Kohler K-3492 Montageanleitung

1035530-X2-A

Installation and Care Guide

Toilet

K-3492

X product numbers are for Thailand (i.e. K-12345X)

 ⌫  

  

1035530-X2-A 2 Kohler Co.

Tools and Materials

Thank You For Choosing Kohler Company

We appreciate your commitment to Kohler quality. Please take a few minutes to review this manual before you start

installation. If you encounter any installation or performance problems, please don’t hesitate to contact us. Our phone

numbers and website are listed on the back cover. Thanks again for choosing Kohler Company.

DANGER: Risk of electric shock. Disconnect power before servicing.

DANGER: Risk of electrical shock. For plug-in installations/wall-mounted electrical supply: Connect only

to a properly-grounded, grounding-type receptacle which is protected by a Ground-Fault Circuit-Interrupter

(GFCI). Do not remove the grounding pin or use a grounding adapter.

DANGER: Risk of electrical shock. For hardwire installations/through-floor electrical supply: Connect only

to a properly-grounded, dedicated 220 VAC, 15 A, 50 Hz circuit protected by a Class A Ground-Fault

Circuit-Interrupter (GFCI) or Earth-Leakage Circuit-Breaker (ELCB).

CAUTION: Risk of hazardous gases. If a new toilet is not installed immediately, temporarily place a rag in the

floor flange opening.

NOTICE: Follow all local plumbing and electrical codes.

NOTICE: Receptacles installed in bathrooms to be located at least 1 meter from a bathtub or shower if practical,

but in no case less than 0.5 meter.

Observe all local plumbing and building codes.

Carefully inspect the new toilet for damage.

Water and electrical supplies may installed through either the wall or the floor. For a more aesthetic look, installation

of the supplies through the floor is recommended.

There is a wiring schematic on the inside of the junction box cover.

Before You Begin

Kohler Co. 3 1035530-X2-A

1. Roughing-In

DANGER: Risk of electric shock. Disconnect power before servicing.

DANGER: Risk of electrical shock. For plug-in installations/wall-mounted electrical supply: Connect only

to a properly-grounded, grounding-type receptacle which is protected by a Ground-Fault Circuit-Interrupter

(GFCI). Do not remove the grounding pin or use a grounding adapter.

DANGER: Risk of electrical shock. For hardwire installations/through-floor electrical supply: Connect only

to a properly-grounded, dedicated 220 VAC, 15 A, 50 Hz circuit protected by a Class A Ground-Fault

Circuit-Interrupter (GFCI) or Earth-Leakage Circuit-Breaker (ELCB).

NOTE: This product is designed for installation with the electrical and water supplies located through either the wall

or the floor.

24-5/8" (62.5 cm)

L of Outlet

16-1/2" (41.9 cm)

16-5/8"

(42.2 cm)

18-1/4"

(46.4 cm)

Wall

14-1/8"

(35.9 cm)

12"

(30.5 cm)

Front of Bowl

3/8" Compression

Supply

6-5/8"

(16.8 cm)

15-7/8"

(40.3 cm)

7-1/4"

(18.4 cm)

4-3/8"

(11.1 cm)

38-3/4"

(98.4 cm)

Hardwire

Electrical Supply

Both the electrical and water supplies

can be installed on either the wall or

the floor. Follow the information for

your particular installation.

3/4" (1.9 cm)

1035530-X2-A 4 Kohler Co.

2. Install the Electrical Service and Water Supply

DANGER: Risk of electric shock. Disconnect power before servicing.

7-1/4" (18.4 cm)

GFCI-Protected

Receptacle

The wall locations of the

electrical and water supply

are interchangeable.

T-Bolts

(15.2 cm)

12" (30.5 cm)

Floor Flange

2-3/4" (7 cm)

3/4" (1.9 cm)

2-3/4" (7 cm)

Maximum Height

Supply Stop

Hardwire

Electrical Supply

DANGER: Risk of electrical shock. For plug-in installations/wall-mounted electrical supply: Connect only

to a properly-grounded, grounding-type receptacle which is protected by a Ground-Fault Circuit-Interrupter

(GFCI). Do not remove the grounding pin or use a grounding adapter.

