LawnMaster LMLS22T Bedienungsanleitung
MODEL NO : LMLS22T, LMLS37T
LawnMaster Log Splitter
Owner’s Manual
ASSEMBLY & OPERATING
INSTRUCTIONS
This safety alert symbol identifies important safety messages in this
manual. Failure to follow this important safety information may
result in serious injury or death.
Table of Contents
Page(s)
Important Safety Information........................................................................................................................................1-6
Intended Use....................................................................................................................................................1
Personal Protective Equipment..................................................................................................................... 1
Safety Decals................................................................................................................................................... 1-2
General Safety.................................................................................................................................................3
Preparation of the Log.................................................................................................................................... 3
Work Area.........................................................................................................................................................3
Operation of the Log Splitter......................................................................................................................... 3-4
Repair and Maintenance Safety....................................................................................................................4
Hydraulic Safety.............................................................................................................................................. 5
Fire Prevention.................................................................................................................................................5-6
Towing Safety.................................................................................................................................................. 6
Assembly Instructions................................................................................................................................................... 7-9
Parts Breakdown Illustrations...................................................................................................................................... 10-11
Operating Instructions...................................................................................................................................................12-13
Engine Oil Recommendations....................................................................................................................... 12
Hydraulic Oil Recommendations...................................................................................................................12
Starting Instructions.........................................................................................................................................12
Operation.......................................................................................................................................................... 13
Towing...............................................................................................................................................................13
Maintenance................................................................................................................................................................... 13
Warranty and Service Information...............................................................................................................................14
Specifications......................................................................................................................................................... Back Cover
WARNING: Read and thoroughly understand all instructions and safety information before assem-
bling
or operating this log splitter. Failure to do so may cause serious injury or death. Do not allow anyone
to operate this log splitter who has not read this manual. As with all power equipment, a log splitter
can be dangerous if assembled or used improperly. Do not operate this log splitter if you have doubts
or questions concerning safe operation. Call our customer service department to address these
concerns.
INTENDED USE
NEVER use this log splitter for any other purposes than splitting wood. It is designed for this use only. Any other use
can cause serious injury or death.
PERSONAL PROTECTIVE EQUIPMENT
BEFORE operating this log splitter make sure that you wear safety gear such as goggles or safey glasses, steel toed
shoes and tight fitting gloves (without loose cuffs or draw strings). Always wear a protective hearing device when operat-
ing this log splitter.
NEVER wear loose clothing or jewelry that can be caught by moving parts of the log splitter. Keep clothing and hair
away from all moving parts when operating this log splitter.
SAFETY DECALS
Make sure that all safety warning decals are in good condition and readable. Always replace missing or defaced decals.
Contact us for replacement decals.
LOCATION: TOP, FRONT END OF TONGUE
Page 1
LOCATION: BOTH STRIPPER
PLATES AND CYLINDER
LOCATION: HYDRAULIC TANK
LOWER TANK, RIGHT CORNER
LOCATION: TOP OF HYDRAULIC CYLINDER
Page 2
GENERAL SAFETY
Failure to follow these instructions may result in serious injury or death.
ALWAYS read the operator’s manual before operation. It is located in the plastic canister on the tongue.
NEVER allow children to operate this log splitter. NEVER allow adults lacking proper instructions and understanding
to operate this log splitter.
KEEP all people and pets a minimum of 10 feet away from your work area when operating this log splitter. Only the
operator is to be near the log splitter during use.
NEVER actuate the control until all people are clear of the work area.
NEVER operate the log splitter when under the influence of alcohol, drugs or medication.
NEVER allow a person who is tired or otherwise not alert to operate the log splitter.
PREPARATION OF THE LOG
Both ends of the log should be cut as square as possible to help prevent the log from riding out of the splitter during
operation. Do not split logs greater than 26 in. in length.
WORK AREA
NEVER operate the log splitter on slippery, wet, muddy or icy ground.
ONLY operate your log splitter on level ground. Operating on a slope could cause the log splitter to roll over or logs to fall
off.
NEVER operate your log splitter in an enclosed area. Exhaust fumes contain carbon monoxide which can be deadly when
inhaled.
NEVER attempt to move your log splitter over hilly or uneven terrain without a tow vehicle or adequate help.
ALWAYS block the wheels to prevent movement of the log splitter while in operation.
ONLY operate your log splitter in daylight or under good artificial light.
ALWAYS keep the work area clean. Remove split wood around your log splitter immediately so that you don’t
stumble over it.
