry cloth.

To remove stubborn marks and stains use a damp

cloth and mild detergent.

DO NOT use abrasive cleaning materials.

LEGEND

1. Thermostat knob

2. Control box

3. Mains inlet gas cock

4. Overheat thermostat

reset button

5. Boiler on light

6. Lockout light

7. Lockout reset button

8. Overheat light

9. Gas control valve

Knob setting Approx flow Approx flow

setting temp οο

οο

οC temp οο

οο

οF

1 60 140

2 65 149

3 70 158

4 75 167

5 80 176

6 85 185

CAUTION.

To avoid the possibility of injury during the use or cleaning of this

appliance care should be taken when handling edges of sheet steel components.

Concord CXS 40-120 - User's Guide

CONCORD CXS 100 - 120 models only

TO SHUT DOWN THE BOILER

For short periods

Turn the boiler off at the time clock or system controls. Wait 6

min. and then turn the boiler control thermostat knob (1) to

OFF. Note the frost warning below.

For long periods

Turn the boiler off at the time clock or system controls. Wait for

6 min. and then turn the boiler control thermostat knob (1) to

OFF. Note the frost warning below.

TO RELIGHT THE BOILER

After short periods

Switch on the time switch or system controls and turn boiler

thermostat knob (1) to the required setting. The boiler will light

providing the external controls are calling for heat.

After long periods

Follow the lighting instructions above. Refill the system if it has

been drained.

FROST WARNING

If frost is likely, leave the boiler thermostat at position 6 and do

not turn off the gas cock.Tthis will enable the built -in frost

thermostat to protect the boiler. Note that this may not protect

remote parts of the system, in which case a seperate frost

thermostat should be fitted or the system drained and the

boiler shut down for as for long periods.

1. Check that the boiler thermostat knob (1) on the control

box (2) is OFF.

2. Ensure that the mains gas inlet cock (3) is open (groove

in the square head in line with the gas pipe).

3. Press in and release the overheat thermostat button (4).

4. Switch on the electrical supply to the boiler.

5. Ensure that all system controls (time switch, system

controls etc.) are calling for heat.

6. Turn the boiler thermostat knob (1) to position 6.

7. The boiler will light at Low rate and the Boiler-on light (5)

will be illuminated. If it does not light the Lockout light

(6) will be illuminated. Press in and release the Lockout

button (7). The controls will reset and attempt to relight.

8. The burner will remain at Low rate for about 3 minutes

before going to High rate.

9. Check all connections for gas soundness, using leak

detection fluid.

10. Set the boiler thermostat knob and the system controls

to the required settings.

11. Turn off the electrical supply to the boiler.

TO LIGHT THE BOILER

LEGEND

1. Thermostat knob

2. Control box

3. Mains inlet gas cock

4. Overheat thermostat

reset button

5. Boiler on light

6. Lockout light

7. Lockout reset button

8. Overheat light

9. LH Gas control valve

10. RH Gas control valve

Caradon Plumbing Limited, P.O. Box 103, National Ave, Kingston upon Hull, HU5 4JN. Telephone:

01482 492 251 Fax: 01482 448 858. Registration No. London 322 137. Registered Office: National

Avenue, Kingston upon Hull, HU5 4JN. A subsidiary of Caradon plc

Caradon Plumbing Limited pursues a policy of continuing

improvement in the design and performance of its

products. The right is therefore reserved to vary

specification without notice.

Technical Training

The Caradon Plumbing Limited Technical Training Centre

offers a series of first class training courses for domestic,

commercial and industrial heating installers, engineers and

system specifiers.

For details of courses please ring: ........... 01270 413 624 April 2000 154 871 A01

Ideal Installer/Technical Helpline: 01482 498376

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere IDEAL Kessel Handbücher

IDEAL

IDEAL he24 Bedienungsanleitung

IDEAL

IDEAL LOGIC+ Combi 24 Bedienungsanleitung

IDEAL

IDEAL Vogue Combi c26 Bedienungsanleitung

IDEAL

IDEAL IMAX XTRA E320 Bedienungsanleitung

IDEAL

IDEAL LOGIC+ SYSTEM2 S15 Benutzerhandbuch

IDEAL

IDEAL classic HE15P Bedienungsanleitung

IDEAL

IDEAL MINI C28 Bedienungsanleitung

IDEAL

IDEAL HE12 Bedienungsanleitung

IDEAL

IDEAL ES24 Bedienungsanleitung

IDEAL

IDEAL RS 50 Montageanleitung

IDEAL

IDEAL Viceroy GT Series Leitfaden

IDEAL

IDEAL LOGIC Combi E 35 Bedienungsanleitung

IDEAL

IDEAL Falcon GTS 4 Bedienungsanleitung

IDEAL

IDEAL EXALT Solo 110 Bedienungsanleitung

IDEAL

IDEAL he15 Bedienungsanleitung

IDEAL

IDEAL IMAX XTRA E80 Bedienungsanleitung

IDEAL

IDEAL Classic LX RS 230 Versionshinweis

IDEAL

IDEAL istor HE260 Bedienungsanleitung

IDEAL

IDEAL Concord CXSi 110 Beilage

IDEAL

IDEAL Henrad SEC 80FF Benutzerhandbuch

IDEAL

IDEAL HE9 Bedienungsanleitung

IDEAL

IDEAL independent 15 Bedienungsanleitung

IDEAL

IDEAL EVO S 50 Bedienungsanleitung

IDEAL

IDEAL classic FF 250 Bedienungsanleitung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung