Kenmore SF22-804 Montageanleitung

Date: 12/28/07 Parts& RepairServices

SLR% (/g LAS H

SF22-804

Page 1 of 6

To Be Read During Regular Working Hours

Division 22, Source 790

Kenmore by EHP 24" Gas Self Clean Wall Ovens

Poor Combustion

JOB CODE &

TYPE OF FLASH MAJOR HEADING SUB HEADING DESCRIPTION

[] Safety PROC ID:

[] Credit GPT-320 Built-In Wall Oven General Repair Per Service

SPECIAL INSTRUCTIONS:

DO NOT ORDER PARTS. The kit will be shipped directly to the customer.

SPECIAL CALL CLOSE INSTRUCTIONS at end of Flash.

790.30472400

Kenmore Model Numbers

790.30473400 790.30473401 790.30474400 790.30479400

Serial# Range

NF401xxxxx -

NF610xxxxx

CONDITION:

Under certain conditions during prolonged or extended broiling times, gas may build up within the

oven cavity and escape as flames when the oven door is opened.

CORRECTION:

To correct this situation install Kit #628.903077-9010 which will reduce the cooling fan speed in bake

and broil modes. In the self-clean cycle the cooling fan will operate at high speed.

NOTES:

• Models with Serial #s NF61 lxxxxx and above have incorporated the dual speed operation and do

not require this kit.

• Only THIS REPAIR is covered by this Service Flash.

- If you are on a call for another reason, and the unit falls within the models and serial numbers in

this flash, call the Pro-Team @1-888-549-4557 and request another Service Order be created.

Advise the customer not to use the broil function until the oven has the kit installed.

- If repairs other than the repair referenced in this flash are required, an additional Service Order

MUST be created.

Parts included in Kit # 628.903077-9010

1 Switch

1 Screw

1 Speed Nut

1 Thermostat -120 °

2 Screws

1 Resistor

#318120711

#73200-2080

#73204-1650

#318003613

#73201-2140

#73213-2350

1 Screw

1 Wire #1 8in .250/skinned

2 Wire #2&3 8in .250/piggyback

2 Wire #4&5 8in .250/.187

1 Wire Nut Connector

1 Instruction Sheet

#73201-2140

#318052584

#318052585

#318052586

#73213-2290

#318205012

Confidential Information -For Internal Use Only

DEPARTMENT 702HSX - Leo Steinys

DEPARTMENT 702PSO - Bob Vondale

Date: 12/28/07 Parts& RepaLrServices

Illustration for the kit wiring...

SF22-804

Page 2 of 6

IMPORTANT: Before servicing always remove power from the unit and turn off the gas supply.

Remove the rear panel from the oven. It may also be helpful to remove the top cover for easier

access to the thermostat and wires. Follow the steps outlined below to install the kit

1. Remove the screws securing the lock

motor assembly and remove the

assembly from the chassis

2. Remove the 2 screws securing the door

lock motor and remove it from the

mounting bracket

Confidential Information -For Internal Use Only

DEPARTMENT 702HSX - Leo Steinys

DEPARTMENT 702PSO - Bob Vondale

Date: 12/28/07 Parts& RepaLrServices SF22-804

Page 3 of 6

3. Position the new switch as shown in the

photo. The new switch is held in place by a

single screw on one end and the tab from

the mounting bracket on the other end.

4. Secure the switch with the long screw and

speed nut.

DO NOT OVER TIGHTEN SCREW.

5. Reinstall the lock motor onto the bracket.

Make sure that the cam on the motor is

pressing the plunger of the new switch.

6. Re install the lock motor assembly onto

the chassis. Take care to ensure the

latch rod is properly inserted into the

motor couplinc].

Confidential Information -For Internal Use Only

DEPARTMENT 702HSX - Leo Steinys

DEPARTMENT 702PSO - Bob Vondale

Date: 12/28/07 Parts& RepaLrServices SF22-804

Page 4of 6

7. Install the resistor on the rear wall as

shown in the photo. Carefully punch or

drill a starter hole for the screw if

necessary.

8. Use existing screw holes to install the

new 120 ° thermostat to the left of the

existing 170 ° thermostat. Mark the

chassis with an "X "or "120" to identify

the new thermostat.

9. Install wire # 1 (318052584) onto the

"C" terminal of the new switch. This

wire has a push on terminal on one

end and is stripped on the other end.

10. Disconnect the power wire from the

170 ° thermostat, cut off the terminal

connector and strip approx. 3/16 inch

of the insulation. The power wire is

the one that does not connect to the

fan motor.

(318052584

From Kit

Confidential Information -For Internal Use Only

DEPARTMENT 702HSX - Leo Steinys

DEPARTMENT 702PSO - Bob Vondale

Date: 12/28/07 Parts& RepaLrServices SF22-804

Page 5 of 6

11. Use the wire nut connector provided to

connect the power wire that was attached to

the 170 ° thermostat to the #1 wire from the

"C" terminal of the new switch.

