Jacuzzi J-435 Bedienungsanleitung

J-435™

J-445™

EXPORT OWNER’S MANUAL

6530-274EE Rev C

Attention New Spa Owner!

Congratulations on the purchase of your new Jacuzzi® spa! The

following is a list of automated functions performed by your spa. These

functions are listed below in an attempt to suppress any operational

concerns you may have during the rst 24 hours of ownership! Also listed

below are important maintenance recommendations you should observe

on a regular basis to protect your new investment.

Maintain Healthy Spa Water

Always maintain your spa’s water chemistry within the following

parameters:

With CLEARRAY®Without CLEARRAY®

pH 7.4-7.6 7.4-7.6

Free chlorine no less than 1.0 ppm 3.0-4.0 ppm

Free bromine no less than 2.0 ppm 2.0-4.0 ppm

Total Alkalinity 100-150 ppm 100-150 ppm

Calcium Hardness 150-250 ppm 150-250 ppm

IMPORTANT: CLEARRAY® Water Purication System is factory

installed. If the CLEARRAY® system is altered or is not operating

efciently then follow the “without CLEARRAY®” water chemistry

parameters as dened by the Association of Pool and Spa Professionals.

CLEARRAY® requires an annual bulb replacement to properly sanitize

your water.

!TO DECREASE RISK OF INFECTION OR DISEASE! Always

maintain your spa lter as outlined below to ensure healthy spa water.

Refer to pages 49-52 (Sec. 13.0) for additional information.

Required Filter Maintenance

Your new spa is equipped with an advanced water ltration system that

provides unsurpassed water quality! To ensure maximum water quality at

all times, you should clean the skimming lter cartridge every 3 months,

or as necessary. See pages 49-52 (Sec. 13.0) for detailed lter

cartridge cleaning instructions.

Required Water Replacement

!TO DECREASE RISK OF INFECTION OR DISEASE! You

should replace the spa’s water every 3 months. The frequency depends

on a number of variables including frequency of use, number of users

and attention paid to water quality maintenance. You will know it is time

for a change when you cannot control sudsing and/or you can no longer

get the normal feel or sparkle to the water, even though the key water

balance measurements are all within the proper parameters. See pages

57-60 (Sec. 14.0) for additional information.

**** Spa operations and functions subject to change without notice ****

Table of Contents

1.0 Important Spa Owner Information.............................................. 1

2.0 FCC Notice.................................................................................... 1

2.1 Industry Canada (IC) Information .................................................. 1

3.0 Important Safety Instructions for all Spa Owners .................... 2

3.1 Entrapment Risk ............................................................................ 6

3.2 Hyperthermia ................................................................................. 7

3.3 Important safety instructions.......................................................... 8

4.0 Choosing a Location.................................................................... 8

4.1 Outdoor Location ........................................................................... 9

4.2 Indoor Location............................................................................ 10

4.3 Location for the Optional ProLink™ Remote

Monitoring System....................................................................... 11

