IEI Technology DRPC-240-TGL Bedienungsanleitung

DRPC-240-TGL Embedded System

Page i

User Manual

Rev. 1.00 –2022-01-18

MODEL:

DRPC-240-TGL

Embedded System with Intel® Core™ i5-1145G7E or Celeron® 6035U

CPU，8 GB DDR4 SO-DIMM, M.2 Slot, PCIe x4 Slot, RS-232,

RS-422/485, HDMI, DP++ and RoHS

DRPC-240-TGL Embedded System

Page ii

Revision

Date

Version

Change

2022-01-18

1.00

Initial Release

DRPC-240-TGL Embedded System

Page iii

The information in this document is subject to change without prior notice in order to

improve reliability, design and function and does not represent a commitment on the part

of the manufacturer.

In no event will the manufacturer be liable for direct, indirect, special, incidental, or

consequential damages arising out of the use or inability to use the product or

documentation, even if advised of the possibility of such damages.

This document contains proprietary information protected by copyright. All rights are

reserved. No part of this manual may be reproduced by any mechanical, electronic, or other

means in any form without prior written permission of the manufacturer.

TRADEMARKS

All registered trademarks and product names mentioned herein are used for identification

purposes only and may be trademarks and/or registered trademarks of their respective

owners.

DRPC-240-TGL Embedded System

Page iv

Manual Conventions

WARNING

Warnings appear where overlooked details may cause damage to the

equipment or result in personal injury. Warnings should be taken

seriously.

CAUTION

Cautionary messages should be heeded to help reduce the chance of

losing data or damaging the product.

NOTE

These messages inform the reader of essential but non-critical

information. These messages should be read carefully as any directions

or instructions contained therein can help avoid making mistakes.

HOT SURFACE

This symbol indicates a hot surface that should not be touched without

taking care.

 
 
DRPC-240-TGL Embedded System 
Page v 
Table of Content 
1 INTRODUCTION.......................................................................................................... 1
1.1 OVERVIEW.................................................................................................................. 2
1.2 FEATURES................................................................................................................... 2
1.3 MODEL VARIATIONS .................................................................................................. 3
1.4 TECHNICAL SPECIFICATIONS ...................................................................................... 4
1.5 FRONT PANEL............................................................................................................. 6
1.6 REAR PANEL .............................................................................................................. 6
1.7 RIGHT SIDE PANEL..................................................................................................... 7
1.8 DIMENSIONS............................................................................................................... 8
2 UNPACKING ................................................................................................................. 9
2.1 UNPACKING.............................................................................................................. 10 
2.2 PACKING LIST .......................................................................................................... 10 
3 INSTALLATION ......................................................................................................... 12 
3.1 ANTI-STATIC PRECAUTIONS...................................................................................... 13 
3.2 INSTALLATION PRECAUTIONS ................................................................................... 13 
3.3 EXTERNAL DEVICE CONNECTION............................................................................. 14 
 HDMI Display Device Connection .................................................................. 14 
 Ethernet
 
Connection ....................................................................................... 14 
 USB Device Connection................................................................................... 15 
 DB-9 RS-232/422/485 Serial Port Connection................................................ 16 
 ATX/AT Mode Selection ................................................................................... 17 
3.4 HDD INSTALLATION................................................................................................. 17 
4 SYSTEM MOTHERBOARD ..................................................................................... 18 
4.1 OVREVIEW ............................................................................................................... 19 
 Layout .............................................................................................................. 19 
4.2 INTERNAL PERIPHERAL CONNECTORS ...................................................................... 20 
 SATA Connector (SATA1)................................................................................. 21 
 SIM Card Slot (SIM1) ...................................................................................... 21 

 
 
