Jandy TruGuard Bedienungsanleitung

H0644400 REV C

ENGLISH |ESPAÑOL

INSTALLATION AND

OPERATION MANUAL

FOR YOUR SAFETY - This product must be installed and serviced by a contractor

who is licensed and qualified in pool equipment by the jurisdiction in which the

product will be installed where such state or local requirements exist. The maintainer

must be a professional with sufficient experience in pool equipment installation and

maintenance so that all of the instructions in this manual can be followed exactly.

Before installing this product, read and follow all warning notices and instructions

that accompany this product. Failure to follow warning notices and instructions

may result in property damage, personal injury, or death. Improper installation and/

or operation will void the warranty.

ATTENTION INSTALLER - This manual contains important information about the

installation, operation and safe use of this product. This information should be

given to the owner/operator of this equipment.

WARNING

Jandy

TruGuard™

with Nature2®Technology

Page 2 ENGLISH Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual

Table of Contents

Section 1. Important Safety Instructions.......3

Section 2. General Description.......................4

2.1 Product Overview..........................................................4

2.2 Product Contents ..........................................................4

Section 3. Installation Requirements.............4

Section 4. Installing the Jandy TruGuard ...... 5

Section 5. Low-Chlorine Recipe ..................... 8

Section 6. Circulation and Filtration ..............9

Section 7. Cartridge Replacement................10

Section 8. Winterizing....................................10

8.1 Warm Climate..............................................................10

8.2 Cold Climate................................................................ 10

Section 9. Disposal........................................ 11

Section 10. Troubleshooting........................... 12

Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual ENGLISH Page 3

Section 1. Important Safety Instructions

READ AND FOLLOW ALL INSTRUCTIONS

The Jandy TruGuard pool sanitizer is designed only for residential

swimming pools.

When installing and using this equipment, basic safety precautions should

always be followed, including the following:

WARNING

EQUIPMENT UNDER PRESSURE

• Always turn pump off prior to installing or changing Nature2cartridge. Your pump/filter system

is operated under pressure and the pressure must be released before you begin work. Please

see your pump/filter owner’s manual for further instructions.

PREVENT CHILD DROWNING

•

Do not let anyone, especially small children, sit, step, lean or climb on any equipment installed as

part of your pool’s operational system. Locate the components of your operational system at least

3 feet from the pool so children cannot use the equipment to access the pool and be injured or

drown.

LOW CHLORINE RECIPE

• You must strictly follow the low chlorine recipe included in this manual to maintain proper water

chemistry and avoid health hazards. Failure to follow these instructions can lead to sickness

from bacteria and other noxious organisms.

CAUTION

PRECAUTIONARY STATEMENT HAZARDS TO HUMANS AND DOMESTIC ANIMALS

In the unlikely event that a cartridge breaks, mineral media should not be

ingested by humans or animals as it may cause gastric distress.

FIRST AID IF INGESTED: Call poison control center or doctor immediately for treatment advice.

SAVE THESE INSTRUCTIONS

ATTENTION INSTALLER

This manual contains important information about the installation,

operation and safe use of this product. This information should be given

to the owner/operator of this equipment.

Page 4 ENGLISH Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual

Section 2. General Description

2.1 Product Overview

This manual provides instructions for installing and replacing the Jandy

TruGuard to sanitize swimming pools from 5,000 to 45,000 gallons. The

TruGuard housing will fit on 2” or 2 1/2” pipe sizes. The Jandy TruGuard

consists of Nature2®technology used in conjunction with a chlorine

delivery device or 0.5 ppm of an EPA registered chlorine pool product.

Nature2® technology consists of silver and copper minerals.

Every pool has it’s own characteristics of water type and exposure to natural

elements. The recipe included in this manual will help ensure good water

quality for your pool that will make your swimming experience more

enjoyable.

NOTICE

It is a violation of Federal law to use this product in a manner

inconsistent with its labeling.

2.2 Product Contents

1 - TruGuard Housing 4 - Owner’s Manual

2 - TruGuard Cartridge 5 - Installation Manual

3 - Winterizing and Pressurizing Cap

Section 3. Installation Requirements

Before installing a new TruGuard cartridge, clean debris and algae out of

the pool and pool equipment. Do not install the new cartridge until the pool

water is clean and chemically balanced. Refer to the Owner’s Manual for

water balance instructions.

Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual ENGLISH Page 5

Section 4. Installing the Jandy TruGuard

The Jandy TruGuard installs on your pool’s return line.

1. Determine the location to install the Jandy TruGuard. It must be

installed:

 •Afterthelteronthemainreturntothepool.

• Before or after the heater (downstream of solar heating systems).

• Before check valve to any chemical dispenser or the discharge of any

off-line chemical dispenser.

Chlorinator

Pump

Filter

Jandy

TruGuard

Heater

Check

Valve

Return Line

Intake Line

2. Locate an area on the return line that is at least 8” to install the Jandy

TruGuard.

3. Turn OFF the pool pump. Your pump/lter system is operated

under pressure. The pressure must be released before you begin

work. Please refer to the pump/lter owner’s manual for further

instructions.

4. Closeanyvalves.Ifyourpoolltrationequipmentisbelowthewater

level of the pool, you will either need to close the return valve or

usewinterizingplugsattheskimmerandreturnttingstoprevent

excessive water loss.

5. Remove the cartridge from the housing and plumb the housing into the

pipe,makingsurethattheowindicatorarrowsonthehousingmatch

theowdirectionofthewater.Pipesmustbecleananddrybefore

gluing.

NOTE: If the ow direction of the water does not match the arrows on the housing,

the unit will not function properly. Housing can be oriented horizontally or

vertically. For ease of servicing and maintenance, it is recommended that

the housing be installed horizontally with the cartridge facing up.

Page 6 ENGLISH Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual

Water Flow

6. Insert the TruGuard cartridge into the housing.

Water Flow

7. Tighten the locking ring.

Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual ENGLISH Page 7

10. Write the installation date and replacement date on the cartridge label.

11. Open any valves that you closed and turn on your pool pump to verify

that there are no leaks.

If there is a leak, turn off the pump, close the valves, and remove the

TruGuard. Check that the o-ring is not pinched, and is seated properly.

Replace the cartridge and hand tighten the nut.

12. Superoxidize the pool water with chlorine according to manufacturer’s

instructions to burn off contaminants and activate cartridge.

IMPORTANT: Initial superoxidation with chlorine is required to burn off

contaminants and activate cartridge.

13. Run the circulating pump for 24 hours a day for 4 days, maintaining

1-2 ppm free chlorine throughout, or 6 hours a day for 14 days,

maintaining 1-2 ppm free chlorine throughout.

14. Let chlorine dissipate to 0.5 ppm once start up period is completed. Do

not enter the pool if the free available chlorine residual is over 3 ppm.

15. Refer to Owner’s Manual for maintaining a low chlorine recipe.

Section 7. Cartridge Replacement

The TruGuard cartridge needs to be replaced every six months. The

installation and replacement date of the cartirdge should be written on the

cartridge label when installed.

1. Turn off the pool pump.

2. Release the pressure from your pool plumbing system. Refer to your

pump/ltermanualforpressurereleaseinstructions.

3. Closeanyvalves.Ifyourpoolltrationequipmentisbelowthewater

level of the pool, you will either need to close the return valve or

usewinterizingplugsattheskimmerandreturnttingstoprevent

excessive water loss.

4. Loosen the locking ring.

5. Remove the old TruGuard cartridge.

6. Install the new TruGuard cartridge.

7. Write the installation date and replacement date on the cartridge label.

8. Tighten the locking ring.

Page 8 ENGLISH Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual

Section 8. Winterizing

8.1 Warm Climate

1. Reduce the number of hours that the pump runs since the cooler

weather decreases the spread of algae and other pollutants.

2. There is no need to superoxidize the pool during cool weather unless

the water becomes cloudy (as may occur after a winter storm). See

cloudy water in Troubleshooting section.

8.2 Cold Climate

1. Check total alkalinity and pH of pool to make sure that they are in

proper balance.

2. Vacuum the pool bottom to remove any debris or other potential

contaminants.

3. Superoxidize the pool with chlorine according to manufacturer’s

instructions to clear the water.