DANGER: Risk of electrical shock. For hardwire installations/through-floor electrical supply: Connect only

to a properly-grounded, dedicated 220 VAC, 15 A, 50 Hz circuit protected by a Class A Ground-Fault

Circuit-Interrupter (GFCI) or Earth-Leakage Circuit-Breaker (ELCB).

Install the Electrical Service

NOTE: This product is designed for installation with the electrical supply located through either the wall or the floor.

Both types are illustrated. Refer to the dimensional information for your chosen installation.

Follow the dimensional information exactly when installing a hardwire electrical supply.

Install the electrical supply for your chosen installation.

Install the Water Supply

NOTE: This product is designed for installation with the water supply located through either the wall or the floor.

Both types are illustrated. Refer to the dimensional information for your chosen installation.

NOTE: A floor mounted water supply stop may be no higher than 2-3/4” (7 cm) from the floor.

Install the water supply. If you are installing a floor supply, study the dimensional information illustrated carefully.

Kohler Co. 5 1035530-X2-A

3. Install the T-Bolts

T-Bolts

Floor

Flange

4 Install the O-Ring

Install two 5/16” diameter T-bolts into the floor flange.

Place the wax ring in the putty ring located on the tank.

1035530-X2-A 6 Kohler Co.

5. Position the Tank

CAUTION: Risk of product damage. Do not push down on any part of the tank assembly other than the

cylinder. Damage may occur.

Outlet Ring

Remove outlet

gasket.

Centerlines

T-Bolts

Tank

Floor Flange

Replace

outlet

gasket.

Press here on cylinder.

Refill Tube

Remove the outlet gasket.

Mark the centerline on the floor.

Align the tank over the floor flange.

Lower the tank onto the floor flange. The T-bolts should align with the mounting slots in the base of the tank.

Carefully align the tank on the centerline.

Position the tank on the T-bolts.

Press down on the cylinder where the gasket was mounted. Do not press anywhere else on the tank assembly.

Replace the outlet gasket.

Position the loose end of the refill tube in the outlet ring.

CAUTION: Risk of product damage. Do not rock or lift the tank after placement. The seal created by the wax

ring may be broken, resulting in leaking.

Kohler Co. 7 1035530-X2-A

6. Secure the Tank

CAUTION: Risk of product damage. Do not overtighten the mounting nuts. Do not shorten the T-bolts.

Place a washer on each T-bolt.

Thread a nut onto each T-bolt.

Hand tighten the nuts.

IMPORTANT! If this installation replaces an existing toilet, a hose other than the one shipped with the water supply

may be used. Use a stainless steel, burst-resistant hose.

NOTE: This installation is configured to accept a floor water supply. A wall supply is also acceptable.

Connect the water.

Open the shut-off valve.

7. Connect the Water

Nut

Washer

T-Bolt

Base of

ank Unit

Flexible Hose

Floor supply shown.

1035530-X2-A 8 Kohler Co.

8. Check the Waterline

CAUTION: Risk of property damage. Before use, return the inlet valve lever to the unlocked (closed) position

to avoid overflow.

NOTE: The waterline is marked inside the tank by a notch and a label.

Turn on the water supply.

Move the lever on the motorized inlet valve into the locked (open) position.

Check the water level in the tank. If the water level is at the marked waterline, return the lever to the unlocked

(closed) position. If adjustments are needed, proceed to the next step.

To adjust the water level, use a flat blade screwdriver to gently turn the adjustment rod on the inlet valve. Turning

the rod counterclockwise will lower and clockwise will raise the water level.

Return the lever to the unlocked (closed) position.

Locked

Unlocked

Waterline

Adjust waterline.

Kohler Co. 9 1035530-X2-A

9. Install the Collar

Place the wiring harness plug, level switch wire, and refill tube on the floor so they extend out the rear access

opening.

Tape them to the floor so they will not be pinched or damaged.

Install the collar onto the tank.

Clip the spray shield into place over the fill valve.