5.0 General Electrical Safety Instructions ..................................... 12

6.0 Electrical Installation Instructions ........................................... 13

7.0 Power Requirements ................................................................. 17

8.0 Spa Fill Up Procedure................................................................ 18

9.0 Spa Features .............................................................................. 22

9.1 J-445 Spa Features ..................................................................... 22

9.2 J-445 Massage/Waterfall Selector Diagram ................................ 23

9.3 J-445 Air Controls Diagram.......................................................... 24

9.4 J-435 Spa Features ..................................................................... 25

9.5 J-435 Massage/Waterfall Selector Diagram ................................ 26

9.6 J-435 Air Controls Diagram.......................................................... 27

10.0 Registration and Start-up.......................................................... 28

10.1 Start-up Sequence....................................................................... 28

10.2 Register Your New Spa................................................................ 28

10.3 ProTouch™ Control Panel ........................................................... 29

11.0 Operating Instructions............................................................... 31

11.1 ProTouch™ Control Panel ........................................................... 31

11.2 Activating the Jets Pumps ........................................................... 31

11.3 Lights Menu ................................................................................. 31

11.4 Music Menu ................................................................................. 32

11.5 Connecting to the BLUEWAVE 2.0 Wireless Audio System ........ 34

11.6 Audio Settings Menu.................................................................... 34

11.7 CLEARRAY on Demand.............................................................. 35

11.8 Adjusting Jet Flow........................................................................ 35

11.9 Adjusting PowerPro™ MX2 Jets.................................................. 35

11.10 Adjusting RX Jets ........................................................................ 35

11.11 Waterfall Control .......................................................................... 36

11.12 Air Controls.................................................................................. 36

11.13 Selecting the Desired Massage Action ........................................ 36

11.14 Indicator Light .............................................................................. 36

11.15 Exterior Lights (Optional)............................................................. 36

12.0 Programming and Operation Instructions............................... 37

12.1 Programming the Heating Mode.................................................. 38

12.2 EcoMode Filtration....................................................................... 39

12.3 Programming the Primary Filter................................................... 39

12.4 Programming the Secondary Filter.............................................. 41

12.5 Cleanup Cycle ............................................................................. 41

12.6 Blow-Out Cycle............................................................................ 41

12.7 Water Care Programming............................................................ 42

12.8 Optional Wi-Fi Setup (50Hz models only).................................... 44

12.9 Locking the Spa........................................................................... 45

12.10 Programming the Time and Date................................................. 46

12.11 Programming the Language ........................................................ 47

12.12 Units Display................................................................................ 48

12.13 System Information...................................................................... 48

13.0 Spa Maintenance........................................................................ 49

13.1 Cleaning the Filter Cartridges...................................................... 49

13.2 Draining and Relling................................................................... 52

13.3 Cleaning the Spa Interior............................................................. 54

13.4 Pillow Care................................................................................... 55

13.5 Maintaining the Synthetic Cabinet ............................................... 55

13.6 Cleaning the Control Panel.......................................................... 55

13.7 Cover Care and Maintenance...................................................... 55

13.8 Winterizing................................................................................... 56

13.9 Restarting Your Spa in Cold Weather.......................................... 57

14.0 Water Quality Maintenance ....................................................... 57

14.1 pH Control.................................................................................... 58

14.2 Sanitizing ..................................................................................... 58

14.3 Other Additives ............................................................................ 59

14.4 CLEARRAY® (Ultraviolet) Water Purication System ................. 59

14.5 CLEARRAY® Bulb Replacement and Quartz

Tube Maintenance ....................................................................... 60

15.0 Error/Display Messages ............................................................ 62

16.0 Troubleshooting Procedures .................................................... 67

17.0 Circuit Board Wiring Diagrams................................................. 69

17.1 Export 50Hz Wiring Diagram ....................................................... 69

17.2 Dip Switch Settings...................................................................... 70

17.3 Single Service 50Hz Connection ................................................. 71

17.4 Dual Service 50Hz Connection.................................................... 72

17.5 Three Service 50Hz Connection.................................................. 72

J-445/J-435 Export

1.0 Important Spa Owner Information

Your Jacuzzi®spa is constructed to the highest standards and is capable

of providing many years of trouble-free use. However, because heat reten-

tive materials are utilized to insulate the spa for efcient operation, an

uncovered spa surface and wall ttings directly exposed to sunlight and

high temperatures for an extended period are subject to permanent dam-

age or discoloration. Damage caused by exposing the spa to this abuse

is not covered under warranty. We recommend that you always keep the

spa full of water when it is exposed to direct sunlight and that you keep the

Jacuzzi insulating cover in place at all times when the spa is not in use.

Read and carefully follow the requirements for your spa’s support base

found in the Section 4.0 titled, “Choosing a Location” (page 8).

