Kathrein ZAS 40 Bedienungsanleitung

1 / 2

ZAS 40 20410011

ZAS 41 20410012

Rafter fasteners for the sat antennas CAS 06/60/80/90 and KEA 650/750/850/1000

About this guide

This document is part of the product.

►Do not install or use the device until you have read and understood

this document.

►Perform all operating steps described in this manual in the speciﬁed

sequence.

►Keep this document for reference throughout the service life of the

device. Pass this document on to any new owner or user.

For the most up-to-date version of this document, go to

www.kathrein-ds.com.

Features

■TÜV certiﬁed for parabolic antennas with a diameter of up to Ø1m

■ZAS 41 for one parabolic antenna

ZAS 41 for one parabolic antenna and an additional VHF antenna

■Mounting directly from the outside or through the battens onto the

rafter

■Flexibly adjustable to the gaps between the rafters by means of a

telescopic tube

■Continuously adjustable for any roof slope (limited only by the cover

plate)

■Hot-dip galvanised

■Cable is inserted through mast tip by means of the ZTC 08 (included

in the scope of delivery of the ZTS40/ZTS 41ro/ZTS 41sw)

■Designed to withstand lightning current (100kA, 10/350 µs according

to DIN VDE 0855-300)

Scope of delivery

●Rafter fastener

●6wood screws 10x100mm

●Earthing terminal

●Mast cover

●4 nuts M10

●Fastening screw M10 x 20

●User manual

ZAS 40 and ZAS 41 are rafter fasteners for mounting parabolic antennas with a diameter of up to Ø100cm on the roof.

Any other use, or failure to comply with these instructions or documentation and instructions enclosed with the devices, will result in voiding of

warranty or guarantee.

Intended use

Technical data

Type Unit ZAS40 ZAS41

Order no. 20410011 20410012

Length mm 900 1300

Diameter mm 48 48

Gaps between rafters mm 510–900

Roof slope ° 0–90

Rafter frame dimensions mm 580–980x148x40

Suitable for sat antennas CAS06/CAS60/CAS80/CAS90, KEA 650/750/850/1000

Suitable mounting accessories see „Mounting sets ZTS40/ZTS 41ro/ZTS 41sw“ on page <?>

Packing unit mm 940 x 190 x 115 1350 x 190 x 115

Perm. bending moment Nm 700

Packing unit/weight, approx. pc./kg 1/6.5 1/7.5

Mounting sets ZTS40/ZTS 41ro/ZTS 41sw

●For securing the rafter fasteners ZAS 4x

●Consists of:

–ZTB 61: Lead cover plate (410 x 410 mm)

ZTB 60ro/ZTB 60sw: Aluminium cover plate (500 x 450 mm)

–ZTC 08: Mast cap for insertion of eight or ten cables

–ZTC 48: Cover collar (ø 48mm)

The items in the sets are

also available individually.

Please ﬁnd further moun-

ting accessories under

www.kathrein-ds.com

2 / 2

www.kathrein-ds.com | support@kathrein-ds.com 936500101/g/A4/STM/1121/GB |Subject to change.

KATHREIN Digital Systems GmbH | Anton-Kathrein-Str. 1–3 | 83022 Rosenheim | Germany | Phone +49 731 270 909 70

Installation

Safety instructions

WARNING!

Danger of falling during assembly work on the roof

►The equipment described may only be installed by trained specialist personnel.

►Make sure that the supporting structure has sucient load-bearing capacity.

►Wear stable shoes with non-slip soles.

►Make sure that the roof and climbing aid are dry, clean and non-slip.

►Mount the sat antenna (max. ø 100 cm) only up to a height of 800 mm (see sticker marking).

►For a mast length of 1300mm (ZAS 41), install the reﬂector below and the FM antenna above.

Required tools

●Drill bit Ø 6.5mm

●17 AF open-ended spanner

●Spirit level

Installing the rafter fastener

1. Remove a sucient number of roof tiles.

2. Extend the rafter fastener to the width of rafters or counter

battens.

Align the rafter fastener and the lead cover plate to

suit the covering materials of the roof. Take care to

leave enough overhang above and below the gap in

the rooﬁng material.

The cross-tube of the ZAS 40 and ZAS 41 rafter faste-

ners has an oset of about 2 cm relative to the side

securing clips. Depending on the alignment, this

oset allows the rafter fastener to be moved upwards

or downwards within the roof space and, for instance,

in the conjunction with the rafter fastener installation

set ZTS 40, to achieve an optimum position relative

to the existing roof tiles. When installing on steeper

roofs, make sure the shorter securing section points

downwards relative to the slope of the roof.

3. Mark six screw holes on rafters or counter battens.

4. Pre-drill screw holes 50 mm deep using a Ø 6,5 mm drill bit.

5. Screw in the six wood screws 10 x 100 mm from above on

the rafters or counter battens using an A7 19 open-ended

spanner. If the counter battens are too thin, place a suitable

piece of wood underneath the rafter bracket in the areas of

the bolts.