OPERATION OF THE LOG SPLITTER
ONLY operate the log splitter from the operator zone
as shown in the diagram. The operator has the safest
and most effcient access to the control valve and the
beam in this location.Failure to operate the log splitter
in this position can result in serious injury or death.
Page 3
ENGINE
TONGUE
FOOT PLATE
BEAM
OPERATOR
ZONE
KNOW how to stop the log splitter and disengage the controls before operating it.
NEVER place hands or feet between the log and splitting wedge during forward or reverse stroke. Serious injury or death
could result.
NEVER straddle or step over the log splitter during operation.
NEVER reach or bend over the log splitter to pick up a log.
NEVER try to split two logs on top of each other.
NEVER try to cross split a log.
NEVER attempt to load your log splitter when the ram or wedge is in motion.
ALWAYS use your hand to operate the control lever on the valve. NEVER use your foot, a rope or any extension device.
NEVER move the log splitter while the engine is running. Shut off the engine even if you are leaving the log splitter for a
short period of time.
ALWAYS avoid contact with the muffler and other hot areas of the engine during operation or after running to
prevent burns.
REPAIR AND MAINTENANCE SAFETY
NEVER operate your log splitter when it is in poor mechanical condition or in need of repair.
Periodically check that all nuts, bolts, screws, hydraulic fittings and hose clamps are tight.
NEVER alter your log splitter in any manner. Such alterations may cause your log splitter to be unsafe and will void the
warranty.
Perform all recommended maintenance procedures before using your log splitter.
Replace all damaged or worn parts immediately.
NEVER tamper with the engine to run it at excessive speeds. The maximum engine speed is preset by the manufacturer
and is within safety limits. See Honda engine manual.
ALWAYS remove the spark plug wire before performing any service or repair on your log splitter.
ALWAYS check the level of hydraulic oil and engine oil before operation.
ALL replacement parts must meet manufacturer’s specifications.
Page 4
HYDRAULIC SAFETY
The hydraulic system of your log splitter requires careful inspection along with the mechanical parts. Be sure to
replace frayed, kinked, cracked or otherwise damaged hydraulic hoses or hydraulic components.
NEVER check for leaks of hydraulic fluid with your hand. Fluid escaping from a small hole can be almost invisible.
Escaping fluid under pressure can have sufficient force to penetrate skin causing serious personal injury or even death.
Leaks can be detected by passing a piece of cardboard over the suspected leak and looking for discoloration.
ALWAYS seek professional medical attention immediately if injured by escaping hydraulic fluid. Serious infection
or reaction can develop if proper medical treatment is not administered immediately.
ALWAYS be sure to relieve all pressure by shutting off the engine and moving the valve control handle back and
forth should it become necessary to loosen or remove any hydraulic fitting.
NEVER remove the cap from the hydraulic tank or reservoir while the log splitter is running. The tank could contain hot oil
under pressure which could result in serious injury.
NEVER adjust the hydraulic valve. The pressure relief valve on your log splitter is preset at the factory. Only a qualified
service technician should perform this adjustment.
FIRE PREVENTION
NEVER operate your log splitter near a flame or spark. Hydraulic oil and gasoline are flammable and can explode.
NEVER fill the gas tank while the engine is hot or running. Allow the engine to cool before refueling.
NEVER smoke while operating or refueling your log splitter. Gas fumes can easily explode.
ONLY refuel your log splitter in a clear area with no gas fumes or spilled gas.
ALWAYS use an approved fuel container.
ALWAYS replace the gas cap securely.
If gasoline has spilled, move the log splitter away from the area of the spill and avoid creating any source of ignition until
the spilled gas has evaporated.
ALWAYS take a Class B fire extinguisher with you when operating this log splitter in dry areas as a
precautionary measure against possible flying sparks.
ALWAYS drain the fuel tank prior to storage to avoid the potential fire hazard.
ALWAYS store gasoline in an approved, tightly sealed container. Store the container in a cool, dry place.
NEVER store gasoline in the house or near a heating appliance.
ALWAYS turn the fuel shut off valve on the engine to the “OFF” position before towing the log splitter. Failure to do
so may result in flooding the engine.
Page 5
IMPORTANT NOTE:
This log splitter is equipped with an internal combustion engine and should not be used on or near any unimproved
forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark
arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in efffective
working order by the operator. Always check the legal requirements in your area.
TOWING SAFETY
ALWAYS check all local and state regulations regarding towing, licensing, and lights before towing your log splitter.