Jacuzzi® Hot Tubs constantly strives to offer the nest hot tubs

available, therefore, modications and enhancements may be made

which affect the specications, illustrations and/or instructions

contained herein.

2.0 FCC Notice

This device complies with part 15 of the FCC Rules. Operation is subject

to the following two conditions: (1) This device may not cause harmful

interference, and (2) this device must accept any interference received,

including interference that may cause undesired operation.

This equipment has been tested and found to comply with the limits for

a Class B Digital Device, pursuant to Part 15 of the FCC Rules. These

limits are designed to provide reasonable protection against harmful

interference in a residential installation. This equipment generates, uses

and can radiate radio frequency energy and, if not installed and used in

accordance with the instructions, may cause harmful interference to radio

communications. However, there is no guarantee that interference will

not occur in a particular installation. If this equipment does cause harmful

interference to radio or television reception, which can be determined by

turning the equipment off and on, the user is encouraged to try to correct

the interference by one or more of the following measures:

1. Rearrange or relocate the receiving antenna;

2. Increase the separation between the equipment and receiver;

3. Connect the equipment into an outlet on a circuit different from the

circuit connected;

4. Consult the dealer or an experienced radio/TV technician for help.

(Changes or modications not expressly approved by the party

responsible for FCC compliance could void the user’s authority to

operate this equipment.)

2.1 Industry Canada (IC) Information

The installer of this radio equipment must ensure that the antenna

is located or pointed such that it does not emit RF eld in excess of

Health Canada limits for the general population; consult Safety Code 6,

obtainable from Health Canada’s website: www.hc-sc.gc.ca.

J-445/J-435 Export

3.0 Important Safety Instructions for all Spa Owners

READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY!

This spa was manufactured to meet the standards and specications

outlined in the “Virginia Graeme Baker Pool and Spa Safety Act” (VGB

Safety Act). When installing and using this spa, basic safety precautions

should always be followed, including:

1. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

• Extreme caution must be exercised to prevent unauthorized access

by children.

• To avoid accidents, ensure that children do not use this spa unless

supervised at all times. Adult supervision is a critical safety factor in

preventing children from drowning.

• Use the straps and clip tie downs to secure the spa cover when not

in use. This will help discourage unsupervised children from entering

the spa. Keep the spa cover secure in high-wind conditions.

• There is no representation that the cover, clip tie-downs, or actual

locks will prevent access to the spa.

2. !DANGER: RISK OF SEVERE INJURY OR DROWNING!

• Keep hair, loose articles of clothing or hanging jewelry away from

suction ttings, rotating jets or other moving components to avoid

entrapment that could lead to drowning or severe injury.

• Never use the spa unless all suction guards, lter, lter lid, or

skimmer assembly are installed to prevent body and/or hair

entrapment.

• Never operate or use the spa if the lter, lter lid, or skimmer

assembly are broken or any part of the skimmer assembly is missing.

Please contact your dealer or nearest service center for service.

• The suction ttings and suction covers in this spa are sized to match

the specic water ow created by the pump(s). If it is necessary to

replace the suction ttings, suction covers or pump(s), be sure that

the ow rates are compatible and are in compliance with the VGB

Safety Act.

• Never replace a suction tting or suction cover with one rated less

than the ow rate marked on the original suction tting. Using

improper suction ttings or suction covers can create a body or hair

suction entrapment hazard that may lead to drowning or severe

injury.

3. !DANGER: RISK OF SEVERE INJURY FROM ELECTRIC

SHOCK OR DEATH FROM ELECTROCUTION!

• Install the spa at least 5 feet (1.5m), from all metal surfaces. As an

alternative, a spa may be installed within 5 feet of metal surfaces

if each metal surface is permanently connected (bonded) by a

minimum No. 8 AWG (8.4 mm²) solid copper conductor attached

to the wire connector on the grounding lug, inside the equipment

compartment on the equipment box.