6. Tighten the fastening screw of the telescopic tube using an

AF 17 open-ended spanner.

7. Place the earthing wire (16 mm2copper or 25 mm2alumi-

nium) into the earthing terminal and tighten the nut.

8. Slide the mast along the telescopic tube in such a way that

the cover plate matches the joints of the roof tiles.

9. If you intend to lead cables through the mast tip, remove the

mast cap.

10. Swing the mast towards the gable and pull the cover plate

and the cover collar over the mast tip.

11. Mark six screw holes on rafters or counter battens.

12. Pre-drill screw holes 50 mm deep using a Ø 6,5 mm drill bit.

13. Screw in the six wood screws 10 x 100 mm from above on

the rafters or counter battens using an A7 19 open-ended

spanner. If the counter battens are too thin, place a suitable

piece of wood underneath the rafter bracket in the areas of

the bolts.

14. Tighten the fastening screw of the telescopic tube using an

AF 17 open-ended spanner.

15. Place the earthing wire (16 mm2copper or 25 mm2alumi-

nium) into the earthing terminal and tighten the nut.

16. Slide the mast along the telescopic tube in such a way that

the cover plate matches the joints of the roof tiles.

17. If you intend to lead cables through the mast tip, remove the

mast cap.

18. Swing the mast towards the gable and pull the cover plate

and the cover collar over the mast tip

Dieses Handbuch passt für folgende Modelle

Andere Kathrein Antenne Handbücher

Kathrein

Kathrein EAS 124 Bedienungsanleitung

Kathrein

Kathrein HDS 166 Bedienungsanleitung

Kathrein

Kathrein U-LoRa ETSI/FCC Bedienungsanleitung

Kathrein

Kathrein CAS 120 Bedienungsanleitung

Kathrein

Kathrein 50610001 Bedienungsanleitung

Kathrein

Kathrein HDP 600 Bedienungsanleitung

Kathrein

Kathrein 742270V03 Bedienungsanleitung

Kathrein

Kathrein CAS 09 Bedienungsanleitung

Kathrein

Kathrein UAS572 Bedienungsanleitung

Kathrein

Kathrein BZD 40 Bedienungsanleitung

Kathrein

Kathrein UAS 571 Bedienungsanleitung

Kathrein

Kathrein AUY 69 Bedienungsanleitung

Kathrein

Kathrein CAS 90gr Bedienungsanleitung

Kathrein

Kathrein CAS 80gr Bedienungsanleitung

Kathrein

Kathrein CAS 09 Bedienungsanleitung

Kathrein

Kathrein BAS 60 Bedienungsanleitung

Kathrein

Kathrein CAS 06 Bedienungsanleitung

Kathrein

Kathrein CAS 180 Bedienungsanleitung

Kathrein

Kathrein K 51 24 72 Bedienungsanleitung

Kathrein

Kathrein UFO 395 Bedienungsanleitung

Kathrein

Kathrein CAS 80gr Bedienungsanleitung

Kathrein

Kathrein HDP 850 GPS Bedienungsanleitung

Kathrein

Kathrein BZD 40 Bedienungsanleitung

Kathrein

Kathrein CAS 90gr Bedienungsanleitung

Beliebte Antenne Handbücher anderer Marken

Alfa Network

Alfa Network APA-L01 Bedienungsanleitung

Naval

Naval PR-422CA Bedienungsanleitung

Feig Electronic

Feig Electronic ID ISC.ANTH200/200 Series Bedienungsanleitung

TERK Technologies

TERK Technologies TV44 Bedienungsanleitung

Directive Systems & Engineering

Directive Systems & Engineering DSE2324LYRMK Bedienungsanleitung

HP J8999A Bedienungsanleitung

MobilSat

MobilSat MSP-S Bedienungsanleitung

Steren

Steren ANT-UHF 13 Bedienungsanleitung

Novatel

Novatel 600-G Bedienungsanleitung

Radio Shack

Radio Shack Amplified VHF/UHF/FM Indoor Antenna Bedienungsanleitung

TRENDnet

TRENDnet TEW-AO12O Bedienungsanleitung

Radio Shack

Radio Shack 15-1837 Bedienungsanleitung

CommScope

CommScope CMAX-OMFX-43M-I53 Bedienungsanleitung

Ramsey Electronics

Ramsey Electronics DAP25 Bedienungsanleitung

COBHAM

COBHAM SAILOR 800 VSAT Gebrauchs- und Pflegehandbuch

Trango Systems

Trango Systems AD900-9 Bedienungsanleitung

Steren

Steren ANT-100 Bedienungsanleitung

Proxim

Proxim 5054-PA-23 Bedienungsanleitung