4. Add a winter algaecide following manufacturer’s instructions.

IMPORTANT: Do not use a winter algaecide with copper in it. This will

void the Jandy warranty.

5. Backwashthelter.

6. Drain part of the pool water. The amount to drain varies from one part

of the country to another. Consult your dealer for advice.

7. Remove the TruGuard cartridge and discard.

8. Place the Winterizing and Pressurizing Cap in the housing and tighten

the locking ring.

9. Winterize the pipes with pool antifreeze following manufacturer’s

instructions.

10. Drainthewateroutofallequipment(pump,lter,etc.).

11. Store all baskets, hoses and cleaning equipment, indoors if possible.

12. Cover the pool with a winter cover.

Section 9. Disposal

After six months of use, discard the TruGuard cartridge in household trash.

Do not save the cartridge for re-use. The cartridge contains mineral media

that is sealed inside. In the unlikely event that a cartridge breaks, remove it

and vacuum out any media introduced into the pool.

Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual ENGLISH Page 9

Page 10 ENGLISH Jandy® TruGuard™| Installation & Operation Manual Jandy® TruGuard™| Installation & Operation Manual

Andere Handbücher für TruGuard

Inhaltsverzeichnis

Sprachen:

Andere Jandy Beleuchtungsausrüstung Handbücher

Jandy

Jandy R0474000 Bedienungsanleitung

Jandy

Jandy TruFit JHCBUB Bedienungsanleitung

Jandy

Jandy WaterColors CPLVRGBWS30 Bedienungsanleitung

Jandy

Jandy AquaPure Betriebsanleitung

Jandy

Jandy CS100 Bedienungsanleitung

Jandy

Jandy AquaPure Ei Series Bedienungsanleitung

Jandy

Jandy AquaLink RS PS4 Bedienungsanleitung

Jandy

Jandy AquaPure Ei Series Bedienungsanleitung

Jandy

Jandy WPLV100WS30 Bedienungsanleitung

Jandy

Jandy Laminar Jet Bedienungsanleitung

Jandy

Jandy Jandy Pro Series Bedienungsanleitung

Jandy

Jandy Versa-Plumb CL340 Bedienungsanleitung

Jandy

Jandy AquaLink RS Bedienungsanleitung

Jandy

Jandy AquaLink TCX Bedienungsanleitung

Jandy

Jandy Levolor K-1100 Bedienungsanleitung

Jandy

Jandy APURE35 Bedienungsanleitung

Jandy

Jandy iAquaLink 3.0 Bedienungsanleitung

Jandy

Jandy TruFit Bubbler Bedienungsanleitung

Jandy

Jandy WaterColors LED Bedienungsanleitung

Beliebte Beleuchtungsausrüstung Handbücher anderer Marken

Brizo

Brizo 8SP-MU-4 Bedienungsanleitung

LUCE&LIGHT

LUCE&LIGHT BROM 1.0 Bedienungsanleitung

IKEA

IKEA BJÖRKSPIREA Bedienungsanleitung

Laserworld

Laserworld Evolution Series ES-400RGB Bedienungsanleitung

EuroLite

EuroLite LED B-40 Bedienungsanleitung

Qazqa

Qazqa Suplux SL 3 Black 103062 Bedienungsanleitung

Commercial Electric

Commercial Electric 54568141 Bedienungsanleitung

CREE LIGHTING

CREE LIGHTING 304 Series Bedienungsanleitung

Goobay

Goobay 49867 Bedienungsanleitung

ECOMAN ITALIA

ECOMAN ITALIA LED T8 Bedienungsanleitung

Alkalite

Alkalite Krypton KT-81 Bedienungsanleitung

Clas Ohlson

Clas Ohlson GU10 Bedienungsanleitung

DTS

DTS DELTA 10 F Bedienungsanleitung

ring

ring Solar Steplight Bedienungsanleitung

One Stop Gardens

One Stop Gardens 57696 Montageanleitung

SIREM

SIREM Swimeo A2 Bedienungsanleitung

Silvair

Silvair MESH-CEDRP Bedienungsanleitung

S&P

S&P PCRL80 Bedienungsanleitung