Tape

Level

Switch

Wire

Electrical

Plug

Centerline

Refill Tube

Wiring Harness Plug Spray Shield

Collar

Ta n k

1035530-X2-A 10 Kohler Co.

10. Install the Vitreous Shell

WARNING: Risk of personal injury. The vitreous shell weighs 80 lbs. (36 kg). Use proper lifting technique

when handling the vitreous shell.

Carefully pick up the vitreous shell and place it over the tank.

Make sure the trapway seats fully in the outlet gasket. If the vitreous shell does not sit evenly on the floor, the

trapway is not properly seated.

Make all adjustments gently until the trapway is properly seated.

CAUTION: Risk of product damage. Do not set the shell down hard. Gently lift and move the shell if it is not

placed correctly. If handled harshly, the shell may chip or break.

Vitreous

Tank

Collar

Andere Handbücher für K-3492

Inhaltsverzeichnis

Andere Kohler Toilette Handbücher

Kohler

Kohler Heated French Curve K-4649 Montageanleitung

Kohler

Kohler K-18154 Bedienungsanleitung

Kohler

Kohler SAN MARTINE S-TRAP K-5503T-TFC Bedienungsanleitung

Kohler

Kohler C3-230 Montageanleitung

Kohler

Kohler VEIL K-1381T-S Bedienungsanleitung

Kohler

Kohler ARCHER K-3614T Bedienungsanleitung

Kohler

Kohler SANTA ROSA K-20169T-FNS Bedienungsanleitung

Kohler

Kohler New Wellworth K-3998T-W Bedienungsanleitung

Kohler

Kohler K-22250T-130 Bedienungsanleitung

Kohler

Kohler K-28413H Montageanleitung

Kohler

Kohler K-3678 Montageanleitung

Kohler

Kohler ARCHER K-4440T Bedienungsanleitung

Kohler

Kohler K-11456 Montageanleitung

Kohler

Kohler C3-129 Montageanleitung

Kohler

Kohler STERLING Bedienungsanleitung

Kohler

Kohler WELLCOMME K-4349T Bedienungsanleitung

Kohler

Kohler VIA K-20630T-BW Bedienungsanleitung

Kohler

Kohler C3-520 Montageanleitung

Kohler

Kohler K-3324 Montageanleitung

Kohler

Kohler K-4734-NY Montageanleitung

Kohler

Kohler K-25737X-C Montageanleitung

Kohler

Kohler S-TRAP K-3869T Bedienungsanleitung

Kohler

Kohler REVE K-17183T Bedienungsanleitung

Kohler

Kohler OVE K-19950W Bedienungsanleitung

Beliebte Toilette Handbücher anderer Marken

Toto

Toto Washlet TCF4911 Series Bedienungsanleitung

Grohe

Grohe Sensia ARENA Bedienungsanleitung

Geberit

Geberit AQUACLEAN MERA CLASSIC Bedienungsanleitung

Better Bathrooms

Better Bathrooms BUN/BeBa 27555/78725 Bedienungsanleitung

American Standard

American Standard CONCEPT Cube TF-2704 Bedienungsanleitung

BIOLAN

BIOLAN ECO Stücklistenhandbuch

Thetford

Thetford C260 Series Bedienungsanleitung

KELISS

KELISS T162A Series Bedienungsanleitung

BIOLAN

BIOLAN GARDEN TOILET Stücklistenhandbuch

washloo

washloo Prestige Bedienungsanleitung

JABSCO

JABSCO 37010 Series Bedienungsanleitung

Olympia

Olympia EPOQUE 69209 Bedienungsanleitung

DENCK

DENCK PURE-D Bedienungsanleitung

Silent Venus

Silent Venus SVP600 Wartungs- und Serviceanleitung

InBe

InBe IB/04.06050 Bedienungsanleitung

Swiss Madison

Swiss Madison Carré SM-1T264 Bedienungsanleitung

agape

agape PEAR 2 Bedienungsanleitung

Roca

Roca DAMA SENSO COMPACT Bedienungsanleitung