IEI Technology WAFER-CV-D25501 Bedienungsanleitung

WAFER-CV-D25501/N26001 3.5" SBC

Page i

User Manual

3.5" SBC with Intel® Atom™ D2550/N2600 Processor,

DDR3, VGA/Dual LVDS, Dual PCIe GbE, USB 2.0,

PCIe Mini, SATA 3Gb/s, Audio and RoHS

MODEL:

WAFER-CV-D25501/N26001

Rev. 1.05 – October 26, 2017

WAFER-CV-D25501/N26001 3.5" SBC

Page ii

Revision

Date Version Changes

October 26, 2017 1.05 Modified

Figure 3-22: RJ-45 Ethernet Connector

August 27, 2015 1.04 Updated Section

1.4: Dimensions

Updated Section 4.5: Chassis Installation

December 11, 2012 1.03 Added CN6 connector information

23 November, 2012 1.02 Updated the note for the Intel® GMA driver limitation

13 August, 2012 1.01 Added a note for the Intel® GMA driver limitation

26 June, 2012 1.00 Initial release

WAFER-CV-D25501/N26001 3.5" SBC

Page iii

The information in this document is subject to change without prior notice in order to

improve reliability, design and function and does not represent a commitment on the part

of the manufacturer.

In no event will the manufacturer be liable for direct, indirect, special, incidental, or

consequential damages arising out of the use or inability to use the product or

documentation, even if advised of the possibility of such damages.

This document contains proprietary information protected by copyright. All rights are

reserved. No part of this manual may be reproduced by any mechanical, electronic, or

other means in any form without prior written permission of the manufacturer.

TRADEMARKS

All registered trademarks and product names mentioned herein are used for identification

purposes only and may be trademarks and/or registered trademarks of their respective

owners.

WAFER-CV-D25501/N26001 3.5" SBC

Page iv

Manual Conventions

WARNING

Warnings appear where overlooked details may cause damage to the

equipment or result in personal injury. Warnings should be taken

seriously.

CAUTION

Cautionary messages should be heeded to help reduce the chance of

losing data or damaging the product.

NOTE

These messages inform the reader of essential but non-critical

information. These messages should be read carefully as any directions

or instructions contained therein can help avoid making mistakes.

HOT SURFACE

This symbol indicates a hot surface that should not be touched without

taking care.

WAFER-CV-D25501/N26001 3.5" SBC

Page v

Table of Contents

1 INTRODUCTION.......................................................................................................... 1

1.1 INTRODUCTION........................................................................................................... 2

1.2 MODEL VARIATIONS ................................................................................................... 2

1.3 CONNECTORS ............................................................................................................. 3

1.4 DIMENSIONS............................................................................................................... 4

1.5 DATA FLOW................................................................................................................ 6

1.6 TECHNICAL SPECIFICATIONS ...................................................................................... 7

2 PACKING LIST............................................................................................................. 9

2.1ANTI-STATIC PRECAUTIONS...................................................................................... 10

2.2 UNPACKING PRECAUTIONS....................................................................................... 10

2.3 PACKING LIST............................................................................................................11

2.4 OPTIONAL ITEMS...................................................................................................... 12

3 CONNECTORS ........................................................................................................... 13

3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 14

3.1.1 WAFER-CV-D25501/N26001 Layout .............................................................. 14

3.1.2 Peripheral Interface Connectors ..................................................................... 15

3.1.3 External Interface Panel Connectors............................................................... 16

3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 16

3.2.1 5 V SATA Power Connectors............................................................................ 16

3.2.2 12 V Power Connector..................................................................................... 17

3.2.3 Audio Connector .............................................................................................. 17

3.2.4 Backlight Inverter Connectors......................................................................... 18

3.2.5 Battery Connector............................................................................................ 19

3.2.6 Digital Input/Output (DIO) Connector............................................................ 20

3.2.7 Fan Connectors................................................................................................ 21

3.2.8 Keyboard/Mouse Connector ............................................................................ 22

3.2.9 LVDS1 Connector ............................................................................................ 23

3.2.10 LVDS2 Connector .......................................................................................... 24

WAFER-CV-D25501/N26001 3.5" SBC

Page vi

3.2.11 LVDS2 Backlight Control Connector............................................................. 26

3.2.12 PCIe Mini Card Slots..................................................................................... 26

3.2.13 Power & HDD LED Connector..................................................................... 28

3.2.14 Power Button Connector................................................................................ 29

3.2.15 Reset Button Connector ................................................................................. 30

3.2.16 RS-232 Serial Port Connectors...................................................................... 30

3.2.17 RS-422/485 Serial Port Connector................................................................ 31

3.2.18 SATA Drive Connectors ................................................................................. 32

3.2.19 USB Connectors............................................................................................. 33

3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 34

3.3.1 Ethernet Connectors ........................................................................................ 34

3.3.2 Serial Port Connector (COM1) ....................................................................... 35

3.3.3 USB Connectors............................................................................................... 36

3.3.4 VGA Connector................................................................................................ 36

4 INSTALLATION ......................................................................................................... 38

