Kia RIO 2005 Konfigurationshandbuch
GENERAL
GI -2 GENERAL INFORMATION
GENERAL
IDENTIFICATION NUMBER
LOCATIONS EE840C2D
Engine number
(See page GI - 3)
Vehicle Identification number
(See page GI - 3)
Manual Transaxle number
(See page GI - 4)
Automatic Transaxle number
(See page GI - 4)
LAJF001A
GENERAL GI -3
IDENTIFICATION NUMBER DESCRIPTION
VEHICLE IDENTIFICATION NUMBER
6 0000015222EDANK
1 2 3 4 5 6 7 8 9 10 11 12~17
1
LAJF002A
1-3:M
ake/Vehicletype
-KNE,KNA = Kia Passenger Car
4-5:Ve
hicle Line / Series
-DE=PR
IDE
6-7:Bo
dy type
-22=4D
oor Sedan
-24=5D
oor Hatchback
8 : Enginetype
-1=1.4G
asoline (G4EE)
-2=1.6G
asoline (G4ED)
-4=1.5D
iesel (D4FA)
9:Trans
axle type
- Check digit
- 2 = 5 speedmanual
-3=Autom
atic
10 : Model year
- 5 = 2005, 6 = 2006
11 : Plant location
-6=Sohap
lant
12 : Sequential number
- 000001 ~ 999999
PAINT CODE
CODE COLOR
UD CLEAR WHITE
6C CLEAR SILVER
J1 POLAR SILVER
J4 CASHMERE BEIGE
2D SOFT GREEN
T5 SAPPHIRE
06 SUNSET ORANGE
08 TROPICAL RED
7V OLIVE GRAY
9B MIDNIGHT BLACK
GI -4 GENERAL INFORMATION
ENGINE IDENTIFICATION NUMBER
GEC45000001
1 2 3 4 5 6~11
AAJF003A
1. Engine fuel
- G = Gasoline
2. Engine range
- 4 = 4 cycle 4 cylinder
3. Engine development order
-E=ALP
HA Engine
4. Engine capacity
- D = 1,599cc
-E=1,399cc
5. Production year
- 5 : 2005, 6 : 2006
6. Engine production sequence number
- 000001 ~ 999999
TRANSMISSION IDENTIFICATION NUMBER
MANUAL
MANUAL
R 18735 000001
12 3 4
AAJF004A
1. Model
-R=M5CF1
-P=M5CF2
2. Production year
- 5 : 2005, 6 : 2006
3. Gear ratio(Tooth number)
<Diffe
rential drive gear tooth number / Output shaft
gear tooth number >
- 1873 = 73/18 = 4.056
4. Transaxle production sequence number
- 000001 ~ 999999
AUTOMATIC
TNUD5
1234 5 6
AAJF005A
5. Modle
-T=A4
AF3
6. Production year
- 5 : 2005, 6 : 2006
7. Gear ratio
-N=4.041
8. Detailed chassification
-UD=1
.4 DOHC
-WD=1
.6 CVVT
9. Spare
10. Transaxle production sequence number
- 000001 ~ 999999
GENERAL GI -5
WARNING / CAUTION LABEL LOCATIONS
AIRDUCT WARNING
BATTERY CAUTION
FAN CAUTION
RADIATOR CAP
CAUTION
SIDE AIRBAG INFORMATION
ATTENTION
SRSVEHICLE
THIS CAR IS EQUIPPED WITH A SUPPLEMENTAL
RESTRAINT SYSTEM.TO PROVIDE CONTINED RELIABLITY,
CERTAIN ELEMENTS OF THE SUPPLEMENTAL RESTRAINT
SYSTEM SHALL BE SERVICED OR REPLACED BY AUTHORIZED
DEALER TENYEARS AFTER VEHICLE LABEL. FOR FURTHER
INFORMATION.
SEE OWNER'S MANUAL.
SIDE AIR BAG
THIS CAR IS EQUIPPED WITH A SIDE AIRBAG SYSTEM.
TO PROVIDE CONTINUED RELIABILITY, CERTAIN ELEMENTS
OF THE SIDE AIRBAG SYSTEM SHALL BE SERVICED OR
VEHICLE MANUFACTURE DATE SHOWN ON CERTIFICATION LABEL.
FOR FURTHER INFORMATION
SEE OWNER'S MANUAL.
LAJF003A
GI -6 GENERAL INFORMATION
AIR BAG WARNING / CAUTION LABEL
CAUTION
AIRBAG : Handing is limited to trained personnel.
To be used only in prescribed vehicles.If not propely
installed, device may become a dangerous projectile.
See serivce manual instruction
DRIVE MODULE CAUTION
Caution
Don't open, remove or transfer to another vehicle.
Risk of malfunction and bodily injury!
This unit is to be installed and/or dismantled by trained
personnel only.
This item contains an explosive to be installed igniter.
LAJF004A
GENERAL GI -7
AIR BAG WARNING / CAUTION LABEL (CONT’D)
C
D
B
A
S R S
AIRBAG
S R S
AIRBAG
AAJF008A
GI -8 GENERAL INFORMATION
AIR BAG WARNING / CAUTION LABEL (CONT’D)
A:WARNING
SEE OWNER’S MANUAL.