12. Install the #2 (318052585 - Red) wire

from the "NC" terminal of the new switch to

the open terminal of the 170 ° thermostat that

the power wire previously attached to.

new switch

13. Disconnect the wire from the fan to

the 170 ° thermostat. Connect this

wire to the piggyback terminal on the

#3 (318052585 - Red) wire. Connect

these two wires onto the open

terminal of the 170 ° thermostat.

14. Connect the other end of the red #3

wire to the resistor. Connect the #4

(318052586-Brown) wire to one

terminal of the 120 ° thermostat.

Connect the other end to the

resistor.

Confidential Information -For Internal Use Only

DEPARTMENT 702HSX - Leo Steinys

DEPARTMENT 702PSO - Bob Vondale

Date: 12/28/07 Parts& RepaLrServices SF22-804

Page 6 of 6

15. Connect the #5 (318052586 - Brown)

wire to the remaining terminal of the

120 ° thermostat. Connect the other end

to the "NO" terminal of the new switch

PARTS: Order parts using the normal ordering procedure.

Division 22, Source 628, Part number #903077-9010

[] Truck Stock Not Recommended

[] Order Part (see below)

SPECIAL SERVICE ORDER CLOSE INFORMATION:

In Order for the Service Unit to receive proper credit, the service order MUST contain the following

information.

• Complete model and serial numbers

• Close the call using "PAYROLL TRANSFER" (50/950)

• Type "Repair per Service Flash" in Tech Comments field

• Always include the part number on each Service Order

Confidential Information -For Internal Use Only

DEPARTMENT 702HSX - Leo Steinys

DEPARTMENT 702PSO - Bob Vondale

Dieses Handbuch passt für folgende Modelle

Andere Kenmore Ofen Handbücher

Kenmore

Kenmore 790.4890 Series Bedienungsanleitung

Kenmore

Kenmore 30" Built In Wall Oven Bedienungsanleitung

Kenmore

Kenmore 318205128 Bedienungsanleitung

Kenmore

Kenmore 911.41065 Bedienungsanleitung

Kenmore

Kenmore 4802 - Elite 27 in. Wall Oven Bedienungsanleitung

Kenmore

Kenmore 4776 Bedienungsanleitung

Kenmore

Kenmore 911.49042 Bedienungsanleitung

Kenmore

Kenmore 100.06905 Bedienungsanleitung

Kenmore

Kenmore 790. 3017 Bedienungsanleitung

Kenmore

Kenmore 790.4807 Bedienungsanleitung

Kenmore

Kenmore 911.47712 Bedienungsanleitung

Kenmore

Kenmore 665.63792 Bedienungsanleitung

Kenmore

Kenmore 790. 4043 Bedienungsanleitung

Kenmore

Kenmore 36725 Montageanleitung

Kenmore

Kenmore 22-45262 Bedienungsanleitung

Kenmore

Kenmore 911.41389 Bedienungsanleitung

Kenmore

Kenmore 790-4942 Series Bedienungsanleitung

Kenmore

Kenmore ELITE 790.4907 Series Bedienungsanleitung

Kenmore

Kenmore Kenmore 911.47692 Bedienungsanleitung

Kenmore

Kenmore Elite 100.90005 Bedienungsanleitung

Kenmore

Kenmore 790.4802 Bedienungsanleitung

Kenmore

Kenmore 4061 - 24 in. Clean Double Wall Oven Bedienungsanleitung

Kenmore

Kenmore 790.41003 Bedienungsanleitung

Kenmore

Kenmore Roaster oven 238.48238 Bedienungsanleitung

Beliebte Ofen Handbücher anderer Marken

Bosch

Bosch HVA531NS0 Bedienungsanleitung

Electrolux

Electrolux EOF6P46X Bedienungsanleitung

NEFF

NEFF B44S32 5GB Series Bedienungsanleitung

Combi

Combi BLODGETT BC142GDS Bedienungsanleitung

AEG

AEG COMPETENCE 311704300 Bedienungsanleitung

Falcon

Falcon DOMINATOR PLUS G3106 Series Benutzerhandbuch

Rational

Rational SCC WE 61G Bedienungsanleitung

Smeg

Smeg DOSPA38X Installations- und Betriebshandbuch

Electrolux

Electrolux air-o-convect 20 GN 2/1 Bedienungsanleitung

Miele

Miele HR 1954-2 Bedienungsanleitung

KHIND

KHIND OT50 Bedienungsanleitung

Henny Penny

Henny Penny Smoker Box Bedienungsanleitung

Lang

Lang ECOD-AP Bedienungsanleitung

AEG

AEG BEK455310M Bedienungsanleitung

Frigidaire

Frigidaire FNGE90JGR Bedienungsanleitung

Hotpoint

Hotpoint FE9 S831 JSH IX Bedienungsanleitung

GE Advantium SCB2000 Bedienungsanleitung

AEG

AEG DE401301DM Bedienungsanleitung