4.1ANTI-STATIC PRECAUTIONS...................................................................................... 39

4.2 INSTALLATION CONSIDERATIONS.............................................................................. 39

4.3 SO-DIMM INSTALLATION ....................................................................................... 41

4.4 JUMPER SETTINGS .................................................................................................... 42

4.4.1 AT/ATX Power Selection Jumper..................................................................... 42

4.4.2 Clear CMOS Jumper........................................................................................ 43

4.4.3 LVDS1 Voltage Selection.................................................................................. 44

4.4.4 LVDS2 Voltage Selection.................................................................................. 45

4.4.5 LVDS2 Panel Type Selection Jumper............................................................... 46

4.5 CHASSIS INSTALLATION............................................................................................ 47

4.5.1 Heat Sink Enclosure......................................................................................... 47

4.5.2 Motherboard Installation................................................................................. 49

4.6 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 50

4.6.1 Audio Kit Installation....................................................................................... 50

4.6.2 LVDS LCD Installation.................................................................................... 51

4.6.3 Full-size PCIe Mini Card Installation ............................................................. 53

4.6.4 Half-size PCIe Mini Card Installation............................................................. 55

4.6.5 SATA Drive Connection ................................................................................... 56

4.6.6 Single RS-232 Cable........................................................................................ 57

WAFER-CV-D25501/N26001 3.5" SBC

Page vii

4.6.7 Keyboard/Mouse Y-cable Connector ............................................................... 58

5 BIOS.............................................................................................................................. 61

5.1 INTRODUCTION......................................................................................................... 62

5.1.1 Starting Setup................................................................................................... 62

5.1.2 Using Setup...................................................................................................... 62

5.1.3 Getting Help..................................................................................................... 63

5.1.4 Unable to Reboot after Configuration Changes.............................................. 63

5.1.5 BIOS Menu Bar................................................................................................ 63

5.2 MAIN........................................................................................................................ 64

5.3ADVANCED............................................................................................................... 65

5.3.1 ACPI Settings................................................................................................... 65

5.3.2 RTC Wake Settings........................................................................................... 66

5.3.3 CPU Configuration.......................................................................................... 68

5.3.4 IDE Configuration........................................................................................... 69

5.3.5 USB Configuration........................................................................................... 70

5.3.6 F81866 Super IO Configuration...................................................................... 71

5.3.6.1 Serial Port n Configuration....................................................................... 71

5.3.7 F81866 H/W Monitor....................................................................................... 75

5.3.7.1 Smart Fan Mode Configuration................................................................ 76

5.3.8 Serial Port Console Redirection ...................................................................... 77

5.3.9 iEi Feature ....................................................................................................... 80

5.4 CHIPSET ................................................................................................................... 81

5.4.1 Host Bridge Configuration .............................................................................. 81

5.4.1.1 Intel IGD Configuration............................................................................ 82

5.4.2 South Bridge Configuration............................................................................. 84

5.5 BOOT........................................................................................................................ 85

5.6 SECURITY................................................................................................................. 87

5.7 EXIT......................................................................................................................... 87

6 SOFTWARE DRIVERS.............................................................................................. 89

6.1AVAILABLE SOFTWARE DRIVERS .............................................................................. 90

6.2 STARTING THE DRIVER PROGRAM ............................................................................ 90

6.3 CHIPSET DRIVER INSTALLATION............................................................................... 91

6.4 GRAPHICS DRIVER INSTALLATION............................................................................ 95

WAFER-CV-D25501/N26001 3.5" SBC

Page viii

6.5 LAN DRIVER INSTALLATION.................................................................................... 99

6.6AUDIO DRIVER INSTALLATION ............................................................................... 101

A REGULATORY COMPLIANCE............................................................................ 104

B BIOS OPTIONS ........................................................................................................ 106

C TERMINOLOGY ..................................................................................................... 109

D DIGITAL I/O INTERFACE......................................................................................113

D.1 INTRODUCTION.......................................................................................................114