This car is equipped a side airbag for each front seat.
•Do not use any accessory seat covers.
•Use of other seat covers could reduce the
effect of the system.
•Do not install any accessories on the side
or near the side airbag.
•Do not use excessive force on the side of the seal.
•For further information, see the owner’s manual.
B:CAUTION
AIRBAG ESPE UNIT
Detach connector before unmounting. Assemble
strictly according to manual instructions.
C : PASSENGER MODULE CAUTION
CAUTION
Don’t open, remove or transfer to another vehicle.
Risk of malfunction and bodily injury!
This unit is to be installed and/or dismantled by
trained personnel only. This item contains an
explosivetobeinstalledigniter.
D : SUPPLEMENTAL RESTRAINT SYSTEM
(AIRBAG) INFORMATION
•The airbag is a Supplement Restraint
System (SRS).
You must always wear the seat belts.
•The airbag system condition is normal
when the "SRS" lamp in the cluster flashes
approximately 6 times after the ignition key
is turned on and then goes off.
•If any of the following condition occur, the
system must be serviced.
• "SRS" lamp does not light up when
the key is turned on.
• "SRS" lamp stays lit or flashes continuously.
• The airbag has inflated.
•The airbag system must be inspected by an
authorized dealer ten years after the vehicle
manufacture date shown on the certification label,
located on left front door opening area.
WARNING
Failure to the above instructions may result in injury
to you or other occupants in the vehicle
•See the "SRS" section in Owner’s Manual for
more information about airbags.
GENERAL GI -9
BATTERY CAUTION LABEL DESCRIBTION
Wear eye protection
when charging or working
near a battery.
Always provide ventilation
when working in an
enclosed space.
When lifting a plastic-cased
battery, excesive pressure on
acid to leak resulting in personal
injury. Lift with a battery carrier
or with your hands on opposite
corners.
Never attempt to change the
battery when the battery
cables are connected.
The electrical ignition system
works with high voltage.
Never touch these components
with the engine running
or the ignition switched on.
Keep lighted cigarettes
and all other flames or
sparks away from the
battery.
Keep batteries out of the
reach of children
because batteries
contain highly corrosive
SULFURIC ACID. Do not
allow battery acid to
contact your skin, eyes,
clothing or paint finish.
If any electrolyte gets into your eyes,
flush your eyes with clean water for
at least 15 minutes and get immediate
medical attention. If possible, continue
to apply water with a sponge or cloth
until medical attention is received.
If electrolyte gets on your skin, throughly
wash the contacted area.
If you feel a pain or a burning sensation,
get medical attention immediately.
Always read the following
instructions carefully
when handing a battery.
Hydrogen, which is a
highly combustible gas,
is always presents in battery
cells and may explode if
ignited.
EAKE007E
GI -10 GENERAL INFORMATION
LIFT AND SUPPORT POINTS
WARNING
When heavy rear components such as suspen-
sion, fuel tank, spare tire, tailgate and trunk lid
are to be removed, place additional weight in the
luggage area before hoisting. When substantial
weight is removed from the rear of the vehicle, the
center of gravity may change and cam cause the
vehicle to tip forward on the hoist.
NOTE
•Since each tire/wheel assembly weights approx-
imately 30lbs (14kg), placing the front wheels in
the luggage area can assist with the weight dis-
tribution.
•Use the same support points to support the vehi-
cleonsafetystands.
1. Placetheliftblocksunderthe support pointsasshown
in the illustration.
2. Raise the hoist a few inches (centimeters) and rock
the vehicle to be sure it is firmly supported.
3. Raise the hoist to full height to inspect the lift points
for secure support.
[FRONT]
LIFT BLOCK LIFT BLOCK
[REAR]
LAJF005A
Dieses Handbuch passt für folgende Modelle
1
Inhaltsverzeichnis
Andere Kia Automobil Handbücher
Kia
Kia Automobile Bedienungsanleitung
Kia
Kia Spectra Bedienungsanleitung
Kia
Kia niro ev 2020 Stücklistenhandbuch
Kia
Kia Optima 2013 Bedienungsanleitung
Kia
Kia Soul 2024 Bedienungsanleitung
Kia
Kia Automobile Bedienungsanleitung
Kia
Kia Borrego 2017 Bedienungsanleitung
Kia
Kia 2007 Rio Bedienungsanleitung
Kia
Kia Rio 2007 Stücklistenhandbuch
Kia
Kia 2006 Automobile Bedienungsanleitung
Kia
Kia Rio 2004 Bedienungsanleitung
Kia
Kia K900 2017 Stücklistenhandbuch
Kia
Kia Seltos 2019 Bedienungsanleitung
Kia
Kia SOUL 2021 Stücklistenhandbuch
Kia
Kia Morning 2009 Bedienungsanleitung
Kia
Kia K5 2024 Bedienungsanleitung
Kia
Kia 2012 soul Stücklistenhandbuch
Kia
Kia Stinger 2020 Montageanleitung
Kia
Kia Sedona 2014 Bedienungsanleitung
Kia
Kia 2015 Rio Bedienungsanleitung