J-445/J-435 Export

• A grounding wire connector is provided on this unit to connect a

minimum No. 8 AWG (8.4 mm²) solid copper conductor between

this unit and any metal equipment, metal enclosures of electrical

equipment, metal water pipe, or conduit within 5 feet (1.5m) of the

unit.

• Never permit any electrical appliance, such as a light, telephone,

radio, television, etc. within 5 feet (1.5m) of a spa unless such

appliances are built-in by the manufacturer.

• Never bring any electrical appliances into or near the spa.

• Never operate any electrical appliances from inside the spa or when

you are wet.

• The electrical supply for this product must include a suitably rated

switch or circuit breaker to open all ungrounded supply conductors

to comply with Section 422-20 of the National Electrical Code/USA,

ANSI/NFPA 70. The disconnecting means must be readily accessible

and visible to the spa occupant but installed at least 5 feet (1.5m),

from the spa.

• The electrical circuit supplied for the hot tub must include a suitable

ground fault circuit interrupter (GFCI) as required by NEC Article

680-42.

4. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Extreme caution must be exercised to prevent diving or jumping

into the spa or slipping and falling, which could result in

unconsciousness, drowning, or serious injury. Remember that wet

surfaces can be very slippery.

• Never stand, walk or sit on the top railing of the spa.

5. !WARNING: RISK OF HYPERTHERMIA (OVER-HEATING)

CAUSING SEVERE INJURY, BURNS, WELTS OR DEATH!

• Water temperature in excess of 40°C (104°F) may be injurious to

your health.

• Refer to Section 3.2 Hyperthermia for specic causes and symptoms

of this condition.

• The water in the spa should never exceed 40°C (104°F). Water

temperatures between 38°C (100°F) and 40°C (104°F) are

considered safe for a healthy adult.

• Lower water temperatures are recommended for young children

(children are especially sensitive to hot water) and when spa use

may exceed 10 minutes.

• The Consumer Products Safety Commission/USA has stated that the

water temperature in a spa should not exceed 40°C (104°F).

• Always test the spa water temperature before entering the spa.

The user should measure the water temperature with an accurate

thermometer since the tolerance of water temperature-regulating

devices may vary as much as +/- 2°C (5°F).

J-445/J-435 Export

6. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Since excessive water temperatures have a high potential for causing

fetal damage during the early months of pregnancy, if pregnant or

possibly pregnant, consult your physician before using a spa.

• Pregnant or possibly pregnant women should limit spa water

temperatures to 38°C (100°F).

• Persons suffering from obesity or a medical history of heart disease,

low or high blood pressure, circulatory system problems, diabetes,

infectious diseases or immune deciency syndromes should consult a

physician before using a spa.

• If you experience breathing difculties in association with using or

operating your spa, discontinue use and consult your physician.

• Persons using medication should consult a physician before using

a spa since some medication may induce drowsiness, while other

medication may affect heart rate, blood pressure, and circulation.

• Persons suffering from any condition requiring medical treatment, the

elderly, or infants should consult with a physician before using a spa.

• The use of alcohol, drugs, or medication before or during spa use may

lead to unconsciousness with the possibility of drowning.

7. !WARNING: RISK OF SEVERE INJURY OR DEATH!

• Prolonged immersion in a spa may be injurious to your health.

• Observe a reasonable time limit when using the spa. Exposures at

higher temperatures can cause high body temperature (over-heating).

Symptoms may include dizziness, nausea, fainting, drowsiness, and

reduced awareness. These effects could possibly result in drowning or

serious injury.

• Never use a spa immediately following strenuous exercise. Enter and

exit the spa slowly. Wet surfaces can be slippery.

8. !WARNING: TO DECREASE RISK OF INFECTION OR DIS-

EASE!

• To reduce the risk of contracting a waterborne

illness (e.g. an infection,

bacteria or virus) and/or respiratory ailments

, maintain water chemistry

within the parameters listed on the inside cover of this manual and

consult with a licensed engineer regarding proper ventilation if installed

indoors or in an enclosed area.