ALWAYS check before towing to make sure that the log splitter is correctly and securely attached to the towing
vehicle and that the safety chains are secured to the hitch or bumper of the vehicle with enough slack to allow turning.
Always use a Class I, 2” ball with this log splitter.
NEVER carry any cargo or wood on your log splitter.
NEVER allow anyone to sit or ride on your log splitter.
ALWAYS disconnect your log splitter from the towing vehicle before operating it.
ALWAYS be careful when backing up with your log splitter in tow. It could jackknife.
ALWAYS allow for added length of your log splitter when turning, parking, crossing intersections and in all
driving situations.
NEVER exceed 45 kph when towing your log splitter. Towing the log splitter at speeds higher than 45 kph could result
in loss of control, damage to the equipment , serious injury or death. Adjust towing speed for terrain and conditions. Be
extra cautious when towing over rough terrain especially railroad crossings. Never tow on public land/ roads unless it
complies with the New Zealand law.
Page 6
ASSEMBLY INSTRUCTIONS
NOTE: This log splitter was partially assembled at the factory. Refer to the drawings and parts list should it become
necessary to disassemble the unit for repair or replacement of parts
ITEM NO.
PART NO.
DESCRIPTION
QTY.
1
401611R0
Beam Assembly
1
2
40127500
Beam Lock Assembly
1
3
40160900
Tank Assembly
1
4
400312B0
Tire and Wheel
2
5
40127300
Tongue Assembly
1
40115400
Hardware Kit
1
NOTE: This log splitter was partially assembled at the factory. Refer to the drawing and parts list should it become
necessary to disassemble the unit for repair or replacement of parts.
STEP 1: Remove all the components from the shipping container.Inspect each piece for shipping damage. If any part is
damaged, contact your dealer or delivering carrier.
STEP 2: Attach the two wheels (2) to the tank assembly (1) wheel spindles using the 3/4” light flat washers(3) , 3/4” NF
slotted nuts (4), 1/8” x 1-1/2” cotter pins (5) and the hub caps (6). These items are in the hardware package.
Tighten the slotted nuts and make sure the wheels rotate freely.
ITEM NO.
PART NO.
DESCRIPTION
QTY.
1
40160900
Tank Assembly
1
2
400312B0
Wheel Assembly
2
3
O/L
3/4” Light Flatwasher
2
4
17012000
3/4” Slotted Nut
2
5
O/L
1/8” x 1-1/2” Cotter Pin
2
6
40033200
Hub Cap
2
O/L- Obtain locally. Common fasteners available through
hardware and farm stores.
Page 7
STEP 3: Attach the tongue assembly (5) to the tank assembly (1) using two 1/2” NC x 4-1/2” hex cap bolts (2), two 1/2”
lock washers (3) and two and two 1/2” hex nuts (4). Tighten.
ITEM NO. PART NO.
DESCRIPTION
QTY.
1
40160900
TankAssembly
1
2
O/L
1/2” NC x 4-1/2 Hex Bolt
2
3
O/L
1/2” Lock Washer
2
4
O/L
1/2” NC Hex Nut
2
5
40127300
Tongue Assembly
1
O/L- Obtain locally. Common fasteners available through
hardware and farm stores.
STEP 4: Stand the beam (1) up on end. Two people may be needed for this step to ensure safety. Make sure that the
beam is stable and on a level surface. Remove the pivot pin (3) and clip pin (2) from the tank assembly.Roll
the tongue/ tank assembly into position between the two tabs on the beam (1). Slide the pivot pin (3) through
the aligned holes and lock in place with the clip pin (2).
ITEM NO. PART NO.
DESCRIPTION
QTY
1
401611R0
Beam Assembly
1
2
O/L
1/2”-3/4” R Clip Pin
1
3
071022WC
Pivot Pin
1
O/L- Obtain locally. Common fasteners available through
hardware and farm stores.
Page 8
Dieses Handbuch passt für folgende Modelle
1
Inhaltsverzeichnis
Beliebte Holzspalter Handbücher anderer Marken
Scheppach
Scheppach OX 3-1000 Montageanleitung
Swisher
Swisher 21200 Bedienungsanleitung
Elem Garden Technic
Elem Garden Technic FBHT65-22TCH Bedienungsanleitung
Champion Power Equipment
Champion Power Equipment 90720 Handbuch
Boss Industrial
Boss Industrial ES5T20 Bedienungsanleitung
Villager
Villager LSP 12 T Bedienungsanleitung
