LG DLE9577 Installationsanleitung
Digital Appliance
DLE9577/DLG9588 Dryer Training
Spring 2007
Service
TRAINING MANUAL
DRYER 9577/9588
DLE9577/DLG9588 Page 2 of 58 TRAINING MANUAL
DLG9577/DLE9588
Safety Notices and Warnings 1
Contact Information 1
Contents 2
Specifications 4
Safety Notices (Gas and Electric) 5
Serial Number Identification 6
Introduction 7
Controls 8
Installation 9
Accessories 10
Drying Rack 10
Stacking Kit 11
Pedestal Kit 12
Electrical Connection 14
4-wire Connection 14
3-wire Connection 15
Electrical Connection to Gas Dryer 16
Gas Connection 17
Vent Pipe Connection (side, bottom, or rear vent with kit) 18
Remote Monitor and Modem 19
Dryer Cycle Chart 20
Diagnostic Test Mode 21
Test 1 – AC Electrical Supply 22
Test 2 – Thermistor 25
Test 3 – Motor 26
Test 4 – Moisture Sensor 27
Test 5 – Door Switch 28
Test 6 – Heater (Electric) 29
Test 7 – Valve (Gas) 30
Component Test Procedure 31
Disassembly and Repair 34
Block Wiring Diagram (Electric and Gas) 35
Motor Diagram and Schematic 36
Safety Switches 37
Gas Conversion (Natural Gas to Propane) 38
DRYER 9577/9588
DLE9577/DLG9588 Page 3 of 58 TRAINING MANUAL
Gas Valve Operation 40
Disassembly/Repair 41
Top Plate 41
Control Panel 42
Front Cabinet Cover 43
Door Reversal 43
Drum Front 44
Drum Assembly and Belt 44
Drum Lamp 45
Filter Assembly and Moisture Sensor 46
Blower Housing 46
Air Duct 47
Back Cover 47
Rollers 48
Vent Replacement 49
Main Board 50
Exploded Views 51
Top Plate and Control Panel 51
Cabinet, Door, Vent, and Wiring Harness 52
Drum, Motor, and Heater (Electric) 53
Drum, Motor, and Heater (Gas) 54
Parts List 55
070119
DRYER 9577/9588
DLE9577/DLG9588 Page 4 of 58 TRAINING MANUAL
SPECIFICATIONS
DRYER 9577/9588
DLE9577/DLG9588 Page 5 of 58 TRAINING MANUAL
SAFETY
GAS
Check the local laws and regulations concerning the installation and connection
of gas. In most localities, it is illegal to connect gas piping, re-jet or adjust burners,
or repair gas-fired equipment unless you are certified so to do.
ELECTRIC
The gas dryer uses 120 VAC. The electric dryer uses 240 VAC. Even when these
products are turned OFF, there is live voltage on some of the internal terminals.
Always unplug the appliance before opening the case or servicing.
DRYER 9577/9588
DLE9577/DLG9588 Page 6 of 58 TRAINING MANUAL
SERIAL NUMBER IDENTIFICATION
The serial number is unique to each product. It gives information concerning the
time and place of manufacture. The serial number is required to be paid for
warranty service and to get the correct part in the event a running production
change was made. Some models may have four (4) letters instead of two (2) for
the product code number. The third and fourth letters are significant only to the
manufacturing facility.
This chart will help you decode the serial number.
DRYER 9577/9588
DLE9577/DLG9588 Page 7 of 58 TRAINING MANUAL
INTRODUCTION
The 9577/9588 dryer is very similar to other LG dryers with the exception of the
front panel and the control panel. The control panel is designed to allow the
customer to choose the location of either the top or the bottom, which allows for
easier access to the controls when the dryer is stacked on top of the washer.
(See
page 42.) The dryer is shipped from the factory with the control panel in the
lower position.
DRYER 9577/9588
DLE9577/DLG9588 Page 8 of 58 TRAINING MANUAL
CONTROLS
The control panel features discrete buttons for each selection rather than
requiring the user to cycle through numerous choices to pick one.
A couple of buttons serve double functions. Pressing and holding RACK DRY will
turn the Child Lock ON or OFF. Pressing and holding CUSTOM PROGRAM will
store the customer’s favorite setting (one that is used most of the time.)
The main control board is located in the top of the machine rather than in the
front panel. The communication between the main control board and the control
panel is handled by a UART (Universal Asynchronous Receiver Transmitter) and
a 7-wire cable rather than by a 28-wire cable as in previous models. This
simplification is what makes it possible to have a re-locatable control panel.
DRYER 9577/9588
DLE9577/DLG9588 Page 9 of 58 TRAINING MANUAL
INSTALLATION
The 9577/9588 dryer is designed to be used stacked on top of a WM2496
washer, so the control panel is shipped in the lower position. It can be converted
easily to be used as a conventional dryer next to a washer. The customer can do
this himself. (See page 42 of this training manual.)
The 9577/9588 dryer can be installed in a laundry closet if the clearance
guidelines are met. (See drawing, above.) It does not matter whether the dryer is
stacked, as long as the closet door opening provides the appropriate vertical
clearance for lifting and stacking in the closet.
DRYER 9577/9588
DLE9577/DLG9588 Page 10 of 58 TRAINING MANUAL
ACCESSORIES
The 9577/9588 dryer is shipped with a drying rack and a stacking kit. The
pedestal is optional. The dryer is designed to stack on the matching WM2496
washer. Both products can be stacked on a single pedestal, if desired, but the
dryer must always be on top of the washer.
DRYING RACK STACKING KIT PEDESTAL
INSTALLATION (RACK)
It’s simple!
Open the dryer door.
Set the rack in place.
Select RACK DRY.
(2nd button from top on the option row
on the right of the panel)
Press START.
Be sure the front of the rack is
properly situated in the notches on
either side of the filter. The back of the
rack should rest on the drum and
allow the drum to rotate.
Dieses Handbuch passt für folgende Modelle
1
Inhaltsverzeichnis
Andere LG Trockner Handbücher
LG
LG SteamDryer DLGX3251R Bedienungsanleitung
LG
LG DLG1320W Bedienungsanleitung
LG
LG DLEX8388WM Installationsanleitung
LG
LG DLEY1701*E Bedienungsanleitung
LG
LG RT8DIHP Bedienungsanleitung
LG
LG RC9055*P*Z Bedienungsanleitung
LG
LG DLEC888R Bedienungsanleitung
LG
LG DLEX7300 E Series Bedienungsanleitung
LG
LG DLG7101 Series Bedienungsanleitung
LG
LG DLEX3885C Bedienungsanleitung
LG
LG DLE3050 Bedienungsanleitung
LG
LG DLE3777 Bedienungsanleitung
LG
LG DLEX5101V Bedienungsanleitung
LG
LG DLGX8001V Bedienungsanleitung
LG
LG FDJ608W Bedienungsanleitung
LG
LG DLE3050 Bedienungsanleitung
LG
LG VH2-S16W Bedienungsanleitung
LG
LG DLE0442 Bedienungsanleitung
LG
LG DLGX4371K/00 Bedienungsanleitung
LG
LG TD-H901MW Bedienungsanleitung
Beliebte Trockner Handbücher anderer Marken
Indesit
Indesit IDV 75 Bedienungsanleitung
Infiniton
Infiniton SD-DG85C Bedienungsanleitung
BOMANN
BOMANN WT 5019 Bedienungsanleitung
Alliance Laundry Systems
Alliance Laundry Systems TMB795C Bedienungsanleitung
Asko
Asko T793C Bedienungsanleitung
Kenmore
Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Bedienungsanleitung