DRPC-240-TGL Embedded System 
Page vi 
 M.2 A-Key Card Slot (M2_A1)......................................................................... 22 
 M.2 B-Key Card Slot (M2_B1) ........................................................................ 23 
 CPU Fan Connector ........................................................................................ 25 
4.3 EXTERNAL PERIPHERAL CONNECTORS ..................................................................... 25 
 HDMI Connector (HDMI1) ............................................................................. 26 
 DP Connector (DP1) ....................................................................................... 26 
 USB 3.2 Gen 2 Connectors (USB2_CON1)..................................................... 27 
 USB 2.0 Connectors (USB1)............................................................................ 27 
 RS-232 Connectors (COM1/2)......................................................................... 28 
 RS-422/485 Serial Port Connectors (COM3/4)............................................... 29 
 Remote Power Connector (PW_BTN1) ........................................................... 29 
 Dual LAN Connectors (PLAN1, PLAN2)......................................................... 29 
 Power Input Connector (PWR1)...................................................................... 30 
 System Fan Connector ................................................................................... 30 
A SAFETY PRECAUTIONS ......................................................................................... 31 
A.1 SAFETY PRECAUTIONS ............................................................................................ 32 
A.1.1 General Safety Precautions............................................................................. 32 
A.1.2 Anti-static Precautions .................................................................................... 33 
A.1.3 Product Disposal ............................................................................................. 34 
A.2 MAINTENANCE AND CLEANING PRECAUTIONS........................................................ 35 
A.2.1 Maintenance and Cleaning.............................................................................. 35 
A.2.2 Cleaning Tools................................................................................................. 35 
B REGULATORY COMPLIANCE .............................................................................. 36 
C HAZARDOUS MATERIALS DISCLOSURE ......................................................... 41 
 

DRPC-240-TGL Embedded System

Page vii

List of Figures

Figure 1-1: DRPC-240-TGL ............................................................................................................2

Figure 1-2: DRPC-240-TGL Front Panel........................................................................................6

Figure 1-3: DRPC-240-TGL Rear Panel.........................................................................................7

Figure 1-4: DRPC-240-TGL Right Side Panel...............................................................................7

Figure 1-5: DRPC-240-TGL Dimensions.......................................................................................8

Figure 3-1: LAN Connection........................................................................................................15

Figure 3-2: USB Connection........................................................................................................16

Figure 3-3: Serial Device Connection.........................................................................................16

Figure 3-4: ATX/AT Mode Selection............................................................................................17

Figure 4-1: System Motherboard (Front)....................................................................................19

Figure 4-2: System Motherboard (Rear).....................................................................................20

Figure 4-3:SATA Connector ........................................................................................................21

Figure 4-4: SIM Card Slot (SIM1).................................................................................................22

Figure 4-5: HDMI Connector........................................................................................................26

Figure 4-6: DP Connector............................................................................................................27

Figure 4-7: USB 2.0 Connector....................................................................................................28

Figure 4-8: RS-232 Connector.....................................................................................................28

Figure 4-9: RJ-45 Connector .......................................................................................................30

DRPC-240-TGL Embedded System

Page viii

List of Tables

Table 1-1: Model Description.........................................................................................................3

Table 1-2: Technical Specifications..............................................................................................5

Table 2-1: Packing List.................................................................................................................11

Table 4-1: Internal Peripheral Connectors.................................................................................20

Table 4-2: SATA Connector Pinoouts (SATA1) .........................................................................21

Table 4-3: SIM Card Slot Pinouts (SIM1) ....................................................................................21

Table 4-4: M.2 A-Key Card Slot Pinouts (M2_A1)......................................................................23

Table 4-5: M.2 B-Key Slot Pinouts (M2_B1) ...............................................................................24

Table 4-6: CPU Fan Connector Pinouts (CPU/FAN1)................................................................25

Table 4-7: HDMI Connector Pinouts (HDMI1).............................................................................26

Table 4-8: DP Connector Pinouts (DP1).....................................................................................26

Table 4-9: USB 3.2 Gen 2 Connector Pinouts (USB2_CON1)...................................................27

Table 4-10: USB 2.0 Connector Pinouts (USB1)........................................................................27

Table 4-11: RS-232 Connector Pinouts (COM1, COM2)............................................................28

Table 4-12: RS-422/485 Serial Port Connector Pinouts (COM3, COM4)..................................29

Table 4-13: Remote Power Connector (PW_BTN1)...................................................................29

Table 4-14: LAN Connector Pinouts (PLAN1, PLAN2)..............................................................29

Table 4-15: Power Input Connector Pinouts (PWR1)................................................................30

Table 4-16: System Fan Connector Pinouts (FAN1) .................................................................30

DRPC-240-TGL Embedded System

Page 1

Chapter

1Introduction

DRPC-240-TGL Embedded System

Page 2

1.1 Overview

Figure 1-1: DRPC-240-TGL

The DRPC-240-TGL is an embedded system pre-installed with Intel® Core™ i5-1145G7E

or Celeron® 6305 processor and 8GB DDR4 SO-DIMM memory. It is designed for harsh

environment applications, and supports DIN rail mounting method.