D.2ASSEMBLY LANGUAGE SAMPLE 1...........................................................................115

D.3ASSEMBLY LANGUAGE SAMPLE 2...........................................................................115

E WATCHDOG TIMER................................................................................................116

F HAZARDOUS MATERIALS DISCLOSURE.........................................................119

WAFER-CV-D25501/N26001 3.5" SBC

Page ix

List of Figures

Figure 1-1: WAFER-CV-D25501/N26001 .......................................................................................2

Figure 1-2: Connectors ..................................................................................................................3

Figure 1-3: WAFER-CV-D25501/N26001 Dimensions (mm)........................................................5

Figure 1-4: Data Flow Diagram......................................................................................................6

Figure 3-1: Connectors and Jumpers.........................................................................................14

Figure 3-2: 5 V SATA Power Connector Locations...................................................................16

Figure 3-3: 12 V Power Connector Location..............................................................................17

Figure 3-4: Audio Connector Location.......................................................................................18

Figure 3-5: Backlight Inverter Connector Locations.................................................................19

Figure 3-6: Battery Connector Location.....................................................................................20

Figure 3-7: Digital I/O Connector Location ................................................................................21

Figure 3-8: Fan Connector Locations.........................................................................................22

Figure 3-9: Keyboard/Mouse Connector Location....................................................................23

Figure 3-10: LVDS1 Connector Location ...................................................................................24

Figure 3-11: LVDS2 Connector Location ...................................................................................25

Figure 3-12: LVDS2 Backlight Control Connector Location ....................................................26

Figure 3-13: PCIe Mini Card Slot Locations...............................................................................27

Figure 3-14: Power & HDD LED Connector Location................................................................28

Figure 3-15: Power Button Connector Location........................................................................29

Figure 3-16: Reset Button Connector Location.........................................................................30

Figure 3-17: RS-232 Serial Port Connector Locations..............................................................31

Figure 3-18: RS-422/485 Connector Location............................................................................32

Figure 3-19: SATA Drive Connector Locations .........................................................................32

Figure 3-20: USB Connector Locations......................................................................................33

Figure 3-21: External Peripheral Interface Connector..............................................................34

Figure 3-22: RJ-45 Ethernet Connector......................................................................................35

Figure 3-23: COM1 Pinout Locations..........................................................................................35

Figure 3-24: VGA Connector .......................................................................................................37

Figure 4-1: SO-DIMM Installation................................................................................................41

Figure 4-2: AT/ATX Power Selection Jumper Location............................................................43

WAFER-CV-D25501/N26001 3.5" SBC

Page x

Figure 4-3: Clear CMOS Jumper Location .................................................................................44

Figure 4-4: LVDS1 Voltage Selection Jumper Location ...........................................................45

Figure 4-5: LVDS2 Voltage Selection Jumper Location ...........................................................46

Figure 4-6: LVDS2 Panel Type Selection Switch Location.......................................................47

Figure 4-7: Heat Sink Retention Screws ....................................................................................48

Figure 4-8: Motherboard Installation Example ..........................................................................49

Figure 4-9: Audio Kit Cable Connection.....................................................................................50

Figure 4-10: LVDS Connector......................................................................................................52

Figure 4-11: Backlight Inverter Connection...............................................................................53

Figure 4-12: Remove the Retention Screw for the Full-size PCIe Mini Card..........................54

Figure 4-13: Insert the Full-size PCIe Mini Card into the Socket at an Angle.........................54

Figure 4-14: Secure the Full-size PCIe Mini Card......................................................................55

Figure 4-15: Remove the Retention Screws for the Half-size PCIe Mini Card........................55

Figure 4-16: Insert the Half-size PCIe Mini Card into the Socket at an Angle........................56

Figure 4-17: Secure the Half-size PCIe Mini Card .....................................................................56

Figure 4-18: SATA Drive Cable Connection...............................................................................57

Figure 4-19: Single RS-232 Cable Installation ...........................................................................58

Figure 4-20: Keyboard/mouse Y-cable Connection..................................................................59

Figure 6-1: Chipset Driver Screen...............................................................................................91

Figure 6-2: Chipset Driver Welcome Screen..............................................................................92

Figure 6-3: Chipset Driver License Agreement.........................................................................93

Figure 6-4: Chipset Driver Read Me File ....................................................................................93

Figure 6-5: Chipset Driver Setup Operations ............................................................................94

Figure 6-6: Chipset Driver Installation Finish Screen...............................................................95