• People with infectious diseases should not use a spa to avoid water

contamination, which could result in spreading infections to others.

• Always shower before and after using your spa. Maintain water chem-

istry in accordance with manufacturer’s instructions. Failure to do

so may result in contracting a waterborne

illness (e.g. an infection,

bacteria or virus).

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Jacuzzi Whirlpool Handbücher

Jacuzzi

Jacuzzi Projecta JP 7 Bedienungsanleitung

Jacuzzi

Jacuzzi Premium J-325 Betriebsanleitung

Jacuzzi

Jacuzzi J-Sha Mi Bedienungsanleitung

Jacuzzi

Jacuzzi J-ALLURE J-ALLURELuxury Bathing and Entertainment... Bedienungsanleitung

Jacuzzi

Jacuzzi Corian Aura Corner 140 Bedienungsanleitung

Jacuzzi

Jacuzzi J - 460 Bedienungsanleitung

Jacuzzi

Jacuzzi Duetta 6642 Bedienungsanleitung

Jacuzzi

Jacuzzi LUXURA 5.5 Bedienungsanleitung

Jacuzzi

Jacuzzi Profile Bedienungsanleitung

Jacuzzi

Jacuzzi POWERACTIVE 2.1 Bedienungsanleitung

Jacuzzi

Jacuzzi J-400 Series Bedienungsanleitung

Jacuzzi

Jacuzzi PALIO Bedienungsanleitung

Jacuzzi

Jacuzzi SWIMSPA Power Pro J19 Bedienungsanleitung

Jacuzzi

Jacuzzi J - 460 Bedienungsanleitung

Jacuzzi

Jacuzzi LCD Series Bedienungsanleitung

Jacuzzi

Jacuzzi Aura Series Bedienungsanleitung

Jacuzzi

Jacuzzi city spa Bedienungsanleitung

Jacuzzi

Jacuzzi Skylounge Bedienungsanleitung

Jacuzzi

Jacuzzi Z100 Bedienungsanleitung

Jacuzzi

Jacuzzi Premium J-315 Bedienungsanleitung

Jacuzzi

Jacuzzi Fresco Y950 Bedienungsanleitung

Jacuzzi

Jacuzzi capella 55 Bedienungsanleitung

Jacuzzi

Jacuzzi Finestra EV95 Bedienungsanleitung

Jacuzzi

Jacuzzi Cetra 532 Bedienungsanleitung

Beliebte Whirlpool Handbücher anderer Marken

Bestway

Bestway Lay-Z-Spa 54189 Bedienungsanleitung

Morphy Richards

Morphy Richards Essentials PC4006 Bedienungsanleitung

Softub

Softub PRESTIGE Bedienungsanleitung

JNJ SPAS

JNJ SPAS SPA-318 Installationshandbuch

KIRAMI

KIRAMI Comfort Family Bedienungsanleitung

QCA Spa

QCA Spa VS501 PAK (VL260 TOPSIDE) Bedienungsanleitung

HoMedics

HoMedics FB-655HJ-GB Bedienungsanleitung

Everyday Hot Tubs

Everyday Hot Tubs 530 Bedienungsanleitung

anko

anko SS-601A Bedienungsanleitung

Pooli

Pooli OS030979B Bedienungsanleitung

ab Solares Smart Spa Bedienungsanleitung

CalderaSpas

CalderaSpas CalderaSpas Utopia Series Bedienungsanleitung

Outsunny

Outsunny 848-047V70 Bedienungsanleitung

Aquatic

Aquatic INFINITY 1 Bedienungsanleitung

Master Spas

Master Spas MP Force Bedienungsanleitung

Asteria

Asteria 5630 Bedienungsanleitung

Image

Image IMSB61610, IMSG61610 Bedienungsanleitung

ViSAGE

ViSAGE FM-588D Bedienungsanleitung