The DRPC-240-TGL accepts a wide range of DC power input (12 V ~ 28 V), allowing it to

be powered anywhere. It is equipped with two USB 3.2 Gen 2 (10Gb/s), two USB 2.0, four

2.5GbE, two RS-232 ports, two RS-422/485 ports, one HDMI and one DisplayPort++ to

provide rich I/O options for various applications.

Furthermore, the DRPC-240-TGL also has a PCIe x4 slot to support IEI's accelerator

cards - Mustang-V100-MX8 or Mustang-V100-MX4.

1.2 Features

The DRPC-240-TGL features are listed below:

Pre-installed Intel® Core™ i5-1145G7E or Intel® Celeron® 6305 CPU

8GB DDR4 SO-DIMM memory

1 x 2.5" SATA 6Gb/s HDD/SSD bay

2 x USB 3.2 Gen 2 (10Gb/s) port

2 x USB 2.0 port

Andere Handbücher für DRPC-240-TGL

Inhaltsverzeichnis

Andere IEI Technology Hauptplatine Handbücher

IEI Technology

IEI Technology NANO-PV-D4251-R10 Bedienungsanleitung

IEI Technology

IEI Technology IMBA-C2360-i2 Bedienungsanleitung

IEI Technology

IEI Technology IMBA-C2460 Bedienungsanleitung

IEI Technology

IEI Technology KINO-G45A Bedienungsanleitung

IEI Technology

IEI Technology IMBA-C2260-i2 Bedienungsanleitung

IEI Technology

IEI Technology PM-PV-D4251 Bedienungsanleitung

IEI Technology

IEI Technology NANO-LX2 Bedienungsanleitung

IEI Technology

IEI Technology IMB-C2060 Bedienungsanleitung

IEI Technology

IEI Technology KINO-6612LVDS Bedienungsanleitung

IEI Technology

IEI Technology tKINO-AL-N2-R10 Bedienungsanleitung

IEI Technology

IEI Technology NANO-8522 Bedienungsanleitung

IEI Technology

IEI Technology IMBA-H110 Bedienungsanleitung

IEI Technology

IEI Technology NANO-945GSE2 Bedienungsanleitung

IEI Technology

IEI Technology KINO-945GSE2 Bedienungsanleitung

IEI Technology

IEI Technology IMBA-690AM2 Bedienungsanleitung

IEI Technology

IEI Technology IMBA-XQ354-R11 Bedienungsanleitung

IEI Technology

IEI Technology IMBA-X9654 Bedienungsanleitung

IEI Technology

IEI Technology NOVA-GM45A Bedienungsanleitung

IEI Technology

IEI Technology Kino-9654G4 Bedienungsanleitung

IEI Technology

IEI Technology KINO-9455 Bedienungsanleitung

IEI Technology

IEI Technology KINO-AA750-i2 Bedienungsanleitung

IEI Technology

IEI Technology IMBA-C604EP Bedienungsanleitung

IEI Technology

IEI Technology KINO-GM45A Bedienungsanleitung

IEI Technology

IEI Technology SAGP-648E Bedienungsanleitung

Beliebte Hauptplatine Handbücher anderer Marken

DFI

DFI SD170 Bedienungsanleitung

ASROCK

ASROCK ROMED8-2T Bedienungsanleitung

Asus

Asus P2L97A Bedienungsanleitung

Winmate

Winmate IC70 Bedienungsanleitung

Asus

Asus MES-B Bedienungsanleitung

Grantech

Grantech SYS8F377VGGA-3OMN Bedienungsanleitung

Telit Wireless Solutions

Telit Wireless Solutions SL869-3DR Bedienungsanleitung

Texas Instruments

Texas Instruments ADS8372EVM Bedienungsanleitung

Commell

Commell MS-C73 Bedienungsanleitung

Gigabyte

Gigabyte GA-9IVDT Bedienungsanleitung

IBT Technologies

IBT Technologies MB860 Bedienungsanleitung

Nvidia

Nvidia TEGRA DG-04927-001_V01 Bedienungsanleitung

Intel

Intel D33217CK Bedienungsanleitung

Asus

Asus F1A55-M LX PLUS R2.0 Bedienungsanleitung

EPC

EPC EPC9147C Bedienungsanleitung

Asus

Asus EX-B760M-V5 D4 Bedienungsanleitung

EPOX

EPOX MU-8KHA0010 Bedienungsanleitung

Ski-Doo

Ski-Doo Bombardier MPEM 219 700 090 Bedienungsanleitung