Figure 6-7: Graphics Driver Welcome Screen...........................................................................96

Figure 6-8: Graphics Driver License Agreement.......................................................................97

Figure 6-9: Graphics Driver Read Me File..................................................................................97

Figure 6-10: Graphics Driver Setup Operations........................................................................98

Figure 6-11: Graphics Driver Installation Finish Screen ..........................................................98

Figure 6-12: LAN Driver Welcome Screen .................................................................................99

Figure 6-13: LAN Driver Installation ........................................................................................ 100

Figure 6-14: LAN Driver Installation Complete....................................................................... 100

Figure 6-15: Audio Driver Installation File Extraction............................................................ 101

Figure 6-16: Audio Driver Welcome Screen............................................................................ 102

Figure 6-17: Audio Driver Installation...................................................................................... 102

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere IEI Technology Einplatinencomputer Handbücher

IEI Technology

IEI Technology DRPC-230-ULT5 Series Bedienungsanleitung

IEI Technology

IEI Technology PCIE-690S1 Bedienungsanleitung

IEI Technology

IEI Technology PSC-586VGA Bedienungsanleitung

IEI Technology

IEI Technology WSB-9152 Bedienungsanleitung

IEI Technology

IEI Technology WAFER-EHL-J6412 Bedienungsanleitung

IEI Technology

IEI Technology PCIE-Q370 Bedienungsanleitung

IEI Technology

IEI Technology NANO-7240 Bedienungsanleitung

IEI Technology

IEI Technology NANO-QM770-R10 Bedienungsanleitung

IEI Technology

IEI Technology KINO-DAL-N1 Bedienungsanleitung

IEI Technology

IEI Technology KINO-QM770 Bedienungsanleitung

IEI Technology

IEI Technology PM-PV-N4551/D5251 Bedienungsanleitung

IEI Technology

IEI Technology KINO-DBT Series Bedienungsanleitung

IEI Technology

IEI Technology KINO-PV-D5253-D4253 Bedienungsanleitung

IEI Technology

IEI Technology WAFER-945GSE3 Bedienungsanleitung

IEI Technology

IEI Technology NANO-LX2 Bedienungsanleitung

IEI Technology

IEI Technology HYPER-AL series Bedienungsanleitung

IEI Technology

IEI Technology KINO-CV-D25501 Bedienungsanleitung

IEI Technology

IEI Technology NANO-KBN-i1 Bedienungsanleitung

IEI Technology

IEI Technology DRPC-124-EHL Series Bedienungsanleitung

IEI Technology

IEI Technology HPCIE-Q470 Bedienungsanleitung

IEI Technology

IEI Technology AESQ170-969 Bedienungsanleitung

IEI Technology

IEI Technology PSB-810EAV Bedienungsanleitung

IEI Technology

IEI Technology WAFER-ULT-i1 Bedienungsanleitung

IEI Technology

IEI Technology KINO-TGL-U Bedienungsanleitung

Beliebte Einplatinencomputer Handbücher anderer Marken

WIN Enterprises

WIN Enterprises PL-80910 Bedienungsanleitung

AXIOMTEK

AXIOMTEK SBC81206 Series Bedienungsanleitung

Embest

Embest SOM-PH8800 Bedienungsanleitung

SeaLevel

SeaLevel SBC-R9 Bedienungsanleitung

SMART Embedded Computing

SMART Embedded Computing ATCA-8310 Bedienungsanleitung

WinSystems

WinSystems PPM-LX800-G Bedienungsanleitung

GIGAIPC

GIGAIPC QBiX-PPC Series Bedienungsanleitung

OLIMEX

OLIMEX A10S-OLinuXino-MICRO Bedienungsanleitung

Commell

Commell FS-978 Bedienungsanleitung

GIGAIPC

GIGAIPC QBiP-8665A/ Bedienungsanleitung

VersaLogic

VersaLogic Python EBX-11 Bedienungsanleitung

Micro Computer Specialists

Micro Computer Specialists IRV-3702 Bedienungsanleitung

CompuLab

CompuLab SB-A510 Bedienungsanleitung

Boser

Boser HS-7321 Bedienungsanleitung

Premier Farnell

Premier Farnell Embest SBC8530 Bedienungsanleitung

MicroSys Electronics

MicroSys Electronics miriac SBC-LS1043A2 Bedienungsanleitung

Aaeon

Aaeon UP Bedienungsanleitung

Portwell

Portwell WUX Series Bedienungsanleitung